brake FIAT 500 ABARTH 2013 2.G Owner's Manual

FLUIDS AND CAPACITIES
Component Fluid, Lubricant, or Genuine Part Capacities
Engine Coolant1.4L Turbo
We recommend you use MOPAR®Antifreeze/Engine Coolant 10 Year/150,000 Mile Formula OAT (OrganicAdditive Technology).
4.6 Quarts(4.4 Liters)
Engine Oil withFilter 1.4L TurboWe recommend you use API CertifiedSAE 5W-40 Full Synthetic Engine Oil.4 Quarts(3.8 Liters)
Engine Oil FilterWe recommend you use MOPAR®Engine Oil Filters.—
Fuel Selection1.4L Turbo91 Octane Recommended – 87 OctaneAcceptable
10.5 Gallons(40 Liters)(Approximate)
ManualTransmissionWe recommend you use MOPAR®C635 DDCT/MTX Transmission Fluid—
Brake MasterCylinder
We recommend you use MOPAR®DOT 3, SAE J1703. If DOT 3, SAEJ1703 brake fluid is not available, thenDOT 4 is acceptable.
—
Spark PlugsWe recommend you use MOPAR®Spark Plugs - Gap 0.026 in (0.65 mm)—
CAUTION!
• Mixing of engine coolant (antifreeze) other than specified Organic Additive
Technology (OAT) engine coolant (antifreeze), may result in engine damage
and may decrease corrosion protection. Organic Additive Technology (OAT)
engine coolant is different and should not be mixed with Hybrid Organic Ad-
ditive Technology (HOAT) engine coolant (antifreeze) or any “globally com-
patible” coolant (antifreeze). If a non-OAT engine coolant (antifreeze) is intro-
duced into the cooling system in an emergency, the cooling system will need
to be drained, flushed, and refilled with fresh OAT coolant (conforming to
MS-12106), by an authorized studio as soon as possible.
•Do not use water alone or alcohol-based engine coolant (antifreeze) products.
Do not use additional rust inhibitors or antirust products, as they may not be
compatible with the radiator engine coolant and may plug the radiator.
• This vehicle has not been designed for use with propylene glycol-based en-
gine coolant (antifreeze). Use of propylene glycol-based engine coolant (anti-
freeze) is not recommended.
MAINTAINING YOUR VEHICLE
63

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change indicator system. The oil
change indicator system will remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change indicator message will illumi-
nate. This means that service is required for your vehicle. Operating conditions such
as frequent short-trips, trailer tow, extremely hot or cold ambient temperatures, and
E85 fuel usage will influence when the “Change Oil” message is displayed. Severe
Operating Conditions can cause the change oil message to illuminate as early as
3,500 miles (5,600 km) since last reset. Have your vehicle serviced as soon as pos-
sible, within the next 500 miles (805 km).
NOTE:Under no circumstances should oil change intervals exceed 10,000 miles (16,000 km) ortwelve months, whichever comes first.
Once A Month Or Before A Long Trip:
• Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual wear or damage
• Check the fluid levels of the coolant reservoir, brake master cylinder, and trans-
mission as needed
• Check function of all interior and exterior lights
Required Maintenance Intervals.
Refer to the Maintenance Schedules on the following pages for required mainte-
nance.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregular wear, even if it occurs before theoil indicator system turns on.
•Inspect battery and clean and tighten terminals as required.
•Inspect brake pads, shoes, rotors, drums, hoses and park brake.
•Inspect engine cooling system protection and hoses.
•Inspect exhaust system.
•Inspect engine air cleaner if using in dusty or off-road conditions.
MAINTAINING YOUR VEHICLE
64

Maintenance ChartMileage or time passed (whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional InspectionsInspect the CV joints. X X X X XInspect front suspension, tie rod ends, boot seals, and replace ifnecessary.
XXX X X X X
Inspect the brake linings, parking brake function. X X X X X X XAdditional MaintenanceReplace cabin/air conditioning filter. X X X X X X XClean and lube sun roof tracks. X X X X X X XReplace engine air filter. X X X X XReplace the spark plugs. ** X X X X XFlush and replace the engine coolant at 10 years or150,000 miles (240,000 km) whichever comes first.
XX
Inspect and replace PCV valve if necessary.
X
Replace the timing belt.
X
** The spark plug change interval is mileage based only, yearly intervals do not apply.
MAINTAINING YOUR VEHICLE
65

Underhood Fuses
•A second fuse panel is located on the drivers side of the engine compartment, next to
the battery. To access the fuses, press the release tabs and remove the cover.
• The ID number of the electrical component corresponding to each fuse can be
found on the back of the cover.
Cavity Maxi Fuse Mini Fuse Description
F01 60 Amp Blue Body Controller
F02 20 Amp Yellow Audio Amplifier
F03 20 Amp Yellow Ignition Switch
F04 40 Amp Orange Anti-Lock Brake Pump
F05 70 Amp Tan Electric Power Steering
F06 20 Amp Yellow Radiator Fan - Single Speed
F06 30 Amp Green Radiator Fan - Low Speed
F07 40 Amp Orange Radiator Fan - High Speed
F08 30 Amp Green Blower Motor
F09 10 Amp Red Powertrain
F10 10 Amp Red Horn
F11 15 Amp Blue Powertrain
F11 10 Amp Red Powertrain (Multiair – If Equipped)
F14 5 Amp Tan High beam (Shutter)
F15 15 Amp Blue Cigar Lighter
F16 7.5 Amp Brown Transmission
F17 25 Amp White Powertrain (Multiair – If Equipped)
F17 15 Amp Blue Powertrain
F18 15 Amp Blue Powertrain
F18 5 Amp Tan Powertrain (Multiair – If Equipped)
F19 7.5 Amp Brown Air Conditioning
F20 15 Amp Blue Heated Seats – If Equipped
F21 15 Amp Blue Fuel Pump
F23 20 Amp Yellow Anti-Lock Brake Valves
F24 7.5 Amp Brown Stability Control System
F30 15 Amp Blue Fog Lamps
F82 30 Amp Green Sunroof/Convertible Top
F84 10 Amp Red Transmission
F85 15 Amp Blue Rear Defroster, Heated Mirrors
F87 5 Amp Tan Lights
F90 5 Amp Tan Heated Mirrors
MAINTAINING YOUR VEHICLE
69

SUMMER/THREE-SEASON TIRES
• This vehicle may be equipped with wheels and tires to enhance traction in both
wet and dry conditions.
• Summer tires are not intended to be driven in snow or on ice.
• Use summer tires only in sets of four.
NOTE:
Summer tires will not contain the “all season” designation or mountain/snowflake
symbol on the sidewall of the tire.
WARNING!
Do not use summer tires in snow/ice conditions. You could lose control, resulting
in severe injury or death.
WHEEL AND WHEEL TRIM CARE
• All wheels and wheel trim, especially aluminum and chrome plated wheels,
should be cleaned regularly with a mild soap and water to prevent corrosion.
• To remove heavy soil and/or excessive brake dust, use a wheel cleaner or
equivalent or select a non-abrasive, non-acidic cleaner.
CAUTION!
Do not use scouring pads, steel wool, a bristle brush, or metal polishes. Do not
use oven cleaner. These products may damage the wheel's protective finish.
Avoid automatic car washes that use acidic solutions or harsh brushes that may
damage the wheel's protective finish.
MAINTAINING YOUR VEHICLE
71

Alarm (Security Alarm). . . . . . . . . . .9
Arming Theft System (Security Alarm) . . .9
Automatic Temperature Control (ATC) . .24
Automatic Transmission
Fluid Type. . . . . . . . . . . . . . .63
Belts, Seat. . . . . . . . . . . . . . . . .10
BLUE&ME™ Hands-Free
Communication. . . . . . . . . . . .34
Brake Fluid. . . . . . . . . . . . . . . . .63Break-In Recommendations, NewVehicle. . . . . . . . . . . . . . . . .17Bulb Replacement. . . . . . . . . . . . .72
Child Restraint. . . . . . . . . . . . . . .12Child Restraint Tether Anchors. . . . . .12Clock Setting. . . . . . . . . . . . . . . .33Cooling SystemCoolant Capacity. . . . . . . . . . .63Cruise Control (Speed Control). . . . . .21Cruise Light. . . . . . . . . . . . . . . .21Customer Assistance. . . . . . . . . . .73
Defects, Reporting. . . . . . . . . . . .74Disarming, Theft System. . . . . . . . . .9Driver Cockpit. . . . . . . . . . . . . . . .4
ElectronicsYour Vehicle's Sound System. . . .30Electronic Speed Control(Cruise Control). . . . . . . . . . . . .21Electronic Throttle Control WarningLight. . . . . . . . . . . . . . . . . . .45Electronic Vehicle InformationCenter (EVIC). . . . . . . . . . . . . .40Emergency, In Case ofBrake Warning Light . .. . . . . . .47Towing. . . . . . . . . . . . . . . . .57EngineBreak-In Recommendations. . . . .17Compartment. . . . . . . . . . . . .62Oil Selection. . . . . . . . . . . . . .63Overheating. . . . . . . . . . . . . .48Enhanced Accident ResponseFeature. . . . . . . . . . . . . . . . .57Event Data Recorder. . . . . . . . . . .60Exterior Lights. . . . . . . . . . . . . . .72
Flash-To-Pass .. . . . . . . . . . . . . .18Fluid Capacities . . . . . . .. . . . . . .63Fluids . . . . . .. . . . . . . . . . . . . .63Folding Rear Seat. . . . . . . . . . . . .15Freeing A Stuck Vehicle . . .. . . . . . .59FuelSpecifications. . . . . . . . . . . . .63Fuse. . . . . . . . . . . . . . . . . . . .68Fuses. . . . . . . . . . . . . . . . . . . .68
Hands-Free Communication —BLUE&ME™. . . . . . . . . . . . . .34Hood Release .. . . . . . . . . . . . . .61
Instrument Cluster Warning Lights . .6, 44Introduction. . . . . . . . . . . . . . . . .2iPod®/USB/MP3 Control. . . . . . . . .39
Key Fob . . . . . . . . . . . . . . . . . . .8
Lane Change Assist. . . . . . . . . . . .18Lap/Shoulder Belts . . . . .. . . . . . .10LATCH (Lower Anchors and Tether forCHildren) . . .. . . . . . . . . . . . .12LightsTurn Signal. . . . . . . . . . . . . .18Warning (Instrument ClusterDescription) . . .. . . . . . . . . . . .6
Maintenance Record. . . . . . . . . . .67Maintenance Schedule . . .. . . . . . .64Malfunction Indicator Light(Check Engine) . . . . . . . . . . . . .47Manual Transmission . . . .. . . . . . .25MOPAR® Accessories . .. . . . . . . .75
New Vehicle Break-In Period. . . . . . .17
Oil, EngineCapacity. . . . . . . . . . . . . . . .63OutletPower .. . . . . . . . . . . . . . . .42Overheating, Engine. . . . . . . . . . . .48
Placard, Tire and Loading Information . .70PowerOutlet (Auxiliary Electrical Outlet) . .42Programmable Electronic Features . . .40
INDEX
77