brake sensor VOLKSWAGEN JETTA 1998 Owner's Guide

Downloaded from www.Manualslib.com manuals search engine 01-191


V.A.G 1551 print-
out Possible cause
Repair
00283
Left front ABS
wheel speed
sensor -G47-
1)
Electrical
malfunction in
current circuit
Open circuit in wiring between
left front ABS wheel speed
sensor -G47- and ABS control
module (w/EDL) -J104-
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
- Read measured value block
Page 01
-240 Display group number
001
If the malfunction occurs again:

Left front ABS wheel speed
sensor -G47- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace left front ABS wheel
speed sensor -G47-
1) This DTC is recognized when vehicle is stationary.
Стр. 33из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-193


V.A.G 1551 print-
out Possible cause
Repair
00283
Left front ABS
wheel speed
sensor -G47-
Mechanical fault
1)
Excessive air gap between
left front ABS wheel speed
sensor-G47- and rotor (signal
not OK) Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on front
and rear axles - Check installation of left front ABS
wheel speed sensor -G47- and rotor
- Read measured value block
Page 01
-240 Display group numbers
001 and 002
- Perform test drive

Short to positive or ground in
wiring - Check wiring and connections using
wiring diagram
- Perform electrical check Page
01-288
Left front ABS wheel speed
sensor -G47- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace left front ABS wheel speed
sensor -G47-
1) Type of DTC, this DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 35из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-194


V.A.G 1551 print-
out Possible cause
Repair
00285
Right front ABS
wheel speed
sensor -G45-
1)
Electrical
malfunction in
current circuit
Open circuit in wiring between
Right front ABS wheel speed
sensor -G45- and ABS control
module (w/EDL) -J104-
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
- Read measured value block
Page 01
-240 Display group number
001
If the malfunction occurs again:

Right front ABS wheel speed
sensor -G45- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace Right front ABS wheel
speed sensor -G45-
1) This malfunction is recognized when vehicle is stationary.
Стр. 36из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-196


V.A.G 1551 print-
out Possible cause
Repair
00285
Right front ABS
wheel speed sensor
-G45-
Mechanical
malfunction
1)
Excessive air gap between
Right front ABS wheel speed
sensor-G45- and rotor
(signal not OK)
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of right front
ABS wheel speed sensor -G45- and
rotor
- Read measured value block
Page 01
-240 Display group
numbers 001 and 002
- Perform test drive


Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288

Right front ABS wheel speed
sensor -G45- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace Right front ABS wheel
speed sensor -G45-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 38из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-197


V.A.G 1551 print-
out Possible cause
Repair
00287
Right rear ABS
wheel speed
sensor -G44-
1)
Electrical
malfunction in
current circuit
Open circuit in wiring between
Right rear ABS wheel speed
sensor -G44- and ABS control
module (w/EDL) -J104-
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
- Read measured value block
Page 01
-240 Display group number
001
Right rear ABS wheel speed
sensor -G44- faulty - Replace right rear ABS wheel
speed sensor -G44-
Repair Manual, Brake System,
Repair Group 45
1) This malfunction is recognized when vehicle is stationary.
Стр. 39из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-199


V.A.G 1551 print-
out Possible cause
Repair
00287
Right rear ABS
wheel speed
sensor -G44-
1)
Mechanical
malfunction
Excessive air gap between
Right rear ABS wheel speed
sensor -G44- and rotor
(signal not OK) Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of speed sensor
-G44- and rotor
- Read measured value block
Page 01
-240 Display group numbers
001 and 002
- Perform test drive

Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
Right rear ABS wheel speed
sensor -G44- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace speed sensor -G44-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 41из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-200


V.A.G 1551
print-out Possible cause
Repair
00290
Left rear ABS
wheel speed
sensor -G46-
1)
Open circuit; short to positive or ground,
or loose contact in connections between
Left rear ABS wheel speed sensor -
G46- and ABS control module (w/EDL) -
J104-
Repair Manual, Brake
System, Repair Group 45;
Removing and installing parts of
ABS system on front and rear
axles - Check wiring and connections
using wiring diagram
- Perform electrical check
Page 01
-288
- Read measured value block
Page 01
-240 Display group
number 001
If the malfunction occurs again:


Left rear ABS wheel speed sensor -
G46- faulty
Repair Manual, Brake
System, Repair Group 45 - Replace Left rear ABS wheel
speed sensor -G46-
1) This DTC is recognized when vehicle is stationary.
Стр. 42из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-202


V.A.G 1551 print-
out Possible cause
Repair
00290
Left rear ABS
wheel speed
sensor -G46-
1)
Mechanical
malfunction
Excessive air gap between
Left rear ABS wheel speed
sensor -G46- and rotor
(signal not OK) Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles - Check installation of speed sensor -
G46- and rotor
- Read measured value block
Page 01
-240 Display group numbers
001 and 002
- Perform test drive

Short to positive or ground in
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288
Left rear ABS wheel speed
sensor -G46- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace Left rear ABS wheel speed
sensor -G46-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 44из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-203


V.A.G 1551 print-out
Possible cause
Repair
00493
ESP-Sensor Unit, vehicles
from 02.02
No Signal/Communication
or
ESP-Sensor Unit faulty
Open circuit, short to
positive or ground in
CANbus wiring

ESP-Sensor Unit -
G419- faulty
Brake systems; Repair group 45;
Removing and installing parts of
ESP system - Check wiring and connectors of
data bus wiring using current flow
diagram
- Perform electrical check Page
01-288
- Replace ESP-Sensor Unit -G419-
- Perform a zero compensation:
- Initiate basic setting Page 01
-
264 Display group number 063
- Initiate basic setting Page 01-
264 Display group number 0691)
1) 4MOTION vehicles only
Стр. 45из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-206


V.A.G 1551 print-out
Possible cause
Repair
00538
Reference voltage
Electrical malfunction in
current circuit
Short to positive or ground in
voltage supply wiring:

Voltage supply less than 5
Volt

Sender for rotation rate -
G202-

Sensor for transverse
acceleration -G200-

Sender 1 for brake booster -
G201-

Longitudinal acceleration
sensor -G251
-1) - Check wiring and connections
using wiring diagram

- Perform electrical check
Page 01
-288
1) 4MOTION vehicles only
Стр. 48из 129 On Board Diagnostic (OBD), performing