belt TOYOTA RAIZE 2023 Workshop Manual

4117-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
WARNING
When trouble arises
7
⚫In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with plenty of water and seek medical
attention
Place a wet sponge or cloth over the affected area until medical attention
can be received
⚫If you accidentally swallow electrolyte
Drink a large quantity of water or milk. Get emergency medical attention
immediately.
⚫Always wash your hands after handling the battery and other peripheral
components
⚫Do not allow children near the battery
⬛After removing the battery fixing bracket and the battery terminal nut
Tighten them securely. If the nuts loosen while driving, it may cause a short cir-
cuit and result in a fire.
⬛To prevent damage to the vehicle
Do not start the vehicle by pushing or pulling it.
The catalytic converter may overheat and cause a fire.
NOTICE
⬛To prevent battery discharge
⚫Turn off the lights and air conditioning system when the engine is not run-
ning.
⚫If you stop for a long time due to a traffic jam or other situations, turn off
unnecessary electrical components.
⬛When handling jumper cables
When connecting the jumper cables, ensure that they do not become entan-
gled in the cooling fans or engine drive belt.
RAIZE_OM_General_BZ358E.book 411 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4137-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
eAdd coolant if necessary
Water can be used in an emergency if
coolant is unavailable.
fStart the engine and turn the air co nditioning system on to check that
the radiator cooling fan operates and to check again for coolant leaks
from the radiator core or hoses
The fan operates when the air conditioning system is turned on immediately after a
cold start. Confirm that the fan is operat ing by checking the fan sound and air flow.
If it is difficult to check them, turn the air conditioning system ON and OFF repeat-
edly.
(The fan may not operate in freezing temperatures)
g If the fan is not operating:
Stop the engine immediately and contact your Toyota dealer
If the fan is operating:
Have the vehicle inspected at the nearest Toyota dealer
WARNING
⬛Before taking measures
Do not remove the radiator cap if the coolant is hot. The radiator cap is under
the pressure of the coolant. Therefore, steam or hot water may spurt out of it,
causing serious injury such as burns.
⬛To prevent an accident or injury when inspecting under the hood of your
vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
⚫If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot.
⚫Keep hands and clothing (especially a tie, a scarf or a muffler) away from the
fan and belts. Failure to do so may caus e the hands or clothing to be caught,
resulting in serious injury.
⚫Do not loosen the radiator cap an d the coolant reservoir cap while the
engine and radiator are hot. High te mperature steam or coolant could spray
out.
KBRO721003N
RAIZE_OM_General_BZ358E.book 413 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4208-1. List of specifications
RAIZE_OM_General_BZ358E
⬛Engine number
The engine number is stamped on the engine block as shown.
▶WA-VE engine▶1KR-VET engine
Engine
*For Saudi Arabia, Sultanate of Oman, Bahrain, United Arab Emirates, Qatar,
Kuwait
KBRO810102NKBRO810103N
ModelWA-VE1KR-VET
Type3-cylinder in line, 4-cycle, gasoline
Bore and stroke73.5 x 94.1mm (2.89 x 3.70 in.)71.0 x 84.0 mm (2.80 x 3.31 in.)
Displacement1198 cm3 (73.1 cu.in.)998 cm3 (60.9 cu.in.)
Valve clearance
(engine cold)Automatic adjustment
Intake: 0.145 - 0.235 mm
(0.006 - 0.009 in.)
Exhaust: 0.275 - 0.365 mm
(0.011 - 0.014 in.)
Drive belt tensionAutomatic adjustment
Maximum vehicle
speed*160 km/h (99 mph)175 km/h (108 mph)
Maximum
torque* (NET)
113 N·m (11.5 kgf·m,
83.3 ft·lbf) @4500 rpm140 N·m (14.3 kgf·m,
103.3 ft·lbf) @2400 - 4000 rpm
Maximum out-
put*(NET)65 kW (87.1 HP) @6000 rpm72 kW (96.5 HP) @6000 rpm
RAIZE_OM_General_BZ358E.book 420 ページ ２０２２年５月１７日　火曜日　午後１時５９分

440
RAIZE_OM_General_BZ358E
Alphabetical index
Alphabetical index
A
ABS (Anti-lock Brake System)........ 232
Air conditioning system Automatic air conditioning system ......................................... 254
Changing the filter ...................... 338
Manual air conditioning system .......... ...................... 244, 248
Airbags .................................................. 37
Arrangement .................................. 37
Conditions for deployment ......... 43
SRS airbag warning light............ 380
Alarm ..................................................... 73
Antenna .............................................. 284
Anti-clip system Power windows ............................ 160
Assist grips ......................................... 281
Auto lighting (automatic light on/off function) .............................. 198
Auto lock and unlock function ..... 136
Automatic air conditioning system .............................................. 254
Automatic light control system .... 198
Automatic light off system ............ 200
Average fuel economy ...................... 90
B
Baby seats............................................ 49
Back door ........................................... 142
Back-up lights
Replacing light bulbs .................. 352
Watts .............................................. 428
Battery ................................................. 321
If the vehicle battery is discharged ................................. 408
Preparation and inspection
before winter ............................. 238 To prevent battery discharge ... 411
Battery replacement (key) ............. 344
Bottle holder ...................................... 268
Brake assist ........................................ 232
Function ......................................... 232
Slip indicator ................................. 380
Brake fluid .......................................... 427
Brakes Brake system warning light....... 379
Maintenance data ....................... 427
Parking brake ............................... 197
BSM (Blind Spot Monitor) .............. 211
Buzzer
Automatic light-off .. ...........200, 391
Brakes .......... ..................... ....379, 387
BSM (Blind Spot Monitor) .......... 211
Driver’s seat belt
reminder ...... ......................381, 390
Driving with the parking
brake not released ..........382, 391
Electric power steering .....380, 388
Front corner sens ors .........222, 391
Front passenger’s seat belt reminder ...... ......................381, 390
Key removal reminder ................ 182
Key-free system ... ...............123, 393
RCTA (Rear Cross Traffic Alert) ......... 218
Rear seat belt reminder ....381, 391
Reverse .......................................... 193
Reverse sensors...... ............222, 391
when a door is not fully
closed .......... .......................381, 390
RAIZE_OM_General_BZ358E.book 440 ページ ２０２２年５月１７日　火曜日　午後１時５９分

441Alphabetical index
RAIZE_OM_General_BZ358E
C
Carpet.................................................. 290
Cleaning......................................... 290
How to install floor mats.............. 28
Change lever (shift lever) Continuously variable
transmission .............................. 189
Manual transmission .................. 194
Reverse warning buzzer ............ 193
Shift lever cannot be shifted ..... 191
Child restraint system ....................... 49
How to install.................................. 60
How to select .................................. 49
Installing using ISOFIX attachment points ...................... 63
Securing it with a seat belt .......... 61
Child-protector lock ......................... 135
Clean air filter .................................... 338
Cleaning Seat belts....................................... 290
Vehicle exterior ............................ 284
Vehicle interior ............................. 289
Cleaning and protecting Seat belts....................................... 290
Vehicle exterior ............................ 284
Vehicle interior ............................. 289
Clips
Floor mats ....................................... 28
Clock ............................................... 86, 98
Clock adjustment ...................... 88, 105
Condenser .......................................... 320
Continuously variable transmission Shift lever cannot be shifted ..... 191
Coolant
Checking ........................................ 319
Maintenance data ....................... 425
Preparation and inspection before winter ............................. 238
Cruising distance ................................ 90
Cup holder ......................................... 268
Curtain shield airbag ......................... 37
Customizations ................................. 430
D
D assist switching steering
switch ................................................ 190
Daytime running lights ................... 198
Deck board ......................................... 271
Deck board under tray ................... 272
Defogger
Rear window defogger ......249, 256
Windshield .... .......................249, 256
Dimensions ........................................ 418
Do-it-yourself service precautions ..................................... 309
Door handle (outer handle) .......... 133
Door linked (Illuminated entry system) ......... 264
Door pocket ....................................... 270
Door windows ................................... 160
Doors ................................................... 133
Auto lock and unlock
function....................................... 136
Child-protector lock .................... 135
Door pockets ................................ 270
Door windows .............................. 160
Inside lock button (power door lock)...................... 134
Key-free system ........................... 121
Open door warning light ........... 381
Wireless remote control ............ 131
RAIZE_OM_General_BZ358E.book 441 ページ ２０２２年５月１７日　火曜日　午後１時５９分

442Alphabetical index
RAIZE_OM_General_BZ358E
Driving................................................. 166
Correct driving posture................ 30
Eco-friendly driving ..................... 169
Procedures ................................... 166
Winter driving tips ....................... 238
Driving on flooded roads ............... 176
E
eCall....................................................... 68
Electric power steering ................... 232
Electronic key
Not working properly ................. 406
Operating range .......................... 122
Running out of the key battery......................................... 406
Emergency brake signal (emergency stop signal) .............. 232
Emergency flashers (hazard lights) ................................ 366
Replacing light bulbs .................. 352
Switch ............................................. 366
Watts .............................................. 428
Emergency key
(mechanical key) ............................ 118
Emergency seat belt fixing mechanism ....................................... 33
Emergency stop signal (emergency brake signal) ........... 232
Ending screen ................................... 103
Engine Compartment ............................... 315
Engine switch ......... ............. 180, 184
Hood............................................... 311
How to start ......... ................ 180, 184
Identification number................. 420
Ignition switch ..... ................ 180, 184
Malfunction indicator lamp ....... 379
Overheating .................................. 412
The engine does not start ......... 405
Engine oil ............................................ 420
Checking ........................................ 316
Engine oil deterioration warning light.............................. 382
Engine oil deterioration warning reset ..................... 94, 112
Low engine oil pressure
warning indicator ..................... 379
Maintenance data ....................... 420
Preparation and inspection before winter ............................. 238
Engine switch Operation method .. ...........180, 184
Event Data Recorder (EDR) ................ 7
Exhaust gas .......................................... 47
Exterior light bulbs .......................... 352
Replacement procedure ............ 352
Watts .............................................. 428
F
Fire extinguisher .............................. 369
Floor jack ............................................ 314
Floor mats ............................................ 28
Fluid Brake .............................................. 427
Clutch ............................................. 427
Continuously variable
transmission .............................. 426
Manual transmission .................. 426
Fog lights ............................................ 201
Replacing light bulbs .................. 352
Switch ............................................. 201
Watts .............................................. 428
Front corner sensors ....................... 221
Front passenger’s seat belt
reminder warning light ............... 381
RAIZE_OM_General_BZ358E.book 442 ページ ２０２２年５月１７日　火曜日　午後１時５９分

446Alphabetical index
RAIZE_OM_General_BZ358E
Meter (gauges and meters)............ 84
Display change button .......... 87, 99
Indicators ........................................ 81
Multi-information display............. 86
TFT color mult i-information
display ........................................... 98
Warning lights .............................. 379
Mirrors
Inside rear view mirror............... 156
Outside rear view mirrors ......... 157
Vanity mirror................................. 276
Multi-information display ................ 86
O
Oils....................................................... 418
Capacity and brand of oils ......... 418
Open tray ........................................... 270
Opener Back door ...................................... 142
Fuel tank cap ................................ 209
Hood............................................... 311
Opening screen ................................ 103
Outer handle (door handle) .......... 133
Outside rear view mirrors ............. 157
Adjustment ................................... 157
Automatic mode .......................... 158
BSM (Blind Spot Monitor) .......... 211
Operation ...................................... 157
Outside temperature indication .... 91
Overheating ....................................... 412
P
Parking brake .................................... 197
Maintenance data ....................... 427
Non-release
warning buzz er ................382, 391
Operation ...................................... 197
Parking brake non release
warning light.............................. 382
Power door lock
(inside lock button) ....................... 134
Power mode ...................................... 190
Power outlet ...................................... 277
Power steering system Electric power steering system warning light.............................. 380
Power windows ................................ 160
Jam protection function ............. 160
Operation ...................................... 160
Unable to close ............................ 161
Window lock switch (Power window OFF switch).... 160
Preparation before winter (Winter driving tips) ...................... 238
Procedure to connect the jumper
cables ................................................ 408
Push-button start switch ................ 184
R
Radiator
Overheating .................................. 412
Radiator (cooling system) .............. 320
Maintenance data ....................... 425
Overheating .................................. 412
Rear seat belt reminder warning
light ................................................... 381
RAIZE_OM_General_BZ358E.book 446 ページ ２０２２年５月１７日　火曜日　午後１時５９分

447Alphabetical index
RAIZE_OM_General_BZ358E
Rear seats........................................... 149
Adjustment ................................... 149
Head restraints ............................ 152
Warning on the rear seats ........ 150
Rear turn signal lights .................... 196
Replacing light bulbs .................. 352
Turn signal lever .......................... 196
Watts .............................................. 428
Rear window defogger switch ............................ ........... 249, 256
Rear wiper .......................................... 205
Rear-view camera ............................ 228
Refueling ............................................ 207
Maintenance data ....................... 421
Refueling procedure ................... 209
Replacement Air conditioning filter .................. 338
Fuses .............................................. 348
Key battery .................................... 344
Light bulbs .................................... 352
Tires ................................................ 396
Wiper rubbers .............................. 340
Retractable assist grips .................. 281
Reverse sensors ............................... 221
S
Scheduled maintenance ................ 294
Seat belt pretensioners .................... 33
Functions ......................................... 33
Pretensioner warning light ....... 380
Seat belt reminder warning light .................................. 381
Seat belts .............................................. 32
Cleaning and protecting ............ 290
Emergency seat belt fixing mechanism .................................. 33
Fastening and releasing the seat belt ................................................. 32 Seat belt reminder
warning light.............................. 381
Securing the child restraint system in place............................ 60
Usage by children.......................... 35
Usage by pregnant women ........ 35
Wearing the seat belt
correctly ........................................ 32
Seats Adjustment .... ......................148, 149
Child restraint system................... 49
Cleaning and protecting ............ 290
Correct driving posture................ 30
Front seats .................................... 148
Head restraints ............................ 152
Rear seats...................................... 149
Securing the child restraint
system in place............................ 60
Warnings on the seat adjustment .... ....................148, 150
Warnings on the seats ......148, 150
Security indicator ............................... 72
Shift lever
Continuously variable
transmission .............................. 189
Manual transmission .................. 194
Reverse warning buzzer ............ 193
Shift lever cannot be shifted ..... 191
Shift lock system ............................... 191
Shift position ............................189, 194
Side airbag ........................................... 37
Side mirrors (outside rear view mirrors) ......... 157
Operation ...................................... 157
RAIZE_OM_General_BZ358E.book 447 ページ ２０２２年５月１７日　火曜日　午後１時５９分

450Alphabetical index
RAIZE_OM_General_BZ358E
W
Warning buzzerAutomatic light-off .. ........... 200, 391
Brakes ...... ............................. 379, 387
BSM (Blind Spot Monitor) .......... 211
Driver’s seat belt reminder...... ...................... 381, 390
Driving with the parking brake not released .......... 382, 391
Electric power st eering ..... 380, 388
Front corner sens ors ......... 222, 391
Front passenger’s seat belt
reminder...... ...................... 381, 390
Key removal reminder ................ 182
Key-free system ..... ............. 123, 393
RCTA (Rear Cross Traffic Alert) ......... 218
Rear seat belt reminder .... 381, 391
Reverse .......................................... 193
Reverse sensor s.................. 222, 391
when a door is not fully
closed .......................... ....... 381, 390
Warning lights ................................... 379
Anti-lock Brake System (ABS) .... 380
Brake Override System .............. 381
Brakes ............................................ 379
BSM OFF indicator....................... 380
Charging system.......................... 379
Continuously variable
transmission .............................. 379
Driver’s seat belt reminder........ 381
Electric power steering .............. 380
Engine ............................................ 379
Engine oil deterioration warning light.............................. 382
Front corner sensor/ Reverse sensor indicator ........ 380 Front passenger’s seat belt
reminder ..................................... 381
High coolant temperature......... 379
Low engine oil pressure warning light.............................. 379
Low fuel level ................................ 381
Malfunction indica tor lamp ....... 379
Master warning light................... 380
Parking brake not released ....... 382
Pretensioner ................................. 380
RCTA OFF indicator ..................... 381
Rear seat belt reminder ............. 381
Slip indicator ................................. 380
SRS airbags ................................... 380
Tire pressure ................................ 382
When a door is not fully closed .......................................... 381
Warning messages .......................... 387
Washer .................... ...................203, 205
Checking ........................................ 324
Preparation and inspection
before winter ............................. 238
Refilling the fluid .......................... 324
Switch .......... ..........................203, 205
Washing .............................................. 284
Watts .................................................... 428
Waxing ................................................ 284
Wheel nut wrench ............................ 397
Wheels ................................................. 336
Maintenance data ....................... 428
Replacement................................. 396
When children are in the vehicle .................................... 48
Child restraint system................... 49
Installing the ch ild restraint
system ........................................... 60
Seat belt use by children ............. 34
RAIZE_OM_General_BZ358E.book 450 ページ ２０２２年５月１７日　火曜日　午後１時５９分

451Alphabetical index
RAIZE_OM_General_BZ358E
Warning on the back door ........ 145
Warnings on the airbags ............. 39
Warnings on the battery ............ 410
Warnings on the power windows...................................... 162
Warnings on the seat belts ......... 35
Warnings when children are in the vehicle................................ 35
Window lock switch (Power window OFF switch) ... 160
Window lock switch
(Power window OFF switch) ....... 160
Windows ............................................. 160
Power windows ............................ 160
Rear window defogger...... 249, 256
Washer.......... ........................ 203, 205
Windshield wipers and
washer ............................ ......... 203, 205
Winter driving tips ........................... 238
Wireless remote control ................. 131
Battery replacement ................... 344
Operation ...................................... 133
Signaling of the operation......... 131
RAIZE_OM_General_BZ358E.book 451 ページ ２０２２年５月１７日　火曜日　午後１時５９分