tow FIAT FIORINO 2017 Owner handbook (in English)

Thousands of kilometres 30 60 90 120 150 180
Years 2 4 6 8 10 12
Replace the toothed timing drive belt
(3)
Replace accessory drive belt/s(3)
Replace air cleaner cartridge(4)●●●●●●
Change the brake fluid
(5)
Replace the passenger compartment cleaner(4)●●●●●●
(3) Areas that are not dusty: recommended maximum mileage 120,000 km. The belt must be replaced every 6 years, regardless of
distance travelled. Dusty areas and/or demanding use of the car (cold climates, town use, long periods of idling): advised maximum
mileage 60,000 km. The belt must be replaced every 4 years, regardless of distance travelled.
(4) If the vehicle is used in dusty areas, this cleaner must be replaced every 15,000 km.
(5) The brake fluid replacement has to be done every two years, irrespective of the mileage.
193
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Thousands of kilometres 35 70 105 140 175
Years 2 4 6 8 10
Check cleanliness of sliding side door lower guides (or every 6 months)●●●●●
Check handbrake lever travel and adjust, if necessary●●●●●
Check condition and wear of front disc brake pads and operation of pad
wear indicator●●●●●
Check rear drum brake lining condition and wear●●
Visually inspect condition of the accessory drive belt(s)●●
Check mechanical gearbox fluid●
Change engine oil and replace oil filter (versions with DPF)
(2)
Replace accessory drive belt/s(3)
Replace fuel filter cartridge(4)●●
Replace air cleaner cartridge●●●●●
Change the brake fluid
(5)
Replace the passenger compartment cleaner●●●●●
(2) The actual interval for changing the engine oil and replacing the engine oil filter depends on the vehicle usage conditions and is
signalled by the warning light or message (if present) in the instrument panel (see chapter "Warning lights and messages"). In any
case, it must never exceed 24 months. Change engine oil and filter every 12 months if the vehicle is driven mainly in towns.
(3) Areas that are not dusty: recommended maximum mileage 120,000 km. The belt must be replaced every 6 years, regardless of
distance travelled. Dusty areas and/or demanding use of the car (cold climates, town use, long periods of idling): advised maximum
mileage 60,000 km. The belt must be replaced every 4 years, regardless of distance travelled.
(4) If the vehicle runs on fuel with quality below the relevant European specification, this filter must be replaced every 35,000 km
(5) The brake fluid replacement has to be done every two years, irrespective of the mileage.
195
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

REGULAR CHECKS
Every 1,000 km or before long journeys, check and, if
necessary, top up the following:
engine coolant level;
brake fluid level;
windscreen washer fluid level;
tyre inflation pressure and condition;
operation of lighting system (headlamps, direction
indicators, hazard warning lights, etc.);
operation of screen wash/wipe system and
positioning/wear of windscreen/rear window
wiper blades.
Check and top up, if required, the engine oil level
every 3,000 km.
HEAVY USAGE OF THE VEHICLE
If the vehicle is used mainly under one of the
following conditions:
towing a trailer or caravan;
dusty roads;
short, repeated journeys (less than 7-8 km) at
sub-zero outside temperatures;
engine often idling or driving long distances at low
speeds or long periods of inactivity;
the following checks must be carried out more often
than indicated in the Scheduled Servicing Plan:
check front disc brake pad condition and wear;
check cleanliness of bonnet and boot locks,
cleanliness and lubrication of linkage;
visually inspect the conditions of: engine, gearbox,
transmission, pipes and hoses (exhaust/fuel
supply/brakes), rubber parts (boots/sleeves/
bushes, etc.);
check battery charge and battery fluid level
(electrolyte);
visually inspect condition of the auxiliary drive
belts;
check and, if necessary, change engine oil and
replace oil filter;
check and, if necessary, replace pollen filter;
check and, if necessary, replace air filter.
196
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

WEIGHTS
Weights (kg)1.4 Euro 6
Cargo "Minimum" versions Cargo "Maximum" versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1070 1160
Payload including the driver: 610 520
Payload excluding the driver: 535 445
Maximum permitted loads
(**)
- front axle: 900 900
– rear axle: 950 950
- total: 1680 1680
Towable loads
- braked trailer: 600 600
- non-braked trailer: 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100
Maximum load on ball joint (braked
trailer):60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
232
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.3 16V Multijet 80HP Euro 6 1.3 16V Multijet 95 HP Euro 6
Cargo
"Minimum"
versionsCargo
"Maximum"
versionsCargo
"Minimum"
versionsCargo
"Maximum"
versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1090 1180 1090 1180
Payload including the driver: 610 520 610 520
Payload excluding the driver: 535 445 535 445
Maximum permitted loads
(**)
- front axle: 900 900 900 900
– rear axle: 950 950 950 950
- total: 1700 1700 1700 1700
Towable loads
- braked trailer: 1000 1000 1000 1000
- non-braked trailer: 400 400 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100 100 100
Maximum load on ball joint (braked
trailer):60 60 60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
233
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.4 Euro 6
Cargo "Minimum" PTT 1500
versionsCargo "Maximum" PTT 1500
versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1070 1160
Payload including the driver: 430 340
Payload excluding the driver: 355 265
Maximum permitted loads
(**)
- front axle: 900 900
– rear axle: 950 950
- total: 1500 1500
Towable loads
- braked trailer: 600 600
- non-braked trailer: 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100
Maximum load on ball joint (braked
trailer):60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
234
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.3 16V Multijet 80 HP Euro 6 1.3 16V Multijet 95 HP
Cargo
"Minimum"
PTT 1500
versionsCargo
"Maximum"
PTT 1500
versionsCargo
"Minimum"
PTT 1500
versionsCargo
"Maximum"
PTT 1500
versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1090 1180 1090 1180
Payload including the driver: 410 320 410 320
Payload excluding the driver: 335 245 335 245
Maximum permitted loads
(**)
- front axle: 900 900 900 900
– rear axle: 950 950 950 950
- total: 1500 1500 1500 1500
Towable loads
- braked trailer: 1000 1000 1000 1000
- non-braked trailer: 400 400 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100 100 100
Maximum load on ball joint (braked
trailer):60 60 60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
235
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.3 16V Multijet 80HP Euro 6 1.3 16V Multijet 95 HP Euro 6
Cargo
"Minimum"
PTT 1750
versionsCargo
"Maximum"
PTT 1750
versionsCargo
"Minimum"
PTT 1750
versionsCargo
"Maximum"
PTT 1750
versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1090 1180 1090 1180
Payload including the driver: 660 570 660 570
Payload excluding the driver: 585 495 585 495
Maximum permitted loads
(**)
- front axle: 900 900 900 900
– rear axle: 950 950 950 950
- total: 1750 1750 1750 1750
Towable loads
- braked trailer: 1000 1000 1000 1000
- non-braked trailer: 400 400 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100 100 100
Maximum load on ball joint (braked
trailer):60 60 60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
236
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.4 Euro 6
Combi N1 "Minimum"
versions (4 seats)Combi N1
"Maximum"
versions (4 seats)Combi M1
versions (5 seats)
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1170 1255 1165
Payload including the driver: 565 480 515
Payload excluding the driver: 490 405 445
Maximum permitted loads
(**)
- front axle: 950 950 950
– rear axle: 980 980 950
- total: 1735 1735 1680
Towable loads
- braked trailer: 600 600 600
- non-braked trailer: 400 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100 100
Maximum load on ball joint (braked
trailer):60 60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
CATEGORY M1: optional equipment is included in the capacity.
237
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Weights (kg)1.3 16V Multijet 80 HP Euro 6
Combi N1
"Minimum" versions
(4 seats)Combi N1
"Maximum" versions
(4 seats)Combi M1 versions
(5 seats)
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1190 1275 1185
Payload including the driver: 565 480 515
Payload excluding the driver: 490 405 445
Maximum permitted loads
(**)
- front axle: 950 950 950
– rear axle: 950 950 950
- total: 1755 1755 1700
Towable loads
- braked trailer: 1000 1000 1000
- non-braked trailer: 400 400 400
Maximum load on the roof (with roof
rack bars):
(***)100 100 100
Maximum load on ball joint (braked
trailer):60 60 60
(**)Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load platform within
the maximum permitted loads.
(***)Including the weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NOTE Adventure versions have the same capacities as the other versions.
CATEGORY M1: optional equipment is included in the capacity.
238
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX