tailgate SSANGYONG KORANDO 2013 Service Manual

0000-00
Luggage lamp switch
Overhead console
switchFront seat heating and ventilation switch
With heating and ventilation
switchWith heating switch
Driver power seat
switch
Center room lamp
switch
Rear door switch (RH)Rear door switch (LH)
Tailgate switch

2. INPUT SIGNALS
NO Input signal Logic
1 IGN1 ON = Battery voltage (IGN ON or START)
2 IGN2 ON = Battery voltage (IGN ON)
3 Alternator ON = Battery voltage (engine running)
4 Key reminder switch IN = Battery voltage (key inserted)
5 Driver door LOCK detecting switch LOCK = GND, UNLOCK = OPEN
6 Driver door UNLOCK detecting switch LOCK = OPEN, UNLOCK = GND
7 Passenger door LOCK detecting switch LOCK = GND, UNLOCK = OPEN
8 Passenger door UNLOCK detecting
switchLOCK = OPEN, UNLOCK = GND
9 Rear door LOCK detecting switch LOCK = OPEN, UNLOCK = GND
10 Puddle lamp ON = (-) OUTPUT
11 Driver door open switch OPEN = GND, CLOSE = OPEN
12 Passenger door open switch OPEN = GND, CLOSE = OPEN
13 Rear LH door open switch OPEN = GND, CLOSE = OPEN
14 Rear RH door open switch OPEN = GND, CLOSE = OPEN
15 Tailgate switch OPEN = GND, CLOSE = OPEN
16 Hood switch OPEN = GND, CLOSE = OPEN
17 Sunroof switch OPEN = GND, CLOSE = OPEN
18 headlamp switch ON = GND, OFF = OPEN
19 Folding/unfolding switch ON = GND, OFF = OPEN
20 Crash door LOCK/UNLOCK switch ON = GND, OFF = OPEN
21 Crash sensor (air bag) ON = 200 ms Low signal, OFF = OPEN
22 Front defogger (heated wire) switch ON = GND, OFF = OPEN
23 Rear defogger (heated wire) switch ON = GND, OFF = OPEN
24 Wiper switch 1 ON = GND, OFF = OPEN
25 Wiper switch 2 ON = GND, OFF = OPEN
26 Driver seat belt switch Unbuckled = GND, Fastened = OPEN
27 Passenger seat belt switch (only EU) Unbuckled = GND, Fastened = OPEN
28 Rain & AUTO light sensor LIN communication

8710-01
Item Functionw/o
SKMw/ SKM
10 Ignition key remote
control functionTransmitter function O X
Remote control door LOCK O X
Remote control door UNLOCK O X
Remote control panic O X
Remote control escort O X
AUTO door LOCK after 30 seconds O X
11 Door
LOCK/UNLOCK
controlDoor LOCK/UNLOCK control by door knob switch O O
Door LOCK/UNLOCK control by center door LOCK
switchOO
Door LOCK/UNLOCK control by REKES key signal O X
Door LOCK/UNLOCK control by smart key X O
Door LOCK/UNLOCK control by door handle switch
(passive entry)XO
AUTO door LOCK control O O
AUTO UNLOCK upon receiving air bag deployment
signalOO
12 Panic alarm Panic alarm control by REKES key signal O X
Panic alarm control by smart key signal X O
13 Tailgate control Tailgate open control
(for vehicles without SKM)OX
Tailgate open control
(for vehicles with SKM)XO
14 Theft deterrent
alarm controlTheft deterrent alarm control (for vehicles without
SKM)OX
Theft deterrent alarm control (for vehicles with SKM) X O
15 Time lag window
controlTime lag power window control O O

All doors LOCK prevention function
When the LOCK signal is input with the doors (driver/passenger/rear) open and the ignition key
removed or IGN ON).
The UNLOCK signal is output for 0.5 seconds (T1) immediately after the LOCK signal output. A.
B. Operation 1.
All doors are closed during the UNLOCK output.
The UNLOCK output continues. C.
D. Operation 2.
When the ignition key is inserted, the ignition key reminder is operated. E. Operation 3.Except tailgate and hood -
Operating process
This function does not work if the vehicle speed is over 10 km/h.

8710-01
REKES key switch description
Door LOCK (locks the doors and tailgate when pressed briefly) 1.
All doors and the tailgate are locked and the theft deterrent mode is activated.
When the theft deterrent mode is activated, the hazard warning lamp flashes twice. When this
button is pressed once more within 4 seconds, the hazard warning lamp flashes twice and the
buzzer sounds once. -
-
Panic (Press and hold for 2 seconds or more) 3.
If this button is pressed for 2 seconds or more, the hazard warning lamp flashes while the buzzer
sounds for approx. 30 seconds.
If the door LOCK button or panic button is pressed, this function is deactivated. -
- Door UNLOCK (unlocks the doors and tailgate when pressed briefly) 2.
If this button is pressed briefly, all doors and the tailgate are unlocked and the theft deterrent
mode is deactivated.
When the theft deterrent mode is deactivated, the hazard warning lamp flashes once.
In theft deterrent mode, if a door, tailgate or engine hood is not opened within 30 seconds after
the door is unlocked by a remote controller, the doors are locked with the hazard warning lamp
and buzzer activated (lamp flashes twice and buzzer sounds once, the theft deterrent mode is
activated again). -
-
-
13. REMOTE KEYLESS ENTRY SYSTEM (REKES)
REKES key (Transmitter)
When the user operates the switch of the REKES key, the vehicle control message formatted by the
remote controller CPU is sent to the main part via radio transmission. The CPU of the main part controls
the vehicle and the main part controls the vehicle operations.
Door LOCK
Door UNLOCK
Panic
The escort function is activated with the headlamp ON for 20 seconds when the door LOCK button
is pressed for 0.5 seconds or more in the theft deterrent mode. If the door LOCK button is pressed
briefly or the ignition is turned ON during the escort operation, the escort is deactivated.

Door LOCK/UNLOCK by REKES key
When the REKES LOCK switch is pressed less than 0.5 seconds (T1), the door LOCK relay is
activated for 0.5 seconds (T2).
All of following conditions are met within 0.2 seconds (T4) after the chattering time (T3): A.
B. Operation 1.
When the REKES UNLOCK switch is pressed less than 2 seconds (T5), the door UNLOCK relay is
activated for 0.5 seconds (T2).
The door UNLOCK conditions are met, the turn signal lamp is operated once for 1 second. D.
E. Operation 2.
All doors closed
Hood closed
Tailgate closed
Door LOCK detection switch in LOCK state -
-
-
-
The turn signal lamp flashes 2 times at intervals of 0.5 sec. ON/0.5 sec. OFF. C.
Operating process (for vehicles without SKM)
Do not operate the REKES key with the ignition key inserted or for 1 second after the ignition key is
removed. (to prevent the remote controller switch malfunction)
When one of the LOCK switches is unlocked after the door LOCK, all doors will be unlocked. -
-

AUTO door LOCK control
REKES LOCK
The vehicle is driven at 30 km/h or more.
The door LOCK relay is activated for 0.5 seconds (T2).
The door LOCK relay is not activated when all doors (except tailgate) are locked or door malfunction
signal is input. A.
B.
C. Operation 1.
The UNLOCK signal by other switch is received.
The door LOCK signal is output 5 times for the switch. F.
G. Operation 3. (during operation 2)
A door is unlocked.
The door LOCK signal is output 5 times (T3) except the door LOCK carried out in operation 1. D.
E. Operation 2. (after operation 1)
The door LOCK system outputs UNLOCK signal automatically when the LOCK output conditions
are met by this function or the ignition is turned ON to OFF. (even when there is no LOCK output
while the vehicle is driven at over 30 km/h under LOCK condition). - If a door is unlocked after the 5 times of LOCK output, the door is regarded as malfunctioning.
If there is a malfunctioning door, the AUTO door LOCK is not activated but the LOCK operation by
the central door LOCK switch is available.
If a malfunction occurs when the vehicle is driven at 30 km/h or more, the AUTO door LOCK will not
be activated even when the vehicle speed decreases to 30 km/h or less and then increases to 30
km/h or more.
The faulty door will be reset when the unlocked malfunctioning door is locked. -
-
-
-
The faulty door will be reset when the ignition is turned OFF.
When one of the door LOCK switches is in LOCK position with the ignition turned OFF, all doors
are unlocked. -
-

Tailgate open control (for vehicles without SKM)
The ignition is turned OFF or ON, or ACC is turned ON with the driver door unlocked.
When the tailgate open switch is pressed for more than 0.1 seconds (T1), the tailgate open relay is
activated for 1 second. A.
B. Operation 1.
The tailgate open relay is activated.
The vehicle is driven at 3 km/h or more with the driver door locked or IGN ON.
The tailgate open relay is deactivated immediately. C.
D.
E. Operation 2.
The vehicle is driven at 3 km/h or more with IGN ON.
The tailgate open relay is not activated when the tailgate open switch is pressed. F.
G. Operation 3.
16. TAILGATE OPEN CONTROL

Tailgate open control (for vehicles with SKM)
The ignition is turned OFF or ON, or ACC is turned ON with the driver door unlocked.
When the tailgate open switch is pressed for more than 0.1 seconds (T1), the tailgate open relay is
activated for 1 second. With the ignition turned ON, the tailgate open relay is activated only when the
vehicle is driven at 3 km/h or less. A.
B. Operation 1.
The tailgate open relay is activated.
The vehicle is driven at 3 km/h or more with the driver door locked or IGN ON.
The tailgate open relay is deactivated immediately. C.
D.
E. Operation 2.
The vehicle is driven at 3 km/h or more with IGN ON.
The tailgate open relay is not activated when the tailgate open switch is pressed. F.
G. Operation 3.
The ignition is turned OFF or ON, or ACC is turned ON with the driver door and tailgate door locked.
The tailgate open switch is pressed for 0.1 seconds or more.
The BCM sends the verification request to the SKM through B-CAN. The SKM verifies the smart key
and sends the signal to the BCM through B-CAN.
The BCM activates the tailgate open relay after the valid smart key verification.
(In theft deterrent mode, only the theft deterrent for tailgate is deactivated.) -
-
-
- Operation 4.
The tailgate open signal is input by the smart key when the vehicle is not in stationary or the power is
not turned OFF.
The BCM keeps the tailgate open relay ready to operate for 30 seconds.
If the signal from the tailgate open switch is input within this 30 seconds,
The tailgate open relay is activated.
If no signal is input within 30 seconds in theft deterrent mode, the mode remains on. The system
enters the theft deterrent mode immediately when the LOCK signal from the smart key is input. -
-
-
- Operation 5.
The tailgate closed signal is input in theft deterrent mode with power OFF.
The BCM searches a verified smart key in the luggage compartment after 1 second.
If a verified smart key is found in the luggage compartment, the BCM activates the external buzzer for
5 seconds.
The driver presses the tailgate open switch to find the smart key.
The BCM deactivates the tailgate LOCK function so that the tailgate can be opened even when the
driver door is locked. (standby to operate without verification) -
-
-
-
- Operation 6.

Theft deterrent mode entering by REKES key (for vehicles without SKM)
All doors (including hood and tailgate) are closed with the ignition key removed.
REKES LOCK signal is received.
The door LOCK relay is activated.
All doors (including hood and tailgate) are locked
The system enters the theft deterrent mode after operating the hazard warning lamp twice. A.
B.
C.
D.
E. Operation 1.
REKES LOCK signal is received again within 4 seconds of theft deterrent mode activation.
The hazard warning lamp flashes twice and the warning horn is operated once in the theft deterrent
mode. F.
G. Operation 2.
REKES LOCK signal is received with one or more doors open.
The LOCK relay is activated followed by activation of UNLOCK relay. H.
I. Operation 3.
REKES LOCK signal is received with the tailgate and hood open.
Only the LOCK relays of the closed doors except hood and tailgate are activated.
The system does not enter theft deterrent mode.
If the open tailgate and hood are closed.
The system enters the theft deterrent mode after operating the hazard warning lamp twice. J.
K.
L.
M.
N. Operation 4.
All doors are opened or the ignition key is not inserted within 30 seconds (T5) after the REKES
UNLOCK signal is received.
The LOCK relay is activated and the system enters the theft deterrent mode after operating the
hazard warning lamp twice. O.
P. Operation 5.
17. THEFT DETTERENT FUNCTION
The theft deterrent mode will not be activated when the door is locked by the door key. -