engine TOYOTA HILUX 2023 Owners Manual

6389-1. Specifications
HILUX_OM_OM0K789E_(EE)
*1: Minimum pedal clearance when depressed with a force of 490 N (50 kgf, 110 lbf) while the engine is running.
*2: Parking brake lever travel when pulled up with a force of 200 N (20 kgf,45 lbf)
*3: Without 205R16C tires
*4: With 205R16C tires
*5: With rear drum brake
*6: With rear disc brake
Clutch (vehicles with manual transmission)
Pedal free play 5  15 mm (0.2  0.6 in.)
Fluid type SAE J1703 or FMVSS No.116 DOT 3 or
SAE J1704 or FMVSS No.116 DOT 4
Brakes
Pedal
clear-
ance*1
Without VSC82 mm (3.2 in.)*3
92 mm (3.6 in.)*4
With
VSC
Left-
hand
drive
vehicles
4WD
models
82 mm (3.2 in.)*5
89 mm (3.5 in.)*6
Pre
Runner82 mm (3.2 in.)
Right-hand drive
vehicles
82 mm (3.2 in.)*5
87 mm (3.4 in.)*6
Pedal free play1.0  6.0 mm
(0.04  0.24 in.)
Parking brake lever travel*27 9 clicks*5
8 10 clicks*6
Fluid type
SAE J1703 or FMVSS No.116
DOT 3 or SAE J1704 or FMVSS
No.116 DOT 4

6449-1. Specifications
HILUX_OM_OM0K789E_(EE)
Fuel infor mation
◆Gasoline engine
When you find these types of fuel label at the gas station, use only
the fuel with one of the following labels.

You must only use unleaded gasoline.
Select unleaded gasoline with a Research Octane Number of 91 or
higher for optimum engine performance.
◆Diesel engine
When you find these types of fuel label at the gas station, use only
the fuel with one of the following labels.

EU area:
You must use diesel fuel conforming to European standard EN590,
EN16734 or EN15940*.
Except EU area (vehicles without DPF system):
You must use only diesel fuel with a cetane number of 48 or higher.
Except EU area (vehicles with DPF system):
You must use only diesel fuel that contains 10 ppm or less of sulfur
with a cetane number of 48 or higher.
*: In case that a vehicle which has “XTL” label on the fuel lid, XTL (EN15940,
paraffin diesel) can be used.
*

645
9
9-1. Specifications
Vehicle specifications
HILUX_OM_OM0K789E_(EE)
■Use of ethanol blended gasoline in a gasoline engine
Toyota allows the use of ethanol blended gasoline where the ethanol content
is up to 10%. Make sure that the ethanol blended gasoline to be used has a
Research Octane Number that follows the above.
■ If you plan to drive in foreign countries (vehicles with DPF system)
Low sulfur diesel fuel may not be avai lable, so please check the availability
with your distributor.
■ If your engine knocks
● Consult any authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
● You may occasionally notice light knocking for a short time while accelerat-
ing or driving uphill. This is normal and there is no need for concern.
NOTICE
■ Notice on gasoline fuel quality
● Do not use improper fuels. If improper fuels are used, the engine will be
damaged.
● Do not use gasoline with metallic additives, for example manganese, iron
or lead, otherwise it may cause damage on your engine or emission con-
trol system.
● Do not add aftermarket fuel additives which contain metallic additives.
● Do not use the methanol blended gasoline such as M15, M85, M100. The
use of gasoline containing methanol may cause engine damage or failure.
● Bioethanol fuel sold under names such as “E50” or “E85” and fuel contain-
ing a large amount of ethanol should not be used. Your vehicle can use
gasoline mixed with 10% max ethanol. The use of fuel with more than 10%
ethanol content (E10) will damage the vehicle’s fuel system. You must
ensure that refueling is carried out only from a source where fuel specifica-
tion and quality can be guaranteed. In case of any doubt, ask any autho-
rized Toyota retailer or Toyota authorized repairer, or any reliable repairer.

6469-1. Specifications
HILUX_OM_OM0K789E_(EE)
NOTICE
■Notice on diesel fuel quality
● Do not use improper fuels. If improper fuels are used, the engine will be
damaged.
● Vehicles with DPF system: Do not use a fuel that contains more than 10
ppm of sulfur. Use of such a high sulfur fuel may damage the engine.
● EU area: FAME (Fatty Acid Methyl Ester) fuel sold under names such as
“B30” or “B100” and fuel containing a large amount of FAME should not be
used. The use of these fuels will damage the vehicle’s fuel system. In case
of any doubt, ask any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer.
● Except EU area: FAME (Fatty Acid Methyl Ester) fuel sold under names
such as “B30” or “B100” and fuel containing a large amount of FAME
should not be used. Your vehicle can use diesel mixed with 5% max
biodiesel FAME (B5) or diesel equivalent to EN590/EN16734/EN15940*.
The use of fuel with more than 5% FAME content (B5) or diesel not equiv-
alent to EN590/EN16734/EN15940* will damage the vehicle’s fuel sys-
tem. You must ensure that refueling is carried out only from a source
where fuel specification and quality can be guaranteed.
In case of any doubt, ask any authorized Toyota retailer or Toyota autho-
rized repairer, or any reliable repairer.
*: In case that a vehicle which has “XTL” label on the fuel lid, XTL
(EN15940, paraffin diesel) can be used.

6509-2. Customization
HILUX_OM_OM0K789E_(EE)
■PCS (Pre-Collision System)*1 ( P. 272)
*1: If equipped
*2: The system is automatically enabled each time the engine switch is
turned to the “ON” position (vehicles without smart entry & start system)
or IGNITION ON mode (vehicles with smart entry & start system).
■LDA (Lane Departure Alert With Yaw Assist Function)*
( P. 283)
*: If equipped
FunctionCustomized setting
PCS (Pre-Collision System)*2On, Off–O–
Sensitivity (adjust alert timing)Early, Middle, Late–O–
123
FunctionCustomized setting
Yaw AssistOn, Off–O–
Warning sensitivityStandard, High–O–
Vehicle sway warning functionOn, Off–O–
Vehicle sway warning sensitivityHigh, Standard, Low–O–
123

6519-2. Customization
HILUX_OM_OM0K789E_(EE)
9
Vehicle specifications
■RSA (Road Sign Assist)*1 (P. 294)
*1: If equipped
*2: RSA function becomes on when the engine switch is turned to the “ON”
position (vehicles without smart entry & start system) or IGNITION ON
mode (vehicles with smart entry & start system).
*3: If a speed limit with supplemental mark is exceeded, the notification buzzer
does not operate.
*4: Vehicles with navigation system
■Dynamic Radar Cruise Control with Road Sign Assist*
( P. 3 1 1 )
*: If equipped
FunctionCustomized setting
RSA (Road Sign Assist)*2On, Off–O–
Excess speed notification
method*3Display only, Display and
buzzer, No notification–O–
No overtaking notification
method
Display only, Display and
buzzer, No notification–O–
Other notifications method (No-
entry notification)*4Display only, Display and
buzzer, No notification–O–
Excess speed notification level
2 km/h (1 mph),
5 km/h (3 mph),
10 km/h (5 mph)
–O–
123
FunctionCustomized setting
Dynamic Radar Cruise Control
with Road Sign AssistOn, Off–O–
123

6549-2. Customization
HILUX_OM_OM0K789E_(EE)
WARNING
■During customization
As the engine needs to be running during customization, ensure that the
vehicle is parked in a place with adequate ventilation. In a closed area such
as a garage, exhaust gases including harmful carbon monoxide (CO) may
collect and enter the vehicle. This may lead to death or a serious health
hazard.
NOTICE
■ During customization
To prevent battery discharge, ensure that the engine is running while cus-
tomizing features.

6559-3. Initialization
HILUX_OM_OM0K789E_(EE)
9
Vehicle specifications
Items to initialize
The following items must be initialized for normal system opera-
tion after such cases as the battery is reconnected, or mainte-
nance is performed on the vehicle.
ItemWhen to initializeReference
Engine oil
maintenance data
(if equipped)
After changing engine oilP. 491
Panoramic view
monitor (if equipped)
• The battery has been rein-
stalled.
• The steering wheel has
been moved while the bat-
tery was being reinstalled.
• The battery power is low.
Refer to the “Navi-
gation and multi-
media system
Owner’s manual”
or “Multimedia
Owner’s Manual”

658What to do if... (Troubleshooting)
HILUX_OM_OM0K789E_(EE)
What to do if... (Troubleshooting)
●If you lose your keys or mechanical keys, new genuine keys or mechanical
keys can be made by any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer. ( P. 149)
●Vehicles with smart entry & start system:
If you lose your electronic keys, the risk of vehicle theft increases signifi-
cantly. Contact any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer immediately. ( P. 150)
●Is the key battery weak or depleted? (P. 516)
●Vehicles with smart entry & start system:
Is the engine switch in IGNITION ON mode?
When locking the doors, turn the engine switch off. ( P. 225)
●Vehicles with smart entry & start system:
Is the electronic key left inside the vehicle?
When locking the doors, make sure that you have the electronic key on
your person.
●The function may not operate properly due to the condition of the radio
wave. ( P. 156, 164)
●Is the rear door child-protector lock set?
The rear door cannot be opened from inside the vehicle when the lock is
set. Open the rear door from outside and then unlock the rear door child-
protector lock. ( P. 154)
If you have a problem, check the following before contacting any
authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
The doors cannot be locked, unlocked, opened or closed
You lose your keys
The doors cannot be locked or unlocked
The rear door cannot be opened
(vehicles with rear door child-protector lock)

659What to do if... (Troubleshooting)
HILUX_OM_OM0K789E_(EE)
●Vehicles with manual transmission:
Do you turn the key with the clutch pedal depressed firmly? ( P. 219)
●Vehicles with automatic transmission:
Is the shift lever in P? ( P. 2 1 9 )
●Is the steering wheel unlocked? (P. 221)
●Is the battery discharged? (P. 604)
●Did you press the engine switch while firmly depressing the brake pedal?
( P. 222)
●Vehicles with automatic transmission:
Is the shift lever in P? ( P. 2 2 2 )
●Is the electronic key anywhere detectable inside the vehicle? (P. 162)
●Is the steering wheel unlocked? (vehicles with manual transmission)
( P. 227)
●Is the electronic key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( P. 601)
●Is the battery discharged? (P. 604)
●Vehicles without smart entry & start system:
Is the engine switch in the “ON” position?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in the “ON” position: P. 236
●Vehicles with smart entry & start system:
Is the engine switch in IGNITION ON mode?
If you cannot release the shift lever by depressing the brake pedal with the
engine switch in IGNITION ON mode: P. 236
If you think something is wrong
The engine does not start
(vehicles without smart entry & start system)
The engine does not start
(vehicles with smart entry & start system)
The shift lever cannot be shifted from P even if you depress
the brake pedal (vehicles with automatic transmission)