battery KIA SEDONA 2019 Workshop Manual

Maintenance
58
7
Main fuse
If the main fuse is blown, it must be
removed as follows:
1. Turn off the engine.
2. Disconnect the negative battery
cable.
3. Remove the nuts shown in the pic- ture above.
4. Replace the fuse with a new one of the same rating.
5. Reinstall in the reverse order of removal.
✽ ✽NOTICE
The electronic system may not func-
tion correctly even when the engine
room and internal fuse box’s indi-
vidual fuses are not disconnected. In
such case the cause of the problem
may be disconnection of the main
fuse (BFT type), which is located
inside the positive battery terminal
(+) cap.
Since the main fuse is designed more
intricately than other parts, have the
vehicle checked by an authorized
Kia dealer.
OYP074052N
CAUTION
Visually inspect the battery cap
to ensure it is securely closed.If the battery cap is not securelyclosed, moisture may enter thesystem and damage the electri-cal components.

Maintenance
64
7
Fuse Name Fuse rating Circuit Protected
SENSOR (B+) 10A Battery Sensor
B/ALARM HORN 15A B/Alarm Horn Relay FUEL LID 10A Fuel Lid Relay DEICER 15A Deicer Relay
DRL 10A DRL Relay
FUEL PUMP 15A Fuel Pump Relay HORN 15A Horn Relay
WIPER 25A Front Wiper (Low) Relay
ECU3 30A Engine Control Relay, Fuse - ECU1
FUEL HEATER 30A -
REAR HEATED 40A Rear Heated Relay SENSOR5 10A - TCU 10A Transmission Range Switch
MDPS 10A MDPS Unit (Rack)
DCU 10A -
B/UP LAMP 10A Audio, A/V & Navigation Head Unit, Rear Combination Lamp (IN) LH/RH, Electro Chromic \
Mirror A/CON 7.5A Rear A/C Control Switch, A/C Control Module
ECU1 15A PCM ABS3 7.5A ESC Module, Steering Angle Sensor
SENSOR4 10A Fuel Pump Relay ECU2 20A ECU Unit
SENSOR1 15A Oxygen Sensor #1/#2/#3/#4, PCM, E/R Junction Box (Cooling Fan1 Relay)
SENSOR2 10A PCM, Canister Close Valve, Variable Intake Solenoid Valve #1/#2, Purge Control Solenoid Valve, Oil Control
Valve #1/#2 (Intake), Oil Control Valve #1/#2 (Exhaust)
SENSOR3 10A PCM, Injector
IGN COIL 20A Ignition Coil #1~#6, Condensor #1/#2 ECU3 20A ECU Unit

765
Maintenance
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 8.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specifiedwattage. net-work failure
The headlamp, taillight, and fog light
may light up when the head lamp
switch is turned ON, and not light up
when the taillight or for light switch is
turned ON. This may be cause by
network failure or vehicle electrical
control system malfunction. If there is
a problem, we recommend the sys-
tem be serviced by an authorized Kia
dealer.
trical control system stabilization
A normally functioning lamp may
flicker momentarily. This momentary
occurrence is due to stabilization
function of the vehicle's electrical on
control system. If the lamp soon
returns to normal, the vehicle does
not require service.
However, if the lamp goes out after
the momentary flickering, or the flick-
ering continues, we recommend the
system be serviced by an authorized
Kia dealer.
WARNING- Working on the lights
Prior to working on the light,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle and burning your fingers or
receiving an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.

799
Maintenance
2. Evaporative emission con-trol (including ORVR:
Onboard Refueling Vapor
Recovery) system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos-
phere.
(The ORVR system is designed to
allow the vapors from the fuel tank to
be loaded into a canister while refu-
eling at the gas station, preventing
the escape of fuel vapors into the
atmosphere.)
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust emission control
system
The Exhaust Emission Control System
is a highly effective system which con-
trols exhaust emissions while main-
taining good vehicle performance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could
affect its performance, safety or dura-
bility and may even violate governmen-
tal safety and emissions regulations.
In addition, damage or performance
problems resulting from any modifi-
cation may not be covered under
warranty.
If you use unauthorized electronic
devices, it may cause the vehicle to
operate abnormally, wire damage,
battery discharge and fire. For your
safety, do not use unauthorized
electronic devices.

I3
Index
Automatic transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14Automatic transmission operation . . . . . . . . . . . . . . 5-14
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 5-19
AUX, USB port. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-210
Back-up lamp bulb replacement (Rear combination lamp Type A) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
80
Back-up lamp bulb replacement (Rear combination lamp Type B) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
83
Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 7-36 Battery recharging . . . . . . . . . . . . . . . . . . . . . . . . . . 7-37
For best battery service . . . . . . . . . . . . . . . . . . . . . . 7-36
Recharging the battery . . . . . . . . . . . . . . . . . . . . . . . 7-38
Reset items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-38
Battery replacement(Folding key) . . . . . . . . . . . . . . . . 4-10
Battery replacement(Smart key) . . . . . . . . . . . . . . . . . . 4-20
Battery saver function . . . . . . . . . . . . . . . . . . . . . . . . . 4-135
Before driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Blind-Spot Collision Warning (BCW) system . . . . . . . 5-85 BCW (Blind-Spot Collision Warning) . . . . . . . . . . . 5-86
Driver's Attention . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-92
RCCW (Rear Cross-Traffic Collision Warning) . . . 5-88
Bonnet see the hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-57
Bottle holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-195
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-25\
Checking the brake fluid level . . . . . . . . . . . . . . . . . 7-25 Brake system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
Anti-lock Brake System (ABS) . . . . . . . . . . . . . . . . 5-33
Auto hold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-30
Electronic Parking Brake (EPB) . . . . . . . . . . . . . . . 5-24
Electronic Stability Control (ESC) . . . . . . . . . . . . . 5-35
Hill-start Assist Control (HAC) . . . . . . . . . . . . . . . . 5-42
Parking brake – Foot type . . . . . . . . . . . . . . . . . . . . 5-23
Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
Vehicle Stability Management (VSM) . . . . . . . . . . . 5-40
Bulb replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-65
Bulb replacement precaution . . . . . . . . . . . . . . . . . . . . 7-65
Bulb wattage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Button start/stop, see engine start/stop button . . . . . . . 5-10
Capacities (Lubricants) . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Care Care of seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-51
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-89
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-95
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-39\
Care of seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-30
Center console storage . . . . . . . . . . . . . . . . . . . . . . . . 4-193
Central door lock switch. . . . . . . . . . . . . . . . . . . . . . . . 4-28
Checking fluid levels . . . . . . . . . . . . . . . . . . . . . . . . . . 7-19
Checking tire inflation pressure . . . . . . . . . . . . . . . . . . 7-40
C
B

Index
6I
Explanation of scheduled maintenance items . . . . . . . 7-15Air cleaner filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Air conditioning refrigerant . . . . . . . . . . . . . . . . . . 7-19
Automatic transmission fluid . . . . . . . . . . . . . . . . . . 7-17
Brake discs, pads, calipers and rotors . . . . . . . . . . . 7-18
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-18
Brake hoses and lines . . . . . . . . . . . . . . . . . . . . . . . . 7-17
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
16
Cooling system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Drive belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Drive shafts and boots . . . . . . . . . . . . . . . . . . . . . . . 7-19
Engine oil and filter . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Exhaust system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-19
Fuel filter (for gasoline) . . . . . . . . . . . . . . . . . . . . . . 7-15
Fuel lines, fuel hoses and connections . . . . . . . . . . . 7-15
Parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-18
Power steering pump, belt and hoses . . . . . . . . . . . . 7-19
Spark plugs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Steering gear box, linkage & boots/lower arm ball joint . . . . . . . . . . . . . . . . . . . . . . . . 7-18
Suspension mounting bolts . . . . . . . . . . . . . . . . . . . 7-18
Vacuum crankcase ventilation hoses . . . . . . . . . . . . 7-16
Valve clearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Vapor hose and fuel filler cap . . . . . . . . . . . . . . . . . 7-15
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-89
Exterior features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-208 Roof rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-208
Exterior overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2 Flat tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 6-9
A flat tire indoor storage . . . . . . . . . . . . . . . . . . . . . 6-12
Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-12
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-9
Removing and storing the spare tire . . . . . . . . . . . . 6-10
Storing the spare tire . . . . . . . . . . . . . . . . . . . . . . . . 6-11
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-205
Fluid Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-25
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . 7-26
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-27
Folding key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
5 Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Key operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
Record your key number . . . . . . . . . . . . . . . . . . . . . . 4-5
Transmitter precautions . . . . . . . . . . . . . . . . . . . . . . . 4-9
Folding the outside rearview mirror . . . . . . . . . . . . . . . 4-86
Forward Collision-Avoidance assist (FCA) . . . . . . . . . 5-44 Brake operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-48
FCA front radar/Camera sensor . . . . . . . . . . . . . . . . 5-48
FCA warning message and system control . . . . . . . 5-46
Limitation of the system . . . . . . . . . . . . . . . . . . . . . 5-52
Recognizing pedestrians. . . . . . . . . . . . . . . . . . . . . . 5-56
System malfunction . . . . . . . . . . . . . . . . . . . . . . . . . 5-50
System setting and activation . . . . . . . . . . . . . . . . . . 5-44F

Index
10I
License plate lamp bulb replacement. . . . . . . . . . . . 7-84
Light bulb position (Front). . . . . . . . . . . . . . . . . . . . 7-67
Light bulb position (Rear) . . . . . . . . . . . . . . . . . . . . 7-68
Light bulb position (Side) . . . . . . . . . . . . . . . . . . . . 7-69
Luggage lamp (Bulb type) bulb replacement. . . . . . 7-87
Map lamp (Bulb type) bulb replacement . . . . . . . . . 7-85
Position lamp (LED type) replacement (Headlamp Type A) . . . . . . . . . . . . . . . . . . . . . . . . 7-73
Rear turn signal lamp (Bulb type) bulb replacement (Rear combination lamp Type A). . . . . . . . . . . . . . 7-77
Rear turn signal lamp (Bulb type) bulb replacement (Rear combination lamp Type B). . . . . . . . . . . . . . 7-82
Room lamp bulb replacement . . . . . . . . . . . . . . . . . 7-85
Side marker (front) (Bulb type) bulb replacement (Headlamp Type A) . . . . . . . . . . . . . . . . . . . . . . . . 7-72
Side marker (rear) (Bulb type) bulb replacement (Rear combination lamp Type A). . . . . . . . . . . . . . 7-78
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B). . . . . . . . . . . . . . 7-81
Side repeater lamp (LED type) bulb replacement . . 7-74
Stop and tail lamp (Bulb type) bulb replacement (Rear combination lamp Type A). . . . . . . . . . . . . . 7-75
Stop and tail lamp (LED type) bulb replacement (Rear combination lamp Type B). . . . . . . . . . . . . . 7-81
Tail lamp (inside) (Bulb type) bulb replacement (Rear combination lamp Type A). . . . . . . . . . . . . . 7-79
Vanity mirror lamp (Bulb type) bulb replacement . . 7-87 Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-135
Auto light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137
Battery saver function . . . . . . . . . . . . . . . . . . . . . . 4-135
Daytime running light . . . . . . . . . . . . . . . . . . . . . . 4-135
Dynamic Bending Light (DBL) . . . . . . . . . . . . . . . 4-143
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-143
Headlight (Headlamp) escort function . . . . . . . . . . 4-135
Headlight leveling device . . . . . . . . . . . . . . . . . . . . 4-143
Headlight position . . . . . . . . . . . . . . . . . . . . . . . . . 4-136
High - beam operation . . . . . . . . . . . . . . . . . . . . . . 4-137
High beam assist . . . . . . . . . . . . . . . . . . . . . . . . . . 4-138
Parking & Tail light . . . . . . . . . . . . . . . . . . . . . . . . 4-136
Turn signals and lane change signals . . . . . . . . . . . 4-142
Limp home (override) procedure . . . . . . . . . . . . . . . 4-13
Loss of the smart key (Smart key) . . . . . . . . . . . . . . . . 4-18
Lubricants and capacities . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Luggage lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-149
Luggage lamp (Bulb type) bulb replacement . . . . . . . . 7-88
Luggage net (Holder) . . . . . . . . . . . . . . . . . . . . . . . . . 4-207
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Maintenance Engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Explanation of scheduled maintenance items . . . . . 7-15
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7
M

I13
Index
Scheduled maintenance service . . . . . . . . . . . . . . . . . . . 7-9Maintenance under severe usage conditions . . . . . . 7-13
Normal maintenance schedule . . . . . . . . . . . . . . . . . 7-10
Seat belt restraint system . . . . . . . . . . . . . . . . . . . . . . . 3-35
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
3-35 Care of seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-51
Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-49
Pre-tensioner seat belt . . . . . . . . . . . . . . . . . . . . . . . 3-46
Seat belt restraint system . . . . . . . . . . . . . . . . . . . . . 3-35
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Seat warmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-196
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . 3-2 2nd row seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
2nd row seat (ForSXL). . . . . . . . . . . . . . . . . . . . . . . . 3-3
3rd row seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
3rd row seat (ForSXL) . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Front seat (ForSXL) . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Securing a child restraint seat withchild seat lower anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
3-59
Securing a child restraint seatwith tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
3-58
Side air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-78\
Side curtain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-206
Side marker (front) (Bulb type) bulb replacement (Headlamp Type A) . . . . . . . . . . . . . . . . . . . . . . . . . 7-72 Side marker (rear) (Bulb type) bulb replacement
(Rear combination lamp Type A) . . . . . . . . . . . . . . . 7-78
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) . . . . . . . . . . . . . . . 7-81
Side repeater lamp (LED type) bulb replacement . . . . 7-74
Sliding the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
Smart cruise control with stop & go system . . . . . . . . 5-63 Limitations of the system . . . . . . . . . . . . . . . . . . . . . 5-76
Smart cruise control switch . . . . . . . . . . . . . . . . . . . 5-65
Speed setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-65
To adjust the sensitivity of smart cruise control system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
75
To convert to cruise control mode . . . . . . . . . . . . . . 5-75
Vehicle to vehicle distance setting . . . . . . . . . . . . . . 5-70
Smart key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
14 Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . 4-20
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . 4-21
Loss of the smart key . . . . . . . . . . . . . . . . . . . . . . . . 4-18
Record your key number . . . . . . . . . . . . . . . . . . . . . 4-14
Smart key function . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
Smart key precautions . . . . . . . . . . . . . . . . . . . . . . . 4-19
Smart key function (Smart key) . . . . . . . . . . . . . . . . . . 4-14
Smart key precautions (Smart key) . . . . . . . . . . . . . . . 4-19
Smart liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46 Detecting area. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
How to deactivate the smart liftgate function using the smart key . . . . . . . . . . . . . . . . . . . . . . . . 4-49
How to use the smart liftgate . . . . . . . . . . . . . . . . . . 4-47