oil BMW MOTORRAD R 1150 GS 2002 Rider's Manual (in English)

i
2
Introduction
12
General information and
controls
General view, left side
R 1150 GS ............................ 4
General view, right side
R 1150 GS ............................ 5
General view, left side
R 1150 GS Adventure ........... 6
General view, right side
R 1150 GS Adventure ........... 7
Cockpit ................................. 8
Telltale and warning lights ..... 9
Ignition switch and steering
lock ................................ 10-11
Hazard warning lights .......... 12
Power socket ...................... 13
Left handlebar fitting ........... 14
Right handlebar fitting ......... 15
Dualseat R 1150 GS ..... 16-18
Seat
R 1150 GS Adventure .... 19-20
System case .................. 21-23
Aluminium case .............. 24-26
Adjusting the windscreen .... 27Safety check
Checklist ........................ 28-29
Engine oil ....................... 30-31
Fuel ................................ 32-33
Handlebar levers ............ 34-35
Brake system - general .. 36-37
Brake system - without
BMW Integral ABS ......... 38-40
Brake system - with
BMW Integral ABS ......... 41-44
Clutch ................................. 45
Lights ............................. 46-49
Suspension spring
preload .......................... 50-51
Shock absorber .................. 52
Wheels ........................... 53-55
Accessories and tyres......... 56
Accessories and loads ... 56-57
Contents
10geBKg6.book Seite 2 Dienstag, 19. November 2002 1:11 13

11
4
General information and controls
391256784
1011
R 1150 GS1Suspension strut,
adjustment, front (
b50)
2 Oil level sight glass,
engine (
b31)
3 Engine oil filler (
b31)
4 Reservoir for clutch fluid
(
b45)
5 Power socket, 12 VOA
Provision for connecting
additional equipment – max.
load 5 A
OAOptional accessories
6Suspension strut,
adjustment, rear (
b51)
7 Lifting handle
8 Suspension strut, adjusting
shock absorber (
b52)
9 Dualseat lock (
b 16-18)
10 Primary spark plug, left
11 Secondary spark plug, left
( ) Figure in bracketsbpage number for
description
General view, left side
10ge01g6.fm Seite 4 Montag, 7. Juni 2004 10:11 10

111
9
General information and controls
1Telltale light, left turn
indicator repeater green
s
2 Warning light, battery
charge current red
r
3 Warning light, fuel tank
content approx. 4 litres
(0.9 gal) orange
m (b33)
4 Telltale light, neutral green
k (b69)
5 Warning light,
ABS
l red OE
OEOptional extra
6Warning light, engine oil
pressure red
p
7Telltale light, right turn
indicator repeater green
t
8 Warning light, general
red
e (b 84-89)
9 Telltale light, high (main)
beam blue
q
( ) Figures in brackets bpage number
for description
*
n depending on national-market
specification
Telltale and warning lights
124637
9
5*
8
10geBKg6.book Seite 9 Dienstag, 19. November 2002 1:11 13

2
29
Safety check
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
–Brakes
– Brake fluid level
– Clutch fluid level
– Warning lights and telltale lights
–Lights
– Shock absorber settings and spring preload
– Wheel rim and tyre condition,
tread depth and tyre
pressures
– Load, gross weight – Check regularly (every time
you stop for fuel),
on the basis of the following
section:
– Engine oil level
(every second/third stop for
fuel):
– brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10geBKg6.book Seite 29 Dienstag, 19. November 2002 1:11 13

2
30
Safety check
Engine oil
Checking oil levelCheck the oil level at regular
intervals.
Always check the oil level when
the engine is at operating tem-
perature, because the differ-
ence between the oil level
indicated when the engine is at
operating temperature and the
oil level indicated when the
engine is very cold due to
extremely low outdoor temper-
atures (-10 °C/14 °F) can be as
much as 10 mm (0.393 in).
After switching off the engine at
operating temperature, wait at
least 5 minutes for the oil to
drain back into the sump.Checking the oil level after the
engine has been run only briefly
or when it is not properly warm
will falsify the reading and could
lead to the engine being oper-
ated with the wrong quantity of
oil, because cold oil is viscous
and takes longer to drain back
into the sump. At extremely low
outdoor temperatures (-10 °C/
14 °F), this can take as long as
12 hours.
e
Attention:
To avoid damage to the engine:
– Never exceed the maximum oil level.
– Always keep the oil level above the minimum mark.
Always check the oil level with
the motorcycle upright.
 Check the oil level with the engine at its regular operating
temperature
 Check the oil level after the engine has been stopped for
at least 5 minutes
 Make sure that the motorcy-
cle is upright
– Make sure the ground is level and firm
10geBKg6.book Seite 30 Dienstag, 19. November 2002 1:11 13

2
31
Safety check
1
MAXMIN2
 Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the
two marks is approx. 0.5 litre
(0.88 pint)
 If necessary, remove oil filler plug 2 and top up the engine
oil through engine oil filler 1.
 Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 9) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10geBKg6.book Seite 31 Dienstag, 19. November 2002 1:11 13

3
73
Starting – Riding – Parking
5
Engine oil pressureWarning light5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to a halt
 Check engine oil level
(b 31)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Warning lights
10geBKg6.book Seite 73 Dienstag, 19. November 2002 1:11 13

3
74
Starting – Riding – Parking
The Rider Information Display
operates only when the ignition
is on.
Engine oil temperature
indicator 1
A= engine oil too hot ( red)
OEOptional extra
e Attention:
Switch off the engine, wait 5 min-
utes and then check the oil level
(
b 30). If the oil level is correct, al-
ways consult a specialist work-
shop without delay, preferably an
authorised BMW motorcycle
dealer.
Avoid high engine speeds until
the problem has been dealt with.
B = engine oil at regular operating
temperature
C = engine oil cold ( blue)
Rider Information DisplayOE (RID)
1
A
B
C
10geBKg6.book Seite 74 Dienstag, 19. November 2002 1:11 13

3
79
Starting – Riding – Parking
Brake system - general
Oil and grease on brakes
d Warning:
Brake discs and pads must be
free from oil or grease.
Dirt or mud on brakesWhen riding on loose surfaces
or muddy roads, the brakes
may fail to take effect immedi-
ately because of dirt or mois-
ture on the discs or brake pads.
d Warning:
The brakes must first be
applied until the discs and
pads are clean.
Dirt on the brakes increases
the rate of pad wear.
d Warning:
If the brake lever can be moved
right to the limit of its travel, this
indicates a mechanical or hy-
draulic fault. The brake system is
defective.
Immediately consult a specialist
workshop, preferably an author-
ised BMW motorcycle dealer.
10geBKg6.book Seite 79 Dienstag, 19. November 2002 1:11 13

4
93
Arrive safely
Protecting the environment
Development …Motorcyclists have an intensive
relationship with nature. BMW
has made sure that they con-
tinue to enjoy the best possible
prospects for successful riding
in the future.
For instance, your new Boxer is
available with exhaust emission
control by closed-loop, three-
way catalytic converter.
… waste disposal …Behind the scenes, in the repair
shop, we do not neglect the
pro-environmental aspects of
our work either.
Wherever possible, we use
environmentally acceptable
biodegradable materials. We
ensure strict compliance with
all environmental legislation, for
example the correct disposal of
old oil, which is now classified
as hazardous waste in many
countries.
…recyclingAlongside the correct disposal
of environmentally hazardous
materials, recycling is another
high-priority issue for BMW.
For example, plastics that are
marked according to type can
more easily be returned to the
materials cycle. Remember:
when it comes to making
repairs to your motorcycle, the
authorised BMW motorcycle
workshop is far better equipped
to protect the environment than
you are at home.
10geBKg6.book Seite 93 Dienstag, 19. November 2002 1:11 13