coolant DODGE NEON 2000 Service Owner's Guide

SPECIFICATIONS
COOLING SYSTEM CAPACITY
TORQUE SPECIFICATIONSSPECIAL TOOLS
COOLING
6.2 Liters (6.5 qts.)
CAPACITY, Includes Heater and Coolant Reserve
System
DESCRIPTION N´m Ft.
Lbs.In.
Lbs.
A/C Condenser to RadiatorÐ
Screws5.4 Ð 50
Automatic Belt Tensioner
PulleyÐBolt27 20 Ð
Coolant Recovery ContainerÐ
Nut/Screw4Ð35
Fan Module to RadiatorÐ
Screws7.2 Ð 65
Fan Motor to ShroudÐScrews 3.8 Ð 34
Fan Blade to Motor ShaftÐ
Nut3.8 Ð 34
In Rush Current SupressorÐ
Screw2.6 Ð 23
Generator MountingÐPivot
Bolt54 40 Ð
Generator MountingÐLocking
Nut54 40 Ð
Radiator (Cooling Module) to
BodyÐScrews10 Ð 90
Thermostat Housing/Water
Outlet ConnectorÐScrews12 Ð 105
Transmission HoseÐClamps 2 Ð 18
Water Pump to Engine
BlockÐBolts12 Ð 105
Water Pump Inlet Tube to
Engine BlockÐBolts12 Ð 105
Hose Clamp Pliers 6094
Coolant Refractometer 8286
7 - 30 COOLING SYSTEMPL

(4) Remove the thermowrap from vehicle.
INSTALLATION
For installation, reverse the above procedures.
BATTERY TRAY
REMOVAL
(1) Remove battery. Refer to Battery Removal and
Installation in this section.
(2) Remove two nuts to the rear and two bolts to
the front of the battery tray (Fig. 18).
(3) Slide battery tray out form under the air
cleaner assembly. Do not remove the air cleaner
assembly.
(4) Remove battery tray from vehicle.
INSTALLATION
For installation reverse the above procedures.
SPECIFICATIONS
BATTERY SPECIFICATIONS
COLD CRANK RATING
The current battery can deliver for 30 seconds and
maintain a terminal voltage of 7.2 volts or greater at
±18É C (0É F).
RESERVE CAPACITY RATING
The length of time a battery can deliver 25 amps
and maintain a minimum terminal voltage of 10.5
volts at 27ÉC (80ÉF).TORQUE
DESCRIPTION TORQUE
Battery Hold Down Bolt Clamp Bolt . . 135615 in.
lbs.
Battery Mount Fasteners....... 105610 in. lbs.
Fig. 18 Battery Tray Removal
1 ± BATTERY TRAY
2 ± LEFT STRUT TOWER
3 ± PDC
4 ± MOUNTING HOLES/SLOTS
5 ± COOLANT RESERVOIR
Load Test Cold
CrankingReserve
(Amps) Rating @
-18ÉC (0ÉF)Capacity
225 Amp 450 Amp 85 Minutes
PLBATTERY 8A - 11
REMOVAL AND INSTALLATION (Continued)

TORQUE SPECIFICATION
DESCRIPTION TORQUE
Camshaft Position Sensor Screw.......... 9N´m
(80 in. lbs.)
SOHC Cam Magnet/Target . . . 3.4 N´m (30 in. lbs.)
Crankshaft Position Sensor Screw........ 9N´m
(80 in. lbs.)
Coolant Temp. Sensor.....18.6 N´m (165 in. lbs.)
Ignition Coil to Cyl. Head . . 11.9 N´m (105 in. lbs.)
Knock Sensor.............. 10N´m(90in.lbs.)
MAP/IAT Sensor Plastic Manifold......... 2N´m
(20 in. lbs.)
Spark Plugs................ 28N´m(20ft.lbs.)
SPARK PLUG CABLE RESISTANCEÐSOHC
SPARK PLUG
Engine Spark Plug Gap Thread Size
2.0L RC9YC 0.033 TO 0.038 14mm (3/4 in.) reach
IGNITION COIL
Coil ManufacturePrimary Resistance at 21ÉC-27ÉC
(70ÉF-80ÉF)Secondary Resistance at 21ÉC-27ÉC
(70ÉF-80ÉF)
Weastec (Steel Towers) 0.45 to 0.65 Ohms 11,500 to 13,500 Ohms
Diamond (copper towers) 0.53 to 0.65 Ohms 10,900 to 14,700 Ohms
CABLE RESISTANCE
#1,#4 3500 ohmsÐ 4900 ohms
#2,#3 2950 ohmsÐ 4100 ohms
Coil Polarity
Coil Polarity
PLIGNITION SYSTEM 8D - 11
SPECIFICATIONS (Continued)

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch Relay............8W-42
A/C Compressor Clutch.................8W-42
A/C Cycling Switch....................8W-42
A/C Heater Blower Motor...............8W-42
A/C Heater Control....................8W-42
A/C Pressure Switches..................8W-42
Airbag Control Module.................8W-43
Airbags.............................8W-43
Antenna.............................8W-47
Automatic Shut Down Relay.............8W-30
Back-Up Lamp Switch..................8W-51
Back-Up Lamps.......................8W-51
Battery.............................8W-20
Blower Motor Resistor Block.............8W-42
Brake Lamp Switch....................8W-30
Brake Shift Interlock Solenoid...........8W-30
Brake Warning Indicator Switch..........8W-40
Camshaft Position Sensor...............8W-30
Cargo Lamp..........................8W-44
Center High Mounted Stop Lamp.........8W-51
Center Stack Lamp....................8W-44
Cigar Lighter/Power Outlet..............8W-41
Circuit Breakers (FB)..................8W-11
City Lamps..........................8W-50
Clockspring.....................8W-33, 41, 43
Clutch Interlock Switch.................8W-30
Combination Flasher...................8W-52
Controller Anti-Lock Brake..............8W-35
Crankshaft Position Sensor..............8W-30
Data Link Connector...................8W-30
Decklid Release Switch.................8W-44
Decklid Solenoid......................8W-61
Diode No. 1..........................8W-42
Dome Lamp..........................8W-44
Dome Lamp/Intrusion Sensor............8W-44
Door Ajar Switches....................8W-40
Door Lock Motors.....................8W-61
Engine Coolant Temperature Sensor.......8W-30
Engine Oil Pressure Switch..............8W-30
Engine Starter Motor Relay.............8W-21
Engine Starter Motor..................8W-21
Fog Lamps........................8W-50, 51
Front Fog Lamp Switch.................8W-50
Fuel Injectors........................8W-30
Fuel Pump Module....................8W-30
Fuel Pump Relay......................8W-30
Fuel Tank...........................8W-30
Fuses (FB)...........................8W-11
Fuses (PDC).........................8W-10
Fuse Block...........................8W-11
Fusible Link A11...................8W-20, 21
Grounds.............................8W-15Component Page
Generator...........................8W-20
Glove Box Lamp/Switch.................8W-44
Headlamp Beam Select..............8W-40, 50
Headlamp Leveling Motors..............8W-50
Headlamp Leveling Switch Illumination....8W-50
Headlamp Leveling Switch..............8W-50
Headlamp Switch...................8W-50, 51
Headlamps..........................8W-50
Horns..............................8W-41
Horn Relay..........................8W-41
Horn Switch.........................8W-41
Hood Ajar Switch......................8W-39
Idle Air Control Motor..................8W-30
Ignition Coil.........................8W-30
Ignition Switch.......................8W-10
Indicators...........................8W-40
Indicator Drivers......................8W-40
Inlet Air Temperature Sensor............8W-30
Instrument Cluster....................8W-40
Instrument Panel Drivers...............8W-40
Knock Sensor.........................8W-30
Leak Detection Pump..................8W-30
License Lamps........................8W-51
Manifold Absolute Pressure Sensor........8W-30
Map/Reading Lamps...................8W-44
Multi- Function Switch.........8W-40, 50, 51, 52
Noise Suppressor......................8W-30
Oxygen Sensors.......................8W-30
Park Brake Switch....................8W-40
Park/Neutral Position Switch............8W-51
Park/Turn Signal Lamps................8W-52
Power Distribution Center...............8W-10
Power Mirror Switch...................8W-62
Power Steering Pressure Switch..........8W-30
Powertrain Control Module..............8W-30
PRNDL Lamp........................8W-44
Proportional Evap/Purge Solenoid.........8W-30
Radiator Fan Motor....................8W-42
Radiator Fan Relay....................8W-42
Radio...............................8W-47
Rear Window Defogger Switch...........8W-48
Rear Window Defogger.................8W-48
Remote Keyless Entry Module............8W-39
Repeater Lamps......................8W-52
Seat Belt Switch......................8W-40
Sentry Key Immobilizer Module..........8W-39
Side Marker Lamps....................8W-50
Siren...............................8W-39
Speakers............................8W-47
Splice Information.....................8W-70
Sunroof Control Module................8W-64
Sunroof Motor........................8W-64
PL8W - 02 COMPONENT INDEX 8W - 02 - 1

8W-30 FUEL/IGNITION SYSTEM
Component Page
A/C Compressor Clutch Relay...........8W-30-9
A/C High Pressure Switch.............8W-30-11
Airbag Control Module................8W-30-4
Automatic Shut Down Relay........8W-30-2, 3, 5
Brake Lamp Switch............8W-30-12, 13, 14
Brake Shift Interlock Solenoid.........8W-30-13
Brake Warning Indicator Switch........8W-30-13
Camshaft Position Sensor..............8W-30-7
Center High Mounted Stop Lamp.......8W-30-14
Clockspring........................8W-30-12
Clutch Interlock Switch..............8W-30-15
Controller Anti-Lock Brake..........8W-30-4, 13
Crankshaft Position Sensor............8W-30-7
Data Link Connector................8W-30-2, 4
Engine Coolant Temperature Sensor.....8W-30-7
Engine Oil Pressure Switch............8W-30-2
Engine Starter Motor Relay...........8W-30-15
Fuel Injector No. 1...................8W-30-5
Fuel Injector No. 2...................8W-30-5
Fuel Injector No. 3...................8W-30-5
Fuel Injector No. 4...................8W-30-5
Fuel Pump Module..................8W-30-10
Fuel Pump Relay...................8W-30-10
Fuel Tank.........................8W-30-10
Fuse 6 (FB)........................8W-30-13
Fuse 7 (FB)........................8W-30-13
Fuse 10 (FB).....................8W-30-9, 10
Fuse 11 (FB).....................8W-30-9, 10
Fuse 21 (PDC)..................8W-30-2, 4, 10
Fuse 23 (PDC)......................8W-30-13
Fuse Block....................8W-30-9, 10, 13
G101........................8W-30-3, 12, 15Component Page
G102.......................8W-30-2, 4, 13, 15
G201.............................8W-30-12
G303.............................8W-30-10
Generator.........................8W-30-11
Idle Air Control Motor................8W-30-8
Ignition Coil........................8W-30-5
Inlet Air Temperature Sensor...........8W-30-6
Instrument Cluster................8W-30-4, 10
Knock Sensor.......................8W-30-6
Leak Detection Pump.................8W-30-9
Left Tail/Stop Lamp.................8W-30-14
Manifold Absolute Pressure Sensor......8W-30-6
Multi-Function Switch...............8W-30-14
Noise Suppressor....................8W-30-5
Oxygen Sensor 1/1 Upstream...........8W-30-3
Oxygen Sensor 1/2 Downstream.........8W-30-3
Park/Neutral Position Switch..........8W-30-15
Power Distribution Center......8W-30-2, 4, 10, 13
Power Steering Pressure Switch........8W-30-15
Powertrain Control Module.....8W-30-2, 3, 4, 5, 6,
7, 8, 9, 10, 11, 12, 13, 15
Proportional Evap/Purge Solenoid.......8W-30-15
Radiator Fan Relay...................8W-30-9
Remote Keyless Entry Module..........8W-30-4
Right Tail/Stop Lamp................8W-30-14
Sentry Key Immobilizer Module.........8W-30-4
Throttle Position Sensor...............8W-30-6
Torque Converter Clutch Solenoid.......8W-30-9
Vehicle Speed Control Servo........8W-30-12, 13
Vehicle Speed Control Switch..........8W-30-12
Vehicle Speed Sensor.................8W-30-8
PL8W - 30 FUEL/IGNITION SYSTEM 8W - 30 - 1

312
CRANKSHAFT
POSITION
SENSOR
8V
SUPPLYSENSOR
GROUND
K7
20
OR
1
32
8V
SUPPLY
SENSOR
GROUNDCAMSHAFT
POSITION
SENSOR
CAMSHAFT
POSITION
SENSOR
SIGNAL
S123
K24
20
GY/BK
K4
20
BK/LB
K4
20
BK/LB
K4
20
BK/LB
C243
SENSOR
GROUND
1
2
S130
C1
2632C1 C133
K44
20
TN/YL
SENSOR TEMPERATURE
COOLANT
ENGINE
CRANKSHAFT
POSITION
SENSOR
SIGNALCAMSHAFT
POSITION
SENSOR
SIGNALENGINE
COOLANT
TEMPERATURE
SENSOR
SIGNAL CRANKSHAFT
POSITION
SENSOR
SIGNAL
MODULE CONTROL
POWERTRAIN
BK/LB20 K4
C1012
BK/LB18 K4
S113
K2
20
TN/BK
K4
20
BK/LB
C244
SUPPLY8V K7
20
OR
K7
20
OR
C1014K7
20
OR
(8W-70-2)
(8W-70-3)
(8W-30-6)
PL8W-30 FUEL/IGNITION SYSTEM 8W - 30 - 7
PLI03007008W-10

8W-40 INSTRUMENT CLUSTER
Component Page
A/C Heater Control..................8W-40-10
Airbag Control Module................8W-40-6
Brake Warning Indicator..............8W-40-11
Brake Warning Indicator Switch........8W-40-5
Center Stack Lamp..................8W-40-10
Circuit Breaker No. 2 (FB)............8W-40-12
Combination Flasher................8W-40-3, 4
Controller Anti-Lock Brake.............8W-40-5
Data Link Connector.................8W-40-5
Dome Lamp........................8W-40-9
Dome Lamp/Intrusion Sensor...........8W-40-9
Driver Door Ajar Switch.............8W-40-7, 8
Engine Coolant Temperature Sensor.....8W-40-5
Engine Oil Pressure Switch............8W-40-5
Front Fog Lamp Switch..............8W-40-14
Fuel Pump Module...................8W-40-6
Fuse 1 (FB).......................8W-40-3, 4
Fuse 10 (FB)........................8W-40-2
Fuse 11 (FB)........................8W-40-2
Fuse 13 (PDC)......................8W-40-2
Fuse 15 (FB)........................8W-40-2
Fuse 15 (PDC).....................8W-40-3, 4
Fuse 19 (FB).......................8W-40-13
Fuse 20 (FB).......................8W-40-14
Fuse Block................8W-40-2, 3, 4, 12, 13
G101..............................8W-40-5
G204............................8W-40-2, 9
G301.............................8W-40-11
Headlamp Beam Select...............8W-40-12
Headlamp Leveling Switch............8W-40-10
Headlamp Switch...............8W-40-2, 12, 14Component Page
High Beam Indicator.................8W-40-11
Ignition Switch....................8W-40-7, 8
Indicator Drivers....................8W-40-11
Instrument Cluster.......8W-40-2, 3, 4, 6, 7, 8, 9,
10, 11, 12, 13, 14
Instrument Panel Drivers......8W-40-6, 7, 8, 9, 14
Left Front Fog Lamp................8W-40-13
Left Front Turn Signal Lamp...........8W-40-3
Left Park/Turn Signal Lamp..........8W-40-3, 4
Left Rear Door Ajar Switch...........8W-40-7, 8
Map/Reading Lamps..................8W-40-9
Multi-Function Switch..........8W-40-2, 3, 4, 9,
11, 12, 13, 14
Park Brake Switch..................8W-40-11
Passenger Door Ajar Switch..........8W-40-7, 8
Power Distribution Center.......8W-40-2, 3, 4, 14
Powertrain Control Module............8W-40-5
PRNDL Lamp......................8W-40-10
Radio.............................8W-40-10
Rear Window Defogger Switch.........8W-40-10
Remote Keyless Entry Module........8W-40-6, 8
Right Front Fog Lamp...............8W-40-13
Right Front Turn Signal Lamp..........8W-40-3
Right Park/Turn Signal Lamp.........8W-40-3, 4
Right Rear Door Ajar Switch..........8W-40-7, 8
Seat Belt Indicator..................8W-40-11
Seat Belt Switch....................8W-40-11
Sentry Key Immobilizer Module.........8W-40-6
Traction Control Switch..............8W-40-10
Vehicle Speed Sensor.................8W-40-5
PL8W - 40 INSTRUMENT CLUSTER 8W - 40 - 1

2
1
C266
C112
SENSOR TEMPERATURE
COOLANT
ENGINE
SWITCH PRESSURE
OIL
ENGINE
POWERTRAIN
CONTROL
MODULE
26C17565
59 71
A
(8W-40-6)10
A3
BRAKE
WARNING
SWITCHVEHICLE
SPEED
SENSOR
TO
S217
C20C104
67 2
CONTROLLER
ANTI-LOCK
BRAKE
20D25
20
VT/YL
D20
20
LGD21
20
PKK2
20
TN/BKG6
20
GY
G7
20
WT/ORG9
18
GY/BKD25
20
VT/YL
D25
20
VT/YLD25
18
VT/YL
D25
22
VT/YL
SCI
RECEIVESCI
TRANSMITENGINE
COOLANT
TEMPERATURE
SENSOR
SIGNALENGINE
OIL
PRESSURE
SWITCH
SENSE SIGNAL SENSOR TEMPERATURECOOLANTENGINE
VEHICLE
SPEED
SENSOR
SIGNALSENSE SWITCH PRESSUREOIL ENGINE
RED
BRAKE
WARNING
INDICATOR
DRIVER PCI
BUS
BUSPCI
C2 C2
SIGNAL SENSORSPEED VEHICLEG7
20
WT/OR
3C102 C2 C2
B
G101
S112
Z1
18
BK
Z1
18
BK
INDICATOR S104 CONNECTORLINK DATA
(8W-30-7)
(8W-30-2)
(8W-30-2)
(8W-30-4)
(8W-30-7)
(8W-30-8)
(8W-30-13)
(8W-30-8)
(8W-35-2)
(8W-15-3) (8W-15-3) (8W-30-4) (8W-30-4)
PL8W-40 INSTRUMENT CLUSTER 8W - 40 - 5
PLI04005008W-10

INSTRUMENT
CLUSTER
A (8W-40-5)
21
193
AIRBAG
CONTROL
MODULE
FUEL
PUMP
MODULE
MODULE ENTRY
KEYLESS
REMOTEFROM
C104
A12C30512G4
18
DB
G4
18
DB
D25
18
VT/YLD25
20
VT/YLD25
22
VT/YL
D25
22
VT/YL
S217
FUEL
LEVEL
SENSOR
SIGNALPCI
BUS
BUSPCI
BUSPCI
VT/YL22 D25
2
MODULE IMMOBILIZER
KEY
SENTRY
2 7
INSTRUMENT
PANEL
DRIVERS
SPEEDOMETER FUEL
GAUGE
INDICATOR PRESSURE
OIL
LOW BRAKE
WARNING
INDICATOR TRACTION
OFF
INDICATOR AIRBAG
WARNING
INDICATORLOW
FUEL
INDICATOR ABS
INDICATOR CHECK
ENGINE
INDICATOR
GAUGE TEMPERATURE
COOLANT
ENGINE TACHOMETER
ODOMETER/TRIP
INDICATOR AJAR
DOOR TRACTION
CONTROL
OFF
INDICATOR INDICATOR
ENGAGED
CRUISE(8W-43-2)
(8W-30-10)
(8W-39-10)
(8W-39-11) (8W-39-3)
(8W-30-4)
8W - 40 - 6 8W-40 INSTRUMENT CLUSTERPL
008W-10PLI04006

K4
18
BK/LB
POWERTRAIN
CONTROL
MODULE
S130
VEHICLE
SPEED
SENSOR
SENSOR POSITION
CRANKSHAFT
CAMSHAFT
POSITION
SENSOR
C1012
K4
18
BK/LB
BK/LB20 K4
BK/LB20 K4
S113SENSOR KNOCKSENSOR PRESSURE
ABSOLUTE
MANIFOLD
ENGINE
COOLANT
TEMPERATURE
SENSOR
43C2
11
22 2
2
K4
20
BK/LBK4
20
BK/LBK4
18
BK/LBK4
20
BK/LBK4
20
BK/LB
(8W-30-8)
(8W-30-3)(8W-30-7)
(8W-30-7) (8W-30-6)(8W-30-6)
(8W-30-7)
(8W-30-6)
PL8W-70 SPLICE INFORMATION 8W - 70 - 3
PLI07003008W-10