flat tire DODGE SPRINTER 2008 2.G Manual PDF

599 *Technical data
6 *Technical data
Genuine Sprinter Vehicle parts........... 600
Vehicle electronics........... 602
Service products and capacities........... 604
Rims and tires........... 623
Tire inflation pressure........... 626
Lashing points and carrier systems........... 629
Vehicle identification labels........... 632
nf_BA.book Page 599 Friday, January 25, 2008 3:53 PM

624 *Technical dataRims and tires
6
Warning
G
Loose wheel nuts or bolts could cause the
vehicle to lose a wheel while it is in mo-
tion. This would jeopardize the operating
and road safety of the vehicle. You could
lose control of the vehicle as a result,
cause an accident an injure yourself or
others.If a wheel was replaced or new wheel nuts
are used, the wheel bolts or wheel nuts
must be retightened to the specified tight-
ening torque after 30 miles (50 km).
Continued
Warning (Continued)
G
If new or repainted wheels are mounted,
the wheel bolts or wheel nuts must be re-
tightened again to the specified tighten-
ing torque after approximately 600 to
3000 miles (about 1000 to 5000 km).
iFurther information on tires and rims
is available at any authorized Sprint-
er Dealer.
A placard with the recommended
cold tire inflation pressure is located
on the driver’s door B-pillar
(\2
page 354).
In addition to the placard also con-
sult the tire inflation pressure table
(
\2
page 628).
The tire inflation pressure should be
checked regularly and should only be
adjusted on cold tires.
nf_BA.book Page 624 Friday, January 25, 2008 3:53 PM

626 *Technical dataTire inflation pressure
6
\3 Tire inflation pressureObserve the information on recom-
mended tire inflation pressure in the
“Operation” section (
\2
page 361).
The following table lists the recommen-
ded cold tire inflation pressures for all
load conditions up to the maximum per-
missible weight limits (GAWR). The tire
inflation pressures listed apply to the ti-
res installed as original equipment.
iIn addition to the following table the
recommended cold tire inflation
pressures are listed on a placard lo-
cated on the driver’s door B-pillar
(\2
page 354).
Warning
G
Follow recommended tire inflation pres-
sures.
Do not underinflate tires. Underinflated
tires wear excessively and/or unevenly,
adversely affect handling and fuel econo-
my, and are more likely to fail from being
overheated.
Do not overinflate tires. Overinflated tires
can adversely affect handling and ride
comfort, wear unevenly, increase stop-
ping distance, and result in sudden defla-
tion (blowout) because they are more
likely to become punctured or damaged
by road debris, potholes etc.
nf_BA.book Page 626 Friday, January 25, 2008 3:53 PM

627 *Technical data
Tire inflation pressure
6
Set the correct tire pressure before
loading the vehicle. If the vehicle has
been loaded, check the tire pressures
and correct them if necessary.
The tires can be considered cold if the
vehicle has been parked for at least
3 hours or driven less than 1 mile
(1.6 km) at an ambient temperature of
approximately 68 °F (20 °C).
Keeping the tires properly inflated pro-
vides the best handling, tread life and
riding comfort.
Tire temperature and tire inflation pres-
sure are also increased while driving, de-
pending on the driving speed and the
tire load.Tire inflation pressure changes by ap-
proximately 1.5 psi (0.1 bar) per 18 °F
(10 °C) of air temperature change. Keep
this in mind when checking tire inflation
pressure where the temperature is dif-
ferent from the outside temperature.
For example:
If the inside temperature is 68 °F
(20 °C) and the outside temperature is
32 °F (0 °C) then the cold tire inflation
pressure should be increased by 3 psi
(0.2 bar), which equals 1.5 psi (0.1 bar)
for every 18 °F (10 °C) for this outside
temperature condition.Check tire inflation pressures more of-
ten if subject to a wide range of outdoor
temperatures, as tire inflation pressures
vary with temperature changes.
!
CAUTION
The pressure difference between the
tires on a single axle should not ex-
ceed 1.5psi (10kPa).
nf_BA.book Page 627 Friday, January 25, 2008 3:53 PM

628 *Technical dataTire inflation pressure
6
Tire
Permissible axle loads (see certification label)Front axle
Rear axle
3970 lbs
(1801 kg)
4080 lbs
(1851 kg)
4410 lbs
(2000 kg)*
5360 lbs
(2431 kg)
7060 lbs
(3202 kg)
7720 lbs
(3502 kg)
LT 215/85 R 16
115/112 N
—
55 psi (3.8 bar)
61 psi (4.2 bar)
—
55 psi (3.8 bar)
61 psi (4.2 bar)
LT 215/85 R 16
115/112 Q
—
55 psi (3.8 bar)
61 psi (4.2 bar)
—
55 psi (3.8 bar)
61 psi (4.2
bar=)
LT 245/75 R 16
120/116 L
47 psi (3.2 bar)
—
—
70 psi (4.8 bar)
—
—
LT 245/75 R 16
120/116 N
47 psi (3.2 bar)
—
—
70 psi (4.8 bar)
—
—
nf_BA.book Page 628 Friday, January 25, 2008 3:53 PM

637 Index
Numerics
12 V socket
. . . . . . . . . . . . . . . . . 297
A
ABSsee Antilock Brake SystemAcceleration skid control (ASR)
. 73
activating/deactivating . . . . . . . . 74
display message . . . . . . . . 500–501
indicator lamp . . . . . . . . . . 462–465
malfunction . . . . . . . . . . . . . . . . 465
warning lamp . . . . . . . . . . . . 73,461
Accessory weight
. . . . . . . . . . . . 393
Accident
. . . . . . . . . . . . . . . . . . . . 432
Additional turn signal lamp
. . . . 526
ADRsee Operating speed governorAir conditioning
. . . . . . . . . . . . . 215
air distribution . . . . . . . . . . . . . . 221
air vents
in the dashboard . . . . . . . . . . 215
see Rear heater . . . . . . . . . . . . . 233
Air conditioning in the rear
. . . . 225
Air conditioning, regulatedrefrigerant . . . . . . . . . . . . . . . . . 616Air pressuresee Tire inflation pressureAir ventsair distribution . . . . . . . . . . 221
,230
in the rear . . . . . . . . . . . . . . . . . 226
Airbagco-driver's . . . . . . . . . . . . . . . . . . 50driver's . . . . . . . . . . . . . . . . . . . . .50
safety notes . . . . . . . . . . . . . . . . . .46
thorax sidebag . . . . . . . . . . . . . . . .51
windowbag . . . . . . . . . . . . . . . . . .53
Airconditioningair distribution . . . . . . . . . . . . . . 215Air-conditioning systemheating . . . . . . . . . . . . . . . . . . . 219
ventilation/cooling . . . . . . . . . . 219Air-conditioning system in the rear
compartmentair cleaner . . . . . . . . . . . . . . . . . 415Air-recirculation modeair conditioning in the rear . . . . 226
heater . . . . . . . . . . . . . . . . . . . . 231
rear heating . . . . . . . . . . . . . . . . 226
Tempmatic . . . . . . . . . . . . . . . . 221
A
nf_BA.book Page 637 Friday, January 25, 2008 3:53 PM

641 Index
Checking tire pressure electronically
with the Advanced Tire Pressure
Monitoring System
(Advanced TPMS)
. . . . . . . . . . . . 373
Checking tire pressure electronically
with the Tire Pressure Monitoring
System (TPMS)
. . . . . . . . . . . . . . 367
Checks, regular
. . . . . . . . . . . . . . 312
Childrenin the vehicle . . . . . . . . . . . . . . . . 55
ISOFIX seat securing system . . . . 61
LATCH type child restraint
system . . . . . . . . . . . . . . . . . . . . . 61
restraint systems . . . . . . . . . . . . . 56Chock
. . . . . . . . . . . . . . . . . . . . . . 521
Cigarette lighter
. . . . . . . . . . . . . 295
Cleaning
. . . . . . . . . . . . . . . . 416
,424
after driving off-road or
on construction sites . . . . . . . . . 425
air cleaner element . . . . . . . . . . 415
cockpit . . . . . . . . . . . . . . . . . . . . 424
headlamps . . . . . . . . . . . . . . . . . 421
padded boss of the steering
wheel . . . . . . . . . . . . . . . . . . . . . 424
radio display . . . . . . . . . . . . . . . 424
rear view camera lens . . . . . . . . 422
rear view camera monitor . . . . . 424
rear window . . . . . . . . . . . . . . . . 421
side windows . . . . . . . . . . . . . . . 421
vehicle . . . . . . . . . . . . . . . . . . . . 418
windshield . . . . . . . . . . . . . . . . . 420
windshield wipers . . . . . . . . . . . 420
Clearance lampchanging bulbs . . . . . . . . . . . . . 535
see identification lamp . . . . . . . 533Clocksetting
vehicles with steering wheel
buttons . . . . . . . . . . . . . . . . . . 168
vehicles without steering
wheel buttons . . . . . . . . . . . . 150Cockpit
. . . . . . . . . . . . . . . . . . . . . .18
Cold tire inflation pressure
. . . . 394
COMANDsee the separate Operating
InstructionsComfort seat
. . . . . . . . . . . . . . . . 114
Constant headlamp mode
. . . . . 171
nf_BA.book Page 641 Friday, January 25, 2008 3:53 PM

645 Index
Environmental protection
. . . . . . . 5
ESP
®/ASR warning lamp
. . 22
,73,461
Exterior lighting
. . . . . . . . . . . . . 129
additional bulbs . . . . . . . . . . . . . 533
Constant headlamp mode
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 171
delayed switch-off
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 173
front bulbs . . . . . . . . . . . . . . . . . 526
lamp failure monitor . . . . . . . . . 129
locator lighting
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 172
rear bulbs . . . . . . . . . . . . . . . . . 530
Exterior mirrors
. . . . . . . . . 208
,209
Eyeglasses compartment
. . . . . 290
F
Fastening seat beltssee Wearing seat beltsFault memorysee Malfunction memoryFax machine
. . . . . . . . . . . . . . . . 315
Fire extinguisher
. . . . . . . . . . . . 514
First-aid kit
. . . . . . . . . . . . . . . . . 514
Flat tirechanging a wheel . . . . . . . . . . . . 548
Premium tire sealant . . . . . . . . . 557Flow improvers
. . . . . . . . . . . . . . 615
Folding table in the backrest
. . 291
Front foglamps
. . . . . . 130
,134
,526
changing bulbs . . . . . . . . . . . . . 527
Fuelgauge . . . . . . . . . . . . . . . . . . . . 145
line . . . . . . . . . . . . . . . . . . 433
,435
loss . . . . . . . . . . . . . . . . . . 433,435
malfunctions . . . . . . . . . . . . . . . 434
see Gasoline or Diesel
Fuel filter with
water separatordraining . . . . . . . . . . . . . . . . . . . 542Fuel requirementsdiesel engine . . . . . . . . . . . . . . . 612
gasoline engine . . . . . . . . . . . . . 611Fuse boxin the driver's seat . . . . . . . . . . 594
main . . . . . . . . . . . . . . . . . . . . . 589Fuse chart
. . . . . . . . . . . . . . . . . . 589
Fuses
. . . . . . . . . . . . . . . . . . . . . . 589
F
nf_BA.book Page 645 Friday, January 25, 2008 3:53 PM

648 Indexbrake pad/lining wear . . . . . . . . 470
coolant . . . . . . . . . . . . . . . . . . . . 474
engine diagnostic . . . . . . . . . . . . 477
ESP
®
. . . . . . . . . . . . . . . . . 462
,468
handbrake . . . . . . . . . . . . . . . . . 189
operating speed governor (ADR) . . 274poly-V-belt . . . . . . . . . . . . . . . . . 469
preglow . . . . . . . . . . . . . . . 186
,476
reserve warning
indicator (fuel) . . . . . . . . . . 475,476
windshield washer/headlamp
cleaning system washer fluid
level . . . . . . . . . . . . . . . . . . . . . . 482
Inflation pressuresee Tires, Inflation pressuresInformation regarding electronic
recording devices
. . . . . . . . . . . . . 16
Instrument cluster
. . . . . . . . 20
,142
lighting . . . . . . . . . . . . . . . . . . . . 144
speedometer . . . . . . . . . . . . . . . 145
tachometer . . . . . . . . . . . . . . . . 145
vehicles with steering wheel buttons
selecting the language . . . . . . 166
setting the status line . . . . . . . 167
Instrument lighting
. . . . . . . . . . . 144
Interior lightingchanging bulbs . . . . . . . . . . . . . . 537
front . . . . . . . . . . . . . . . . . . . . . . 137
rear . . . . . . . . . . . . . . . . . . . . . . 138Interior lighting, rear
. . . . . . . . . 138
Interior motion sensor
. . . . . . . . . 80
Intermittent wipe
. . . . . . . . . . . . 210
ISOFIX child seat securing
system
. . . . . . . . . . . . . . . . . . . . . . 61
TopTether . . . . . . . . . . . . . . . . . . 64
J
Jackjacking points . . . . . . . . . . . . . . 551
preparing . . . . . . . . . . . . . . . . . . 550
storage location . . . . . . . . . . . . . 515Jump-starting
. . . . . . . . . . . . . . . 581
connection point . . . . . . . . . . . . 582
Jump-starting connection
point
. . . . . . . . . . . . . . . . . . . . . . . 582
J
nf_BA.book Page 648 Friday, January 25, 2008 3:53 PM

650 IndexLimit speedflat tire . . . . . . . . . . . . . . . . . . . . 570Load distribution
. . . . . . . . . . . . . 279
Loading guidelines
. . . . . . . . . . . 276
Locator lightingsetting
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 172Locking button (key)
. . . . . . . . . . 85
Locking knob
. . . . . . . . . . . . . . . . . 89
Low-beam headlamps
. . . . 131
,526
automatic headlamp control . . . 132
changing bulbs . . . . . . . . . . . . . . 527
constant headlamp mode
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 171
driving abroad . . . . . . . . . . . . . . 311
M
Magnetic door retainer
. . . . . . . 101
Malfunction memory
(vehicles with steering wheel
buttons)
. . . . . . . . . . . . . . . . . . . . 160
Maximum engine speed
. . . . . . . 145
Maximum load rating, tires
. . . . 396
Maximum loaded vehicle weight,
tires
. . . . . . . . . . . . . . . . . . . . . . . 396
Maximum roof load
. . . . . . . . . . 630
Maximum speedprogrammed . . . . . . . . . . . . . . . 311Menu (vehicles with steering
wheel buttons)audio . . . . . . . . . . . . . . . . . . . . . 158
malfunction memory . . . . . . . . . 160operation . . . . . . . . . . . . . . . . . . 157
overview . . . . . . . . . . . . . . . . . . 154
settings . . . . . . . . . . . . . . . . . . . 161
telephone . . . . . . . . . . . . . . . . . 178
trip computer . . . . . . . . . . . . . . . 176
Messagesbulbs . . . . . . . . . . . . . . . . . . . . . 503
coolant . . . . . . . . . . . . . . . . . . . 502
doors . . . . . . . . . . . . . . . . . . . . . 511
engine oil level . . . . . . . . . . 508
–510
reserve fuel . . . . . . . . . . . . . . . . 511
telephone . . . . . . . . . . . . . . . . . 501
washer fluid . . . . . . . . . . . . 496,512
Mirrorsexterior mirrors . . . . . . . . . . . . . 209
rear-view mirror . . . . . . . . . . . . . 208
M
nf_BA.book Page 650 Friday, January 25, 2008 3:53 PM