transmission GMC YUKON DENALI 2003 Service Manual

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key
to LOCK in each shift lever position.
0 The key should turn to LOCK only when the
The key should come out only in LOCK.
shift
lever is in PARK (P).
Parking Brake and Automatic
Transmission Park
(P) Mechanism
Check
WI..,.J you are doin, ,his cl.,:k, your --hide
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front
of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transmission in NEUTRAL
(N), slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
0 To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-1 3

Part D: Recommended Fluids and
Lubricants
Flyids and lubricants identified below by mme,
part number or specification may be obtained from
your dealer.
Usage
Engine Oil
Engine Coolant
Hydraulic Brake
System
Windshield
Washer Solvent
Fluid/Lubricant
Engine oil with the American
Petroleum Institute Certified for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see Engine
Oil on
page
5- 13.
50/50 mixture of clean, drinkable
water and use only
DEX-COOL@Coolant. See Engine
Coolant on page
5-22.
Delco Supreme 1 l@ Brake Fluid or
equivalent
DOT-3 brake fluid.
GM Optikleen@Washer Solvent or
equivalent.
Usage
Power Steering System
Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
Front and
Rear Axle
Transfer Case
Fluid/Lubricant
GM Power Steering Fluid (GM Part No.
U.S. 1052884, in Canada
993294, or equivalent).
DEXRON@-Ill Automatic
Transmission Fluid.
Mulit-Purpose Lubricant, Superlube
(GM Part No.
U.S. 12346241 , in
Canada 10953474, or equivalent).
Chassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGl
#2,
Category LB or GC-LB.
SAE 75W-90 Synthetic Axle Lubricant (GM Part
No. U.S.
12378261, in Canada 10953455) or
equivalent meeting GM Specification
99861
15.
DEXRON@-Ill Automatic
Transmission Fluid.
6-1 5

Reporting Safety Defects to General
Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you’ll notify us.
Please call us at
1 -800-GMC-8782 (1 -800-462-8782),
or write:
Pontiac-GMC Customer Assistance Center
P.O. Box 33172
Detroit,
MI 48232-51 72
In Canada, please call us at 1-800-263-3777 (Englishj
or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1
H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL
SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case
Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments, and specifications for GM
transmissions, transaxles, and transfer cases.
RETAIL
SELL PRICE: $50.00
7-1 0

Automatic Headlamp System ............................ 3-1 4
Automatic Level Control
................................... 4-46
Automatic Transmission Fluid
.......................................................... 5-20
Operation
................................................... 2-22
Automatic Transmission Check
.......................... 6-1 1
Automatic Transmission Shift Lock Control
System Check
............................................. 6-12
AutorideTM
................................................. 4-46
B
Backing Up .................................................... 4-54
Battery
.......................................................... 5-39
Battery Replacement
......................................... 2-6
Battery Run-Down Protection
............................ 3-1 7
Before You Drive
............................................ 3-72
Bench Seat
.................................................... 1-17
Bench Seat Split (50/50)
.................................. 1-1 1
Bench Seat, Split (60/40)
................................... 1-9
Body Lubrication Service
.................................. 6-12
Brake
Parking
...................................................... 2-25
System Inspection
....................................... 6-1 4
BATTERY NOT
CHARGING
............................. 3-54
Before Leaving on a Long Trip
......................... 4-34
System Warning Light
.................................. 3-34
Brake
Brake
Brake
2 Adjustment
............................................ 5-39
Fluid
.................................................... 5-36
Pedal. Throttle
....................................... 2-20 Brake Pedal Travel
......................................... 5-39
Brake Wear
................................................... 5-38
Brakes
.......................................................... 5-36
Braking
........................................................... 4-6
Braking in Emergencies
..................................... 4-8
Break-in, New Vehicle
..................................... 2-18
Bucket Seats, Rear
......................................... 1-22
Bulb Replacement
........................................... 5-49
Center High-Mounted Stoplamp (CHMSL)
........ 5-52
Front Turn Signal, Sidemarker and Daytime
Halogen Bulbs
............................................ 5-49
Headlamps
................................................. 5-49
Replacement Bulbs
...................... ........ 5-53
Taillamps
........................................ .... 5-52
Buying New Tires
....................................... 5-58
Running Lamps
........................................ 5-50
C
California Fuel ................................. .......... 5-6
Canada
........................................................... 7-4
Canadian Owners
................................................ ii
Canadian Roadside Assistance ........................... 7-7
Capacities and Specifications ............................ 5-96
Carbon Monoxide
................... 4-37, 4-47, 2.13, 2-29
Care
of
Safety Belts ............................. .... 5-80
Care
of Your
Cassette Tape Player
............................... 3-87
CD and DVD Player .................................... 3-89

Exit Lighting ........................................ 3-16
Extender, Safety Belt
....................................... 1-47
Exterior Lamps
......................... ~ ~ ................ 3-1 3
FabricKarpet
...
Engine Air Cleaner ..............................
Finding a P TY Station (RDS and XMTM) .....
Filter
Finding a Station
....................................
F
....
Finish Care
Finish Damage
................................
Fixed Mast Antenna .........................
Flash-to-Pass ...................................
Flat Tire .........................................
Flat Tire, Changing ..........................
Fluid
Automatic Transmission
.................
Power Steering ............................
Windshield Washer .......................
-
.....................................
..
.....
...
.... 5-78
.... 5-17
.... 3-63
.... 3-61
.... 5-81
.... 5-83
.... 3-89
...... 3-8
.... 5-63
............. 5-63
.......... 5-20
.......... 5-34
.......... 5-34
FM Stereo
..................................................... 3-87
Fog Lamps
.................................................... 3-1 5
Folding the Seatback ....................................... 1-17
Folding the Seatbacks
............................. 1-12, 1-22
Folding the Seatbacks (60/40 Split Bench Seat) .... 1-9
Following Distance
.......................................... 4-53
Footnotes
........................................ ......... 6-5
Front Axle
.................................... ... 5-47 Frontal
Air Bags
...................................... 1-77
Fuel
............................................................... 5-5
Additives ...................................................... 5-6
California Fuel
.............................................. 5-6
Filling Your Tank
........................................... 5-7
Fuels in Foreign Countries
.......................... 5-6
Gasoline Octane
....................................... 5-5
Gasoline Specifications .................................. 5-5
System Inspection ....................................... 6-14
Filling
a Portable Fuel Container
..................... 5-9
Gage
............................. .................... 3-42
Low Warning Light
....................................... 3-42
Fuel Information Button
.................................... 3-45
FUEL LEVEL LOW
......................................... 3-55
Fuses
Fuses and Circuit Breakers
........................... 5-87
Windshield Wiper
......................................... 5-87
G
Gage
Engine Coolant Temperature
............. .... 3-36
Fuel
...................................................... 3-42
Oil Pressure
........................................... 3-40
Speedometer
.......................................... 3-30
Tachometer
............................................. 3-30
Transmission Temperature
......................... 3-37
Voltmeter Gage ....................................... 3-34
Garage Door Opener
....................................... 2-38
6

Gasoline Octane
........................................................ 5-5
Gate Operator and Canadian Programming ........ 2-40
Glass surfaces 3-o~
Glove Box ..................................................... 2-42
GM Mobility Program for Persons with
Disabilities
................................... 7-5
Specifications ............................................... 5-5
rn r nn ...............................................
H
Hazard Warning Flashers ............................... 3-5
Head Restraints
........................................... 1-6
Headlamp High/Low-Beam Changer
.................... 3-8
Headlamps
.................................................... 5-49
Bulb Replacement
....................................... 5-49
Front Turn Signal, Sidemarker and Daytime
Running Lamps
........................................ 5-50
Halogen Bulbs ............................................ 5-49
Headphones
................................................... 3-77
Heated Seats
................................................... 1-4
Heating
......................................................... 3-23
Highway Hypnosis
........................................... 4-35
Hill and Mountain Roads
.................................. 4-35
Hitches
.......................................................... 4-52
HomeLink Transmitter, Programming
.................. 2-38
HomeLinkO Transmitter
............................ 2-38
Hood Checking Things Under
................................ 5-10
Release
..................................................... 5-1 0
Horn ............................................................... 3-6
How
to Add Coolant to the Coolant Surge Tank ...... 5-29
How
to Add Fluid ............................................ 5-22
How
to Check ........................................ 5-20, 5-56
How to Check Lhrizzri-it ................................... 5-48
How
to Check Power Steering Fluid .................. 5-34
How
to Use This Manual ...................................... ii
How to Wear Safety Belts Properly ................... 1-30
Hydroplaning
.................................................. 4-31
I
If No Steam Is Coming From Your Engine .......... 5-27
If Steam Is Coming From Your Engine ............... 5-26
If the Light is Flashing
..................................... 3-39
If the Light Is On Steady ................................. 3-39
If You Are Stuck in Sand, Mud, Ice or Snow
....... 4-41
If You Do Decide To Pull
A Trailer ..................... 4-48
If You’re Caught in a Blizzard
........................... 4-39
Ignition Positions
............................................. 2-18
Ignition Transmission Lock Check
...................... 6-13
Illuminated Visor Vanity Mirrors
......................... 2-15
Infants and Young Children, Restraints
............... 1-50
Inflation -- Tire Pressure ..................... ..... 5-55
Inspection
Brake System
............................................. 6-14
Engine Cooling System
................................ 6-14
Exhaust System
.......................................... 6-14
Fuel System
............................................... 6-14
Part C
- Periodic Maintenance ....................... 6-14
7

........... 3-30
....... 4-13
New
Vehicle Break-In
...................................... 2-18
Normal Maintenance Replacement Parts
............ 5-98
0
Odometer ................................
Oil Off-Road Recovery
............
Engine .............. .............. 5-13
Pressure Gage
.......... .................. 3-40
OIL LIFE RESET ............................................ 3-53
OIL PRESSURE LOW
..................................... 3-53
Older Children. Restraints
................................ 1-48
Online Owner Center
........................................ 7-3
Onstar@ Personal Calling
................................. 2-37
Onstar@ Services
............................................ 2-36
Onstar@ Steering Wheel Controls
...................... 2-37
Onstar@ System
............................................. 2-36
Onstar@ Virtual Advisor
.................................... 2-37
Operating Your All-Wheel-Drive Vehicle
Off
Paved Roads .............................................. 4-1 6
Other Warning Devices
...................................... 3-6
Outlet Adjustment
............................................ 3-25
Outside Automatic Dimming Mirror with Curb
View Assist
............................................. 2-35
Convex Mirror
............................................. 2-34
Heated Mirrors
............................................ 2-35 Outside
(cont.)
Power Mirrors
............................................. 2-34
Overheated Engine Protection Operating Mode
..... 5-25
Owners. Canadian
............................................... ii
Owner’s Information
........................................ 7-11
P
Park (P)
Parking Shifting Out
of
............................................ 2-28
Brake
........................................................ 2-25
Over Things That Burn
................................. 2-29
Parking Brake and Automatic Transmission Park
(P) Mechanism Check
.................................. 6-13
Parking on Hills .............................................. 4-55
Park( P)
Shifting Into
................................................ 2-26
Part
A - Scheduled Maintenance Services ............ 6-4
Part B
- Owner Checks and Services ................ 6-10
Part C
- Periodic Maintenance Inspections .......... 6-14
Part
D - Recommended Fluids and Lubricants .... 6-15
Part E
- Maintenance Record ........................... 6-17
Passenger Air Bag Indicator
............................. 2-33
Passenger Sensing System
.......................... 1-81
PASSENGER
DOOR AJAR ........ ............ 3-56
Passing
............................................. 4-13, 4-53
Passlock@
...................................................... 2-17
Personalization Button
..................................... 3-47
Passenger
Air Bag Status Indicator
................... 3-32
10

Traction
Off Light ............... ....................... 3-36
StabilitrakO System ..................................... 4-9
TRACTION ACTIVE .................................... 3-57
Tractioii Control Operatioii ..... ................ 41c
Trailer
Recommendations
....................................... 4-47
Trailer Brakes ................................................. 4-52
Trailer Wiring Harness ..................................... 4-56
TRANS HOT IDLE ENGINE ............................. 3-55
Transfer Case ................................................ 5-46
Transmission
Fluid, Automatic
........................................... 5-20
Temperature Gage ....................................... 3-37
Transmission Operation, Automatic .................... 2-22
Transmission, Transaxle, Transfer Case Unit
Transportation Options
.......... ......... 7-7
Trip Information Button ................. ............ 3-44
Turn and Lane Change Signals .......................... 3-7
TURN SIGNAL ON ...................... ............ 3-54
Turn SignaVMultifunction Lever .......... ......... 3-7
Turn Signals When Towing a Trailer ............... 4-54
TRANSMISSION HOT ..................................... 3-55
Repair Manual ............................................ 7-10
Underbody Flushing Service ............................. 6-15
Underhood Fuse Block .................................... 5-91
Understanding Radio Reception ........................ 3-87
Unfolding the Seatback .................................... 1-18
Unfolding the Seatbacks .................................. 1-12
Uniform Tire Quality Grading ......................... 5-59
United States ................................. .......... 7-4
Using the Recovery Hoods ............................... 4-42
Using HomeLink@ ........................................... 2-41
v
Vehicle
Control ......................................
... 4-5
Damage Warnings ........................................... iv
Loading
...................................................... 4-44
Symbols ......................................................... iv
Vehicle Identification
Number (VIN)
............................................. 5-86
Service Parts Identification Label ................... 5-86
Vehicle Personalization
Memory Seat
.............. ........................ 2-47
Vehicle Storage .................. .................... 5-39
Ventilation Adjustment ...................................... 3-25
Video Screen ................................................. 3-75
Vinyl ............................................................. 5-79
Visors ........................................................... 2-15
Voltmeter Gage .............................................. 3-34