ESP LAMBORGHINI GALLARDO 2009 Owner's Manual
Page 413 of 1659
9
L714 01 42 00
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
: L U H V L J Q D O V
) R U W K H R S H U D W L R Q W K H ( * H D U V \ V W H P Q H H G V W K H I R O O R Z L Q J V L J Q D O V F R P L Q J I U R P V S H F L ¿ F V H Q V R U R U I U R P R W K H U Y H K L F O H system. • 6 S H F L ¿ F V H Q V R U V I R U 6 H O H V S H H G • Clutch speed sensor:
• Position sensors: clutch , gear and shift actuators
• Pressure sensor of the Selespeed hydraulic circuit
• Single Signals coming from other vehicle system.
• Engine speed (wired frequency signal, coming from engine ECU or from the dashboard )
• Brake pedal switch
• wake-up line
• Ignition key (cranking position KL_50).
& $ 1 V L J Q D O V
Other signals coming from vehicle systems via CAN network • Engine speed
• Engine Torque
• Water/Oil Engine Temperature
• Brake pedal switch
• Handbrake
• Wheels Speeds
• Sport Switch
• Accelerator Pedal (real and virtual)
• External Temperature
• Lateral Acceleration
• Steering wheel angol
• ...
Page 419 of 1659
15
L714 01 42 00
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
• The Automatic mode is available only for Normal and Sport mode.
• The ESP program (Normal and Sport) is connected to the E-Gear driving program.
( 3 6 2 1 ( 3 6 2 ) )
. 2 0 % , * H D U E R [
map 8 S V K L I W
Thrust
0 R G H ( 6 3
Status . 2 0 % ,
* H D U E R [
map 8 S V K L I W
Thrust
0 R G H ( 6 3
Status
1 2 5 0 $ /
(Default at
key on)
1 2 3 4 5 6NORMAL MANUAL YES NO NORMAL
1 2 3 4 5 6
NORMAL
MANUAL YES NO OFF
(panic
mode)
1 2 5 0 $ /
$ 8 7 2
R N ANORMAL AUTO YES NO NORMAL
R N A
NORMAL
AUTO YES NO OFF
(panic
mode)
6 3 2 5 7
S1 2 3 4 5 6SPORT
MANUAL YES NO SPORT
S1 2 3 4 5 6
SPORT
MANUAL YES NO OFF
(panic
mode)
6 3 2 5 7
$ 8 7 2
R N ASSPORT AUTO YES NO SPORT
R N AS
SPORT
AUTO YES NO OFF
(panic
mode)
& 2 5 6 $
C1 2 3 4 5 6CORSA
MANUALNONO SPORT
C1 2 3 4 5 6
CORSA
MANUAL NOYES
1
OFF
0 $ 1 8 $ / * ( $ 5 % 2 ; n.a. n.a. n.a. n.a. n.a. NORMALn.a. n.a. n.a. OFF
(panic
mode)
Page 421 of 1659
17
L714 01 42 00
A
) L J
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
Launch Control
The mode “Launch Control” realises the max. possible acceleration during pick up.
The activation is done if the following condition are true: •Brake pressed
• CORSA mode activated
• ESP deactivated
When the “launch control” is activated the engine speed is reasing according to the gas pedal position.
The Pick-UP starts immediately when the Brake pedal is Released.
& O X W F K 7 H P S H U D W X U H : D U Q L Q J
A Special buzzer is used by the dashboard, that indicate that the clutch is too hot (c,a 200°), is switched on by Gear- box ECU.
) D X O W , Q G L F D W L R Q W R W K H G U L Y H U
A Driver Warning Message in the dashboard display, that indicate that the car need workshop attention, is switched
on by Gearbox ECU.
The Symbol ( $ ) L J ) is displayed permanently.
Page 429 of 1659
2
L714 02 01 03
) L J
C
A ) L J
( '
%
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
$ ' L V D V V H P E O L Q J W K H O H I W I X H O W D Q N 3 U H O L P L Q D U \ R S H U D W L R Q V •Empty the fuel tank
• Disassemble the engine unit .
• Disassemble the control unit plate .
' L V D V V H P E O L Q J W K H O H I W I X H O W D Q N 1. Disconnect the following pipes by removing the corresponding clamps •Rear air conditioner pipe ( $ ) L J ).
• Power steering circuit pipes ( % ) L J ).
• Brake vacuum pump pipe ( & ) L J ).
2. Disassemble the bulkhead ( ' ) L J ), removing the corresponding mounting screws ( ( ) L J ).
Page 434 of 1659
7
L714 02 01 03
A ) L J
'C ) L J
%
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
% ' L V D V V H P E O L Q J W K H U L J K W I X H O W D Q N 3 U H O L P L Q D U \ R S H U D W L R Q V •Empty the fuel tank .
• Disassemble the engine unit .
• Disassemble the control unit plate .
' L V D V V H P E O L Q J W K H U L J K W I X H O W D Q N 1. Loosen the 2 screws ( % ) L J ) to remove the rear water pipe ( $ ) L J ).
2. Disassemble the bulkhead ( & ) L J ), removing the corresponding mounting screws ( ' ) L J ).
Page 439 of 1659
12
L714 02 01 03
) L J
C
A
%
' ) L J
(
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
& ' L V F R Q Q H F W L Q J W K H I X H O W D Q N F R Q Q H F W L R Q S L S H V 3 U H O L P L Q D U \ R S H U D W L R Q V •Empty the fuel tank .
• Disassemble the engine unit .
• Disassemble the control unit plate .
' L V F R Q Q H F W L Q J W K H I X H O W D Q N F R Q Q H F W L R Q S L S H V 1. On the left side, disconnect the following pipes by removing the corresponding clamps: •Rear air conditioner pipe ( $ ) L J )
• Power steering circuit pipes ( % ) L J ).
• Brake vacuum pump pipe ( & ) L J ).
2. Loosen the 2 screws ( ( ) L J ) to remove the rear water pipe ( ' ) L J ) on the right side.
Page 466 of 1659
1
L714 02 03 00
Fig.1
DC
B
A
E
® Automobili Lamborghini S.p.A.
7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
) X H O $ Q W L ( Y D S R U D W L R Q 6 \ V W H P
The anti-evaporation system prevents the fuel vapors, which consist of the lightest fractions of the hydrocarbons that form in the tank, from discharging into the atmosphere and being suctioned again to be burned.
The system operates especially when the outside temperature is high and the fuel temperature rises, thus increasing the tendency to evaporate. 2 S H U D W L Q J 3 U L Q F L S O H
7 K H I X H O Y D S R U V L Q W K H W D Q N D U H F R Q Y H \ H G E \ P H D Q V R I D À R D W L Q J Y D O Y H L Q V W D O O H G R Q W K H W D Q N W R D F D Q L V W H U Z K L F K F D Q
absorb them when the engine is off. 7 K H À R D W L Q J Y D O Y H K D V W K H I R O O R Z L Q J I X Q F W L R Q V •
It prevents the fuel from reaching the canister in the case of hard acceleration/deceleration when the car has a
full tank, or from spilling from the tank, in case the car rolls over;
• It allows the vapors to pass from the tank to the canister;
• It enables to discharge into the atmosphere any excess pressure inside the tank (electrovalve malfunctioning,
clogged pipe).
The canister is connected, by means of two solenoid valves, to two pipes that convey the vapors to the engine intake
manifolds. With the engine running, each solenoid valve is piloted in duty-cycle by the engine control unit according
to engine speed and load, thus putting the canister into communication with the intake manifold and allowing the
suction of the vapors inside the canister. At high engine speed, a venting valve, connecting the canister to the
D W P R V S K H U H E \ P H D Q V R I D Q D G H T X D W H D L U ¿ O W H U S U H Y H Q W V W K H F D Q L V W H U L P S O R V L R Q W K D W F D Q E H F D X V H G E \ W K H H Q J L Q H vacuum.
Fuel anti-evaporation system layout (Fig.1)
A. Fuel pump
B. Left fuel tank
C. Right fuel tank
D. Filter Canister
E. Diagnosis pump
Page 473 of 1659
L714 02 03 03
) L J
A
%
C
) L J
'
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
& ' L V D V V H P E O L Q J W K H & D Q L V W H U S X P S ¿ O W H U 3 U H O L P L Q D U \ R S H U D W L R Q V •Raise the vehicle on the car lift .
• Disassemble the right rear wheel .
• Disassemble the right rear wheel arch .
' L V D V V H P E O L Q J W K H & D Q L V W H U S X P S ¿ O W H U 1. Disconnect the connection pipe ( $ ) L J E H W Z H H Q W K H D F W L Y H F D U E R Q ¿ O W H U & D Q L V W H U D Q G W K H S X P S E \ G H W D F K L Q J
the corresponding clamp.
2. Disconnect the air inlet pipe ( % ) L J ) by detaching the corresponding clamp.
3. Loosen the screw ( & ) L J V H F X U L Q J W K H F O D P S W R W K H D F W L Y H F D U E R Q ¿ O W H U S X P S & D Q L V W H U V X S S R U W E U D F N H W
4. 5 H P R Y H W K H & D Q L V W H U S X P S ¿ O W H U ' ) L J ).
Page 483 of 1659
6
L714 02 03 05
) L J
C
'
%
A
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
C) Assembling the Canister S X P S ¿ O W H U
Assembling the Canister S X P S ¿ O W H U
1. 3 R V L W L R Q W K H & D Q L V W H U S X P S ¿ O W H U $ ) L J ) inside its housing.
2. 7 L J K W H Q W K H F O D P S W R W K H D F W L Y H F D U E R Q ¿ O W H U S X P S Canister) support bracket by tightening the screw ( % ) L J ).
3. Connect the connection pipe ( & ) L J E H W Z H H Q W K H D F W L Y H F D U E R Q ¿ O W H U Canister) and the pump by fastening
the corresponding clamp.
4. Connect the air inlet pipe ( ' ) L J ) by connecting the corresponding clamp.
• Assemble the right rear wheel arch .
• Assemble the right rear wheel .
Page 493 of 1659
7
L714 02 51 03
) L J
%1
C1
A1
%2
C2
A2 '
(
) L J
)G
H
® Automobili Lamborghini S.p.A. 7 K H L Q I R U P D W L R Q D Q G S U R F H G X U H V S X E O L V K H G E H O R Z D U H V W U L F W O \ F R Q ¿ G H Q W L D O D Q G H [ F O X V L Y H O \ I R U W K H / D P E R U J K L Q L ' H D O H U 1 H W Z R U N D Q G $ X W K R U L ] H G 6 H U Y L F H 3 R L Q W V $ O O F R S \ U L J K W V D U H S U R S H U W \ R I $ X W R P R E L O L
/ D P E R U J K L Q L 6 S $ E D V H G R Q F R S \ U L J K W O D Z $ O O R I W K H 3 ' ) F K D S W H U V L Q W K H : ( % Z R U N V K R S P D Q X D O V G H V F U L E H G E H O R Z D U H E D V H G R Q L Q I R U P D W L R Q D Y D L O D E O H D W W K H W L P H R I S X E O L F D W L R Q 7 K H F R P S D Q \ U H V H U Y H V
W K H U L J K W W R P D N H X S G D W H V D Q G P R G L ¿ F D W L R Q V 7 K H I R O O R Z L Q J D U H S U R K L E L W H G U H S U L Q W L Q J U H S U R G X F W L R Q I R U Z D U G L Q J W R X Q D X W K R U L ] H G S H R S O H D Q G R U W K L U G S D U W L H V D Q G W U D Q V O D W L R Q L Q F O X G L Q J S D U W L D O Z L W K R X W
Z U L W W H Q D X W K R U L ] D W L R Q I U R P $ X W R P R E L O L / D P E R U J K L Q L 6 S $
% ' L V D V V H P E O L Q J W K H V L O H Q F H U K H D W S U R R I S D Q H O V 3 U H O L P L Q D U \ R S H U D W L R Q V • Remove the silencer ( 3 R L Q W $).
' L V D V V H P E O L Q J W K H S D Q H O V 1. / R R V H Q W K H V S H F L ¿ F V F U H Z V W R U H P R Y H W K H K H D W S U R R I S D Q H O V L Q W K H I R O O R Z L Q J R U G H U
• Side panels ( $ ) L J )
• Side panels ( % ) L J )
• Side panels ( & ) L J )
• ) U R Q W F H Q W U H S D Q H O ' ) L J )
• Rear centre panel ( ( ) L J )
To remove the panel ( ( ) L J ¿ U V W G L V D V V H P E O H W K H I R O O R Z L Q J F R P S R Q H Q W V
5 H P R Y H W K H V D I H W \ Z D V K H U ) ) L J D Q G H [ W U D F W W K H ¿ [ L Q J G L V N * ) L J ) with the corresponding spring
( + ) L J ) so that the heat-proof panel can be replaced.