oil filter TOYOTA xB 2009 Owners Manual (in English)

234
CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the engine switch is
off if you work near the electric
cooling fans or radiator grille. With
the engine switch on, the electric
cooling fans will automatically start
to run if the engine coolant temper-
ature is high and/or the air condi-
tioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Take care when filling the brake and
clutch reservoirs because brake or
clutch fluid can harm your hands or
eyes. If fluid gets on your hands or
in your eyes, flush the affected area
with clean water immediately. If you
still feel uncomfortable with your
hands or eyes, go to the doctor.

235
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based nonsilicate,
nonamine, nonnitrite, and nonbo-
rate coolant with longlife hybrid
organic acid technology to fill the
radiator. “Toyota Super Long Life
Coolant” is a mixture of 50% cool-
ant and 50% deionized water.
 If you spill some of the coolant, be
sure to wash it off with water to
prevent it from damaging the parts
or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the hood, check to
see that you have not forgotten any
tools, rags, etc.
Parts and tools
Here is a list of parts and tools you will
need to perform do −it−yourself mainte-
nance. Remember all Scion parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Genuine Motor Oil” or equivalent. See
page 241 for details about engine oil
selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non −silicate, non −amine, non− ni-
trite, and non −borate coolant with long −
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water.
Tools:
Funnel (only for adding coolant)

263
Service specifications
ENGINE
Valve clearance (engine cold), mm (in.):Intake 0.19 – 0.29 (0.007 – 0.012)
Exhaust 0.38 – 0.48 (0.015 – 0.019)
Spark plug type: DENSO SK20R11
NGK IFR6A11
Spark plug gap, mm(in.): 1.1 (0.043)
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt.,
Imp.qt.): With filter 4.3 (4.5, 3.8)
Without filter 4.1 (4.3, 3.6)
“Genuine Motor Oil” is used in your Scion
vehicle. Use Scion approved “Genuine Mo-
tor Oil” or equivalent to satisfy the follow-
ing grade and viscosity. Oil grade:
ILSAC multigrade engine oil
Please contact your Scion dealer for fur-
ther details.
Recommended oil viscosity: SAE 5W −20 or 0W −20
Outside temperature
COOLING SYSTEM
Total capacity, L (qt., Imp.qt.):
Manual transmission 6.0 (6.3, 5.3)
Automatic transmission 5.9 (6.2, 5.2)
Coolant type:
“Toyota Super Long Life Coolant” is
used in your Scion vehicle at factory fill.
In order to avoid technical problems,
only use “Toyota Super Long Life Cool-
ant” or similar high quality ethylene gly-
col based non −silicate, non− amine, non−
nitrite, and non −borate coolant with
long− life hybrid organic acid technology.
(Coolant with long −life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
Please contact your Scion dealer for fur-
ther details.
BATTERY
Open voltage* at 20 C (68 F):
12.6 – 12.8 V Fully charged
12.2 – 12.4 V Half charged
11.8 – 12.0 V Discharged
*: Voltage that is checked 20 minutes after the key is removed with all the
lights turned off
Charging rates: 5 A max.

272
A
Adding washer fluid255
. . . . . . . . . . . . . . . .
Adjustment
Front seats 26
. . . . . . . . . . . . . . . . . . . . . . .
Seat belt 31
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning filters 136
. . . . . . . . . . . . . . .
Air conditioning system 130
. . . . . . . . . . . . .
Airbags 40
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −glare inside rear view mirror 82 . . . . .
Anti −lock brake system
warning light 97
. . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 108 . . . . . .
Appearance care Cleaning the interior 223
. . . . . . . . . . . . . .
Protecting your Scion from
corrosion 220
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 221
. . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 109
. . . . . . . . . . . . . . . . . . .
Shift lock override button 215
. . . . . . . . . .
Shift pattern 109
. . . . . . . . . . . . . . . . . . . . .
Shift speed 109
. . . . . . . . . . . . . . . . . . . . . .
AUX adapter 145
. . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 21
. . . . . . . . .
B
Back door 20
. . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 20
. . . . . . . . . . . . . . . . . . . . . .
Battery Checking battery condition 252 . . . . . . . .
Gas caution 252
. . . . . . . . . . . . . . . . . . . . .
Handling safety 252
. . . . . . . . . . . . . . . . . .
Recharging precautions 253
. . . . . . . . . . .
Winter driving tips 189
. . . . . . . . . . . . . . . .
Before starting the engine 186
. . . . . . . . . . .
Bottle holders 148
. . . . . . . . . . . . . . . . . . . . . .
Brake pad wear limit indicators 162 . . . . . .
Brake system 159
. . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 97
. . . . . . . . . .
Brakes
Fluid level 243
. . . . . . . . . . . . . . . . . . . . . . .
Pad wear indicators 162
. . . . . . . . . . . . . .
Parking 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 152
. . . . . . . . . . . . . . . . . . . . . .
Brightness control 88
. . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 155
. . . . . . . . . . .
Cargo and luggage Capacity 179
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 180
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 180
. . . . . . . . . . . . .
Certification label 162
. . . . . . . . . . . . . . . . . . Charging system warning light 97
. . . . . . . .
Checking and replacing fuses 254 . . . . . . . .
Checking and replacing tires 246 . . . . . . . .
Checking brake fluid 243
. . . . . . . . . . . . . . . .
Checking the engine oil level 240 . . . . . . . .
Checking the radiator and condenser 242
. . . . . . . . . . . . . . . . . . . . . . .
Child restraint Child restraint system 61
. . . . . . . . . . . . .
Installation 63
. . . . . . . . . . . . . . . . . . . . . . .
Precautions 60
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 62 . . . . . .
Cleaning the interior 223
. . . . . . . . . . . . . . . .
Clock 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather Operation 189
. . . . . . . . . . . . .
Controls, Instrument panel 2
. . . . . . . . . . . .
Cooling system Coolant level 242
. . . . . . . . . . . . . . . . . . . .
Engine overheating 199
. . . . . . . . . . . . . . .
Radiator and reservoir 242
. . . . . . . . . . . .
Radiator cap 242
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 189
. . . . . . . . . . . . . . . .
Corrosion prevention 220
. . . . . . . . . . . . . . .
Cruise control 125
. . . . . . . . . . . . . . . . . . . . .
Cup holders 147
. . . . . . . . . . . . . . . . . . . . . . .

Where to obtain the Repair Manual
The repair manual for xB may be purchased
from any Scion dealer or the Material Distribu-
tion Center. To purchase the repair manual,
please contact your Scion dealer or call the Ma-
terial Distribution Center tollfree at
18006222033.
Maintenance procedures for the engine,
chassis, body, electric al system, and more,
are clearly explained and illustrated.
Periodic maintenance and tuneup
Periodic maintenance and tuneup helps to pre-
vent small problems from growing into larger ones lat-
er on. The repair manual outlines exactly what main-
tenance is required and clearly explains how to do the
work yourself stepbystep.
Areas covered include such things as spark plug re-
placement, valve clearance adjustment and engine oil
and filter replacement.