tailgate MITSUBISHI LANCER 2005 Owner's Manual

[x] Cancel search | Manufacturer: MITSUBISHI, Model Year: 2005, Model line: LANCER, Model: MITSUBISHI LANCER 2005
Pages: 788, PDF Size: 45.98 MB

MITSUBISHI LANCER 2005 Owner's Manual LANCER 2005 MITSUBISHI MITSUBISHI https://www.carmanualsonline.info/img/19/57321/w960_57321-0.png MITSUBISHI LANCER 2005 Owner's Manual

Search: (seat adjustment, child lock, change key battery, washer fluid, rims, fuel tank removal)

Load previous 10 pages

Page 373 of 788

MITSUBISHI LANCER 2005 Owners Manual MARK
EXTERIOR51-35
2. Installation procedure
(1) Use 3M ATD Part number 8906 or equivalent
to clean the mark installation surfaces on the
body.CAUTION
When attaching the marks, the ambient
temperat

MARK
EXTERIOR51-35
2. Installation procedure
(1) Use 3M ATD Part number 8906 or equivalent
to clean the mark installation surfaces on the
body.CAUTION
When attaching the marks, the ambient
temperature should be 20 − 38°C and the air
should be completely free of dust. If the ambient
temperature is lower than 20°C, the marks and
the places on the vehicle body where the marks
are to be attached should be heated to 20 − 38°C.
(2) Peel off the protection sheet on the back of the
marks to paste it on the installation position.
AC304163
2. Three-diamond mark

Centre line
of vehicleCentre line
of vehicle
Trunk lid
press linePress line112 mm
53 ± 1 mm
AC
AC304164
3. Lancer mark
Rear combination
lamp terminal
Trunk lid terminal
Tailgate terminal
33 mm
24 mm45 ± 1 mm
13 ± 1 mm19 ± 1 mm

AB

Page 471 of 788

MITSUBISHI LANCER 2005 Owners Manual HIGH-MOUNTED STOP LAMP
CHASSIS ELECTRICAL54A-83
<Wagon>
REMOVAL SERVICE POINT
<<A>> HIGH-MOUNTED STOP LIGHT
REMOVAL <WITH REAR SPOILER>
Use the following steps to easily route high-mounted
stop ligh

HIGH-MOUNTED STOP LAMP
CHASSIS ELECTRICAL54A-83

REMOVAL SERVICE POINT
<> HIGH-MOUNTED STOP LIGHT
REMOVAL
Use the following steps to easily route high-mounted
stop light harness in the event of installation:
CAUTION
Ensure that the string is tightly tied.
1. Tie a string on the high-mounted stop light
harness (at the connector side).
2. Carefully pull out the high-mounted stop light.
AC304722AB
2
1
Removal steps
•Tailgate trim upper (Refer to
GROUP 52A, Tailgate trim
P.52A-19.)
•High-mounted stop lamp connector
connection
•Rear washer hose connection
(Refer to GROUP 51, Rear wiper
and washer P.51-29.)1. Tailgate spoiler (Refer to GROUP
51, Tailgate spoiler P.51-19.)
•Rear washer nozzle (Refer to
GROUP 51, Rear wiper and
washer P.51-29.)
2. High-mounted stop lampRemoval steps (Continued)
AC005190
String
Connector
AC

Page 607 of 788

MITSUBISHI LANCER 2005 Owners Manual 80-1
GROUP 80
CONFIGURATION
DIAGRAMS
CONTENTS
OVERALL CONFIGURATION
DIAGRAM. . . . . . . . . . . . . . . . . . . . . .80-2
OVERALL WIRING DIAGRAM
<SEDAN (LHD) > . . . . . . . . . . . . . . . . . .

80-1
GROUP 80
CONFIGURATION
DIAGRAMS
CONTENTS
OVERALL CONFIGURATION
DIAGRAM. . . . . . . . . . . . . . . . . . . . . .80-2
OVERALL WIRING DIAGRAM
. . . . . . . . . . . . . . . . . . . . 80-2
OVERALL WIRING DIAGRAM
. . . . . . . . . . . . . . . . . . . . 80-3
OVERALL WIRING DIAGRAM
. . . . . . . . . . . . . . . . . . . 80-4
OVERALL WIRING DIAGRAM
. . . . . . . . . . . . . . . . . . . 80-5
ENGINE COMPARTMENT. . . . . . . . .80-6
ENGINE COMPARTMENT . . . . . . . 80-6
ENGINE COMPARTMENT . . . . . . 80-7
ENGINE AND TRANSMISSION. . . . .80-8
ENGINE AND TRANSMISSION
<4G1-MPI (LHD) > . . . . . . . . . . . . . . . . . . . 80-8
ENGINE AND TRANSMISSION
<4G1-MPI (RHD) > . . . . . . . . . . . . . . . . . . . 80-10
ENGINE AND TRANSMISSION
<4G6-MPI (LHD) > . . . . . . . . . . . . . . . . . . . 80-12
ENGINE AND TRANSMISSION
<4G6-MPI (RHD) > . . . . . . . . . . . . . . . . . . . 80-14
DASH PANEL . . . . . . . . . . . . . . . . . . .80-16
DASH PANEL . . . . . . . . . . . . . . . . . 80-16
DASH PANEL . . . . . . . . . . . . . . . . . 80-19
FLOOR AND ROOF . . . . . . . . . . . . . .80-22
FLOOR AND ROOF . . . . 80-22
FLOOR AND ROOF . . . . 80-23
FLOOR AND ROOF . . . 80-24
FLOOR AND ROOF . . . 80-25
DOOR . . . . . . . . . . . . . . . . . . . . . . . . .80-26
DOOR . . . . . . . . . . . . . . . . . . . . . . . 80-26
DOOR . . . . . . . . . . . . . . . . . . . . . . . 80-27
TRUNK
(LUGGAGE COMPARTMENT). . . . . .80-28
TRUNK (LUGGAGE COMPARTMENT)
. . . . . . . . . . . . . . . . . . . . 80-28
TRUNK (LUGGAGE COMPARTMENT)
. . . . . . . . . . . . . . . . . . . . 80-29
TAILGATE. . . . . . . . . . . . . . . . . . . . . .80-30
TAILGATE . . . . . . . . . . 80-30
TAILGATE . . . . . . . . . . 80-31

Page 610 of 788

MITSUBISHI LANCER 2005 Owners Manual OVERALL CONFIGURATION DIAGRAM
CONFIGURATION DIAGRAMS80-4
OVERALL WIRING DIAGRAM <WAGON (LHD) >M1801000100592
NOTE: .
1. This illustration shows only major wiring harnesses.
2. *: also equipped at the

OVERALL CONFIGURATION DIAGRAM
CONFIGURATION DIAGRAMS80-4
OVERALL WIRING DIAGRAM M1801000100592
NOTE: .
1. This illustration shows only major wiring harnesses.
2. *: also equipped at the right side.
AC301177AB
Front wiring
harness (RH)Control wiring
harnessInstrument panel
wiring harnessRoof wiring
harnessFloor wiring
harness (RH)
Battery wiring
harnessFront wiring
harness (LH)Front door
wiring harness Floor wiring
harness (LH)Fuel wiring
harnessRear door
wiring harness
Front bumper
wiring harness
Rear bumper
wiring harness
**
Tailgate wiring
harness

Page 611 of 788

MITSUBISHI LANCER 2005 Owners Manual OVERALL CONFIGURATION DIAGRAM
CONFIGURATION DIAGRAMS80-5
OVERALL WIRING DIAGRAM <WAGON (RHD) >M1801000100600
NOTE: .
1. This illustration shows only major wiring harnesses.
2. *: also equipped at the

OVERALL CONFIGURATION DIAGRAM
CONFIGURATION DIAGRAMS80-5
OVERALL WIRING DIAGRAM M1801000100600
NOTE: .
1. This illustration shows only major wiring harnesses.
2. *: also equipped at the right side.
AC301178AB
Front wiring
harness (RH)Control wiring
harnessInstrument panel
wiring harnessRoof wiring
harnessFloor wiring
harness (RH)
Battery wiring
harnessFront wiring
harness (LH)Front door
wiring harness Floor wiring
harness (LH)Fuel wiring
harnessRear door
wiring harness
Front bumper
wiring harness
Rear bumper
wiring harness
**
Tailgate wiring
harness

Page 636 of 788

MITSUBISHI LANCER 2005 Owners Manual TA I L G AT E
CONFIGURATION DIAGRAMS80-30
TA I L G AT E
TAILGATE <WAGON (LHD) >M1801001900223
AC301173AB
F-01 F-02F-03
F-10F-22
F-09
F-11
F-17 F-19 Floor wiring
harness (LH)
F-21Defogger
earthFloor wi

TA I L G AT E
CONFIGURATION DIAGRAMS80-30
TA I L G AT E
TAILGATE M1801001900223
AC301173AB
F-01 F-02F-03
F-10F-22
F-09
F-11
F-17 F-19 Floor wiring
harness (LH)
F-21Defogger
earthFloor wiring
harness (RH)F-06
F-15
Rear bumper
wiring harness
Antenna
feeder cable
Connector colour
code
B : Black
BR : Brown
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet
Y : Yellow
F-20
F-07
F-08
F-12
F-18
F-13
8
Tailgate wiring
harness
Connector
symbol
F
F-01 (2) Rear speaker (LH)
F-02 (6) Floor wiring harness (LH) and Floor
wiring harness (RH) combination
F-03 (1) Roof antenna
F-06 (1) Rear window defogger (−)
F-07 (4) Rear wiper motor
F-08 (2) Rear speaker (RH)
F-09 (2) Accessory socket
F-10 (2) High mount stop lamp
F-11 (6-B) Rear combination lamp (RH)
F-12 (8) Floor wiring harness (RH) and tailgate
wiring harness combinationF-13 (2-B) Tailgate lock actuator
F-15 (2-GR) Licence plate lamp (RH)
F-17 (1) Tailgate switch
F-18 (2-GR) Licence plate lamp (LH)
F-19 (4-GR) Floor wiring harness (LH) and rear
bumper wiring harness combination
F-20 (2) Rear fog lamp
F-21 (6-B) Rear combination lamp (LH)
F-22 (1) Rear window defogger (+)

Page 637 of 788

MITSUBISHI LANCER 2005 Owners Manual TA I L G AT E
CONFIGURATION DIAGRAMS80-31
TAILGATE <WAGON (RHD) >M1801001900234
AC301174AB
F-01
F-03F-10F-22
F-09
F-11
F-17
F-19 Floor wiring
harness (LH)
F-21Defogger
earthFloor wiring
harness (RH)F-

TA I L G AT E
CONFIGURATION DIAGRAMS80-31
TAILGATE M1801001900234
AC301174AB
F-01
F-03F-10F-22
F-09
F-11
F-17
F-19 Floor wiring
harness (LH)
F-21Defogger
earthFloor wiring
harness (RH)F-06
F-15
Antenna
feeder cable
Connector colour
code
B : Black
BR : Brown
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet
Y : Yellow
F-07
F-08
F-12
F-18
F-13
8
Tailgate wiring
harness
F-14
Rear bumper
wiring harness
Connector
symbol
F
F-01 (2) Rear speaker (LH)
F-03 (1) Roof antenna
F-06 (1) Rear window defogger (−)
F-07 (4) Rear wiper motor
F-08 (2) Rear speaker (RH)
F-09 (2) Accessory socket
F-10 (2) High mount stop lamp
F-11 (6-B) Rear combination lamp (RH)
F-12 (8) Floor wiring harness (RH) and tailgate
wiring harness combinationF-13 (2-B) Tailgate lock actuator
F-14 (2) Rear fog lamp
F-15 (2-GR) Licence plate lamp (RH)
F-17 (1) Tailgate switch
F-18 (2-GR) Licence plate lamp (LH)
F-19 (4-GR) Floor wiring harness (LH) and rear
bumper wiring harness combination
F-21 (6-B) Rear combination lamp (LH)
F-22 (1) Rear window defogger (+)

Page 704 of 788

MITSUBISHI LANCER 2005 Owners Manual ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP <WAGON (LHD)>
CIRCUIT DIAGRAMS90-66
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP <WAGON (LHD)> (CONTINUED)
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP

ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP
CIRCUIT DIAGRAMS90-66
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP (CONTINUED)
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP (CONTINUED)
FRONT
SIDE
COMBINATION
METER
ETACS-ECU
DOOR
SWITCH
(FRONT: RH)DOOR
SWITCH
(REAR: RH)DOOR
SWITCH
(REAR: LH)DOOR
SWITCH
(FRONT: LH) REAR
PERSONAL
LAMP (LH) REAR
PERSONAL
LAMP (RH)
(FUSE )15
KEY
REMINDER
SWITCH
(WHEN
REMOVING
KEY: ON)
TAILGATE
SWITCH
Wire colour code
B : Black LG : Light green G : Green L : Blue
W : White Y : Yellow SB : Sky blue BR : Brown
O : Orange GR : Grey R : Red P : Pink V : Violet
J/B SIDE
LUGGAGE
ROOM LAMP
DIAGNOSIS
CONNECTOR DIODE
REAR
PERSONAL
LAMP (LH)REAR
PERSONAL
LAMP (RH) FRONT
ROOM
LAMP
FRONT
ROOM
LAMPREAR
ROOM
LAMP ETACS-
ECU
ETACS-
ECUETACS-
ECU ETACS-
ECU

Page 706 of 788

MITSUBISHI LANCER 2005 Owners Manual ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP <WAGON (RHD)>
CIRCUIT DIAGRAMS90-68
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP <WAGON (RHD)> (CONTINUED)
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP

ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP
CIRCUIT DIAGRAMS90-68
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP (CONTINUED)
ROOM LAMP,PERSONAL LAMP AND LUGGAGE ROOM LAMP (CONTINUED)
(FUSE )15
KEY
REMINDER
SWITCH
(WHEN
REMOVING
KEY: ON)
TAILGATE
SWITCH
Wire colour code
B : Black LG : Light green G : Green L : Blue
W : White Y : Yellow SB : Sky blue BR : Brown
O : Orange GR : Grey R : Red P : Pink V : Violet
J/B SIDE
DIODE LUGGAGE
ROOM LAMP
DIAGNOSIS
CONNECTOR
FRONT
SIDE
COMBINATION
METER
ETACS-ECU
DOOR
SWITCH
(FRONT: LH)DOOR
SWITCH
(REAR: LH)DOOR
SWITCH
(REAR: RH)DOOR
SWITCH
(FRONT: RH) REAR
PERSONAL
LAMP (RH) REAR
PERSONAL
LAMP (LH)
REAR
PERSONAL
LAMP (LH)REAR
PERSONAL
LAMP (RH) FRONT
ROOM
LAMP
FRONT
ROOM
LAMPREAR
ROOM
LAMP ETACS-
ECU
ETACS-
ECUETACS-
ECU ETACS-
ECU

Page 736 of 788

MITSUBISHI LANCER 2005 Owners Manual CENTRAL DOOR LOCKING SYSTEM <LHD WITHOUT KEYLESS ENTRY>
CIRCUIT DIAGRAMS90-98
CENTRAL DOOR LOCKING SYSTEM <LHD WITHOUT KEYLESS ENTRY> (CONTINUED)
<SEDAN> <WAGON>
ETACS-ECU ETACS-ECU
REAR
DOOR LOCK
AC

CENTRAL DOOR LOCKING SYSTEM
CIRCUIT DIAGRAMS90-98
CENTRAL DOOR LOCKING SYSTEM (CONTINUED)

ETACS-ECU ETACS-ECU
REAR
DOOR LOCK
ACTUATOR
(RH)REAR
DOOR LOCK
ACTUATOR
(REAR: RH)TAILGATE
LOCK
ACTUATOR
Wire colour code
B : Black LG : Light green G : Green L : Blue W : White Y : Yellow SB : Sky blue
BR : Brown O : Orange GR : Grey R : Red P : Pink V : Violet ETACS-ECU
(FUSE )
15
DIAGNOSIS
CONNECTORSRS-ECU
CRASH DETECTION
DOOR UNLOCK
SIGNAL PROCESS
CIRCUIT
FRONT
SIDE

Load next 10 pages

Page: < prev 1-10 11-20 21-30 31-40 next >

Search: (hood open, headlight bulb, air suspension, start stop button, fuel consumption, wheel size)