fuel filter Lancia Delta 2010 Owner handbook (in English)

GETTING TO KNOW YOUR CAR15
1
Cleaning DPF (particulate filter) in
progress (only Multijet versions with
DPF - amber)
When the ignition key is turned to MAR (ON),
the warning light switches on but it must switch off after
a few seconds. The warning light comes on constantly to
notify the driver that the DPF system needs to eliminate
captured pollutants (particulate) by the regeneration
process. The warning light does not come on during every
DPF regeneration, but only when driving conditions re-
quire notification of the driver. To switch the warning light
off, the car must stay in motion until regeneration has been
completed. The process normally takes about 15 minutes.
The optimum conditions to end the process are achieved
by keeping the car in motion up to 60km/h with an en-
gine speed higher than 2,000 rpm. This light coming on
is not a car defect and therefore the car does not need to
go to the workshop. A specific message will appear on
the display when the warning light comes on (for ver-
sions/markets, where provided).
h
Fuel reserve (amber)
This warning light comes on when the ignition
key is turned to MAR, but it should go off af-
ter a few seconds. The warning light comes on
when about 5 to 7 litres of fuel are left in the tank.
The display will show a dedicated message.
IMPORTANT The warning light will blink to indicate a
system failure. Go to a Lancia Dealership to have the sys-
tem checked.
K
EOBD/injection system failure (amber)
Under normal conditions, the warning light comes
on when the ignition key is turned to MAR, but
should go off as soon as the engine is started.
If the warning light remains on or comes on whilst driving,
this means that the injection system is not working prop-
erly; in particular, if the warning light comes on constantly,
U
Steering corrector not available
This warning light (or symbol on the display) comes on
when the steering corrector is not available. The display
will show a dedicated message.Always drive at a speed appropriate to the traf-
fic conditions, the weather and speed limits. The
engine may be turned off while the DPF light is
on; however, repeated interruption of the regeneration
process may result in premature exhaustion of engine oil.
For this reason it is always advisable to wait for the li-
ght to go off before turning off the engine, following the
instructions appearing above. It is not advisable to com-
plete DPF regeneration with the vehicle stationary.
001-142 Delta 3ed gb 30-11-2009 11:21 Pagina 15

GETTING TO KNOW YOUR CAR17
1
Glow plug preheating
This warning light comes on when the key is
turned to MAR. It will go out as soon as the glow
plugs have reached a predetermined temperature.
Start the engine as soon as the warning light goes out.
IMPORTANT At high outdoor temperatures the warning
light stays on for an extremely short time.
Glow plug heating failure
The warning light will blink in the event of a failure in the
glow plug preheating system. Go to a Lancia Dealership
as soon as possible.
The display will show a dedicated message.
m
Water in diesel fuel filter (Multijet
versions) (amber)
This warning light comes on when the ignition
key is turned to MAR, but it should go off after
a few seconds. The warning light turns on when there is
water in the diesel fuel filter. The display will show a ded-
icated message.
c
The presence of water in the fuel system circuit
may cause severe damage to the injection sys-
tem and irregular engine operation. If the
c
warning light comes on (together with a message on the
display on some versions), go to a Lancia Dealership
as soon as possible to have the system bled. Water may
have been introduced in the tank if this appears im-
mediately after refuelling: in this case, stop the engine
immediately and contact a Lancia Dealership.
ABS system failure (amber)
This warning light comes on when the ignition
key is turned to MAR, but it should go off after a
few seconds. The warning light lights up when the
system is either not working or not available. Under these cir-
cumstances the braking system will work as normal with-
out the extra performance offered by the ABS system.
Drive carefully to the nearest Lancia Dealership to have the
system checked.
The display will show a dedicated message.
>
Lancia Code system failure (amber)
This warning light (or symbol on the display),
when on constantly with the ignition key turned
to MAR, indicates a possible failure (see “Lancia
Code system” in chapter 1).
Y
001-142 Delta 3ed gb 30-11-2009 11:21 Pagina 17

GETTING TO KNOW YOUR CAR141
1
PROTECTING THE ENVIRONMENT
The devices for reducing petrol engine emissions are the
following:
❍three-way catalytic converter;
❍Lambda sensors;
❍fuel evaporation control system.
In addition, do not let the engine run, even for a test, with
one or more spark plugs disconnected.
The devices for reducing diesel fuel engine emissions are
the following:
❍oxidising catalytic converter;
❍exhaust gas recirculation system (E.G.R.).
❍diesel particulate filter (DPF) (for versions/markets,
where provided).
The catalytic converter reaches high temper-
atures during operation. Do not park on
grass, dry leaves, pine needles or other flam-
mable material: fire risk.
DIESEL PARTICULATE FILTER (DPF)
(for versions/markets, where provided)
The Diesel Particulate Filter is a mechanical filter, inte-
gral with the exhaust system, that physically traps par-
ticulate present in the exhaust gases of Diesel engines. The
diesel particular filter has been adopted to almost totally
eliminate particulate in compliance with current / future
regulations. During normal use of the car, the engine man-
agement control unit records a set of data (e.g.: travel time,
type of route, temperatures reached, etc.) and it will then
calculate the amount of particulate trapped by the filter.
Since this filter physically traps particulate, it should be
regenerated (cleaned) at regular intervals by burning car-
bon particles. The regeneration procedure is controlled au-
tomatically by the engine management control unit ac-
cording to the filter conditions and car use conditions. Dur-
ing the regeneration procedure, the following situations
may occur: limited increase of idle speed, activation of
electric fan, limited increase of smoke, high temperatures
at the exhaust. These are not faults; they do not impair
car performance or damage the environment. If the ded-
icated warning message is displayed, refer to the section
“Instrument panel warning lights” in this chapter.
001-142 Delta 3ed gb 30-11-2009 11:22 Pagina 141

CARE AND MAINTENANCE215
5
Scheduled maintenance ................................................................. 216
Scheduled maintenance plan ......................................................... 217
Periodic checks .............................................................................. 221
Demanding use of the car............................................................... 221
Checking fluid levels ..................................................................... 223
Air filter ........................................................................................ 230
Pollen filter ................................................................................... 230
Diesel fuel filter ............................................................................. 230
Battery .......................................................................................... 231
Wheels and tyres ........................................................................... 234
Rubber hoses ................................................................................ 236
Windscreen wiper/rear wiper ......................................................... 236
Bodywork...................................................................................... 239
Interiors ......................................................................................... 242
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 215

35 70 105 140 175
●● ● ● ●
●
●
●●
●●
●● ● ● ●
●●
●● ● ● ●
220CARE AND MAINTENANCE
Thousands of kilometres
Check engine management system operation (via diagnostic socket)
Replace auxiliary drive belt
Replace toothed timing drive belt (*)
Replace fuel filter
Replace air filter cartridge
Change engine oil and oil filter (versions without DPF) (or every 24 months)
Change engine oil and oil filter (versions with DPF) (**)
Change brake fluid (or every 24 months)
Change pollen filter (or every 15 months)
(*) Regardless of the km covered, the timing belt should be replaced every 4 years for particularly demanding use (cold climates,
driving in the city, idling for a long time) or in any case every 5 years.
(**) The engine oil and the filter must be changed when the instrument panel warning light comes on (see “Warning lights and
Messages” chapter) and in all cases every 2 years.
If the car is used mainly in towns the engine oil and filter need to be changed every 12 months.
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 220

222CARE AND MAINTENANCE
Perform the following inspections more frequently than
shown on the Scheduled Service Plan:
❍check front disc brake pad condition and wear;
❍check cleanness of bonnet and boot locks and linkage
cleanness and lubrication;
❍visually inspect the condition of: engine, gearbox,
transmission, pipes and hoses (exhaust – fuel supply
- brakes) rubber elements (gaiters – hoses - bushes
etc.);❍check battery charge and fluid level (electrolyte); (see
“Battery - Charge and electrolyte level check” in this
chapter);
❍visually inspect the condition of auxiliary drivebelts;
❍check and if necessary replace the pollen filter; in par-
ticular it should be replaced if a decrease in the air flow
into the passenger compartment is detected;
❍check the air filter and replace, if required.
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 222

230CARE AND MAINTENANCE
AIR FILTER/ POLLEN FILTER
Have the air filter or pollen filter replaced by a Lancia
Dealership.
DIESEL FUEL FILTER
DRAINING CONDENSED WATER
(Multijet versions) E-fig. 2-3
The presence of water in the feeding circuit
may cause severe damage to the injection sys-
tem and irregular engine operation. If the
warning light
cgoes on, contact a Lancia Dealer-
ship as soon as possible to have the system bled.
Water may have been introduced in the tank if this
appears immediately after refuelling: in this case,
stop the engine immediately and contact a Lancia
Dealership.
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 230

57 (
)–
8/10 –
7.1 –
4.3 (❍) 3.60 (❍)
4.6 (❍) 3.85 (❍)
1.87 1.7
–0.8
6–57 –
8/10 –
5.9 –
2.75 2.4
2.9 3.3
2.4 ()2 ()
–0.8
6–Unleaded petrol
not less than 95 R.O.N
(Specification EN228)
(

) Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% distilled water and
50% PARAFLU UP (▲)
SELENIA K P.E.
SELENIA WR P.E. (❍)
TUTELA CAR TECHNYX
TUTELA CAR MATRYX ()
TUTELA TOP 4
Mixture of water and fluid
TUTELA PROFESSIONAL SC 35
260TECHNICAL DATA
CONSUMABLES
(▲) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU
UP and distilled water.
1.4 Turbo Jet 1.6 Multijet Recommended fuels litres kg litres kg and original lubricants
Fuel tank:
including a reserve of:
Engine cooling system:
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit withABS system:
Windscreen/rear window
washer fluid reservoir:
243-266 Delta 3ed gb 11-11-2009 12:16 Pagina 260

57 –
8/10 –
7.1 –
4.3 3.60
4.9 4.10
3.1 2.63
–0.8
6–57 –
8/10 –
7.1 –
4.3 3.60
4.9 4.10
3.1 2.63
–0.8
6–Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% distilled water and
50% PARAFLU UP (▲)
SELENIA WR P.E.
TUTELA CAR TECHNYX
TUTELA TOP 4
Mixture of water and fluid
TUTELA PROFESSIONAL SC 35
TECHNICAL DATA261
6
(*) Values in brackets refer to versions with headlight washer.
(
▲) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP
and distilled water.
1.9 Twin Turbo Multijet 2.0 Multijet Recommended fuels litres kg litres kg and original lubricants
Fuel tank:
including a reserve of:
Engine cooling system
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit with
ABS system:
Windscreen/rear window
washer fluid reservoir:
243-266 Delta 3ed gb 11-11-2009 12:16 Pagina 261

268INDEX
Fog lights ............................ 61-72
– bulb replacement ................... 199
Fog lights ................................... 71
Follow me home (device)............. 63
Food compartment ...................... 75
Front/rear armrest................. 74-76
Fuel cap ..................................... 140
Fuel consumption ....................... 264
Fuel feed .................................... 249
Fuel lock .................................... 73
Fuse replacement ....................... 205
Fuses (replacement) ................... 205
Glove box light
(bulb replacement) ................... 204
Glove compartment................ 74-77
Handbrake ................................ 168
Hazard warning lights ................ 71
Headlights .................................. 100
Headrests ................................... 48
Hill Holder system ...................... 111
Identification data ..................... 244In an emergency ......................... 175
Instrument panel
and instruments ....................... 7
Interior fittings ........................... 74
Interiors ..................................... 242
Isofix child seats
(fitting arrangement)................. 155
Keys .......................................... 38
Knowing your car ........................ 5
Lancia CODE system ................. 37
Load compartment
(magic back box - twin
compartment) ........................... 94
Magic back box
(twin load compartment)........... 94
Magic Parking............................. 123
Main beam headlights (control) ... 62
– bulb replacement ................... 197
Manual climate control ............... 52
Manual gearbox (use)................ 169
MSR system ............................... 112 Display readings.......................... 32
Door locking............................... 82
Doors......................................... 82
– child safety device.................. 84
– emergency rear door
locking device ........................ 85
DPF (particulate filter DPF) ....... 141
Driving Advisor ........................... 106
DST system................................. 102
Dualdrive electric power
steering system.......................... 115
Electric windows........................ 85
Engine codes/bodywork versions .. 246
Engine compartment (washing) .. 241
Engine
– features ................................. 247
– identification code ................ 224
EOBD system ............................. 115
External lights ............................ 60
Fix&Go Automatic (device) ....... 177
Flashing the headlights ............... 62
Fluids and lubricants.................. 262
267-274 Delta 4ed gb 12-02-2010 10:22 Pagina 268