ESP VOLKSWAGEN JETTA 1998 Owner's Guide

Downloaded from www.Manualslib.com manuals search engine 01-211


V.A.G 1551
print-out Possible cause
Repair
00778
Steering angle
sensor -G85-
Faulty
1)
Steering angle sensor -G85-
faulty
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ESP system - Replace steering angle sensor -
G85-
- Perform a zero compensation:
- Initiate basic settings Page 01
-
264 Display group number 060
01044
Control module
incorrectly
coded
ABS Control Module (w/EDL) -
J104- incorrectly coded - Re-code for ABS Control Module
(w/EDL) -J104- Page 01
-232

Coding bridge in multi-pin
connector to ABS Control
Module (w/EDL) -J104- open or
short circuit Electrical Wiring Diagrams,
Troubleshooting &Component
Locations binder - Check wiring and connections
using wiring diagram
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 53из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-213


V.A.G 1551
print-out Possible cause
Repair
01164
ESP
operation
Implausible
signal
1)
Electrical interferences from other
sources (high frequency radiation e.g.
uninsulated ignition cable) - Erase DTC memory
- Perform test drive at more
than 20 km/h (13 mph)
- Check DTC memory again


Open circuit, short to positive or ground
in the wiring - Check wiring and
connections using wiring
diagram

- Perform electrical check
Page 01
-288

Steering angle sensor -G85- sends
incorrect setting values - Perform a zero
compensation:
- Initiate basic setting Page
01-264 Display group number
060

ABS Control Module (w/EDL) -J104-
faulty
Repair Manual, Brake
System, Repair Group 45 - Replace ABS Control Module
(w/EDL) -J104-
1) This DTC is only recognized above 20 km/h (13 mph) (carry out test drive).
Стр. 55из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-222


V.A.G 1551 print-out
Possible cause
Repair
01423
Lateral acceleration
sensor -G200-
1)
Electrical malfunction
in current circuit Connections

Voltage supply less than 5
Volt


Open circuit, short to
positive or ground in the
wiring - Check wiring and connections
using wiring diagram
- Perform electrical check Page
01-288

Sensor for transverse
acceleration -G200- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace sensor for transverse
acceleration-G200-
- Perform a zero compensation:
- Initiate basic setting Page 01
-
264 Display group number 063
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 64из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-223


V.A.G 1551 print-
out Possible cause
Repair
01423
Sensor for
transverse
acceleration -G200-
Implausible signal
1)
- Read measured value block
Page 01
-240 Display group number
004

Installation of sensor for
transverse acceleration -
G200- is not OK. - Check installation of sensor for
transverse acceleration -G200-


Open circuit, short to
positive or Ground in the
wiring - Check wiring and connections using
wiring diagram
- Perform electrical check Page
01-288

Sensor for transverse
acceleration -G200- faulty
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ESP system - Replace sensor for transverse
acceleration-G200-

- Perform a zero compensation:


Basic setting was not
correctly performed in the
past - Initiate basic setting Page 01-264
Display group number 063
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 65из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-224


V.A.G 1551 print-out
Possible cause
Repair
01423
Sensor for transverse
acceleration -G200-
1)
No, or incorrect, basic
setting/adaption
Zero compensation was
never performed - Perform zero compensation
- Initiate basic setting Page 01
-
264 Display group number 063
01435
Sender 1 for brake booster
-G201-
No, or incorrect, basic
setting/adaption
1)
Zero compensation was
never performed - Perform zero compensation
- Initiate basic setting Page 01
-
264 Display group number 066
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 66из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-225


V.A.G 1551 print-
out Possible cause
Repair
01435
Sender 1 for
brake booster -
G201-
Implausible
signal
1)
- Read measured value block Page 01
-
240 Display group number 005
Open circuit, short to
positive or ground in
the wiring - Check wiring and connections using wiring
diagram
- Perform electrical check Page 01
-288
Brake light switch
improperly adjusted
Brake light switch
faulty Repair Manual, Brake System, Repair Group 46; Brake pedal - Assembly overview;
Adjusting brake light switch - Adjust brake light switch
Sender 1 for brake
booster-G201- faulty
Repair Manual, Brake System, Repair
Group 45; Removing and installing parts of
ESP system - Replace sender 1 for brake booster -G201-
:
- Perform a zero compensation:
- Initiate basic setting Page 01
-264
Display group number 066
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 67из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine
01-226


V.A.G 1551 print-out
Possible cause
Repair
01435
Sender 1 for brake
booster -G201-
Electrical malfunction
in current circuit
1)
Connections

Voltage supply is less than 5
Volt

Open circuit, short to
positive or Ground in the
wiring - Check wiring and connections
using current
flow diagram
- Perform electrical check Page
01-288

Sender 1 for brake booster-
G201- faulty
Repair Manual, Brake System,
Repair Group 45
- Replace sender 1 for brake
booster-G201-
- Perform a zero compensation:
- Initiate basic setting
Page 01
-
264 Display group number 066
1) For ABS/EDL/ASR/ESP an d ABS/EDL/ASR/ESP 4MOTION
Стр. 68
из 129
On Board Diagnostic (OBD), performing
Volkswagen Technical Site: http://v olkswagen.msk.ru http://vwts.info http://vwts.ru
огромный архив документации по автомобилям Volkswagen, Skoda, Seat, Audi

Downloaded from www.Manualslib.com manuals search engine 01-227


V.A.G 1551
print-out Possible cause
Repair
01486
1)



The ESP driving test is
activated - Perform the complete ESP driving test;
the
- DTC will be erased automatically
- Initiate basic setting Page 01
-264
Display group number 093
01487 /
literature
1)


The ESP driving test time
has been exceeded - Perform the complete ESP driving test
within the allowed time
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 69из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-228


V.A.G 1551 print-
out Possible cause
Repair
01542
Sender for rotation
rate -G202-
Implausible signal
1)
- Read measured value block
Page 01
-240 Display group number
004
Installation of sender for
rotation rate -G202- is not
OK. - Check installation of sender for
rotation rate -G202-

Open circuit, short to positive
or Ground in the wiring - Check wiring and connections using
wiring diagram
- Perform electrical check Page
01-288
Sender for rotation rate -
G202- faulty
Repair Manual, Brake System,
Repair Group 45 - Replace sender for rotation rate -
G202-
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 70из 129 On Board Diagnostic (OBD), performing

Downloaded from www.Manualslib.com manuals search engine 01-229


V.A.G 1551 print-
out Possible cause
Repair
01542
Sender for rotation
rate -G202-
1)
Electrical
malfunction in
current circuit Connections

Voltage supply is less
than 5 Volt


Open circuit, short to
positive or Ground in the
wiring - Check wiring and connections using
wiring diagram
- Perform electrical check Page 01
-
288

Sender for rotation rate -
G202- faulty
Repair Manual, Brake System, Repair
Group 45; Removing and installing parts
of ESP system - Replace sender for rotation rate -
G202-
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 71из 129 On Board Diagnostic (OBD), performing