check engine TOYOTA VERSO 2016 Service Manual

584
5-2. Steps to take in an emergency
VERSO_EE_OM64590E
Check the specified inflation pressure.
The label is placed as shown in the illustration.
Left-hand drive vehicles
Right-hand drive vehicles
Start the vehicle’s engine.
To inject the sealant and inflate
the tire, turn the compressor
switch on.

596
5-2. Steps to take in an emergency
VERSO_EE_OM64590E
Emergency start function (vehicles with smart entry & start system)
When the engine does not start, the following steps can be used as
an interim measure to start the engine if the “ENGINE START STOP”
switch is functioning normally.
Vehicles with a Multidrive
Set the parking brake.
Put the shift lever in “P”.
Set the “ENGINE START STOP” switch to ACCESSORY
mode.
Press and hold the “ENGINE START STOP” switch about 15
seconds while depressing the brake pedal firmly.
Vehicles with a manual transmission
Set the parking brake.
Put the shift lever in “N”.
Set the “ENGINE START STOP” switch to ACCESSORY
mode.
Press and hold the “ENGINE START STOP” switch about 15
seconds while depressing the brake pedal and clutch pedal
firmly.
Even if the engine can be started using the above steps, the system
may be malfunctioning. Have the vehicle checked by any authorized
Toyota dealer or repairer, or another duty qualified and equipped pro-
fessional.

604
5-2. Steps to take in an emergency
VERSO_EE_OM64590E
■ Starting the engine when the battery is discharged (vehicles with a
Multidrive)
The engine cannot be started by push-starting.
■ To prevent battery discharge
● Turn off the headlights and the audio system while the engine is stopped.
● Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic, etc.
Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Vehicles with smart entry & start system: Open and close
any of the doors with the “ENGINE START STOP” switch
off.
Vehicles without smart entry & start system: Maintain the
engine speed of the second vehicle and turn the engine
switch to the “ON” position, then start the vehicle’s engine.
Vehicles with smart entry & start system: Maintain the
engine speed of the second vehicle and turn the “ENGINE
START STOP” switch to IGNITION ON mode, then start the
vehicle’s engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
Once the engine starts, have the vehicle checked at any autho-
rized Toyota dealer or repairer, or another duly qualified and
equipped professional, as soon as possible.

608
5-2. Steps to take in an emergency
VERSO_EE_OM64590E
Diesel engine
Radiator
Cooling fans
If a large amount of coolant leaks,
immediately contact any autho-
rized Toyota dealer or repairer, or
another duly qualified and
equipped professional.
The coolant level is satisfactory if
it is between the “FULL” and
“LOW” lines on the reservoir.
Reservoir
“FULL”
“LOW”
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
Start the engine and turn the air conditioning system on to
check that the radiator cooling fan operates and to check for
coolant leaks from the radiator or hoses.
The fan operates when the air conditioning system is turned on
immediately after a cold start. Confirm that the fan is operating by
checking the fan sound and air flow. If it is difficult to check these,
turn the air conditioning system on and off repeatedly.
(The fan may not operate in freezing temperatures.)

622
6-1. Specifications
VERSO_EE_OM64590E
Diesel engine
Lubrication system
Gasoline engine
*: The engine oil capacity is a reference quantity to be used when changing the
engine oil. Warm up and turn off the engine, wait more than 5 minutes, and
check the oil level on the dipstick.
Fuel type
EU area:
You must only use diesel fuel conforming to Euro-
pean standard EN590.
Except EU area (except Russia):
You must only use diesel fuel that contains 10
ppm or less of sulfur and has a cetane number of
48 or higher.
Except EU area (Russia):
You must only use diesel fuel with a cetane num-
ber of 48 or higher.
Your vehicle must use only diesel fuel confirming
to GOST R52368-2005 (Sulfur max 50ppm).
Cetane number 48 or higher
Fuel tank capacity
(Reference) 55 L (14.5 gal., 12.1 lmp.gal.)
Oil capacity
(Drain and refill - reference*)
With filter
Without filter
4.2 L (4.4 qt., 3.7 Imp.qt.)
3.9 L (4.1 qt., 3.4 Imp.qt.)

627
6-1. Specifications
6
Vehicle specifications
VERSO_EE_OM64590E
Diesel engine
*: The engine oil capacity is a reference quantity to be used when changing the
engine oil. Warm up and turn off the engine, wait more than 5 minutes, and
check the oil level on the dipstick.
Toyota recommends the use of approved “Toyota Genuine Motor Oil
5W-30 Premium Fuel Economy for 1WW/2WW engines”. Contact
any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional, for usage of any other approved engine
oil of matching quality.
Oil capacity
(Drain and refill - reference*)
With filter 5.2 L (5.5 qt., 4.6 Imp.qt.)
NOTICE
■ To prevent damage to the engine
● Use of engine oils other than “Toyota Genuine Motor Oil 5W-30 Premium
Fuel Economy for 1WW/2WW engines” or any other approved engine oil,
may cause damage to the engine.
● If the approved oils are not available, up to 1 liter of the following oils may
be used: ACEA C3 oils.
Confirm that the viscosity grade is SAE 0W-40, 0W-30, 5W-40 or 5W-30.
Viscosities other than these, may damage the engine.

629
6-1. Specifications
6
Vehicle specifications
VERSO_EE_OM64590E
Ignition system (gasoline engine only)
Electrical system
Batteries with vent plugs
Batteries without vent plugs
Spark plug
Make DENSO SC20HR11 or SC16HR11
Gap 1.1 mm (0.043 in.)
NOTICE
■ Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
Battery
Specific gravity reading at
20C (68 F):
1.250 1.290 Fully charged
1.160 1.200 Half charged
1.060 1.100 Discharged
Charging rates
Quick charge
Slow charge
15 A max.
5 A max.
Battery
Open voltage at 20C (68 F): 12.6 12.8 V Fully charged
12.2 12.4 V Half charged
11 . 8 12.0 V Discharged
(Voltage is checked 20 minutes after
the engine and all the lights are
turned off.)
Charging rates 5 A max.

637
6-1. Specifications
6
Vehicle specifications
VERSO_EE_OM64590E
Fuel infor mation
■Use of ethanol blended gasoline in a gasoline engine
Toyota allows the use of ethanol blended gasoline where the ethanol content
is up to 10%. Make sure that the ethanol blended gasoline to be used has a
Research Octane Number that follows the above.
■ If you plan to drive in foreign countries (diesel engine)
Low sulphur diesel fuel may not be avai lable, so please check the availability
with your distributor.
Gasoline engine
EU area:
You must only use unleaded gasoline
conforming to European standard
EN228.
Select unleaded gasoline with a
Research Octane Number of 95 or
higher for optimum engine perfor-
mance.
Except EU area:
You must only use unleaded gasoline.
Select unleaded gasoline with a
Research Octane Number of 95 or
higher for optimum engine perfor-
mance.
Diesel engine
EU area:
You must only use diesel fuel conform-
ing to European standard EN590.
Except EU area (except Russia):
You must only use diesel fuel that con-
tains 10 ppm or less of sulfur and has a
cetane number of 48 or higher.
Except EU area (Russia):
You must only use diesel fuel with a
cetane number of 48 or higher.
Your vehicle must use only diesel fuel
confirming to GOST R52368-2005
(Sulfur max 50ppm).

650
Alphabetical index
VERSO_EE_OM64590E
Electronic key
If your electronic does not
operate properly ................. 600
Electronic power steering ....... 311
Emergency flashers
Switch ................................... 526
Emergency tire puncture
repair kit ................................. 577
Emergency, in case of
If the electronic key does not
operate properly ................. 600
If the engine will not start ...... 594
If the shift lever cannot be
shifted from “P” ................... 597
If the vehicle has discharged
battery................................. 603
If the warning buzzer
sounds ................................ 536
If the warning light
turns on............................... 536
If the warning message is
displayed ............................ 545
If you cannot operate back
door opener ........................ 599
If you have a flat tire ..... 560, 577
If you lose your keys ............. 598
If you think something is
wrong .................................. 534
If your vehicle becomes
stuck ................................... 611
If your vehicle has to be
stopped in an emergency ... 613
If your vehicle needs to be
towed .................................. 527
If your vehicle overheats ....... 607
Engine
Accessory mode ................... 204
Compartment ........................ 444
Engine switch................ 198, 202
Hood ..................................... 440
How to start the
engine......................... 198, 202
Identification number ............ 618
If the engine will not start ...... 594
Ignition switch ............... 198, 202
Overheating .......................... 607
Engine compartment cover .... 446
Engine coolant
Capacity ................................ 628
Checking ............................... 452
Preparing and checking
before winter....................... 320
Engine coolant temperature
indicator (Blue) ...................... 229
Engine coolant temperature
warning light (Red)................ 536
Engine immobilizer system .... 124
Engine oil
Capacity ................................ 622
Checking ............................... 447
Preparing and checking
before winter....................... 320
Engine oil maintenance
data ......................................... 450
Engine switch .................. 198, 202
EPS ........................................... 311
E

657
Alphabetical index
VERSO_EE_OM64590E
Tachometer .............................. 222
Tail lights
Replacing light bulbs ............. 500
Switch ................................... 248
Wattage................................. 636
Theft deterrent system
Alarm..................................... 137
Double locking system .......... 135
Engine immobilizer system ... 124
Intrusion sensor .................... 139
Tire inflation pressure ............. 473
Tire pressure warning
system .................................... 462
Function ................................ 462
Initializing .............................. 463
Installing tire pressure
warning valves and
transmitters......................... 462
Registering ID codes............. 465
Tire pressure warning
reset switch......................... 463
Warning light ......................... 539
Tires
Chains................................... 322
Checking ............................... 461
Emergency tire puncture
repair kit.............................. 577
If you have a flat
tire .............................. 560, 577
Inflation pressure .................. 473
Replacing .............................. 560
Rotating tires......................... 461
Size ....................................... 633
Snow tires ............................. 320
Spare tire .............................. 560
Tire pressure warning
system ................................ 462
Tools ................................. 560, 577
Towing
Emergency towing ................ 529
Trailer towing ........................ 324
Toyota parking
assist-sensor ......................... 296
Traction control ....................... 311
Trailer towing ........................... 324
Transmission shift switches .. 208
TRC ........................................... 311
Trip information display.......... 233
Trip meter ................................. 222
Turn signal lights
Replacing light bulbs............. 500
Switch ................................... 218
Wattage ................................ 636
T