ABS MITSUBISHI LANCER EVOLUTION 2007 Service User Guide

WIRING HARNESS CONFIGURATION DIAGRAMS
Connector
symbol
D
D-01D-26D-02D-03D-04D-05D-06
D-34D-15D-33D-32D-30D-29
D-23
D-22
D-21
D-20
D-19
D-18Y
B-32
FLOOR AND ROOF
R.H. drive vehicles
D-01 (3) Door switch (Front: RH)
D-02 (8) Floor wiring harness (RH) and rear door
wiring harness (RH) combination
D-03 (2) Room lamp
D-04 (2-B) Wheel speed sensor (Rear: RH)

D-05 (2-GR) Rear room lamp
D-06 (3) Door switch (Rear: RH)
D-08 (3) Door switch (Rear: LH)D-09 (5-GR) Fuel pump and fuel gauge unit (Main)
D-10 (2-B) Wheel speed sensor (Rear: LH)

D-12 (8) Floor wiring harness (LH) and rear door
wiring harness (LH) combination
D-13 (3) Door switch (Front: LH)
D-15 (4) Instrument panel wiring harness and
console wiring harness combination

SINGLE PART INSTALLATION POSITION -Relay/ECU
D
Intercooler water
spray relay
Fuel pump
relay 2
Rear fog
lamp relay
Fuel
pump relay 1
Power
window
relay
Defogger
relay
Blower relay
J/B
B-41
ECU
NameSymbolNameSymbol
4WD-ECU L.H. drive vehiclesLFront-ECUC
R.H. drive vehiclesKHeater control unit H
A/C-ECUHImmobilizer-ECUG
ABS-ECUL.H. drive vehiclesAPower window main switch
(incorporatingECU)
M
R.H. drive vehiclesB(incorporating ECU)
Column switch (incorporating column-ECU)FPower window motor
(incorporatingECU)
FrontN
ETACS-ECUE(incorporating ECU)RearO
Engine-ECUISRS-ECUJ
Fan controllerD
NOTE
*: also equipped at the right side.
ABC
D
EFGHI
JKL
MNO**

SINGLE PART INSTALLATION POSITION -ECU
A
ABS-ECU
B
ABS-ECU
C
Front-ECU
D
Fan controller
E
ETACS-
ECU
J/B
F
Column switch
column-ECU>
G
Ignition key cylinder
Immobilizer-
ECU
H
Heater control unit
A/C> or A/C-ECU

I
Engine-ECU
J
SRS-ECU
B-42

SINGLE PART INSTALLATION POSITION -Solenoid Valve
A
Purge control
solenoid valve
Fuel pressure
solenoid valveB
Secondary air
control solenoid
valve
Alternator
EGR solenoid valve
C
Hydraulic unit
(incorporating
solenoid valve)
D
Air cleaner
Waste gate
solenoid valve
B-46
SOLENOID VALVE
NameSymbolNameSymbol
EGR solenoid valveBHydraulic unit
(incorporatingsolenoidvalve)
E
Fuel pressure solenoid valveA(incorporating solenoid valve)
Hydraulic unit (incorporating solenoid valve)

CPurge control solenoid valveA
Secondary air control solenoid valveB
Waste gate solenoid valveD
ABC
D
E

CIRCUIT DIAGRAMSB-68
CENTRALIZED JUNCTION
FUSIBLE LINK
No.CircuitTypeHousing colourRated capacity
(A)
1Multi-purpoes fuses No. 15, 16, 17, 19, 20Screwed typeYellow60
2Cooling circuit and manual air conditioner circuitConnector typeRed50
3ABS circuitConnector typeYellow60
4Ignition switchConnector typeGreen40
5Power window circuitConnector typePink30
6Battery, fusible links No. 1, 2, 3, 4 and 5,
dedicated fuses No. 1, 2, 3, 4, 5, 6, 7, 8, 9, 10,
18, starting system, front-ECUScrewed type-100
7ACDScrewed type-60
(Relay box in engine compartment)
Front of vehicle
(Connected directly to battery positive (+) terminal)

Front of vehicle
1
234
5
6 7
6

CIRCUIT DIAGRAMSB-69
DEDICATED FUSE
Power supply
circuitNo.Rated
capacity (A)Identification
colourCircuit
Battery/alternator
(FusiblelinkNo6)
115BlueSpare connectors
(FusiblelinkNo.6)210RedHorn relay
320YellowEngine control relay and ignition control relay
410RedA/C compressor
515BlueABS-ECU, 4WD-ECU, high-mounted stop lamp and rear
combination lamp
630GreenCondenser fan motor
77.5BrownAlternator
810RedETACS-ECU
9---
1015BlueFuel pump
Front-ECU
(Headlamprelay:
1110RedHeadlamp
(Headlamp relay:
HI)1210RedHeadlamp
Front-ECU
(Headlamprelay:
1310RedFront combination lamp
(Headlamp relay:
LO)1410RedFront combination lamp
Front-ECU
(Tail lamp relay)157.5BrownHeater control unit or A/C-ECU, clock, combination
meter, fog lamp switch, hazard warning switch, radio,
rear combination lamp, headlamp leveling switch, front
combination lamp, cigarette lighter illumination lamp,
ashtray illumination lamp, ACD mode changeover switch
and inter cooler water splay switch
167.5BrownFront combination lamp, licence plate lamp and rear
combination lamp
Ignition switch
(ACC)1710RedClock
Battery/alternator
(Fusible link No. 6)1810RedEngine-ECU, ETACS-ECU, front-ECU and combination
meter
-19---
Fusible link No. 52120YellowIntercooler water splay
-22---
Ignition switch
(IG2)23---
-24---
Battery/alternator
(Fusible link No. 6)2530GreenCondenser fan motor

CIRCUIT DIAGRAMSB-71
MULTI-PURPOSE FUSE (In junction block)
Power supply
circuitNo.Rated
capacity (A)Identification
colourCircuit
Ignition
switch
IG1110RedIgnition coil
switch
27.5BrownColumn switch, combination meter, ETACS-ECU,
SRS-ECU, vehicle speed sensor and ACD mode
changeover switch
37.5BrownETACS-ECU and SRS-ECU
4---
IG257.5BrownA/C compressor relay, A/C-ECU, blower relay,
condenser fan relay, defogger relay, front-ECU,
4WD-ECU, steering wheel sensor and inter cooler
water splay relay
Multi-purpose fuse
No. 20 (Defogger
relay)6---
Ignition
switch
ACC720YellowFront-ECU and windshield wiper motor
switch
IG187.5BrownEngine-ECU and fuel pump relay (1) and fuel pump
relay (2)
ACC915BlueCigarette lighter
10---
117.5BrownA/C-ECU and remote controlled mirror switch
IG2127.5BrownABS-ECU, G-sensor (longitudinal) and G-sensor
(lateral)
ACC13---
14---
Fusible link No. 1
Battery/alternator
1515BlueDiagnosis connector
Battery/alternator
1610RedRear fog lamp relay
1710RedETACS-ECU
18---
1930GreenBlower motor and resistor
2030GreenDefogger

CIRCUIT DIAGRAMSB-198
ABS
L.H. drive vehicles

CIRCUIT DIAGRAMSB-200
ABS (CONTINUED)

CIRCUIT DIAGRAMS
H1J15X28CA
B-202
ABS (CONTINUED)