CHEVROLET PLYMOUTH ACCLAIM 1993 Service Manual

CHEVROLET PLYMOUTH ACCLAIM 1993 Service Manual PLYMOUTH ACCLAIM 1993 CHEVROLET CHEVROLET https://www.carmanualsonline.info/img/24/56861/w960_56861-0.png CHEVROLET PLYMOUTH ACCLAIM 1993 Service Manual
Trending: radiator cap, fuse block, high beam, ESP inoperative, center console, fuel fill door release, engine

Page 401 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual TORQUE SPECIFICATIONS
Ä BATTERY/STARTING/CHARGING SYSTEMS DIAGNOSTICS 8A - 29

Page 402 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual

Page 403 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual BATTERY/STARTER/GENERATOR SERVICE
CONTENTS
page page
BATTERY REMOVAL, INSTALLATION AND SERVICE  ............................. 1 
GENERATOR  ............................ 9  SPECIFICATIONS 
............

Page 404 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual (5) Remove the battery from vehicle. 
(6) Clean top of battery with a solution of warm
water and baking soda. Apply solution with a bristle
brush and allow to soak until acid deposits loosen
(Fig. 4).

Page 405 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual Fig. 7 Cleaning Battery Cable Terminal
Fig. 8 Battery Cables Disconnected
Ä BATTERY/STARTER/GENERATOR SERVICE 8B - 3

Page 406 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual STARTER INDEX
page page 
General Information  ........................ 4 
Neutral Starter and Back-Up Switch  ........... 8 
Starter Component Replacement  .............. 5 
Starter Interlock Switch:

Page 407 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual (8) For installation, reverse above procedures. 
Clean corrosion/dirt from the cable and wire termi-
nals before installing wiring to the solenoid.
BOSCH OR NIPPONDENSO STARTERÐ3.0L/ 3.3L/3.8L ENGINE

Page 408 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual NIPPONDENSO STARTER GEAR AND CLUTCH
REMOVAL AND INSTALLATION (1) Remove the two gear housing attaching screws 
and separate the gear housing from the solenoid
housing (Fig. 10). The pinion gear, pinio

Page 409 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual BOSCH STARTER GEAR AND CLUTCH REPLACEMENT
(1) Remove solenoid assembly (Fig. 18).
(2) Remove the two through-bolts securing the
starter drive end housing to the motor housing (Fig.
19) and separate ho

Page 410 of 2438

CHEVROLET PLYMOUTH ACCLAIM 1993  Service Manual For replacement and adjustment of this switch, re- 
fer to Group 6, Manual Transaxle Clutch, Manual
Transaxle Starter Interlock Switch.
NEUTRAL STARTER AND BACK-UP SWITCH
For electrical diagnostics wh
Trending: airbag, washer fluid, weight, ESP, open hood, clutch, check engine light