battery DAEWOO MATIZ 2003 Service Repair Manual

9E –22 INSTRUMENT/DRIVER INFORMATION
DAEWOO M-150 BL2
SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS

Application

Nm

Lb-Ft

Lb-In
Passenger’s Airbag Module Blank Cover Screw

1.5–2

–

13–18
INSTRUMENT CLUSTER INDICATOR LAMPS SPECIFICATIONS
Indicator Lamp Color Bulb
ABS Warning Amber 14 v 1.4 W
Airbag Warning Red 14 v 1.4 W
Battery Charge Indicator Red 14 v 1.4 W
Fasten Seat Belt Warning Red 14 v 1.4 W
High Beam Indicator Blue 14 v 1.4 W
Low Fuel Level Warning Amber 12 v 3 W Oil Pressure Warning Red 14 v 1.4 W Parking Brake Indicator and Brake Fluid Warning Red 14 v 1.4 W Service Engine Soon Warning Amber 14 v 1.4 W
Turn Signal Indicators

Green

14 v 1.4 W
Instrument Cluster IlluminationBlue12 v 3 W
Rear Fog Lamp IndicatorAmber14 v 1.4 W

DAEWOO M-150 BL2
SECTION 9F
AUDIO SYSTEMS
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 9F-2. . . . . . . . . . . . . . . . . .
Stereo Cassette AM/FM Radio with CD Changer
and RDS/Audio Security System 9F-2. . . . . . . . . . . . .
Front and Rear Speakers 9F-2. . . . . . . . . . . . . . . . . . .
Roof Antenna 9F-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tape Player and Cassette Care 9F-2. . . . . . . . . . . . .
Compact Disc Care 9F-2. . . . . . . . . . . . . . . . . . . . . . . .
Component Locator 9F-3. . . . . . . . . . . . . . . . . . . . . . . .
Audio Systems 9F-3. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 9F-4. . . . .
Audio System 9F-4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Repair Instructions 9F-6. . . . . . . . . . . . . . . . . . . . . . . . .
On–Vehicle Service 9F-6. . . . . . . . . . . . . . . . . . . . . . . . . .
Audio System 9F-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CD Changer 9F-6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Speakers 9F-8. . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Speaker Covers 9F-9. . . . . . . . . . . . . . . . . . . . . .
Rear Speakers 9F-9. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Roof Antenna 9F-10. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 9F-11. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 9F-11. . . . . . . . . .
Schematic and Routing Diagrams 9F-12. . . . . . . . . .
Audio System Circuit 9F-12. . . . . . . . . . . . . . . . . . . . . .

9F –2 AUDIO SYSTEMS
DAEWOO M-150 BL2
DESCRIPTION AND OPERATION
STEREO CASSETTE AM/FM RADIO
WITH CD CHANGER AND
RDS/AUDIO SECURITY SYSTEM
The stereo digital logic cassette AM/FM radio with elec-
tronic tape ejection and the stereo digital logic cassette
AM/FM radio with a CD changer located under the front
seat (LH) are optional equipment.
The radio data system (RDS) uses a single button to se-
lect a specific radio station once it is set to the listener’s
preference.
The audio security system is activated whenever the au-
dio system circuit is disconnected from the battery. A
four-digit security code must be entered in order for the
audio system to be functional once again. The security
code is stamped on a card located in the vehicle (usually
in the glove box). One of the following security code en-
tering procedures can be followed.
With RDS
1. With the ignition switch in the I or II position, turn the
radio ON. At this time, “CODE” will be shown on the
radio display.
2. Press the P-UP button until the correct first digit is
shown on the display.
3. Press the P-DN button to move over to the second
digit and then press P-UP once again to enter the cor-
rect second digit.
4. Use steps two and three to enter the third and fourth
digits using the same method.
5. After entering the correct four-digit security code,
press the TP button. “CODE OK” will briefly appear
on the radio display, and the system is ready for use.
Wrong Code
If the wrong code is entered, “ERROR 1” will appear on
the display. After this, “CODE” will appear once again,
and the correct security code can be entered. The timebetween each new coding attempt is doubled; a total of
ten coding attempts can be made.
FRONT AND REAR SPEAKERS
All audio systems use four speakers: two speakers
mounted in the front doors and two speakers mounted in
the rear parcel side shelf.
ROOF ANTENNA
Roof antenna is located on the roof and is designed to
separate the antenna pole from the antenna base. The
antenna pole should be removed to prevent the painting
damage before washing the vehicle. The roof antenna
cannot be adjusted.
TAPE PLAYER AND CASSETTE CARE
The head and the capstan are the two parts of the tape
player that should be cleaned. This service should be
performed every 100 hours of cassette operation.
In order to clean the head and the capstan, use a cotton
swab dipped in rubbing alcohol.
A cassette cleaning kit may also be used to clean the
head and the capstan. Follow the cleaning kit instruc-
tions to clean the tape player.
Do not touch the tape head with magnetized tools. If the
head becomes magnetized, it will degrade cassettes
played in the player. No service is performed on the cas-
settes. The cassette manufacturer handles warranties
of the cassettes. Store cassettes away from extreme
heat and direct sunlight.
COMPACT DISC CARE
Handle discs carefully. Store the discs in protective
cases away from the sun, heat, and dust. If the surface
is soiled, dampen a clean, soft cloth in a solution of mild
neutral detergent and wipe the disc clean. Mini discs
(about 3 inches in diameter), will not eject and should
not be used.

9F –6 AUDIO SYSTEMS
DAEWOO M-150 BL2
REPAIR INSTRUCTIONS
ON–VEHICLE SERVICE
D109D547
AUDIO SYSTEM
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the instrument cluster trim panel from the in-
strument panel. Refer to Section 9E, Instrument/Driv-
er Information.
3. Remove the audio system from the instrument panel.

Remove the screws (1).

Disconnect the electrical connector and the anten-
na cable (2).

Remove the audio system (3).
D109D548
Installation Procedure
1. Connect the electrical connector and the antenna
cable.
2. Install the audio system with the screws.
3. Install the instrument cluster trim panel. Refer to Sec-
tion 9E, Instrument/Driver Information.
4. Connect the negative battery cable.
D19D549A
CD CHANGER
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the audio system from the instrument panel.
Refer to “Audio System” in this section.
3. Remove the floor console. Refer to Section 9G, Inte-
rior Trim.
4. Disconnect the CD changer electrical connector from
the audio system.
a. CD changer electrical connector.

9F –8 AUDIO SYSTEMS
DAEWOO M-150 BL2
D19D553A
9. Separate the CD changer and the CD changer brack-
et.

Remove the bolts from the CD changer bracket
(1).

Remove the CD changer bracket (2).

Remove the CD changer (3).
D19D554A
Installation Procedure
1. Install the CD changer bracket to the CD changer
with the bolts.
2. Mount the CD changer assembly under the Driver’s
seat with the bolts and the screws.
3. Arrange the CD changer cable with the sponge pads
and the clip.
4. Connect the CD changer electrical connectors.
5. Install the floor console. Refer to Section 9G, Interior
Trim.
6. Install the Audio System to the instrument panel. Re-
fer to ”Audio System” in this section.
7. Connect the negative battery cable.
D109D555
FRONT SPEAKERS
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the door seal trim. Refer to Section 9P,
Doors.
3. Remove the speaker.

Remove the screws (1).

Disconnect the electrical connector.

Remove the speaker (2).
D109D556
Installation Procedure
1. Connect the electrical connector.
2. Install the speaker with the screws.
3. Install the door seal trim. Refer to Section 9P, Doors
4. Connect the negative battery cable.

AUDIO SYSTEMS 9F–9
DAEWOO M-150 BL2
D109D557
FRONT SPEAKER COVERS
Removal Procedure
1. Remove the door trim panel. Refer to Section 9G, In-
terior Trim.
2. Remove the speaker cover from the door trim panel.

Remove the screws (1).

Remove the speaker cover (2).
D109D558
Installation Procedure
1. Install the speaker cover to the door trim panel with
the screws.
2. Install the door trim panel. Refer to Section 9G, Interi-
or Trim.
D109D559
REAR SPEAKERS
Removal Procedure
1. Disconnect the negative battery cable.
2. Open the tailgate.
3. Remove the rear speaker from the rear parcel side
shelf.

Disconnect the electrical connector (1).

Remove the screws (2).

Remove the rear speaker (3).
D109D560
Installation Procedure
1. Install the rear speaker to the rear parcel side shelf
with the screws.
2. Connect the electrical connector.
3. Connect the negative battery cable.

9F –10 AUDIO SYSTEMS
DAEWOO M-150 BL2
D109D561
ROOF ANTENNA
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the interior courtesy lamp. Refer to Section
9B, Lighting Systems.
3. Remove the roof antenna.

Remove the screw from the vehicle inside (1).

Remove the roof antenna (2).
D19D562A
3 Nm
Installation Procedure
1. Install the roof antenna with the screw.
Tighten
Tighten the roof antenna retaining screw to 3 Nm (27
lb-in).
a. Roof antenna retaining screw.
2. Install the interior courtesy lamp. Refer to Section 9B,
Lighting Systems.
3. Connect the negative battery cable.

DAEWOO M-150 BL2
SECTION 9G
INTERIOR TRIM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 9G-2. . . . . . . . . . . . . . . . . .
Interior Trim Panels 9G-2. . . . . . . . . . . . . . . . . . . . . . . .
Pressure Relief Vent 9G-2. . . . . . . . . . . . . . . . . . . . . . .
Floor Console 9G-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Cable Cover 9G-2. . . . . . . . . . . . . . . . .
Floor Carpet 9G-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Component Locator 9G-3. . . . . . . . . . . . . . . . . . . . . . . .
Interior Trim 9G-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions 9G-4. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 9G-4. . . . . . . . . . . . . . . . . . . . . . . . . .
Front Door Trim Panel (Standard) 9G-4. . . . . . . . . . .
Front Door Trim Panel (Deluxe) 9G-5. . . . . . . . . . . . .
Rear Door Trim Panel (Standard) 9G-6. . . . . . . . . . . .
Rear Door Trim Panel (Deluxe) 9G-7. . . . . . . . . . . . . .
Rear Door Interior Garnish Molding 9G-8. . . . . . . . . .
Rear Door Exterior Garnish Molding 9G-9. . . . . . . . . Tailgate Trim Panel 9G-9. . . . . . . . . . . . . . . . . . . . . . . .
A–Pillar Trim Panel 9G-10. . . . . . . . . . . . . . . . . . . . . . .
Upper B–Piller Trim Panel 9G-10. . . . . . . . . . . . . . . . .
Lower B–Pillar Trim Panel 9G-11. . . . . . . . . . . . . . . . .
C–Pillar Trim Panel 9G-11. . . . . . . . . . . . . . . . . . . . . . .
Rear Parcel Shelf 9G-12. . . . . . . . . . . . . . . . . . . . . . . .
Rear Parcel Side Shelf 9G-13. . . . . . . . . . . . . . . . . . . .
Front Rocker Trim Panel 9G-13. . . . . . . . . . . . . . . . . .
Rear Rocker Trim Panel 9G-14. . . . . . . . . . . . . . . . . . .
Floor Console 9G-15. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Cable Cover 9G-15. . . . . . . . . . . . . . . .
Floor Carpet 9G-16. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage Compartment Wheelhouse
Trim Panel 9G-17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Special Tools and Equipment 9G-18. . . . . . . . . . . . . .
Special Tools Table 9G-18. . . . . . . . . . . . . . . . . . . . . . .

INTERIOR TRIM 9G–11
DAEWOO M-150 BL2
D110A501
LOWER B–PILLAR TRIM PANEL
Removal Procedure
1. Remove the bolt on the lower B–pillar trim panel.

Remove the bolt (1).

Remove the spacer and the spring washer (2).

Remove the plastic protector from the seat belt an-
chor.
D109E559
2. Pry off the lower B–pillar trim panel.
D109E560
Installation Procedure
1. Install the lower B–pillar trim panel.
2. Install the bolt on the lower B–piller trim panel. Refer
to Section 8A, Seat Belts.
D109E561
C–PILLAR TRIM PANEL
Removal Procedure
1. Disconnect the negative battery cable.
2. Open the tailgate.
3. Disconnect the rear speaker electrical connector.

9G –12 INTERIOR TRIM
DAEWOO M-150 BL2
D109E562
4. Remove the rear parcel side shelf. Refer to “Rear
Parcel Side Shelf” in this section.
5. Remove the rear seatback.
6. Remove the rear seat belt bolt on the C–pillar trim
panel. Refer to Section 8A, Seat Belts.
7. Pry off the C–pillar trim panel.

Pry off the C–pillar trim panel by hands (1).
D109E563
Installation Procedure
1. Install the C–pillar trim panel.
2. Install the rear seat belt bolt on the C–pillar trim panel.
Refer to Section 8A, Seat Belts.
3. Install the rear seatback.
4. Install the rear parcel side shelf. Refer to “Rear Parcel
Side Shelf” in this section.
5. Connect the rear speaker connector.
6. Connect the negative battery cable.
D109E564
REAR PARCEL SHELF
Removal Procedure
1. Open the tailgate.
2. Remove the rear parcel shelf (1).
D109E565
Installation Procedure
1. Install the rear parcel shelf.