battery TOYOTA VERSO 2016 Repair Manual

606
5-2. Steps to take in an emergency
VERSO_EE_OM64590E
WARNING
■ Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery.
● When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
● Do not lean over the battery.
● In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
● Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
● Do not allow children near the battery.
NOTICE
■To prevent damaging the vehicle (vehicles with a manual transmission)
Do not pull- or push-start the vehicle, because the catalytic converter may
overheat and become a fire hazard.
■ When handling jumper cables
Be careful that the jumper cables do not become tangled in the cooling fan
or any of the belts when connecting or disconnecting them.

629
6-1. Specifications
6
Vehicle specifications
VERSO_EE_OM64590E
Ignition system (gasoline engine only)
Electrical system
Batteries with vent plugs
Batteries without vent plugs
Spark plug
Make DENSO SC20HR11 or SC16HR11
Gap 1.1 mm (0.043 in.)
NOTICE
■ Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
Battery
Specific gravity reading at
20C (68 F):
1.250 1.290 Fully charged
1.160 1.200 Half charged
1.060 1.100 Discharged
Charging rates
Quick charge
Slow charge
15 A max.
5 A max.
Battery
Open voltage at 20C (68 F): 12.6 12.8 V Fully charged
12.2 12.4 V Half charged
11 . 8 12.0 V Discharged
(Voltage is checked 20 minutes after
the engine and all the lights are
turned off.)
Charging rates 5 A max.

644
VERSO_EE_OM64590E
6-3. Initialization
Items to initialize
*: Diesel engine only
ItemWhen to initializeReference
Engine oil mainte-
nance data*After changing engine oil P. 450
Tire pressure
warning system
(if equipped)
• When rotating the tires on
vehicles with differing front
and rear tire inflation pres-
sures
• When changing tire pressure
(such as when changing trav-
eling speed)
• When changing the tire size
P. 463
The following item must be initia lized for normal system operation in
cases such as after the battery is reconnected, or maintenance is
performed on the vehicle.

648
Alphabetical index
VERSO_EE_OM64590E
Automatic air conditioning
system
Air conditioning filter.............. 478
Automatic air conditioning
system ................................ 340
Automatic headlight
leveling system...................... 252
Automatic High Beam ............. 283
Automatic light control
system .................................... 248
AUX port ................................... 384
Auxiliary boxes ................ 400, 416
Back-up light
Replacing light bulb............... 500
Wattage................................. 636
Back door
Back door ................................ 79
Battery
Checking ............................... 455
If the vehicle has discharged
battery................................. 603
Preparing and checking
before winter....................... 320
Bottle holders........................... 399
Brake
Parking brake ........................ 219
Brake assist.............................. 311
Break-in tips ............................. 187
Brightness control
Instrument cluster light
control................................. 224
Care
Exterior ................................. 426
Interior................................... 430
Seat belts .............................. 431
Cargo capacity ......................... 317
Cargo hooks............................. 415
CD player .................................. 357
Chains....................................... 320
Child-protectors......................... 75
Child restraint system
Baby seats, definition............ 159
Baby seats, installation ......... 167
Child seats, definition............ 159
Child seats, installation ......... 167
Installing CRS with ISOFIX
rigid anchor......................... 173
Installing CRS with seat
belts.................................... 168
Installing CRS with top
straps.................................. 174
Junior seats, definition .......... 159
Junior seats, installation ....... 167
B
C

649
Alphabetical index
VERSO_EE_OM64590E
Child safety
Airbag precautions ................ 154
Battery precautions ....... 457, 606
Child-protectors....................... 75
Child restraint system ........... 159
How your child should wear
the seat belt ........................ 100
Installing child restraints........ 167
Panoramic roof shade
precautions ......................... 117
Power window lock switch .... 112
Power window precautions ... 115
Removed key battery
precautions ......................... 484
Seat belt precautions ............ 101
Seat heater
precautions ......................... 407
Cleaning
Exterior.................................. 426
Interior ................................... 430
Seat belts .............................. 431
Clock ........................................ 238
Condenser ................................ 454
Console box ............................. 395
Cooling system
Engine overheating ............... 607
Cruise control .......................... 289
Cup holders .............................. 397
Curtain shield airbags ............. 148
Customizable features ............ 640
Daytime running light
system .................................... 251
Deck board ............................... 415
Defogger
Rear window ......................... 349
Side mirrors .......................... 349
Dimension ................................ 616
Display
Multi-information display ....... 232
Trip information ..................... 233
Warning message ................. 545
Do-it-yourself maintenance .... 436
Door courtesy lights
Door courtesy lights .............. 388
Wattage ................................ 636
Doors
Back door................................ 79
Door glasses ......................... 112
Door lock..................... 42, 64, 73
Double locking system .......... 135
Rear door child protector ........ 75
Side doors............................... 73
Side mirrors .......................... 109
Double locking system ........... 135
Driver’s and front passenger’s
seat belt reminder
light......................................... 539
Driving
Break-in tips .......................... 187
Correct posture ..................... 146
Procedures ........................... 184
Winter driving tips ................. 320
D

650
Alphabetical index
VERSO_EE_OM64590E
Electronic key
If your electronic does not
operate properly ................. 600
Electronic power steering ....... 311
Emergency flashers
Switch ................................... 526
Emergency tire puncture
repair kit ................................. 577
Emergency, in case of
If the electronic key does not
operate properly ................. 600
If the engine will not start ...... 594
If the shift lever cannot be
shifted from “P” ................... 597
If the vehicle has discharged
battery................................. 603
If the warning buzzer
sounds ................................ 536
If the warning light
turns on............................... 536
If the warning message is
displayed ............................ 545
If you cannot operate back
door opener ........................ 599
If you have a flat tire ..... 560, 577
If you lose your keys ............. 598
If you think something is
wrong .................................. 534
If your vehicle becomes
stuck ................................... 611
If your vehicle has to be
stopped in an emergency ... 613
If your vehicle needs to be
towed .................................. 527
If your vehicle overheats ....... 607
Engine
Accessory mode ................... 204
Compartment ........................ 444
Engine switch................ 198, 202
Hood ..................................... 440
How to start the
engine......................... 198, 202
Identification number ............ 618
If the engine will not start ...... 594
Ignition switch ............... 198, 202
Overheating .......................... 607
Engine compartment cover .... 446
Engine coolant
Capacity ................................ 628
Checking ............................... 452
Preparing and checking
before winter....................... 320
Engine coolant temperature
indicator (Blue) ...................... 229
Engine coolant temperature
warning light (Red)................ 536
Engine immobilizer system .... 124
Engine oil
Capacity ................................ 622
Checking ............................... 447
Preparing and checking
before winter....................... 320
Engine oil maintenance
data ......................................... 450
Engine switch .................. 198, 202
EPS ........................................... 311
E

654
Alphabetical index
VERSO_EE_OM64590E
Odometer .................................. 222
Oil
Engine oil .............................. 447
Opener
Fuel filler door ....................... 119
Hood ..................................... 440
Outside rear view mirrors
Adjusting and folding............. 109
Outside temperature
display .................................... 233
Overhead console.................... 397
Overheating, Engine ................ 607
Panoramic roof shade ............. 116
Parking brake ........................... 219
PCS (Pre-Collision System) .... 267
Function ................................ 267
PCS switch............................ 268
Warning light ......................... 539
Personal/interior lights
Switch ........................... 389, 390
Wattage................................. 636
Power heater ............................ 347
Power outlets ........................... 404
Power windows ........................ 112
Pre-Collision System (PCS) .... 267
Function ................................ 267
PCS switch............................ 268
Warning light ......................... 539
Radiator .................................... 454
Radio......................................... 353
Rear fog light
Replacing light bulb .............. 500
Switch ................................... 254
Wattage ................................ 636
Rear seats
Adjustment .............................. 86
Folding the seats .................... 89
Rear side sunshades............... 411
Rear turn signal lights
Replacing light bulbs............. 500
Switch ................................... 218
Wattage ................................ 636
Rear window defogger ............ 349
Rear window wiper and
washer .................................... 260
Replacing
Fuses .................................... 485
Key battery............................ 481
Light bulbs ............................ 500
Tires ...................................... 560
Roof luggage carrier ............... 317
O
P
R

659
Alphabetical index
VERSO_EE_OM64590E
Warning messages
Back door .............................. 549
Clutch start system ............... 546
Cruise control ........................ 546
DPF catalytic converter ......... 549
Engine oil level ...................... 549
Engine oil maintenance......... 549
Engine oil pressure ............... 545
Light reminder ....................... 549
Open door ............................. 549
Parking brake ........................ 549
Smart entry & start system.... 554
Speed limiter system............. 546
Steering lock system ............. 546
Transmission fluid
temperature ........................ 549
Washer
Checking ............................... 459
Preparing and checking
before winter....................... 320
Switch ........................... 255, 260
Washing and waxing ............... 426
Weight ....................................... 616
Wheels ...................................... 475
Window glasses ....................... 112
Window lock switch................. 112
Windows
Power windows ..................... 112
Rear window defogger .......... 349
Washer.......................... 255, 260
Windshield wipers ................... 255
Wireless remote control key
Replacing the battery ............ 481
Wireless remote control .......... 64
WMA disc.................................. 362

660
VERSO_EE_OM64590E
What to do if...
What to do if...
A tire puncturesP. 560, 577If you have a flat tire
The engine does not start
P. 594If the engine will not start
P. 124Engine immobilizer system
P. 603If the vehicle battery is discharged
The shift lever cannot be
moved outP. 597If the shift lever cannot be shifted
from “P”
The high engine coolant temperature warning light (Red) flashes or comes on
Steam can be seen coming
from under the hood
P. 607If your vehicle overheats
The key is lostP. 598If you lose your keys
The battery runs outP. 603If the vehicle battery is discharged
The doors cannot be lockedP. 7 3Side doors
P. 7 9Back door
The horn begins to soundP. 137Alarm
The vehicle is stuck in
mud or sandP. 6 1 1If the vehicle becomes stuck