NISSAN NAVARA 2005 Repair Workshop Manual

SE-30
REAR SEAT
BENCH SEAT LH (DOUBLE CAB)
Removal
1. Remove the seat outer reg cover.
2. Release the seat lock and tilt the seatback down. Remove the
nuts.
3. Raise the seatback.
4. Tilt the seat cushion up.
5. Remove the seat bolts.
6. Remove the seat.
Installation
Installation is in the reverse order of removal.
NOTE:
Make sure the washers are on the rear studs prior to seat assembly installation.
BENCH SEAT RH (DOUBLE CAB)
Removal
1. Remove the seat outer reg cover.
2. Release the seat lock and tilt the seatback down. Remove the
nuts.
3. Raise the seatback.
4. Tilt the seat cushion up.
5. Remove the center seat belt lower anchor bolt.
6. Remove the seat belt buckle from the cushion.
LIIA1953E
LIIA1954E
LIIA1955E

REAR SEAT
SE-31
C
D
E
F
G
H
J
K
L
MA
B
SE
7. Remove the seat bolts.
8. Remove the seat assembly.
Installation
Installation is in the reverse order of removal.
NOTE:
Make sure the washers are on the rear studs prior to seat assembly installation.
LIIA1956E

SE-32
REAR SEAT
Disassembly and Assembly
EIS00DVT
Jump Seat (King Cab)
LIIA1957E

REAR SEAT
SE-33
C
D
E
F
G
H
J
K
L
MA
B
SE
1. Headrest 2. Seatback pad and frame 3. Seatback trim
4. Seat leg cover 5. Seat cushion pad and frame assem-
bly6. Seat cushion trim
7. Bushing 8. Spacer 9. Seat cushion pad and frame
10. Inboard jump seat pivot riser 11. Outboard headrest guide 12. Headrest bracket
13. Headrest holder (locked) 14. Headrest holder (free)

SE-34
REAR SEAT
Bench Seat LH (Double Cab)
LIIA1958E
1. Headrest 2. Headrest holder (free) 3. Seatback pad
4. Seatback trim 5. Reclining device inner cover 6. Seat cushion bumper rubber

REAR SEAT
SE-35
C
D
E
F
G
H
J
K
L
MA
B
SE
7. Inboard pivot riser 8. Seat cushion trim 9. Seat cushion pad
10. Seat cushion pan 11. Reclining device lever knob 12. Reclining device outer cover
13. Outboard pivot riser 14. Seat cushion hinge assembly 15. Seatback frame
16. Seat lock assembly 17. Seat lock release strap 18. Headrest holder (locked)
19. Seat outer leg cover 20. Seat cushion frame assembly 21. Seat striker

SE-36
REAR SEAT
Bench Seat RH (Double Cab)
LIIA1959E
1. Headrest 2. Seat lock assembly 3. Seat lock release strap
4. Seat striker 5. Push nut 6. Armrest pad

REAR SEAT
SE-37
C
D
E
F
G
H
J
K
L
MA
B
SE
7. Armrest trim 8. Seatback pad 9. Seatback trim
10. Seatback armrest board 11. Seat cushion trim 12. Seat cushion pad
13. Seat cushion pan 14. Inboard pivot riser 15. Seat cushion bumper rubber
16. Reclining device inner cover 17. Seat cushion hinge assembly 18. Reclining device lever knob
19. Outboard pivot riser 20. Reclining device outer cover 21. Headrest holder (free)
22. Headrest holder (locked) 23. Seatback frame 24. Seat outer leg cover
25. Seat cushion frame assembly

SE-38
REAR SEAT

SRS-1
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
H RESTRAINTS
CONTENTS
C
D
E
F
G
I
J
K
L
M
SECTIONSRS
A
B
SRS
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)
PRECAUTIONS .......................................................... 3
Precautions for Supplemental Restraint System
(SRS)“AIRBAG”and“SEATBELTPRE-TEN-
SIONER” .................................................................. 3
Precautions for SRS “AIR BAG” and “SEAT BELT
PRE-TENSIONER” Service ..................................... 3
Precautions for Trouble Diagnosis ........................... 3
PREPARATION ........................................................... 4
Special Service Tools ............................................... 4
Commercial Service Tools ........................................ 5
SUPPLEMENTAL RESTRAINT SYSTEM (SRS) ....... 6
SRS Configuration ................................................... 6
Front Seat Belt Pre-Tensioner with Load Limiter ...... 7
Front Side Air Bag .................................................... 7
Side Curtain Air Bag ................................................. 7
Direct-Connect SRS Component Connectors .......... 8
TROUBLE DIAGNOSIS .............................................. 9
Trouble Diagnosis Introduction ................................. 9
DIAGNOSIS FUNCTION ....................................... 9
HOW TO PERFORM TROUBLE DIAGNOSES
FOR QUICK AND ACCURATE REPAIR ............... 9
WORK FLOW ...................................................... 10
SRS Components Parts Location ............................ 11
Schematic .............................................................. 12
Wiring Diagram–SRS– ........................................... 13
CONSULT-II Function (AIR BAG) ........................... 16
CONSULT-II Function ............................................ 16
HOW TO CHANGE SELF-DIAGNOSIS MODE
WITH CONSULT-II .............................................. 16
HOW TO ERASE SELF-DIAGNOSIS RESULTS... 17
Self-Diagnosis Function (Without CONSULT-II) ..... 17
HOW TO CHANGE SELF-DIAGNOSIS MODE... 17
HOW TO ERASE SELF-DIAGNOSIS RESULTS... 18
SRS Operation Check ............................................ 18
DIAGNOSTIC PROCEDURE 1 ........................... 18
Trouble Diagnosis With CONSULT-II ..................... 20
DIAGNOSTIC PROCEDURE 2 ........................... 20
DIAGNOSTIC PROCEDURE 3 ........................... 24
DIAGNOSTIC PROCEDURE 4 (CONTINUEDFROM DIAGNOSTIC PROCEDURE 2) .............. 26
DIAGNOSTIC PROCEDURE 5 ........................... 26
Trouble Diagnosis Without CONSULT-II ................. 30
DIAGNOSTIC PROCEDURE 6 ........................... 30
WARNING LAMP FLASH CODE CHART ........... 31
Trouble Diagnosis: “AIR BAG” Warning Lamp Does
Not Turn OFF ......................................................... 34
DIAGNOSTIC PROCEDURE 7 ........................... 34
Trouble Diagnosis: “AIR BAG” Warning Lamp Does
Not Turn ON ........................................................... 35
DIAGNOSTIC PROCEDURE 8 ........................... 35
DRIVER AIR BAG MODULE .................................... 36
Removal and Installation ........................................ 36
REMOVAL ........................................................... 36
INSTALLATION ................................................... 37
SPIRAL CABLE ........................................................ 38
Removal and Installation ........................................ 38
REMOVAL ........................................................... 38
INSTALLATION ................................................... 39
FRONT PASSENGER AIR BAG MODULE .............. 40
Removal and Installation ........................................ 40
REMOVAL ........................................................... 40
INSTALLATION ................................................... 41
WIRING HARNESS MODIFICATION .................. 41
FRONT SIDE AIR BAG MODULE ............................ 43
Removal and Installation ........................................ 43
REMOVAL ........................................................... 43
INSTALLATION ................................................... 43
SIDE CURTAIN AIR BAG MODULE ........................ 44
Removal and Installation ........................................ 44
REMOVAL ........................................................... 44
INSTALLATION ................................................... 44
SIDE AIR BAG (SATELLITE) SENSOR ................... 46
Removal and Installation ........................................ 46
REMOVAL ........................................................... 46
INSTALLATION ................................................... 46
FRONT SEAT BELT PRE-TENSIONER ................... 47
Removal and Installation ........................................ 47