steering wheel VOLVO V60 2014 Repair Manual

||
08 Starting and driving
08
312
Push in the locking wheel and turn it
anticlockwise
until you hear a click.
Turn the locking wheel down fully, until it comes to a stop. Hold it in this positionwhile pulling the towbar rearward andupward.
WARNING
Secure the towbar safely if it is stored in the car, see Detachable towbar - storage(p. 309).
G018929
Push the protective cover until it snaps tight.
Related information
• Detachable towbar - storage (p. 309)
• Detachable towbar - specifications (p. 309)
• Driving with a trailer (p. 306)
Trailer stabiliser - TSA 17
The trailer stability assist (TSA - Trailer Stability Assist) function is designed to stabi-lise the car and trailer combination if it beginsto snake. The trailer stability assist is included in the stability and traction control system (p. 175)(DSTC - Dynamic Stability and TractionControl).
FunctionThe snaking phenomenon can occur with anycar/trailer combination. Snaking normallyoccurs at high speeds. But, there is a risk of itoccurring at lower speeds (70-90 km/h) if thetrailer is overloaded or the load is improperlydistributed, e.g. too far back. In order for snaking to occur, there must be a triggering factor, e.g.:
• Car with trailer subjected to a sudden and powerful side wind.
• Car with trailer drives on an uneven roadsurface or in a pothole.
• Sweeping steering wheel movements.
OperationIf snaking has started, it could be difficult or even impossible to suppress. This makes thecar/trailer combination difficult to control andthere is a risk that you could, for example,
17
Included in the installation of Volvo genuine towbar.
ProCarManuals.co’

08 Starting and driving
08
313
end up in the wrong lane or leave the car- riageway. The trailer stability assist continually monitors the car's movements, particularly lateralmovements. If snaking is detected, the frontwheels are individually braked. This serves tostabilise the car/trailer combination. This isoften enough to help the driver regain controlof the car. If snaking is not eliminated the first time the trailer stability assist comes into action, thecar/trailer combination is braked with allwheels and engine power is reduced. Oncesnaking has been gradually suppressed andthe car/trailer combination is stable onceagain, the system stops regulating and thedriver once again has full control of the car.For more information, see Stability and trac-tion control system (DSTC) - operation (p.176)
MiscellaneousThe trailer stability assist can engage withinthe speed interval 60-160 km/h.
NOTE
TSA function is switched off if the driver selects Sport mode, see Stability and
traction control system (DSTC) (p. 175).
The trailer stability assist may fail to engage if the driver uses sudden steering wheel move-ments to try to rectify the snaking because in such a situation the system cannot determinewhether it is the trailer or the driver that iscausing the snaking.
When the trailer stability assist isworking, the combined instrument
panel's DSTC symbol flashes.
Related information
•Stability and traction control system (DSTC) - symbols and messages (p. 178)
Towing
During towing, one vehicle is towed by another vehicle using a tow rope.
IMPORTANT
Note that the car must always be towed with the wheels rolling forward. Do not tow the vehicle at speeds higher than 80 km/h or for distances in excess of80 km.
Find out the statutory maximum speed limit for towing before towing begins.
1. Unlock the steering lock by inserting the
remote control key in the ignition switch and giving a long press on the START/
STOP ENGINE button - key position II is
activated, see Key positions (p. 70) formore information about key positions.
2. The remote control key must remain in the ignition switch while the car is beingtowed.
3. Keep the towline taut when the towing vehicle reduces speed by holding yourfoot gently pressed on the brake pedal -thereby avoiding unnecessary jerking.
4. Be prepared to brake to stop.
ProCarManuals.co’

||
08 Starting and driving
08
314
WARNING
•Check that the steering lock is unlocked before towing.
• The remote control key must be in keyposition
II - in position I all airbags are
deactivated.
• Never remove the remote control keyfrom the ignition switch when the caris being towed.
WARNING
The brake servo and power steering do not work when the engine is switched off - thebrake pedal needs to be depressedabout 5 times more heavily and the steer-ing is considerably heavier than normal.
Manual gearboxPrior to towing:
–Move gear lever into neutral and release the parking brake.
Automatic gearbox GeartronicPrior to towing:
–Move the gear selector to position
N and
release the parking brake.
Automatic gearbox PowershiftThe model with Powershift transmission should not be towed as it is dependent on theengine running in order to receive sufficient lubrication. If towing still has to take place,the route must be as short as possible andthen with very low speed. In the event of uncertainty as to whether or not the car is equipped with Powershift trans-mission, this can be verified by checking thedesignation on the gearbox label under thebonnet, see Type designations (p. 386). Thedesignation ”MPS6” means that it isPowershift transmission - otherwise it isGeartronic automatic transmission.
IMPORTANT
Avoid towing.
• However, the car can be towed for a short distance at low speed to move itfrom a dangerous position - not furtherthan 10 km and not faster than10 km/h. Note that the car mustalways be towed with the wheels roll-ing forward.
• In the event of moving a longer dis-tance than 10 km, the car must betransported with the drive wheelsraised from the road - professionalrecovery is recommended.
Prior to towing:
–Move the gear selector to position
N and
release the parking brake.
Jump startingDo not tow the car to bump start the engine. Use a donor battery if the battery is dis-charged and the engine does not start, seeJump starting with battery (p. 270).
IMPORTANT
The catalytic converter may be damaged during attempts to tow-start the engine.
Related information
• Towing eye (p. 315)
ProCarManuals.co’

09 Wheels and tyres
09
328
Tyres - air pressure
Tyres can have different air pressures which are measured in bar.
Check the air pressure in the tyresThe tyre pressures must be checked everymonth.
• Tyre pressure for the car's recommended tyre dimension
• ECO pressure 2
NOTE
•
Check the tyre pressure when the tyres are cold. "Cold tyres" means thatthe tyres are at the same temperatureas the outdoor temperature. The tyreswill heat up and the tyre pressures willincrease after driving for a few kilome-tres.
• Tyre pressures which are too low willincrease fuel consumption, reduce tyreservice life and impair the car's han-dling. Driving with tyre pressureswhich are too low may lead to thetyres overheating and sustaining dam-age. Tyre pressures affect ride com-fort, road noise and steering.
• Tyre pressure decreases over time,this is a natural phenomenon. Tyrepressure also varies depending onambient temperature.
Tyre pressure label
G021830
The tyre pressure label on the driver's side door pillar (between frame and rear door)shows which pressures the tyres should haveat different loads and speed conditions. Thisis also specified in the tyre pressure table,see Tyres - approved tyre pressures (p. 407).
Fuel economy, ECO pressureIn order to obtain optimum fuel economy atspeeds below 160 km/h an ECO pressure isrecommended (applies to both full and lightload), see Tyres - approved tyre pressures (p.407).
Related information
•
Tyres - dimensions (p. 322)
• Tyres - speed ratings (p. 323)
• Tyres - load index (p. 323) •
Tyres - maintenance (p. 318)
• Tyres - tread wear indicators (p. 320)
2
ECO pressure results in improved fuel economy.
ProCarManuals.co’

09 Wheels and tyres
09
}}
335
Emergency puncture repair - operation
Emergency puncture repair, where the emer- gency puncture repair kit (TMK - TemporaryMobility Kit) is used to seal a puncture andcheck and adjust the tyre pressure (p. 407).
Emergency puncture repair
For information on the function of the parts, see Emergency puncture repair kit - overview (p.334).1. Detach the label for maximum permitted
speed (which is fitted on one side of the compressor) and affix it to the steeringwheel.
WARNING
You should not drive faster than 80 km/h after the emergency tyre repair kit hasbeen used. Volvo recommends that youvisit an authorised Volvo workshop forinspection of the sealed tyre (maximumdriving distance is 200 km). The staff therecan determine whether or not the tyre canbe repaired or if it needs to be replaced.
WARNING
The sealing fluid can irritate the skin. In the case of contact with skin, wash away thefluid with soap and water.
2. Check that the switch is in position 0 and
locate the cable and the air hose.
NOTE
Do not break the bottle's seal before use. The seal is broken automatically when thebottle is screwed in.
3. Unscrew the orange cap and unscrew the bottle's stopper. 4. Screw the bottle into its holder.
WARNING
Do not unscrew the bottle, it is equipped with a reverse catch to prevent leakage.
5. Connect the hose from the compressor to
the valve.
6. Plug the cable into the 12 V socket and start the car.
NOTE
If the compressor is connected to one of the two 12 V sockets, in the tunnel con-sole, no other current consumer must beconnected to the other one.
WARNING
Do not leave children in the car without supervision when the engine is running.
ProCarManuals.co’

10 Maintenance and service
10
374* Option/accessory, for more information, see Introduction.
Fuses - in the control module under the glovebox
Fuses in the control module under the glove- box protect airbag and collision warning sys-tem functions, amongst other things.
Positions
FunctionA
Rear window wiper15
––
Interior lighting; Driver's door control panel, power windows;Remote controlled garage dooropener*; Power seats, front*7,5
FunctionA
Combined instrument panel5
Adaptive cruise control, ACC*; collision warning system*10
Interior lighting; Rain sensor7,5
Steering wheel module7,5
Central locking system, fuel filler flap10
FunctionA
Heated steering wheel*15
Heated windscreen*15
Unlocking, tailgate10
Folding head restraint*10
Fuel pump20
ProCarManuals.co’

||
10 Maintenance and service
10
382
Stains on fabric upholstery and roof
upholstery
A special fabric cleaning agent, available from authorised Volvo dealers, is recommended toavoid impairing the fire retardant qualities ofthe upholstery.
IMPORTANT
Sharp objects and Velcro may damage the fabric upholstery.
Stains on leather upholsteryVolvo's leather upholstery is treated to pre- serve its original appearance. Leather upholstery ages and acquires a beau- tiful patina over time. The leather is refinedand processed so that it retains its naturalcharacteristics. It is given a protective coa-ting, but regular cleaning is required in orderto maintain both characteristics and appear-ance. Volvo offers a comprehensive productfor the cleaning and treatment of leatherupholstery which, when used in accordancewith the instructions, preserves the leather'sprotective coating. After a period of use thenatural appearance of the leather will never-theless emerge, depending more or less onthe surface texture of the leather. This is anatural maturing of the leather and showsthat it is a natural product. To achieve best results Volvo recommendscleaning and the application of protectivecream once to four times per year (or more ifnecessary). The Volvo Leather Care kit isavailable from your Volvo dealer.
IMPORTANT
•
Certain items of coloured clothing (for example, jeans and suede garments)may stain the upholstery.
• Never use strong solvents. Such prod-ucts may damage fabric, vinyl andleather upholstery.
Washing instructions for leather upholstery
1. Pour the leather cleaner on the damp-
ened sponge and squeeze out a strong foam.
2. Work the dirt away with gentle circular movements.
3. Dab accurately with the sponge on the stains. Allow the sponge to absorb thestain. Do not rub.
4. Wipe off with soft paper or a cloth and allow the leather to dry completely.
Protective treatment of leather upholstery
1. Pour a small amount of the protective cream on the felted cloth and massage in a thin layer of cream with gentle circularmovements on the leather.
2. Allow the leather to dry for 20 minutes before use.
The leather has now been given improvedprotection against stains and improved UVprotection.
Washing instructions for the leather steering wheel
• Remove dirt and dust with a soft pre- moistened sponge and neutral soap.
• Leather needs to breathe. Never coverthe leather steering wheel with protectiveplastic.
• Use natural oils. Volvo's leather careagents are recommended for best results.
If the steering wheel has stains: Group 1 (ink, wine, coffee, milk, sweat and
blood)
–Use a soft cloth or sponge. Mix a 5% ammonia solution. (For blood stains, usea solution of 2 dl water and 25g salt.)
Group 2 (fats, oils, sauces and chocolate)
1. Same procedure as for group 1.
2. Polish with an absorbent paper or cloth.
ProCarManuals.co’

12 Alphabetical Index
12
428
A
ACC – Adaptive cruise control................. 188Active Bending Lights (ABL)...................... 84
Active chassis - FOUR-C......................... 175
Active high beam....................................... 82
Active Park Assist.................................... 247 function............................................... 248
Limitations.......................................... 251
operation............................................. 249
Symbols and messages..................... 252
Active Xenon headlamps........................... 84
Active Yaw Control.................................. 175
Adapting driving characteristics...... 175, 257
Adaptive Cruise Control........................... 188 change cruise control functionality..... 196
deactivate........................................... 194
fault tracing......................................... 199
function............................................... 189
managing speed................................. 191
overtaking........................................... 194
overview.............................................. 190
radar sensor........................................ 197
setting the time interval...................... 192
standby mode..................................... 193
temporary deactivation....................... 193 Additional heater
electric........................................ 134, 135
fuel-driven........................................... 134
Adjusting the steering wheel...................... 76 Airbag activating/deactivating, PACOS........... 30
driver's side.................................... 28, 36
passenger side......................... 29, 30, 36
AIRBAG ............................................... 28, 29
Airbag system............................................ 28 warning symbol.................................... 27
Air cleaning material............................................... 118
passenger compartment.... 116, 117, 118
Air conditioning........................................ 124 Air conditioning system repair................................................... 352
Air distribution.......................................... 119 Recirculation....................................... 126
table.................................................... 127
Air quality system IAQS........................... 118
Alarm........................................ 171, 172, 173 alarm indicator.................................... 172
alarm signals....................................... 173
automatic re-arming........................... 172
checking the alarm............................. 153
reduced alarm level............................ 173
remote control key not working.......... 172 Alcolock................................................... 259
Allergy and asthma inducing substances. 117
All Wheel Drive, (AWD)............................. 290
All Wheel Drive (AWD).............................. 290
Approach lighting.............................. 89, 152
Automatic car washes............................. 379
Automatic gearbox.......................... 273, 276
manual gear positions (Geartronic)..... 273
towing and recovery........................... 314
trailer................................................... 308
Automatic relocking................................. 164
AWD, All Wheel Drive............................... 290
B
Backrest..................................................... 72 front seat, lowering............................... 72
Backrest rear seat, lowering...................... 75
Bag holder .............................................. 144
Battery..................................... 298, 361, 411 jump starting....................................... 270
maintenance....................................... 361
overload.............................................. 298
remote control key/PCC..................... 158
specification....................................... 411
ProCarManuals.co’

12 Alphabetical Index
12
432
changing............................................. 367
cold zone............................................ 377
engine compartment.......................... 368
General............................................... 367
Start/Stop........................................... 377
under glovebox........................... 372, 374
G
Gearbox................................................... 271automatic.................................... 273, 276
manual................................................ 271
Gear indicator.......................................... 272
Gear selector inhibitor............................. 278Gear selector inhibitor, mechanical disen-
gagement................................................. 278
Geartronic................................................ 273Glass laminated/reinforced............................. 21
Glovebox................................................. 140 locking................................................ 167
Gross vehicle weight............................... 390
GSI - Gear selector assistance................ 272
H
Handbrake............................................... 293
Hazard warning flashers............................ 86
Headlamp control...................................... 78
Headlamp levelling.................................... 79
Headlamp pattern, adjusting..................... 90
Headlamp pattern adjustment................... 90 Active Bending Lights .......................... 90
Headlamps............................................... 353head restraint centre seat, rear.................................... 74
lowering.......................................... 75, 76
Heated washer nozzles.............................. 91 Heating rearview and door mirrors.................... 96
rear window.......................................... 96
seats................................................... 122
steering wheel....................................... 77
Heat-reflecting windscreen........................ 17
High engine temperature......................... 306
High-pressure headlamp washing............. 91
Hill Start Assist........................................ 279
Home safe light duration........................... 89
Horn........................................................... 77
I
IAQS - Interior Air Quality System........... 118
Immobiliser.............................................. 150
Indicator symbols...................................... 64
Inflatable curtain.................................. 33, 36
Information button, PCC.......................... 153
Information display.............................. 59, 60
Inlaid mats............................................... 140
Instrument lighting, see Lighting................ 79Instrument overview left-hand drive car................................ 53
right-hand drive car.............................. 56
Instruments and controls..................... 53, 56 Interior Air Quality System (IAQS) Air cleaning......................................... 118
Interior lighting, see Lighting..................... 88
Interior rearview mirror............................... 96 automatic dimming............................... 97
Intermittent wiping..................................... 90
J
Jack......................................................... 321
Jacket holder........................................... 139
ProCarManuals.co’

12 Alphabetical Index
12
433
Journey statistics..................................... 113
Jump starting........................................... 270
K
Kerb weight.............................................. 390
Key........................................... 149, 150, 162
Key blade......................................... 155, 156
Keyless drive.... 159, 160, 161, 162, 163, 264
Keyless - locking..................................... 161
Keyless start (keyless drive) 159, 160,
161, 162, 163, 264
Keyless - unlocking................................. 161
Keypad in the steering wheel.................... 77
Key positions............................................. 70
L
Labels...................................................... 386
Laminated glass......................................... 21
Lamps, see Lighting................................ 352
Lane Departure Control................... 229, 230Lane keeping assistant operation..................... 230, 231, 236, 237
Lane keeping assistant - LKA.......... 234, 235 Laser sensor............................................ 209
Leather upholstery, washing instructions 382
Light indications, PCC............................. 153
Lighting.................................................... 352
Active Xenon headlamps...................... 84
approach lighting.......................... 89, 152automatic lighting, passenger com-
partment............................................... 88
bulbs, specifications........................... 358
controls................................................. 88
cornering lights..................................... 85
daytime running lights.......................... 80
display lighting...................................... 79
headlamp levelling................................ 79
home safe lighting................................ 89
instrument lighting................................ 79
in the passenger compartment............. 88
main/dipped beam............................... 81
position/parking lamps......................... 80
rear fog lamp........................................ 85
tunnel detection.................................... 81
Lighting, bulb replacement...................... 353 bulb holder rear: direction indicatorsrear, rear fog lamp and reversing
lamp.................................................... 356
cargo area........................................... 357dipped beam (cars with halogen head-
lamps)................................................. 355
direction indicators, front.................... 356 main beam (cars with active xenon
headlamps)......................................... 355main beam (cars with halogen head-
lamps)................................................. 355
number plate lighting.......................... 357
vanity mirror........................................ 358
LKA - Lane keeping assistant.......... 234, 235 Loading cargo area........................................... 142
General............................................... 142
long load............................................. 143
roof load............................................. 143
Lock locking................................................ 164
manual locking.................................... 165
unlocking.................................... 164, 165
Lockable wheel bolts............................... 320
Lock confirmation ................................... 150
Lock indicator.......................................... 150Locking/unlocking glovebox............................................. 167
inside.................................................. 165
tailgate................................................ 167
ProCarManuals.co’