GMC SIERRA 1993 Owners Manual

HOT
WEATHER
COLD
WEATHER
LA t
i SAE low-30
SAE SW-30
PREFERRED
IF NEiTHER SAE 5W-30 NOR SAE 1OW-30
GRADE OILS ARE AVAILABLE, SAE 30
GRADE MAY BE USED AT TEMPERATURES
ABOVE
40 DEGREES F (4 DEGREES C).
ANY OTHER GRADE
OIL NOT RECOMMENDED
DO
NOT USE
SAE 1OW-40, SAE 2OW-50 OR
PO344
SAE 5W-30
Vehicles with Light Duty Emissions (8500 GVWR or less).
As
shown in this chart, SAE 5W-30 is best for your vehicle. However,
you can use
SAE IOW-30 if it’s going to be 0°F (-18°C) or above.
6-23
ProCarManuals.com

Service & Appearance Care
HOT
WEATHER LOOK FOR THIS
LABEL
SAE 5W-30
SAE 1OW-30
PREFERRED
above 0°F (-18°C)
IF NEITHER
SAE 5W-30 NOR SAE 1OW-30
GRADE
OILS ARE AVAILABLE, SAE 30
GRADE MAY BE USED AT TEMPERATURES
ABOVE
40 DEGREES F (4 DEGREES C).
DO NOT USE SAE 1OW-40, SAE 2OW-50 OR
ANY OTHER GRADE OIL NOT RECOMMENDED
PO347
SAE 1OW-30
Vehicles with Heavy Duty
Emissions (8501 GVWR or more).
As shown in this chart, SAE 1OW-30 is best for your vehicle. However,
you can use
SAE 5W-30 if it's going to be colder than 60°F (16°C)
before your next oil change. When it's very cold, below 0°F (-18"C), you
should use
SAE 5W-30.
6-24
ProCarManuals.com

These numbers on an oil container show its viscosity, or thickness.
Do not use other viscosity oils such as
SAE IOW-40 or SAE 2OW-50.
Energy Conserving II
Oils with these words on the container will help you save fuel.
This doughnut-shaped logo (symbol) is used on most oil containers to help
you select the correct oil.
You should look for this on the oil container, and use
only those oils that
display the logo.
GM Goodwrench@ oil (in Canada, GM Engine Oil) meets all the requirements
for your vehicle.
Engine Oil Additives:
Don’t add anything to your oil. Your GM dealer is ready to advise if you think
something should be added.
When to Change Engine Oil:
See if any one of these is true for you:
Most trips are less than 4 miles (6 km).
It’s below freezing outside and most trips are less than 10 miles
(16 km).
The engine is at low speed most of the time (as in door to door
delivery, or in stop-and-go traffic).
You tow a trailer often.
Most trips are through dusty places.
The vehicle is frequently operated off-road.
If any one of these is true for your vehicle, then you need to change your
oil and filter every 3,000 miles (5000 km) or 3 months-whichever comes
first.
Vehicles with Light Duty Emissions (8500 GVWR or less).
If none of them is true, change the oil every 7,500 miles (12 500 km) or 12
months-whichever comes first. Change the filter at the first oil change and at
every other oil change after that.
Vehicles with Heavy Duty Emissions (8501 GVWR or more).
If none of them is true, change the oil every 6,000 miles (10 000 km) or 12
months-whichever comes first. Change the filter at the first oil change and at
every other oil change after that
‘if mileage determines when you change your
oil.
If time determines when you change your oil, change the filter ea\
ch time
you change your oil.
6-25
ProCarManuals.com

Service & Appearance Care
Engine Block Heater:
An engine block heater can be a big help if you have to park outside in very
cold weather,
0°F (-18°C) or colder. If your vehicle has this option, see
“Engine Block Heater” in the Index.
What to Do with Used Oil:
I CAUTION I
Used engine oil contains things that have caused skin cancer
laboratory animals. Don’t let used oil stay on your skin fo\
r very
I
Clean your skin and nails with soap and water, or a good han\
d
cleaner. Wash or properly throw away clothing or rags containin\
g
used engine oil.
Used-oil can be a real threat
to the environment. If you change your own oil,
be sure to drain all free-flowing oil from the filter before disp\
osal. Don’t ever
dispose of oil by putting it in the trash, pouring it on the ground, into sewers,
or into streams or bodies of water. Instead, recycle it by taking it to a place
that collects used
oil. If you have a problem properly disposing of your used
oil, ask your dealer, a service station or a local recycling \
center for help.
Engine Oil (Diesel Engines)
It’s a good idea to check your engine oil level every time you get fuel. In
order
to get an accurate reading, the oil must be warm and the vehicle\
must
be on level ground.
c
-
K2394
Turn off the engine and give the oil a few minutes to drain back into the oil
pan. If you don’t the
oil dipstick might not show the actual level.
6-26
ProCarManuals.com

T-
K2613
To Check Engine Oil: Pull out the dipstick and clean it with a paper towel
or a cloth, then push it back in all the way. Remove it again, keeping the tip
lower.
When to Add Oil: If the oil is at or below the ADD line, then you’ll need to
add some oil. But you must use the right kind. This part explains what kind\

of oil to use. For crankcase capacity, see “Capacities and Spec\
ifications’’ in
the Index.
Don’t add too much oil. If your engine has so much oil that the oil level
gets above the proper operating range, your engine could
be damaged. I
I
w
ii
I
- “‘I
. ..
Ll
6 -”
i f f i
w
K2395
6-27
ProCarManuals.com

r
Service & Appearance Care
Just fill it enough to put the level somewhere in the proper operating range.
Push the dipstick all the way back in when you’re through.
I’ I
What Kind of Oil to Use:
Look for these two things:
CElSG
K2396
I’ : .I
For SAE 15W-40 or SAE 1OW-30, CE must be on the oil container. For
SAE
30, CD must be there. These may be listed alone or with letters,
such as
CEISG, CE/SG/SF, SGICD, etc. These letters show the
American Petroleum Institute (API) levels
of qualijr.
NOTICE
If you use oils that don’t have these designations, you can cause engine
damage which
is not covered by your warranty.
6-28
ProCarManuals.com

LOOK
FOR THIS
LABEL
PO346
SAE 15W-40
AS shown in this chart, SAE 15W-40 is best for your vehicle. How\
ever,
you can use SAE 1OW-30 if
it's going to be colder than 60°F (1 6°C)
before your next oil change. When it's very cold, below 0°F (-18"C), you
should use SAE 1OW-30
to improve cold starting. Also, with
6-29
ProCarManuals.com

Service & Appearance Cam
heavy-duty applications at temperatures above freezing, 32°F (O’C), SAE
30 grade oil is recommended.
These numbers on an oil container show its viscosity, or thickness.
Do not use other viscosity oils such as
SAE IOW-40 or SAE 2OW-50.
This doughnut-shaped logo (symbol) is used on most oil contai\
ners to help
you select the correct oil.
You should
look for this on the oil container, and use only those oils that
display the logo.
GM Goodwrench@ oil (in Canada, GM Engine Oil) meets all the \
requirements
for your vehicle.
Engine Oil Additives:
Don’t add anything to your oil. Your GM dealer is ready to advise if you think
something should be added.
When to Change Engine Oil:
See if any one of these is true for you:
Most trips are less than 4 miles (6 km).
It’s below freezing outside and most trips are less than 10 miles (16
The engine is at low speed most of the time (as in door to door
You tow a trailer often.
Most trips are through dusty places. km).
delivery, or in stop-and-go traffic).
The vehicle is frequently operated off-road .
If any one of these is true for your vehicle, then you need to change your
oil and filter every 2,500 miles (4000 km) or 3 months-whichever comes
first.
If none of these is true, change the oil and filter every 5,000 miles (8000
km) or 12 months-whichever comes first.
6-30
ProCarManuals.com

What to Do with Used Oil:
I
I PAUTION
Used engine oil contains things that have caused skin cancer i\
n I
laboratory animals. Don’t let used oil stay on your skin fo\
r very long.
clnan your skin and nails with soap and water, or a good hand
c,,aner. Wash or properly throw away clothing or rags containing
used engine oil.
I
Used oil can be a real threat to the environment. If you change your own oil,
be sure to drain all free-flowing oil from the filter before disp\
osal. Don’t ever
dispose of
oil by putting it in the trash, pouring it on the ground, into sewers,
or into streams
or bodies of water. Instead, recycle it by taking it to a place
that collects used oil.
If you have a problem properly disposing of your used
oil, ask your dealer, a service station or a local recycling \
center for help.
Air Cleaner
I I
PO216
Refer to the Maintenance Schedule to determine when to replace \
the air
cleaner filter on diesel engines and the air cleaner filter an\
d crankcase ventilation filter on gasoline engines. See “Scheduled Mainten\
ance Services’’
in the Index.
6-3 1
ProCarManuals.com

Service & Appearance Care
I
IC Operating the engine with the air cleaner off can cause you or others
to be burned. The air cleaner not only cleans the air,
it stops flame
if the engine backfires. If it isn't there, and the engine backfires, you
could be burned. Don't drive with it
off, and be careful working on
the engine with the air cleaner
off.
If the air cleaner is off, a backfire can cause a damaging engine fire. And,
dirt can easily get into your engine, which will dan le
it. Alway! 3 tl
air cleaner in place when you're driving.
To remove the air cleaner filter on a gas engine, turn the wing nuts
counterclockwise. Remove the cover and change the filter.
fi 31 Fnning 6.5L Engine
K2151
On a 6.2L diesel engine there are two wing nuts. On a 6.5L \
diesel engine, unhook the clips.
6-32
ProCarManuals.com