wiper FIAT PANDA 2009 169 / 2.G User Guide

185KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
WINDSCREEN/REAR WINDOW
WIPER/WASHERBLADES
Periodically clean the rubber part using special products;
TUTELA PROFESSIONAL SC 35 is recommended.
Replace the blades if the rubber edge is deformed or worn.
In all cases, it is advisable to replace them approximately once
a year.
A few simple precautions can reduce the possibility of dam-
age to the blades:❒
make sure that the rubber part is not stuck to the wind-
screen at sub-zero temperatures. Use an antifreeze
product to release it if required;
❒
remove any snow from the glass: in addition to pro-
tecting the blades, this prevents effort on the motor
and overheating;
❒
do not operate the windscreen and the rear screen
wipers on dry glass.
RUBBER HOSESAs far as the brake system and fuel rubber hoses are concerned,
follow the “Scheduled Servicing Programme” in this chapter care-
fully.
Ozone, high temperatures and prolonged lack of fluid in the sys-
tem may cause hardening and cracking of the hoses, with pos-
sible leaks. Careful control is therefore necessary.
Driving with worn wiper blades is a serious
hazard, because visibility is reduced in bad
weather.
WARNING
169-190 PANDA EN 7-10-2009 14:15 Pagina 185

186KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0218m
fig. 186
F0G0077m
fig. 187
Changing the rear window wiper blade fig. 187
Proceed as follows:❒
raise the cover A and remove the arm from the car,
slackening the nut B that fastens it to the pivot pin;
❒
position the new arm correctly and tighten the nut;
❒
lower the cover. Changing the windscreen wiper blades fig. 186
Proceed as follows:
❒
lift the arm A of the wiper and position the blade so that
it forms an angle of 90° with the arm;
❒
press tab B of the coupling spring and remove the blade
to be replaced from the arm A;
❒
fit the new blade by inserting the tab into the special
slot in the arm. Make sure it is properly locked into
place.
169-190 PANDA EN 7-10-2009 14:15 Pagina 186

Front
mechanicalgear-box
and differentials
Rear differential
4×4 versions
Wheel side
constant velocity
joints
Differential side
constant velocity
joints
Hydraulic brakes
and hydraulic
clutch controls
Cooling circuits Util-
isation percentage:
50% water
50% PARAFLU
UP
To be mixed with
diesel (25 cc per
10 litres)
To be used undiluted
or diluted in wind-
screen/rear window
washer/ wiper systems
Synthetic lubricant, SAE 75W-85 grade.
FIAT 9.55550-MX3specifications
Synthetic lubricant, SAE 75W-85 grade.
FIAT 9.55550-DA4specifications
Molybdenum disulphide grease for high tempera-
tures. Consistency NLGI 1-2 FIAT 9.55580speci-
fications
Polyurea based synthetic grease for high tempera-
tures. Consistency NLGI 2. FIAT 9.55580specifi-
cations
Synthetic fluid for brake and clutch systems. It pass-
es the specifications: FMVSS no. 116 DOT 4,
ISO 4925, SAE J 1704. FIAT 9.55597 specifications
Red protective agent with antifreeze action, based
on inhibited monoethylene glycol with organic for-
mula. It passes CUNA NC 956-16, ASTM D 3306
specifications. FIAT 9.55523specifications
Antifreeze additive for diesel fuel, protecting
Diesel engines
Mixture of alcohol and surfactants
CUNA NC 956-11. FIAT 9.55522specifications
TUTELA CAR
TECHNYX Contractual Technical
Reference no. F010.B05TUTELA CAR
CROSS Contractual Technical
Reference no. F804.D08TUTELA ALL
STARContractual Technical
Reference no. F702.G07TUTELA STAR
325Contractual Technical
Reference no. F301.D03TUTELA TOP 4Contractual Technical
Reference no. F001.A93PARAFLU
UP
Contractual Technical
Reference no. F101.M01TUTELA DIESEL
ARTContractual Technical
Reference no. F601.L06TUTELA PROFES-
SIONAL SC 35Contractual Technical
Reference no. F201.D02
Use Quality specifications of fluids and lubricants Fluids and lubricants Applications
for correct car operation recommended
Lubricants and
greases for drive transmission
systemBrake fluidProtective agent
for radiatorsFuel additiveWindscreen/
rear screen
washer fluidIMPORTANT Do not use fluids with different specifications for topping-up or mixing
205KNOW
YOUR VEHICLE
SAFETY
CORRECT USE OF THE
CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX
191-214 PANDA EN 7-10-2009 14:18 Pagina 205

221KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
– passenger compartment
ventilation and heating ......... 42
– system servicing ..................... 43
– windscreen and front side
window demisting/
defrosting ................................ 42
Mirror adjustment ....................... 36
MSR (system) ................................ 78
MSR system ................................... 78
Multifunction display ................... 17
– control buttons ...................... 19
– setup menu ............................. 20
– standard screen ..................... 17N
umber plate lights
– bulb replacement ................... 156
O
n board instruments (panel) .. 14
Paint (maintenance) ................... 188
– bodywork colour plate ........ 192
Paraflu
– level check and top-up ......... 177
– specifications .......................... 205Parking (sensors) ......................... 82
Parking lights ................................. 48
Parking sensors ............................ 82
Parking the vehicle ...................... 113
Passenger compartment light
adjustment .................................. 52
Performance ................................. 201
Pollen filter .................................... 181
Power sun roof ............................ 58
– opening/closing ...................... 59
Power windows ........................... 63
Preparation for child seats ........ 103
Q
uality specifications of fluid
and lubricants ................... 204-205
Radio transmitters and mobile
phones ......................................... 87
Radio transmitters and mobile
phones ......................................... 87
Rear door locking
emergency device ..................... 62
Rear fog light
– bulb replacement ................... 155– switching on ............................ 54
Rear fog lights ............................... 54
Rear fog lights
– bulb adjustment ..................... 156
– switching on ............................ 54
Rear light units
– bulb replacement ................... 155
Rear seats
– cleaning .................................... 190
– headrests ................................. 32
Rear view mirrors
– inside ........................................ 35
– outside ..................................... 36
Rear window washer ................... 51
– fluid level check
and top-up ............................... 178
– jet .............................................. 187
– operation ................................. 51
Rear window wiper
– blade replacement .................. 186
– operation .................................. 51
– rear window washer fluid
features ..................................... 179
215-224 PANDA EN 7-10-2009 15:09 Pagina 221

Reconfigurable multifunction
display .......................................... 19
– control buttons ...................... 19
– set up menu ............................ 20
– standard screen ..................... 19
Refuelling
– diesel engines ......................... 88
– petrol engines ......................... 87
– technical specifications
(quantity) ................................. 203
Remote control ........................... 7
– additional remote control ... 8
– battery replacement ............. 9
– remote door opening/
closing ...................................... 8
– tailgate opening ...................... 8
Replacing the battery of
the key with remote control .. 9
Rev counter .................................. 14
Reversing light
– bulb replacement ................... 155
Reversing light
– bulb replacement ................... 156Roof rack – ski rack
(preparation) .............................. 71
Roof rack bar fasteners .............. 71
Roof rack/ski-rack bars
(preparation) .............................. 71
Rubber pipes ................................. 185
Safety........................................... 91
Safety belts .................................... 91
– carrying children safely ........ 98
– general instructions .............. 95
– load limiters ............................ 95
– pretensioners ......................... 94
– SBR ........................................... 91
– seat belt height
adjustment .............................. 92
– seat belt maintenance ........... 97
– using the seat belts ............. 91-93
SBR system .................................... 91
Scheduled servicing ..................... 172
Scheduled Servicing
Programme ......................... 170-171
Seat adjustment ...................... 31-32Seat belt pretensioners .............. 94
– load limiters ............................ 95
Side air bags
(side bag - window bag) ........... 107
– general warnings .................... 109
Side light
– front bulb replacement ........ 152
– rear bulb replacement .......... 155
– switching on ............................ 48
Smart washing
(windscreen wiper) ................... 50
Snow chains ..................................
Sound system
(preparation system) ................ 84
Sound system presetting ............ 84
Space-saver wheel ....................... 137
– technical specifications ......... 199
Spark plugs (type) ........................ 194
Speedometer ................................ 14
Steering column lock .................. 10
Steering wheel adjustment ........ 34
Steering wheel levers .............. 48-50
Steering wheel
– adjustment lever .................... 34
222KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
215-224 PANDA EN 7-10-2009 15:09 Pagina 222

Wheels and tyres.......................... 183
– tyre and wheel types ............ 199
– tyre inflation pressure .......... 199
– wheel replacement ................ 137
– winter tyres ............................ 122
Window winders ......................... 64
Windows
– cleaning .................................... 50
Windows
– washing .................................... 50
– windscreen washer fluid
(specifications) ....................... 205
Windscreen washer
– fluid level check
and top-up ............................... 178
– jets ............................................ 187
– operation ................................. 50
– smart washing function ........ 50– windscreen washer fluid
specifications .......................... 205
Windscreen wiper blades
– replacement ............................ 186
Windscreen/rear window
washer fluid
– specifications .......................... 205
– level check and top-up ......... 178
Windscreen
– blade replacement ................. 186
– jet .............................................. 187
– operation ................................. 50
– windscreen washer
fluid features ............................... 179
Winter period
– snow chains ............................ 122
– winter tyres ............................ 122
Fiat Group Automobiles S. p. A.
Customer Services – Technical Services – Service Engineering
Largo Senatore G. Agnelli, 5 – 10040 Volvera – Torino (Italia)
Stampato n. 603.81.649 – 10/2009 – 1 edizione
224KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
215-224 PANDA EN 7-10-2009 15:09 Pagina 224