oil pressure BMW MOTORRAD R 1150 GS 2002 Rider's Manual (in English)

111
9
General information and controls
1Telltale light, left turn
indicator repeater green
s
2 Warning light, battery
charge current red
r
3 Warning light, fuel tank
content approx. 4 litres
(0.9 gal) orange
m (b33)
4 Telltale light, neutral green
k (b69)
5 Warning light,
ABS
l red OE
OEOptional extra
6Warning light, engine oil
pressure red
p
7Telltale light, right turn
indicator repeater green
t
8 Warning light, general
red
e (b 84-89)
9 Telltale light, high (main)
beam blue
q
( ) Figures in brackets bpage number
for description
*
n depending on national-market
specification
Telltale and warning lights
124637
9
5*
8
10geBKg6.book Seite 9 Dienstag, 19. November 2002 1:11 13

2
29
Safety check
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
–Brakes
– Brake fluid level
– Clutch fluid level
– Warning lights and telltale lights
–Lights
– Shock absorber settings and spring preload
– Wheel rim and tyre condition,
tread depth and tyre
pressures
– Load, gross weight – Check regularly (every time
you stop for fuel),
on the basis of the following
section:
– Engine oil level
(every second/third stop for
fuel):
– brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10geBKg6.book Seite 29 Dienstag, 19. November 2002 1:11 13

2
31
Safety check
1
MAXMIN2
 Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the
two marks is approx. 0.5 litre
(0.88 pint)
 If necessary, remove oil filler plug 2 and top up the engine
oil through engine oil filler 1.
 Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 9) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10geBKg6.book Seite 31 Dienstag, 19. November 2002 1:11 13

3
73
Starting – Riding – Parking
5
Engine oil pressureWarning light5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to a halt
 Check engine oil level
(b 31)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Warning lights
10geBKg6.book Seite 73 Dienstag, 19. November 2002 1:11 13

98
Index
i
AAnti-lock braking systemnotes, 88, 89
switching off, 86
BBMW Integral ABS, 60Changing brake fluid, 41
Checking brake fluid level, 41
CCatalytic convertersafety instructions, 61
Checking brake fluid level, 38
Checking brake pads, 37
Checking front brake fluid level, 39, 43
Checking rear brake fluid
level, 40, 44
Checking the brake system, 36
Choke cold start lever, 14
Choke lever
position, 14
Clock (RID), 75
DDipswitch, 14
Dualseat lock, 4
EEngine oil, 31 level check, 4
oil filler, 31 Engine oil filler, 4
Engine oil temperature indicator
(RID), 74
Engine-oil pressure
telltale light, 9
FFront brakebrake fluid reservoir, 5
Front spring preload, 50
Fuel octane number, 33
Fuel cap, 5
Fuel gauge (RID), 74
Fuel tank capacity, 33
Fuse box, 5
GGear shifts, 76, 77
General view left side, 6
Right side, 5, 7
General view, left side, 4
HHandlebar fitting, left, 14
Handlebar fitting, right, 15
Handlebar levers
Clutch lever, 34
handbrake, 35
Hazard warning lights, 12
Heated handlebar grips, 12, 15
Helmet holder, 5
A - H
10geBKg6.book Seite 98 Dienstag, 19. November 2002 1:11 13

99
Index
i
High/low (dipped) headlight switch, 14
Horn, 14
Hydraulic fluid clutch, 45
IIgnition switch and steering lock, 8
function, 10
Instrumente Cockpit, 8
KKatalysator, 61
Key positions, 11
Kill switch, 15
LLights
general instructions, 46, 47
headlight beam throw, 46, 47
MMain (centre) stand, 64, 65
Motorcycle equipment, 95
NNeutral, 69
OOctane number, fuel, 33
Odometer, 8
Oil filler, 4, 31 Oil level
checking, 31
engine oil pressure, 9
Oil level sight glass, 4
PPartially integral brakes, 82
Power socket, 4, 13
RRear brake fluid reservoir, 5
Refuelling, 32, 33
Residual braking function, 42, 83
Revolution counter, 8
Rider Information Display Fuel gauge, 75
Gear indicator, 75
Rider Information Display (RID), 8
clock, 75
engine oil temperature, 74
Rider’s equipment, 94
Riding, 76, 77
Risk of fire, 61
Risk of overheating, 61, 70
Risk of poisoning, 60
Running in new brake pads, 67
Running in new tyres, 67
SSafety checklist, 28
Safety instructions
braking, 78, 79
catalytic converter, 61
general, 60
H - S
10geBKg6.book Seite 99 Dienstag, 19. November 2002 1:11 13

100
Index
i
Seat, 19, 20
Seat, single, 18
Service worldwide, 92
Shock, 52
Shock-absorber adjustment, 52
Side stand, 62, 63
Speedometer, 8
Spokes, 53
Spring preload, rear, 51
Spring strut, 4
Starter button, 15
Switching on the ignition, 68
TTank capacity, 33
Telltale and warning lightsABS check, 9
battery charge current, 9, 73
engine oil pressure, 9
fuel level, 9
general, 9
high-beam headlight, 9
neutral, 9
turn indicator repeater, left, 9
turn indicator repeater, right, 9
Telltale lights
ABS check, 9
Tool box, 18
Toolkit, 5
Topcase, 26
Trip meter, 8
Turn indicator switch left, 14
right, 15 Turn indicators
repeaters, 9
Turn-indicator cancel switch, 15
Type plate, 5
Tyre pressures, 54
Tyre tread, 55
VValve caps, 54
WWarning lights ABS warning light, 72
Battery charge current, 72
Engine oil pressure, 73
Low fuel level, 72
Warning light, general, 72
Wheel rims, 53
Windscreen, adjusting, 27
S - Z
10geBKg6.book Seite 100 Dienstag, 19. November 2002 1:11 13