CHEVROLET TRACKER 1996 Owners Manual

Attach a separate safety chain around the outboard end
of each lower control arm.
Rear Towing
If your vehicle has four-wheel drive, don't have it towed
on the front wheels unless you must. If a vehicle with
four-wheel drive must
be towed on the front wheels, set
your manual, freewheeling
hubs to FREE or unlock your
automatic freewheeling
hubs, and set your transfer case
to two-wheel drive. If your vehicle must be towed on
the-front wheels, don't go more'than 55 mph (90 kmh).
A towing dolly must be used under the front wheels
when towing from the reur.
r
Attach J-hooks around the axle tube.
I NOTICE:
Take care not to damage the brake pipes on the
axle tubes.
5-10
ProCarManuals.com

Attach a separate safety chain around the end of each
axle, inboard
of the spring.
Position the sling crossbar under and forward of the
rear bumper.
z 11
ProCarManuals.com

Engine Overheating
You will find a coolant temperature gage on your Geo
instrument panel.
If Steam Is Coming From Your Engine
Steam from an overheated engine can burn you
badly, even if you just open the hood. Stay away
from the engine if you see or hear steam coming
from it. Just turn it off and get everyone away
from the vehicle until it cools down. Wait until
there is no sign
of steam or coolant before
opening the hood.
If you keep driving when your engine is
overheated, the liquids in it can catch fire. You or
others could be badly burned. Stop your engine if
it overheats, and get out
of the vehicle until the
engine
is cool.
I NOTICE:
If your engine catches fire because you keep
driving with no coolant,
your vehicle can be
badly damaged. The costly repairs would not be
covered
by your warranty.
5-12
ProCarManuals.com

If No Steam Is Coming From Your Engine
If you get the overheat warning but see or hear no
steam, the problem may not be too serious. Sometimes
the engine can get a little
too hot when you:
Climb a long hill on a hot day.
0 Stop after high-speed driving.
Idle for long periods in traffic.
0 Tow a trailer.
If you get the overheat warning with no sign of steam,
try this for a minute or
so:
1. If you have an air conditioner, turn it off.
2. Turn on your heater to full hot at the highest fan
speed and open the window
as necessary.
3. If you’re in a traffic jam, shift to NEUTRAL (N);
otherwise, shift to the highest gear while
or
DRIVE (D) for automatic transmissions.
driving
-- AUTOMATIC OVERDRIVE @
If you no longer have the overheat warning, you can dnve.
Just to be safe, drive slower for about
10 minutes. If the
warning doesn’t come back on, you can dnve normally.
If the warning continues, pull over, stop, and park your
vehicle right away.
If there’s still no sign of steam, you can idle the engine
for two or three minutes while you’re parked, to
see if
the warning stops. But then, if you still have the
warning,
turn off the engine and get everyone out of the
vehicle
until it cools down.
You may decide not to lift the hood but to get service
help right away.
5-13
ProCarManuals.com

When you decide it’s safe to lift the hood, here’s what
you’ll
see:
c
A. Radiator Pressure Cap
B. Electric Engine Fan
C. Coolant Recovery Tank
A CAUTION:
An electric fan under the hood can start up even
when the engine is not running and can injure
you. Keep hands, clothing and tools away from
any underhood electric fan. Don’t reach through
the grille to release the underhood lever.
If the coolant inside the coolant recovery tank is boiling,
don’t do anything
else until it cools down.
5-14
ProCarManuals.com

The coolant level should be at or above FULL. If it
isn’t, you may have a leak in the radiator hoses, heater
hoses, radiator, water
pump or somewhere else in the
cooling system.
Heater and radiator hoses, and other engine
parts, can be very hot. Don’t touch them.
If you
do, you can be burned.
Don’t run the engine
if there is a leak. If you run
the engine, it could lose
all coolant. That could
cause an engine fire, and you could be burned.
Get any leak fixed before you drive the vehicle.
I NOTICE:
Engine damage from running your engine
without coolant isn’t covered
by your warranty.
If there seems to be no leak, with the engine on, check to
see if the electric engine fan is running. If the engine is
overheating, the
fan should be running. If it isn’t, your
vehicle needs service.
5-15
ProCarManuals.com

How to Add Coolant to the Coolant
Recovery Tank
If you haven’t found a problem yet, but the coolant level
isn’t at or above the
FULL mark, add a 50/50 mixture of
clean water (preferably distilled) and a proper antifi-eeze at
the coolant recovery tank. (See “Engine Coolant” in the
Index for more information about the proper coolant mix.)
Adding only plain water to your cooling system
can
be dangerous. Plain water, or some other
liquid
like alcohol, can boil before the proper
coolant mix
will. Your vehicle’s coolant warning
system is set
for the proper coolant mix. With
plain water or the wrong mix, your engine couId
get
too hot but you wouldn’t get the overheat
warning. Your engine could catch fire and
you or
others
could be burned. Use a 50/50 mix of clean
water and a proper antifreeze.
NOTICE:
In cold weather, water can freeze and crack the
engine, radiator, heater core and other parts.
Use the recommended coolant and the proper
coolant
mix.
ProCarManuals.com

You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol
and it will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
When the coolant in the coolant recovery tank is at or
above the FULL mark start your vehicle.
If the overheat warning continues, there’s one more
thing you can try. You can add the proper coolant mix
directly to the radiator, but be sure the cooling system is
cool before you do it.
5-17
ProCarManuals.com

Steam and scalding liquids from a hot cooling
system can blow out and burn you badly. They
are under pressure, and if
you turn the radiator
pressure cap
-- even a little -- they can come out
at high speed. Never turn the cap when the
cooling system, including the radiator pressure
cap, is hot. Wait for the cooling system and
radiator pressure cap to cool if you ever have to
turn the pressure cap.
5-18
ProCarManuals.com

How to Add Coolant to the Rac
2. Then keep turning the pressure cap, but now push
down
as you turn it. Remove the pressure cap.
’ . You can remove the radiator pressure cap when the
cooling system, including the radiator pressure cap
and upper radiator hose, is
no longer hot. Turn the
pressure cap slowly counterclockwise until it first
stops. (Don’t press down while turning the
pressure cap.)
If you hear a hiss, wait for that to stop. A hiss means
there
is still some pressure left.
- 5-19
ProCarManuals.com