Alfa Romeo Giulia 2019 Owner's Manual

SNOW CHAINS
85)
Rear Wheel Drive and All-wheel drive versions
0.28 inch (7 mm) snow chains can be used on all tyres. For tyres up to 8.86 in (225 mm) in width (205/60R16, 225/55R16,
225/50R17, 225/45R18), it is also possible to install 0.35 in (9 mm) chains.
Important notes
The use of snow chains should be in compliance with local regulations of each country. In certain countries, tyres marked with code
M+S (Mud and Snow) are considered as winter equipment; therefore their use is equivalent to that of the snow chains.
The snow chains may be applied only to the rear wheel tyres.
Check the tension of the snow chains after the first few metres have been driven.
IMPORTANT Using snow chains with tyres with non-original dimensions may damage the vehicle.
IMPORTANT Using different size or type (M+S, snow, etc.) tyres between front and rear axle may adversely affect car driveability,
with the risk of losing control of the car and resulting accidents.
WARNING
178)If winter tyres with a lower speed rating than that indicated in the Registration Document are used, do not exceed the maximum speed
corresponding to the speed rating of the tyres used.
IMPORTANT
85)Keep your speed down when snow chains are fitted; do not exceed 50 km/h. Avoid potholes, do not drive over steps or sidewalks and do not
drive long distances over roads without snow, to avoid damaging both your vehicle and the road surface.
189

DIMENSIONS
Dimensions are expressed in inches/mm and refer to the car equipped with its original tyres. Height is measured with car unladen.
AB C D EFGH I
31.3 / 795 111 / 2820 40.5 / 1028 182.8 / 464356.5
/
1436(*)57 /
1450(**)
61.3 /
1557(*)61.4 /
1559(**)
64 / 1625(*)63.1 /
1604(**)79.7 / 2024 73.2 / 1860
(*) RWD versions
(**) AWD versions
Small variations with respect to the reported values are possible depending on the dimensions of the rims.
16410106S0001EM
190
TECHNICAL DATA

WEIGHTS
Weights [lb / kg] 2.0 T4 MAir 2.2 JTD
RWD versions AWD versionsRWD versions(*)RWD versions(**)AWD versions
Unladen weight (with all fluids, fuel tank filled to
90% and without optional equipment)3150/1429 3373/1530 3146/1430 3223/1465 3388/1540
Payload including the driver
(***)1270/576 1268/575 1331/605 1331/605 1353/615
Maximum permitted loads
(**)
– front axle 2028/920 2205/1000 2002/910 2071/940 2244/1020
– rear axle 2506/1137 2557/1160 2541/1155 2543/1156 2557/1160
– total 4420/2005 4641/2105 4477/2035 4554/2070 4741/2155
Maximum combined load (permitted maximum
load + towable weight trailer with brakes)
(***)7931/3605 8151/3705 7997/3635 8074/3670 8261/3755
Towable loads
– braked trailer 3527/1600 3527/1600 3527/1600 3527/1600 3527/1600
– trailer without brakes 1642/745 1642/745 1642/745 1642/745 1642/745
Maximum load on roof 110/50 110/50 110/50 110/50 110/50
Maximum load on tow hitch (trailer with brakes) 141/64 141/64 141/64 141/64 141/64
(*) Manual transmission
(**) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or on the load platform within the maximum permitted loads.
(***) If special equipment is fitted (trailer towing equipment, etc.) the empty weight will increase and consequently the payload will decrease in relation to the maximum
permitted loads.
(***) Never exceed the maximum combined vehicle load value: the maximum towable load is only allowed if it does not exceed the maximum combined vehicleload.
191

REFUELLING
86) 87)
2.0 T4 MAir 2.2 JTDPrescribed fuels and original
lubricants
Fuel tank [UK gal (litres)] 12.76 (58) 11.4 (52)Unleaded petrol
(EN228 specifications)
(2.0 T4 MAir engine) / Automotive
diesel fuel (EN590 and
EN16734 specifications)
(2.2 JTD engine) including a reserve of [UK gal
(litres)]1.98 (9.0) 1.76 (8.0)
AdBlue® tank (where provided)
capacity approximately [UK gal
(litres)]– 3.5 / 16.1AdBlue® (DIN 70 070 and ISO
22241-1 specifications)
(2.2 JTD engine)
Primary cooling system (versions
with manual transmission) [UK
gal (litres)]1.89 (8.6) 1.75 (8.0)
50% mixture of distilled water
and PARAFLU UP
(*)Primary cooling system (versions
with automatic transmission) [UK
gal (litres)]1.89 (8.6)1.92 (8.75) (136 HP/160 HP/
190 HP RWD engines) / 1.96 (8.9)
(190 HP/210 HP AWD engines)
Secondary cooling system [UK
gal (litres)]0.95 (4.3)1.16 (5.3) (190 HP/210 HP AWD
automatic transmission engines)
Engine oil filter [UK gal (litres)] 0.13 (0.6) 0.11 (0.5)SELENIA DIGITEK P.E.
(2.0 T4 MAir engine) / SELENIA
W.R. FORWARD 0W-20 (2.2 JTD
engine) (versions with AdBlue®) /
SELENIA W.R. FORWARD 0W-20
(2.2 JTD 150 HP / 180 HP
engines) (versions without
AdBlue®) / SELENIA W.R.
FORWARD 0W-30 (2.2 JTD
210 HP engines) (versions without
AdBlue®) Engine oil sump [UK gal (litres)] 1.01 (4.6)0.68 (3.1) (RWD versions) / 0.85
(3.9) (AWD versions)
(*) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60% mixture of PARAFLU UP and 40% demineralised water.
192
TECHNICAL DATA

2.0 T4 MAir 2.2 JTDPrescribed fuels and original
lubricants
Hydraulic brake circuit [UK gal
(litres)]0.2(0.9) 0.2 (0.9)TUTELA BRAKE FLUID
EXTREME HT
Windscreen washer tank [UK gal
(litres)]0.92 (4.2) 0.92 (4.2) PETRONAS DURANCE SC 35
Automatic transmission
(2.0 T4 MAir engine) [UK gal
(litres)]2.07 (9.4) (RWD versions) / 2.06
(9.3) (AWD versions)–
TUTELA TRANSMISSION AS 8 Automatic transmission (2.2 JTD
190 HP RWD engine) [UK gal
(litres)]– 2.02 (9.2)
Automatic transmission (2.2 JTD
210 HP AWD engine) [UK gal
(litres)]– 2.0 (9.1)
GETRAG G217 manual
transmission [UK gal (litres)]0.31 (1.4) 0.31 (1.4)TUTELA TRANSMISSION
GEARSYNTH LV
RDU 230-LSD differential [UK
gal (litres)]0.2 (0.9) 0.2 (0.9)
TUTELA TRANSMISSION LS
AXLE FLUID RDU 210-eLSD differential
(where provided) [UK gal (litres)]0.31 (1.4) 0.31 (1.4)
RDU 210/215-LSD differential
[UK gal (litres)]0.24 (1.1) 0.24 (1.1)
193

2.0 T4 MAir 2.2 JTDPrescribed fuels and original
lubricants
AWD System FAD transfer case
[UK
gal (litres)]0.11 (0.5) 0.11 (0.5)TUTELA TRANSMISSION
HYPOIDE GEAR OIL
AWD System TRANSFER CASE
[UK gal (litres)]0.15 (0.7) 0.15 (0.7)TUTELA TRANSMISSION
TRANSFER CASE
IMPORTANT
86)Use AdBlue®only according to DIN 70 070 and ISO 22241-1. Other fluids may cause damage to the system: also exhaust emissions would no
longer comply with the law.
87)The distribution companies are responsible for the compliance of their product. Observe the precautions of storage and maintenance, in order
to preserve the initial qualities. The manufacturer will not recognise any guarantee in case of malfunctions and damage caused to the car due to
the use of UREA (AdBlue
®) not in accordance with regulations.
194
TECHNICAL DATA

FLUIDS AND LUBRICANTS
Your car is equipped with an engine oil that has been thoroughly developed and tested in order to meet the requirements of the
Scheduled Servicing Plan. Constant use of the prescribed lubricants guarantees the fuel consumption and emission specifications.
Lubricant quality is crucial for engine operation and duration.
88)
PRODUCT SPECIFICATIONS
ENGINE LUBRICATION
Use Features SpecificationOriginal fluids and
lubricantsReplacement interval
2.0 T4 MAirSAE 0W-30
ACEA C29.55535-GS1SELENIA DIGITEK P.E.
Contractual Technical
Reference No.F020.B12According to Scheduled
Servicing Plan
2.2 JTDSAE 0W-20
ACEA C29.55535-DSXSELENIA W.R. FORWARD
0W-20
Contractual Technical
Reference No. F013.K15According to Scheduled
Servicing Plan
2.2 JTD 210 HP
(*)SAE 0W-30
ACEA C29.55535-DS1SELENIA W.R. FORWARD
0W-30
Contractual Technical
Reference N°842.F13According to Scheduled
Servicing Plan
(*) Versions without AdBlue - UREA.
If lubricants conforming to the specific request are not available, products that meet the indicated specifications can be used to top
up; in this case optimal performance of the engine is not guaranteed.
195

Use Features SpecificationOriginal fluids and
lubricantsApplications
Lubricants and greases
fordrive transmissionATF Synthetic lubricant 9.55550-AV5TUTELA TRANSMISSION
AS 8
Contractual Technical
Reference No. F139.I11Automatic transmission
SAE 70W API
GL-4 synthetic lubricant9.55550-MZ7TUTELA TRANSMISSION
GEARSYNTH LV
Contractual Technical
Reference No. F055.N15Manual transmission
GETRAG G217 (2.2 JTD
engine)
SAE 75W-85 synthetic
lubricant9.55550-DA9TUTELA TRANSMISSION
LS AXLE FLUID
Contractual Technical
Reference No. F059.N15Differential
RDU 230-LSD RDU
210-eLSD RDU 210/215
-LSD (2.2 JTD engine)
SAE 75W-80 APL
GL-5 synthetic lubricant9.55550-DA10TUTELA TRANSMISSION
HYPOIDE GEAR OIL
Contractual Technical
Reference n° F060.N15AWD System FAD transfer
case
SAE 75W synthetic
lubricant9.55550-DA11TUTELA TRANSMISSION
TRANSFER CASE
Contractual Technical
Reference No. F061.N15AWD System TRANSFER
CASE
Lubricants and greases
for drive transmissionNLGI 0-1 grease for
constant velocity joints
with low friction
coefficient9.55580-GRAS IITUTELA STAR 700
Contractual Technical
Reference No. F701.C07Differential side constant
velocity joints
NLGI 1-2 molybdenum
disulphide grease for high
temperatures9.55580-GRAS IITUTELA ALL STAR
Contractual Technical
Reference No. F702.G07Wheel side constant
velocity joints
Brake fluid DOT 4 9.55597TUTELA BRAKE FLUID
EXTREME HT
Contractual Technical
Reference No. F001.N15Hydraulic brakes and clutch
controls
196
TECHNICAL DATA

Use Features SpecificationOriginal fluids and
lubricantsApplications
Protective agent for
radiatorsP
rotective with antifreeze,
ethylene glycol based
organic formula, free from
amine and 2–EH (2–ethyl
hexanoic acid), containing
corrosion inhibitors and
anti-foam additives. CUNA
NC 956-16, ASTM D 33069.55523 or MS.90032PARAFLU UP
Contractual Technical
Reference N°F101.M01Use rate 50% Not mixable
with different formulation
products.
(*)
Windscreen washer
fluidCUNA NC 956-11 9.55522PETRONAS DURANCE SC
35
Contractual Technical
Reference N° F001.D16To be used diluted or
undiluted in windscreen
washer/wiper systems
AdBlue® additive for
diesel emissionsWater-AdBlue® solutionDIN 70 070 and ISO
22241-1AdBlue®To be used for filling the
AdBlue® tank on vehicles
equipped with Selective
Catalytic Reduction (SCR)
system (2.2 JTD engine)
Diesel fuel additiveAntifreeze additive for
diesel fuel for diesel engine
protectionPETRONAS DURANCE
DIESEL ART
Contractual Technical
Reference N°F601.C06To be mixed with diesel fuel
(25 cc per 10 litres)
Automatic climate
control system (HVAC)R1234yf or R134a
(depending on market)
(*) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60% mixture of PARAFLU UP and 40% demineralised water.
IMPORTANT
88)The use of products with different specifications than those indicated above could cause damage to the engine that is not covered by the
warranty.
197

PERFORMANCE
Top performance after the initial period of car usage.
Versions Maximum speed [mph / km/h]Acceleration from 0-60 mph /
(0-100 km/h) [sec]
2.0 T4 MAir 200 HP RWD(*)146 / 235 6.7
2.0 T4 MAir 280 HP RWD
(*)149 / 240 5.7
2.0 T4 MAir 280 HP AWD
(*)149 / 240 5.2
2.2 JTD 136 HP RWD
(**)130 / 210 9.7
2.2 JTD 136 HP RWD
(**) (***)130 / 210 9.7
2.2 JTD 160 HP RWD
(**)137 / 220 8.4
2.2 JTD 160 HP RWD
(**) (***)137 / 220 8.4
2.2 JTD 190 HP RWD
(**)143 / 230 7.2
2.2 JTD 190 HP RWD
(**) (***)143 / 230 7.2
2.2 JTD 136 HP RWD
(*)130 / 210 9.5
2.2 JTD 136 HP RWD
(*) (***)130 / 210 9.5
2.2 JTD 160 HP RWD
(*)137 / 220 8.1
(*) Automatic transmission
(**) Manual transmission
(***) Version for specific markets.
198
TECHNICAL DATA