lights MAZDA PROTEGE 1992 Owner's Guide

T.&condition
-t
Off
IQ”&” switch
ON
Whik cranking
lgnitlon switch ON
Test switch at “SELF-TEST”
Lamp illuminated for 3 sec. after ignition
SwiIch OFF-KIN
Lamp not illuminated after 3 sec. collect vdtaQe
ReRlar*
ve
For backup
ov
-
V%
Approx. tov
ov
4 5--5.5v With Self-
D&Q”& Check-
er and system
Vi3 st?lt?ctor Input &PJ
- -
0
0
0
0
0
0
- -
- -
0
0
c
- -
0 connectkfl to mnina
Connection to
Stoplight swtch Test condition
-L 1A
Bake pedal released
IEI
IC Main relay
(FUEL INJ relay) Brake pedal depressed
lQ”ih0” switch ON
___-- P/S Qrc?ss"re
switch
Ignition switch
(START) P/S ON at idle
P/S OFF at idle
A/C switch ON
A/C switch OFF
Cwlng fan operatng (Engine coolant tem-
perature over 97°C (207°F) or dlagnosls
connector terminal TFA grounded) (IG ON)
Fan not ooeralmg (Idle) 1D .self-mag”osls
Checker
(Monitor lamp) A!C switch
coohng fan swtctl
Test switch at “02 MONITOR” at idle
Monitor lamp ilfummated
Test switch at “02 MONITOR” at idle
Monitor lamp not illuminated
Lamp illuminated for 3 sec. after ignition
switch OFF&N
Lamp not illuminated after 3 ser.
Lamp illuminated
Lamp not #lluminated VB
Below 2.w With System
Selector test
VB swtch at
“SELF-TEST”
Eelow 2.5v
VS Blower Control
swttch Blower control switch OFF or 1 st posihon
Blower control swtch 2nd or htgher
position 1E
Malfunction indicator
lamp
NJ
Rear window defroster swtch OFF Rear wmdow
defroster switch
Headkght switch Rear window defroster Switch ON
-2-A - I
tieadlghts ON
Headlights OFF
Neutral positton or clutch pedal
depressed
OlhWS l Wiih Self-
DkQnosls
Checker and
Svstem Selector Self- Diaanosis Buzzer sounded for 3 sec. after ignition
switch OFF-ON
Buzzer not sounded after 3 set 6&w 2.5v
V8 Checke;
(Cede Number) I
ov Ignition swtch
ON NeulraliClutch
switches
. ‘.&h System
Selector test
switch at Buzzer sou”ded
1 Below 2.5V 1
VB
ov -
ov -
ov -
ov -
APprox. ov
or 4 5-5 5v
-
Approx. 2V
-
-
AQWOX. Ov
or 4 5-5 5v
-
APQ~OX 1.5V Buzzer not sounded
I VE
I
Ground (Injector)
Ground
(OUtQUt)
Ground (CPU)
Grou”d (Input)
constant
lgnlti swtch ON
klk “SELF-TEST”
ov
-
Ap~rox O.2V
- - Constant
Co”stant lgnller
1H
Constant
Igntho” swdch ON -
- D&ribulor
(Ne-sIgnal) II
1J
1K
1L
1M
1N -
fgnition switch ON
AX switch ON al idle
NC switch OFF at Idle
System Selector lest switch at
“0-z MONITOR” I -
- VB
5&w 2.w -
Vi3
VB Ignition switch
ON
System Selector test swatch at
“SELF-TEST”
ParkIng brake pulled wth lgndlon swtch ON
(DRL OFF) ov
VB
l DRL: oaytime Running tigms
Idle (DFtL ON) Below 2.5v A/C relay
Idle
-
Ignition swtch ON
-
Distributor
(G-stgnal) [DOHC]
3ignosis
x”“ec1or
,TEN terminal) Idle
3RL relay (canada)
-
Accelerator pedal released
Accelerafor pedal depressed
-
ov
VB
-
Ignition switch
ON rhr0ttte sensor
‘Idle switch)

: WIRINQ MAQRAM
70...UOHC
EGI EC-AT
aENGINE CONTROL SYSTEM Cz EC-AT CONTROL SYSTEM(3/3) 0 -CANADA
b -2c
MAIN
%,E,$$$?@&?%(F,
4
GNITION
WITCH
IGSTRUMENT METER
CLUSTER 15A
BACK-UP LIGHTS
(SECTION F-3)
~~~~$~ z,s:EM @-- B/L (F) -0lL (EMi -
5>82-0 1
2P IM
ENGINE CONTROL UNIT 3G 3H
3E IR
:EPT
21 28 2K 2F IT (
Y2-01~==----~-------------~--‘---‘-~~-----~------
B/LG %/%R
(EM) IEM)
1
E/;
:
6 3A
?
‘-01 ENGINE CONTROL UNITfEM) A-02 INHIBITOR SWI!$y
III 1s 10 10 1M IKm 3 IG IE 1C IA 20 2M
2K 21
26 2E 2C
2A
*
W G G/B G/R (Bc) G/ G/W
x llWWlR/I In/LJL/YIL/B B/L R/B
i
3~ 3~ 3” 35 3~ 30 34 3K 31 36 3E 3C
3A
0 L/O Y X L/O * G/O * /L e/o
L L/Y Y/B * * * * * * Y/R @y’ /% a/o
IN 3F 30 38 1 1 ’ I 5 1 n *a
. .
. .
I .’ II’ “‘l-‘-l-’ -I-. 1
’ ’ ’ ” ’ ’ I . . *...
iv ,T ,R IP IN iL IJ ,ti 1F 10 IB 2P 2N 2~ 2J 2H 2F 20 28 32 3X 3”
3T 3A 3P 3N 3L 33 3
1-19 AIRFLOW METER (EM) 82-20 THROTTLE SE+Op 182-23 HOLD SWITCH&+
ttM1 1 162-24 SOLENOID VALVE (EC-AT) &INHIBITOR SWITCH iF)
I
A
__ .._..... -. .._ __._. _ __..... .., .___....__.._ __.. _..~ . . .._...., . . . .

Terminal vdt
wminal lrput
1A -
1B 0
-
1C 0
1D e (ATX) ve: aattefy voltage
1
Connected to
I Test wndition ~cwrect rc4t.gej F&W*
-
0
-
-
3attery
Uain r&y
:FUEL INJ relay) Constant
tgnition swdch V% For backt@
OFF ov
ON V6
Ignition swtch
(START)
Self-Diagnosis
Checker
[monitor lamp)
3 - White crankii npprox 1ov
fgnition switch ON ov
Test swtch at “SELF-TEST’ With Self-
Lamp illuminated for 3 sec. after igmtmn 4.5-5.w Diagnosis Check-
switch OFF-+ON er and System
Selector
Lamp net illuminated after 3 Sec. VS
Test swtch at “02 MONITOR” at idle
i Monitor lamp illuminated 4.5-55v
Test switch at “02 MONtTOR” at idfe
Monitor lamp not illuminated
Malfunction indicator
lamp illuminated for 3 sec. after ignition
Below 2 5v With System
lalllp switch OFF+ON selector test
WLI switch at
Lamp not luminated after 3 sec. VE
“SELF-TEST”
lamp ifluminated BelOW 2.w
Lamp not illuminated VS
Self-Diagnosis Buzzer sounded for 3 sec. after ignrtion
l With Self-
Checker switch OFF-+ON Below 2.5V
Diagm!3s
(code number) Checker and
Buzzer not sounded after 3 set VB
system
Select0 Buzzer sou&?d Below 2 5v l With System
Selector test
I Buzzer not sounded
tgmter Ignition switch ON ov
Idle Appror 0 2v -
Headlight switch Headlights ON
f VB
-
Headlbhts OFF ! ov
Diagnosis
connector
, System Selector test switch at
VS Ignition witch
“02 MONITOR” ON
(TEN terminal)
Rear window
defroster switch
Ground Icalifornia) System Selector tesf switch at
“SELF-TEST”
Rear window defroster watch OFF
Rear window de!roster watch ON
ConSlant QV
ov lgmhon switch
__ ON
VO
ov
- Main relay (canadal fgmtion switch ON VB
AC relay Ignitiin switch ON VB
A/C switch ON at Idle Below 2.5% -
Vehicle speed A/C switch OFF at Gle
/ Vehicle stopped
P/S pressure
switch lgmhon switch ON
P/S ON at idle Iturnino)
I.
P/S OFF at idle I VB Terminal voltage v‘s: Battery vottage
I I
1
Terminal input Output Connected to Test condition comcl voltage Remark
10
0 A/C swatch AIC switch ON Befow25V ignition switch
ON and blower
A/C switch OFF VB I
motor ON
IP
ii Blower control Blower control swtch OFF or 1 St poSItion VB tgnibon switch
switch ON
Blower control switch 2nd or higher
ov
position
1Q
0 Stopltght switch Brake pedal released Below 1 ov
-
IT <; Brake pedal depressed VE
lnhtbitor switch N or P range ov Ignition switch
(P N range) ON
Other ranges VB
Cruise control man Set or Resume swtch ON or vehicle speed lgmhon swtch
switch 8kmih &mph) lower than preset speed &tow 1 5~ ON
(Drwng vehcfe crwse cantrol
OperatiOn)
Fk
z 1v -
3A ’ Throttle Sensor
(Idle switch) Normal conditions
Accelerator pedal released
Accelerator pedal depressed “8
Bebw 1 ov lgnihon swatch
ON
VS
I -
-
- - -
-
-
- - -
D&rib&r
-‘. / b / / (Ne-signal) lgmtion swtch ON
/ ,,,, Approx. OV
or 5v
-
Approx 2v
I ._.
/
28 1
AdlOw meter lgmhon switch ON
Approx 3 BV .,
-
Idle Approx 3 3V
2c j r:
I \’ oxygen sensor fgmtson switch ON ov
1
20 Idle (cold englIIei
Idle (after warn-up)
lncreasma enwe speed (after warm-up) ov
O-l ov -
0 w-1 .ov
_ -
,
Deceleration o-o 4v
Coolmg fan swtch Fan operahng (engine coolant temperature
over 97°C (207’F) or diagnosis connector DV
termmat TFA grounded) -
Fan not operatmg (idle)
Water thermosensor Engine codant temperature L” %, I”” I , ‘Y”8’.“” . . . ...-1.
After warm-up
I
Thrnttb SP”SOi 1 Accelerator pedal released Approx 0.5V
2G .._..._ --..--
-
Accelerator pedal fully depressed Approx. 4 OV
0 ATF thermosensor -XPC (-2o”~)--1x1~c (302°F) aprxox as5-~m lgmhon swtch
ON
ATF temp 20°C (68°F) Approx. 4.6V
13OOC (266°F) Aporox 1.54V
I I I I I I
2H / i, I / Hold switch Hold mode Below 2V Ingbhon switch
Normal mode

j Z WlRiNQ MAQRAM A.. .EC-AT 0 .CANACA
/
l NSTRUMENT CLUSTER & WARNING LAMPS *...WITH PASSIVE SHOULDER BELT
c
BATTERY
0 01 MAIN
BOA
0 0, B (E)
0 (F)
.-I
FLASHER UNIT
SECTION F-l
(SECTION E-3) HEADLIGHTS
(SECTION E-2) INSTRUMENT CLUSTER
ILLUMINATION LAMP
;REFER TO SECTION I-4
k,
JR-06 @
METER
15A
STARTING SYSTEM
(SECTION n-i)
E J&O4 0
WY
Fl
I
INSTRUMENT CLUSTER
OOHC SEYSOR
&
:-04 PARKING BRAKE C-07 WATER THERMOSENSOR
SWITCH (I?) (EMI
(INJI
DOHC

WIUINW lJlAWnAm
JITH
mJI:SE CONTROL
l HEADLIGHTS E-2
DRL CONTROL
DRL CONTROL
qE-04 BULB TRADE NUMBER
HEADLIGHT: 9004 (65/45W)
f v
t-02 COMBINATION
SWITCH (F) E-03 HEADLIGHT LH(F) E-04 HEADLIGHT RH(F) E-05 HEADLIGHT RE;$
”
R/W R W/R
B L/Y LG
E-06 TAILLIGHT REU&
.
Z-56

ZANADA l DAYTIME RUNNING LIGHTS E-3
DRL CONTROL UNIT
-07 DRL RELAY (F) E-08 DRL RESISTOR (F) E-09 DRL CONTROL UNIT (F)
a

! WIRINQ DIAQRAN
l TAILLIGHTS
l LICENSE PLATE LIGHTS mREAR SIDE MARKER LIGHTS n POSITiON LIGHTS E-4
ti;$ik;GHT
(SECTION E-l. 2)
BULB TRADE NUMBER
REAR SIDE MARKER: 194 (3.BW1
TAILLIGHT: 1157 (8W) BULB TRADE NUMBER
LICENSE PLATE: 89 (7.5W1
POSITION. 1157 (8W)
-
I PROTFGF I PROTEGE
SIDE
-n TAILLIGHT Ll ‘-I I , PROTEGE
I k PROTEGE 1
I J
R a I i H“
ION
LH
-10 REAR SIDE MARKER E-II REAR SIDE MARKER E-12 TAILLIGHT LH (R) E-13 TAILLIGHT RH (R)
LIGHT LH (R) LIGHT RH (R) E-14 LICENSE PLATE LI;li;E-I” LICENSE PLATE LK;:‘E-I” LICENSE PLATE L$j;
-17 POSITION LIGHT c;r E-18 POSITION LIGHTRji

1 w ItuNu wnunnm
l TlJRN 6r HAZARD FLASHER LIGHTS F-l
BULB TRADE NUMBER
FRONT TURN: 1157 (27W)
REAR TURN : 1156 (27W)
FLASHER UNIT
____----_----
HAZARD SWITCH
ILLUMINATION LAMP:
REFEA TO SECTION I-4
--0 1 TURN SWITCH (F) F-02 FLASHER UNIT (F)
I= (++&(GIs/vl [ml
WITH CRUISE CONTROL
;;;aT;;l[ CRUISE
--05 HAZARD SWITCH (I) E-12 REAR TURN L$ti; E-13 REAR TU”N,‘R;;;;

: WIRINQ DIAGRAM
. STOPLIGHTS F-2
Y
z!zL
+
B MAIN BTN
BOA 60A
(E) m :>
IX-O l,j lx-0 11 W/R (F)
--I JB-05 (B
STOP
20A
SHIFT-LOCK
UNIT
(SECTION HI
Y JB-05 0
49
9
(6, BULB TRADE NUMBER
STOPLIGHT: 1157 (27W)
HIGH MOUNT
STOPLIGHT: 921 (18.4W) tr-~ (F) +@ ENGINE CONTROL UNIT
(SECTION 6-1~. 2b)
t+G (F) -+@ CRUISE CONTROL UNIT
(SECTION Q)
WITH REAR SPOILER
3HB
B 12
STOPLIGHT
STOPLIGHT
STOPLIGHT 12
STOPLIGH
LH
PROTEGE
“-06 STOPLIGHT
SWITCH (F)
Z-64
F-07 HIGH MOUNT STOP
WITH 1 B 1 G 1 PROTI
REAR SPOILER- (R2 I-12 STOPLIGHT LH (R) c-13 STOPLIGHT RH (R)

! WIRINQ DIAQRAM
HN
ACK-UP LIGHTS F-3
B (F)
n
BTN
I_~
GNITION 60A
WITCH
X-
(F)
JB-05 0
STOP
20A
JB-05 @
\8 JB-06 @
METER
15A
JB-07 @ EXCEPT
EC-AT
I
G/W
(F)
Y::
I
BULB TRADE NUMBER
BACK-UP: 1156 (27W1 ;/0 GjY
F-10
5
BACK-UP LIGHT
SWITCH
F-10
(F) %%E (F)
I CONTROL
/ I
WITHOUT m
CRUISE R/G
,.-- CONTROL BACK-UP LIGHTS (?I INHIBITOR
SWITCH
(SECTION 8-2~) w
R
B G/O Y G B/Y
.--lo BACK-UP LIGHT
SWITCH(F) -02 HORN SWITCH (F)
S-12 BACK-UP LIGHT Lt
F-3) -13 BACK-UP LIGHT R’
(A