CHEVROLET MONTE CARLO 1996 5.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Headlamp Wiring Fuses and Circuit Breakers
The headlamp wiring is protected by a circuit breaker in
the underhood electrical center. An electrical overload
will cause the lamps to
go on and off, or in some cases
to remain off. If this happens, have your headlamp
system checked right away.
Windshield Wipers
The windshield wiper motor is protected by a circuit
breaker and
a fuse. If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools.
If
the overload is caused by some electrical problem,
have
it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse panel protect the power
windows and other power accessories. When the current
load is too heavy, the circuit breaker opens and closes,
protecting the circuit until the problem
is fixed. The
wiring circuits in your vehicle are protected
from short circuits by
a combination of fuses, circuit
breakers, and fusible thermal links
in the wiring itself.
This greatly reduces the chance
of fires caused by
electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace
a bad fuse with a new one of the identical size
and rating.
--.
Instrument Panel Fuse Block

Downloaded from www.Manualslib.com manuals search engine [,) -A B C D E
Circuit .
Breaker Description
C Power Windows
D Power Seats
Fuse Rating Description
1 CIGAR LIGHTER -- Instrument
Panel and Console Cigar Lighters
3. DLRMDL
5
6
10
11
12 13
14
15
Fuse Rating Description
4 HVAC #2 -- WAC Control
Assembly, Solenoid Box
HAZAP
FLASHER
Sunroof Control Unit
I/P ELECTRONICS BATTERY
FEED -- Chime Module, Electronic "
Brake Control Module (EBCM),
Theft-Deterrent Module, Radio
STARTER RELAY
ANTI-THEFT
-- Theft-Deterrent
Module
ABS--Electronic Brake Control
Module (EBCM), ABS Relay
Blower Motor Relay WAC
#1 -- Air Temperature
Valve Motor, Daytime Running
Lamps Module
@RL), HVAC
Control Assembly, Multifunction
Lever Cruise Control Switch
16 REAR DEFOG
-- HVAC Control
Assembly Rear Window
Defogger Switch
POWER ACCESSORY
#2 --
, WAC
BLOWER MOTOR --
6-54

Downloaded from www.Manualslib.com manuals search engine I
I'
Fuse
19
29
Rating Description
Trunk Courtesy Lamp, Door Lock Switches, Power Mirror S-witch
POWER ACCESSORY
#1--
21
AIR BAG -- Air Bag System
23 STOPLAMPS
-- TCCIBrake
24 CRUISE CONTROL Switch
28 CTSY LAMPS
-- Vanity Mirrors,
Defogger Relay,
I/P Compartment
Lamp, Header Courtesy and
Reading Lamp,
US Lighted
Rearview Mirror, Dome Lamp
WIPER
-- Wiper Switch
Fuse Rating Description
30 TURN SIGNAL -- Turn
Signal Flasher
32 POWER LOCKS
-- Door Lock
Relay, Keyless Entry Receiver
3-8 RADIO
-- Radio, Steering Wheel
Radio Switches
39
I/P ELECTRONICS IGNITION
FEED
-- Headlamp Switch,
Cruise Control Cut-Out Switch,
Air Bag System, TCClBrake
Switch, Instrument Cluster,
Chime Module, Keyless Entry
Receiver, Daytime Running
, Lamps Module (DRL)
6-55

Downloaded from www.Manualslib.com manuals search engine Underhood Electrical Center -- Passenger’s Side
Some fuses are in a fuse block on the passenger’s side of
the engine compartment.
...D , :::
/- .-
uuu A.I.R. PMP RlCMPT REL ECM BAT
on0 A/C CONT TCC
F/INJN ECM IGN ELEK IGN
A/C CONT
TCC
Description
A.I.R. Relay
Fuse
A.I.R. PMP
3.4L
R/CMPT REL Remote Trunk Release
ECM
BAT Powertrain Control Module (PCM), Fuel Pump/Oil Pressure
Switch,
Fuel Pump Relay,
Fan Cont
#I Relay
A/C CMPR Relay
(VIN M Only)
Automatic Transaxle, Transaxle
Range Switch
(VIN M only)
6-56

Downloaded from www.Manualslib.com manuals search engine Fuse
F/INJN
ECM IGN
ELEK IGN
10
11
12
13
Description
Fuel Injectors, High Resolution
24X Crankshaft Position Sensor,
Camshaft Position Sensor
Powertrain Control Module (PCM),
Mass Air Flow (MAF) Sensor
(VIN
X only), EGR, CCP, qxygen Sensor,
VAC CAN
SW, Fan #2 Relay
Electronic Ignition
(EI)
Control Module
I/P Fuse Block
FAN CONT
#I Relay
Passenger’s Side Underhood
Electrical Center and
IJP Fuse
Blocks: Fuses
5, 14,23 and 32
FAN CONT #2 Relay and I/P Fuse
Block: Fuse 16, Power Seat
Circuit Breaker D
Relay
14
15
16
17
18
Description
FUEL PUMP
A/C CMPR
FAN CONT #2
-- Secondary
Cooling Fan (Passenger’s Side)
FAN CONT
#I -- Primary
Cooling Fan (Driver’s Side)
Ignition Relay
6-57

Downloaded from www.Manualslib.com manuals search engine Underhood Electrical Center -- Driver's Side
Additional fuses are in a fuse block on the driver's side
of the engine compartment.
L
FOG LPS PARKLPS HORN
OD0 ABS VAR PIS II
Fuse Description
FOG LPS Fog Lamps
PARK LPS Headlamp Switch
HORN Horn Relay, Underhood Lamp
VAR
P/S Steering
ABS Anti-Lock Brake System
6-58

Downloaded from www.Manualslib.com manuals search engine Fuse
10
I1
12
13
Description
IGN SW2 -- I/P Fuse Block: PWR
WDO and Circuit Breaker D;
Passenger’s Side Underhood
Electrical Center: TCC and ENG
EMIS Fuses
IGN SW 1 -- I/P Fuse Block:
Radio, Wiper,
HVAC, ABS and
Turn Signal Fuses; Passenger’s
Side Underhood Electrical Center:
F/IJN, ECM IGN and ELEK
IGN Fuses
HD LPS -- Circuit Breaker to
Headlamp Switch
ABS
-- ABS Relay
Relay
14
16
Description
ABS -- Anti-Lock Brake System
HORN

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
Exterior Lamps Bulb Number
Back-up ............................... 3057
Center High-vounted Stop
............... 89 1 T2
Front Parking/Turn Signal ............... 3357NA
Headlamp. High-Beam
................... 9005
Headlamp. Low-Beam .................... 9006
License Plate ............................ 168
Sidemarker. Front
......................... 194
Sidemarker. Rear
......................... 194
Stop/Tail/Turn Signal
..................... 3057
Interior Lamps Bulb Number
Ashtray ................................. 194
Center Instrument Cluster
............. 16 1 or 194
Console Shift Indicator
............ ‘-4 . .,-. 73
Dome
.................................. 561
Door Lock Switch
......................... 73
GloveBox .............................. 194
Heater and Air Conditioning Control
. . T- 1.75, T- 1.5
High-Beam Indicator ...................... 161
Luggage Compartment
.................... 920
Inside Rearview Mirror Reading
............. 192
Side Window Switch
....................... 73
6-60

Downloaded from www.Manualslib.com manuals search engine Capacities and Specifications
Automatic Transaxle
Pan Removal and Replacement ..................................... 7 quarts (6.7 L)
After Complete Overhaul
......................................... 10 quarts (9.5 L)
When drainingheplacing converte< more fluid may be needed.
Cooling System Including Reservoir
3.1L (Code M) ............................................ 11.6 quarts (10.94 L)
3.4L (Codex) ............................................. 12.3 quarts (11.65 L)
Refrigerant (R-134a), Air Conditioning:’: ......................... 2.0 pounds (0.9 1 kg)
Engine Crankcase - Oil and Filter Change
3.1L (Code M) .............................................. 4.5 quarts (4.2 L)
3.4L (Code X) ............................................... 5.5 quarts (5.2 L)
Length ........................................................ 22” (565 mm)
Type ................................................................. hook
Windshield Wiper Blade Replacement
Fuel Tank
3.1L (Code M) ............................................ 16.1 gallons (60.9 L)
3.4L (Code X)
............................................. 17.1 gallons (64.7 L)
*See “Air Conditioning Refrigerants ”later in this section.
6-61

Downloaded from www.Manualslib.com manuals search engine Engine Specifications ....................
Type ..................................
Displacement ...........................
Compression Ratio .......................
Firing Order ............................
Thermostat Temperature ..................
Horse Power ............................
3.1L (Code M)
V6
191 CID (3.1L)
9.6:
1
1-2-3-4-5-6
195°F (91 "C)
165 @ 5200
3.4L (Code X)
V6
207 CID (3.4L)
9.25:
1
1-2-3-4-5-6
195°F (91°C)
215 @ 5200
.
6-62
..