headlight bulb FIAT DUCATO 2012 Owner handbook (in English)

181
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
B
F0N0830mfig. 176
F0N0829mfig. 177
CHANGING A BULB
GENERAL INSTRUCTIONS
❒When a light is not working, check that the
corresponding fuse is intact before changing a bulb.
For the location of fuses, refer to the paragraph
“If a fuse blows” in this section;
❒before changing a bulb check the contacts for
oxidation;
❒burnt bulbs must be replaced by others of the same
type and power;
❒always check the height of the headlight beam after
changing a bulb for safety reasons. CYLINDER REPLACEMENT PROCEDURE
To replace the bottle, proceed as follows:
❒press button A-fig. 177 to release the replacement
part;
❒fit the new cylinder and press until it is automatically
engaged.
Halogen bulbs must be handled holding
the metallic part only. Touching the
transparent part of the bulb with your
fingers may reduce the intensity of the light
emitted and even compromise the life of the bulb
itself. In the event of accidental contact, rub the
bulb with a cloth dampened with alcohol and let
it dry.

182
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0078mfig. 178
Changes or repairs to the electrical
system (electric control units) carried
out incorrectly and without due consideration
for the technical specifications of the system
can lead to malfunctioning and generate a fire
hazard.
WARNING
Halogen lamps contain gas under
pressure. Their breaking can cause
scattering of glass fragments.
WARNING
C Tubular bulbs: release them from their contacts to
remove.
D-E Halogen bulbs: to remove the bulb, release the clip
holding the bulb in place.
IMPORTANT The headlight inner surface might be
slightly misted: this should not be considered irregular
rather a natural phenomenon due to low temperature
and the air humidity level. Misting will disappear as soon
as the headlights are turned on. The presence of drops
inside the headlights indicates infiltration of water.
Contact a Fiat Dealership.
BULB TYPES fig. 178
Various types of bulbs are fitted to your vehicle.
A Glass bulbs: clipped into position. Pull to extract.
B Bayonet type bulbs: to remove this type of bulb from
its holder, press the bulb and turn it anticlockwise.

184
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0079mfig. 179F0N0080mfig. 180
To replace the main beam bulb/daytime lights, remove
plug C-fig. 180.
To replace the dipped beam/side light bulb, remove plug
B-fig. 180.
To replace the direction indicator bulb, remove bulb
holder A-fig. 180.
After replacement, refit the covers correctly, ensuring
that they are locked in place.REPLACING EXTERIOR BULBS
For the type of bulb and power rating, see “Changing
a bulb”.
FRONT LIGHT CLUSTERS
The front light clusters contain sidelights, dipped beam,
main beam and direction indicator bulbs.
The bulbs are arranged inside the light cluster as
follows, fig. 179:
A direction indicators
B side lights/dipped beams (double light)
C main beam headlights/daytime lights

185
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0082mfig. 181F0N0083mfig. 182
❒release the bulb holding clip B;
❒remove the bulb C and replace it;
❒fit the new bulb, ensuring that the outline of the
metal part coincides with the grooves on the curve
of the headlight. Then reconnect the bulb holder clip
A and reattach electrical connector B;
❒refit protective cover C-fig. 180 by turning it
clockwise, making sure to lock it correctly.
MAIN BEAMS/DAYTIME LIGHTS
(for versions/markets where provided)
To change the bulb, proceed as follows:
❒remove the protection cover C-fig. 180 by turning
counter-clockwise;
❒disconnect the electrical connector A-fig. 183; SIDE LIGHTS
To change the bulb, proceed as follows:
❒remove protective cover B-fig. 180 by turning
anticlockwise;
❒remove snap-fitted bulb holder A-fig. 181, remove
the bulb B and replace it;
❒refit the snap-fitted bulb holder A-fig. 181;
❒refit protective cover B-fig. 180 by turning it
clockwise, making sure to lock it correctly.
MAIN BEAM HEADLIGHTS
To change the bulb, proceed as follows:
❒remove protective cover C-fig. 180 by turning it
anticlockwise;
❒disconnect the electrical connector A-fig. 182;

186
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
❒rotate the bulb holder B-fig. 183 counter-clockwise
and take out the unit;
❒remove the bulb C and replace it;
❒refit the bulb holder B and rotate it clockwise to
lock;
❒reconnect the electrical connector A;
❒refit the protective cover by turning it clockwise
making sure to lock it correctly.DIPPED BEAM HEADLIGHTS
With incandescent bulbs
To change the bulb, proceed as follows:
❒remove protective cover B-fig. 180 by turning it
anticlockwise;
❒disconnect the electrical connector A-fig. 184;
❒release the bulb holding clip B;
❒remove the bulb C and replace it;
❒fit the new bulb, ensuring that the outline of the
metal part coincides with the grooves on the curve
of the headlight. Then reconnect the bulb holder clip
B and reattach electrical connector A;
❒refit the protective cover by turning it clockwise
making sure to lock it correctly;
F0N0084mfig. 184F0N0517mfig. 183

188
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
❒release the bulb holding clip;
❒remove the bulb and replace it;
❒fit the new bulb, ensuring that the outline of the
metal part coincides with the grooves on the curve
of the headlight. Then reconnect the bulb holder clip
and reattach the electrical connector;
❒refit the bayonet cap. FRONT FOG LIGHTS
(for versions/markets, where provided)
To replace the front fog light bulbs A-fig. 188 proceed as
follows:
❒steer fully to the left;
❒open the flap on the front wheel compartment
guard, unscrewing the self-tapping screw;
❒remove the bayonet cap;
❒disconnect the connector;
F0N0170mfig. 187F0N0339mfig. 188

275
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– jump starting ....................... 169
– maintenance ........................ 218
– recharging ............................ 202
– replacement ........................ 218
– tips for extending life ........ 219
Body (marking) ......................... 228
Body
– maintenance ........................ 224
– version code ....................... 229
Bonnet ........................................ 104
Brake Assist (emergency
braking assistance) ................. 110
Brakes
– fluid level .............................. 215
– technical specifications ...... 232
Bulb replacement ..................... 181
– bulb types ....................182-183
– external bulb
replacement ............................ 184
– general information ........... 181
– internal bulb replacement .. 193Cab glove compartment
(Capucine) ............................... 91
Carrying children safely .......... 130
Carrying children safely .......... 130
– “Universal Isofix” child
restraint assembly setup ...... 134
– child seats ............................ 130
– positioning of child seats on
seats ..............................133-136
Ceiling lights .............................. 76
– bulb replacement ....... 193-194
Central door
locking/unlocking system ..... 96
Chassis (marking) .................... 229
Checking the levels ................. 209
Checking the levels ................. 209
– brake fluid ............................ 215
– brake fluid ............................ 216
– engine coolant .................... 213
– engine oil ............................. 211ABS SYSTEM ............................ 108
ABS .............................................. 108
Accessories purchased
by the owner .......................... 121
Additional heater ..................... 60
Additional rear heating ........... 66
Additional independent
heater ....................................... 61
Additional rear air
conditioning ............................ 67
Air filter ..................................... 217
Arm rests.................................... 33
Ashtray ........................................ 88
ASR .............................................. 112
Automatic climate control ..... 54
Automatic headlight sensor
(dusk sensor) .......................... 70
Battery
– battery disconnection
function (disconnector) .... 80
INDEX

276
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– washer fluid for
windscreen/rear
window/headlamps ............ 214
Cigar lighter .............................. 88
Cleaning and maintenance
– bodywork ............................ 223
– engine compartment .......... 225
– front headlights .................... 225
– glasses ................................... 225
– interiors ............................... 225
– leather upholstery .............226
– paintwork ............................ 224
– plastic parts .......................... 226
– rubber tubes ....................... 221
– seats and fabric parts ........ 226
– windows ................................ 225
CO
2emissions........................... 268
Instrument panel .................... 14
Code card................................... 5
Compartment under front
passenger seat ........................ 86
Compartment under the seat .. 36
Controls .................................... 79Cruise Control (constant speed
regulation) ............................... 74
Cruise Control (constant speed
regulator) ................................ 74
Cup/can holder ........................ 87
Dashboard ................................ 3
Daytime lights
– bulb replacement ............... 186
– control ................................. 68
Dead lock (device) .................. 99
Desk/bookrest........................... 90
Dimensions ............................... 237
Dipped beam headlights
– bulb replacement ............... 186
– control ................................. 68
Dipped headlights
– bulb replacement ............... 186
– control................................... 74
Direction indicators
– bulb replacement ....... 187-189
– control ................................. 69Direction indicators
– control ................................. 69
– front bulb replacement ..... 187
– rear bulb replacement ...... 189
Door lock .................................. 81
Door pockets ........................... 86
Doors ......................................... 96
DPF (diesel particulate filter).... 124
DPF (diesel particulate filter).... 124
EBD system .............................. 108
Electric windows ...................... 103
Electrical power supply and fuel
cut off switch .......................... 82
Electrical/electronic devices
(installation) ............................ 121
Electronic alarm ....................... 10
Engine codes ............................. 228
Engine compartment
– bonnet opening/closing ..... 104
– checking the levels ............. 209
– washing.................................. 225
Engine coolant fluid
– checking the level ............... 214

277
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Fluids and lubricants
(quantity and products) 263-264
Fog lights
– alignment ............................. 108
– bulb replacement ............... 188
– control ................................. 79
Follow Me Home (device) ..... 70
Front air bags ............................ 137
Fuel consumption
– engine oil ............................. 212
– fuel ........................................ 266
Fuel flap ...................................... 124
Fuel level gauge ........................ 16
Fuel reserve .............................. 155
Fuel tank cap ............................. 123
Fuel
– consumption ....................... 264
– electricity supply and fuel
cut off switch........................ 82
– fuel cap ................................. 123
– fuel level gauge ................... 16
– saving .................................... 148
Fuses (if a fuse blows) .............195
– fuse list ................................. 198– fuses (if a fuse blows) ........ 195
– general information ........... 195
– location (fuse boxes) ......... 196
– users list ............................... 198
Gearbox
– using the manual gearbox ... 146
General warnings...................... 2
Glove compartment ................ 85
Handbrake ................................ 145
Handbrake lever ...................... 145
Hazard warning lights ............. 79
Head restraints ........................ 40
Headlight alignment
correction ............................... 107
Headlight washers
– control................................... 73
– maintenance ........................ 223
Headlights .................................. 107
– adjusting headlights
abroad .................................. 108
– beam orientation................. 107
– bulb replacement ............... 184 – temperature gauge ............ 16
Engine coolant temperature
gauge ........................................ 16
Engine oil gauge ......................... 17
Engine oil
– checking the level ............... 211
– engine oil gauge .................. 17
– oil consumption ................. 214
– technical specifications ...... 264
Engine
– bonnet .................................. 104
– identification code ............. 229
– marking ................................ 228
– specifications ....................... 230
Environment (protecting) ...... 124
EOBD system ........................... 115
ESP system ................................ 110
External lights ........................... 68
Fiat CODE system .................. 4
Fix & Go automatic (quick tyre
repair kit) ................................ 176
Flashing the headlights ............ 69

278
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– headlight alignment
corrector ............................. 107
Headlights (warning
for cleaning) ............................ 225
Heated rear window ............... 80
Heating and ventilation ...........45
– automatic climate control ... 54
– controls ................................ 46
– front window rapid
defrosting/demisting ...48-51-59
– heated rear window and
external rear view mirrors
defrosting/demisting .... 48-53
– interior air recirculation ... 49
– manual climate control ..... 49
– passenger compartment
air vents ............................... 46
Heavy use of the vehicle
(servicing) ................................ 208
Hill Holder system .................. 111
Identification plates ................. 227
– body paintwork .................. 228
– identification data ............... 227Ignition switch .......................... 12
– steering lock ........................ 13
In an emergency ....................... 169
Installation of electrical/
electronic devices .................. 121
Installing the tow hook ........... 151
– assembly diagrams....... 153-154
Interior fittings ......................... 84
Interiors (maintenance) .......... 225
“Isofix” child seat ..................... 134
Keys ........................................... 5
– Code card ........................... 5
– key with remote control .. 6
– key without remote
control ................................. 8
– replacing the battery ......... 8
Knowing your car .................... 3
Light clusters
– front (bulb replacement) .. 184
– rear (bulb replacement) ... 189
Load (warnings) ....................... 147
Load advice................................ 147Load compartment button .... 108
Load limiters ............................. 127
Lubricants (quantity and
products) .........................263-264
Main beam headlights
– bulb replacement ............... 185
– control ................................. 68
Main beam headlights
– bulb replacement ............... 185
– control ................................. 68
– flashing the headlights ....... 69
Maintenance and care ............. 205
– regular checks ..................... 208
– Scheduled servicing ........... 205
– Scheduled Servicing
Plan ...................................206-207
–Heavy use of the vehicle .... 208
Manual climate control ........... 49
Moving platform........................ 101
MSR (system) ............................ 112
MSR system................................ 112
Multifunction display ............... 18