roof rack DODGE SPRINTER 2007 2.G Owners Manual

3 Introduction
\3 Environmental protection
In this manual, whenever you see instruc-
tions to discard materials, you should first
attempt to reclaim and recycle them. To
preserve our environment, follow appropri-
ate environmental rules and regulations
when disposing of materials.
Environmental note
H
DaimlerChrysler’s declared policy is one of
comprehensive environmental protection.
The objectives are for the natural resources
which form the basis of our existence on this
planet to be used sparingly and in a manner
which takes the requirements of both nature
and humanity into account.
You too can contribute to environmental
protection by operating your vehicle in an
environmentally-responsible manner.
Fuel consumption and engine, transmission,
brake and tire wear depend on the two fol-
lowing factors:
\4Operating conditions of your vehicle
\4Your personal driving style
You can influence both factors.
Observe the following notes:
Operating conditions
\4Avoid driving short distances as this in-
creases fuel consumption.
\4Make sure that the tire pressures are al-
ways correct.
\4Do not carry any unnecessary weight
in / on the vehicle.
\4Keep an eye on the vehicle’s fuel con-
sumption.
\4Remove roof racks once you no longer
need them.
\4A regularly serviced vehicle will contrib-
ute to environmental protection. You
should therefore adhere to the specified
service intervals.
\4Always have maintenance work carried
out at an authorized Sprinter Dealer.
Personal driving style
\4Do not depress the accelerator pedal
when starting the engine.
\4Do not warm up the engine when the ve-
hicle is stationary.
\4Adopt an anticipatory style of driving
and keep a sufficient distance from oth-
er vehicles.
\4Avoid frequent, sudden acceleration.
\4Switch off the engine in stationary traf-
fic.
Environmental concerns and recom-
mendations

145 Controls in detail
Open air
3
Sliding sunroof switch1To open
2To close
3To raise
4To lower\1Switch on the ignition (\2page 67).
\1Press the sliding sunroof switch in the
desired direction as far as the first
pressure point.
\1Release the sliding sunroof switch
when the desired position has been
reached.
Sliding sunroof*Warning
G
M a k e s u r e t h a t n o b o d y c a n b e c o m e t r a p p e d
as you close the sliding sunroof.
The glass may shatter in the event of an ac-
cident.
If you or other occupants are not wearing
your seat belt, there is a risk of being thrown
out of the opening in the event of the vehicle
overturning. Therefore, always wear a seat
belt to reduce the risk of injuries.
In accidents in which the vehicle overturns,
there is an increased risk of injury even for
occupants who have fastened their seat
belts correctly, as their head or limbs could
be thrust through the opening.
Remove the key from the ignition lock even
if you are only leaving the vehicle for a short
time.
!
CAUTION
Do not raise the sliding sunroof if you
have mounted a roof rack. It would oth-
erwise strike the roof rack.
You could thereby damage the sliding
sunroof and the roof rack.
iThe sliding sunroof opens automatical-
ly when you press the sliding sunroof
switch for opening beyond the pressure
point and then release it.
To stop the sliding sunroof, press the
sliding sunroof switch again in any di-
rection.!
CAUTION
Do not transport objects protruding
through the sliding sunroof. You could
otherwise damage the sliding sunroof.

162 Controls in detailTransporting
3
It is possible to mount a roof rack if your
vehicle is equipped with securing rails on
the roof.
1Securing rails
Special mountings (sliding blocks) are
available as accessories. These are avail-
able from any authorized Sprinter Dealer.Carrier systems
Warning
G
Handling and braking characteristics may
change when you have mounted carrier sys-
tems on the vehicle. You could endanger
yourself and others.
Observe the manufacturer’s installation in-
structions. An incorrectly secured carrier
system or load could:
\4come loose
\4fall off
and thereby endanger yourself and others.
Observe the maximum roof loads
(\2page 372), the maximum axle load and
the maximum load-bearing capacity of the
roof rack.
!
CAUTION
Make sure that:
\4the securing bolts for the roof
rack are tightened to a torque of
6.0 – 7.4 lb-ft (8 – 10 Nm) in the
sliding blocks provided
\4the bolts do not make contact with
the rails when tightened
\4the sliding blocks are not posi-
tioned near the plastic caps
\4the sliding blocks have the correct
cross-section
\4the securing rails are free of dirt on
the inside
\4the securing bolts are retightened
evenly after approximately
300 miles (500 km)
This will help to avoid damage to the ve-
hicle.
Only install roof racks that have been
approved or recommended for Sprinter
vehicles. These are available in any au-
thorized Sprinter Dealer.

230 OperationTires and wheels
4
Production options weight
The combined weight of those installed
regular production options weighing over
5 lbs (2.3 kilograms) in excess of those
standard items which they replace, not
previously considered in curb weight or ac-
cessory weight, including heavy duty
brakes, ride levelers, roof rack, heavy duty
battery, and special trim.
PSI (P
ounds per S
quare I
nch)
A standard unit of measure for air pres-
sure. Another metric unit for air pressure is
bar or kilopascal (kPa).
Recommended tire inflation pressure
Recommended tire inflation pressure list-
ed on the placard located on driver’s door
B-pillar for normal driving conditions. Pro-
vides best handling, tread life and riding
comfort.Rim
A metal support for a tire or a tire and tube
assembly upon which the tire beads are
seated.
Side wall
The portion of a tire between the tread and
the bead.
TIN (T
ire I
dentification N
umber)
Unique identifier which facilitates efforts
by tire manufacturers to notify purchasers
in recall situations or other safety matters
concerning tires and gives purchases the
means to easily identify such tires. The TIN
is comprised of the “manufacturer’s identi-
fication mark”, “tire size”, “tire type code”
and “date of manufacture”.
Tire load rating
Numerical code associated with the maxi-
mum load a tire can support.Tire ply composition and material used
This indicates the number of plies or the
number of layers of rubber-coated fabric in
the tire tread and side wall. Tire manufac-
turers also must indicate the ply materials
in the tire and side wall, which include
steel, nylon, polyester, and others.
Tire speed rating
Part of tire designation; indicates the
speed range for which a tire is approved.
Traction
Force exerted by the vehicle on the road
via the tires. The amount of grip provided.
Tread
The portion of a tire that comes into con-
tact with the road.
Treadwear Indicators
Narrow bands, sometimes called
“wear bars” that show across the tread of
a tire when only
1/16
in (1.6 mm) of tread
remains.

372 *Technical dataLashing points and carrier systems
6
Maximum roof load and minimum number
of pairs of roof rack supports on vehicles
with:
The data is valid when the load is distribut-
ed evenly over the entire roof area.
When using a shorter roof rack, reduce the
load proportionately.
The maximum load is 110 lbs (50 kg) per
pair of roof rack supports.Roof carrier systems
Maxi-
mum roof
load
Minimum
number of
pairs of
supports
Standard roof
660 lbs
(300 kg)
6
Raised roof
330 lbs
(150 kg)
3
!
CAUTION
The weight of any load carried on the
roof, including the roof rack, must not
exceed the maximum permissible roof
load.
The roof rack supports must be ar-
ranged at equal distances.
The manufacturer recommends that
you have an anti-roll bar installed on
the front axle.
Warning
G
High roof loads may cause a significant de-
terioration in handling, steering and braking
characteristics even if the maximum permis-
sible gross vehicle weight or axle loads have
not been exceeded.
Always ensure that loads are distributed
correctly and adapt your driving style in ac-
cordance with the load.

387 Index
Removing/installing the floor covering
in the driver’s footwell
. . . . . . . . . . 336
Reserve warning indicator (fuel)
. . 276
Residual heat mode
. . . . . . . . . . . . 134
problems
. . . . . . . . . . . . . . . . . . . . 267
Restraint system
. . . . . . . . . . . . . . . 24
airbags
. . . . . . . . . . . . . . . . . . . . . . . 25
belt force limiters
. . . . . . . . . . . . . . 30
child restraint systems
. . . . . . . . . . 37
display message
. . . . . . . . . . . . . . 288
emergency tensioning retractor
. . . 30
front airbags
. . . . . . . . . . . . . . . . . . 33
malfunction . . . . . . . . . . . . . . . . . . 272
seat belt
. . . . . . . . . . . . . . . . . . . . . . 25
thorax sidebag
. . . . . . . . . . . . . . . . . 34
windowbags
. . . . . . . . . . . . . . . . . . . 35
Reverse lamp . . . . . . . . . . . . . . . . . 309
changing bulbs . . . . . . . . . . . . . . . 310
Reverse warning feature
. . . . . . . . 153
Rims
. . . . . . . . . . . . . . . . . . . . . . . . . 230
Roll-back warning
see Parktronic
Roof load
. . . . . . . . . . . . . . . . . . . . . 372
Roof rack . . . . . . . . . . . . . . . . . . . . . 162
Roof ventilator
. . . . . . . . . . . . . . . . 146
S
Seat
adjusting
. . . . . . . . . . . . . . . . . . . . . 68
folding rear bench seat
. . . . . . . . . . 74
folding seat
. . . . . . . . . . . . . . . . . . . 74
fore-and-aft adjustment
. . . . . . . . . . 69
heating
. . . . . . . . . . . . . . . . . . . . . . . 73
malfunction
. . . . . . . . . . . . . . . . 266
height
. . . . . . . . . . . . . . . . . . . . . . . . 69
suspension
. . . . . . . . . . . . . . . . . . . . 70
swivelling . . . . . . . . . . . . . . . . . . . . . 70
vertical lock . . . . . . . . . . . . . . . . . . . 70
Seat belt
. . . . . . . . . . . . . . . . . . . . . . . 25
adjusting height
. . . . . . . . . . . . . . . . 27
cleaning
. . . . . . . . . . . . . . . . . . . . . 246
telltale
. . . . . . . . . . . . . . . . . . . . . . 280
wearing . . . . . . . . . . . . . . . . . . . . . . 27
Seat heating
switching on
. . . . . . . . . . . . . . . . . . . 73
Seating capacity
. . . . . . . . . . . . . . . 206
Securing a load
. . . . . . . . . . . . . . . . 158
Securing tensioning straps
. . . . . . 158
Selector lever
lock
. . . . . . . . . . . . . . . . . . . . 111
, 121
Service
calling up the due date
vehicles with steering wheel buttons
. . . . . . . . . . . . . . . . . . . . 239
vehicles without steering wheel but-
tons
. . . . . . . . . . . . . . . . . . . . . . 240
indicator . . . . . . . . . . . . . . . . . . . . . 238
Service information
. . . . . . . . . . . . . . 5
Service life
tires
. . . . . . . . . . . . . . . . . . . . . . . . 203
Service products
. . . . . . . . . . . 187
, 237
capacities
. . . . . . . . . . . . . . . . . . . . 365
coolants, lubricants, etc.
. . . . . . . . 362
diesel
. . . . . . . . . . . . . . . . . . . . . . . 359
engine oils
. . . . . . . . . . . . . . . . . . . 356
fuels
. . . . . . . . . . . . . . . . . . . . . . . . 358
gasoline . . . . . . . . . . . . . . . . . . . . . 358
notes
. . . . . . . . . . . . . . . . . . . . . . . 355
windshield washer fluid
. . . . . . . . . 193
Setting the blower speed . . . . . . . . 133
Setting the date
vehicles with steering wheel
buttons
. . . . . . . . . . . . . . . . . . . . . . 102
vehicles without steering wheel
buttons . . . . . . . . . . . . . . . . . . . . . . . 88
Settings
resetting all (vehicles with steering
wheel buttons)
. . . . . . . . . . . . . . . . . 96
Shift range
automatic transmission
. . . . . . . . . 123
display
. . . . . . . . . . . . . . . . . . . . . . 121
S