NISSAN 350Z 2007 Z33 Body, Lock And Security System Repair Manual

POWER DOOR LOCK SYSTEM
BL-51
C
D
E
F
G
H
J
K
L
MA
B
BL
Revision: 2006 November2007 350Z
3. CHECK BACK DOOR OPENER ACTUATOR GROUND CIRCUIT
Check continuity between back door opener actuator harness connector T11 terminal 2 and ground.
OK or NG
OK >> Replace back door opener actuator.
NG >> Repair or replace.2 (B) – Ground : Continuity should exist.
PIIA2354E

BL-52
FUEL FILLER LID OPENER
Revision: 2006 November2007 350Z
FUEL FILLER LID OPENERPFP:78820
System Description/For RoadSterNIS0000Y
Power is supplied at all times

through 40A fusible link (letter F , located in the fuse and fusible link box)

to BCM terminal 55,

through 10A fuse [No.18, located in the fuse block (J/B)]

to BCM terminal 42.
When ignition switch ACC or ON position, power is supplied

through 10A fuse [No. 6, located in the fuse block (J/B)]

to BCM terminal 11.
Ground is supplied

to BCM terminal 52

through body grounds M30 and M66.
FUEL LID OPEN OPERATION
When fuel lid opener switch is ON (pushed), ground is supplied

to BCM terminal 58

through fuel lid opener switch terminals 1 and 2, and

through body grounds M30 and M66.
And power is supplied

to BCM terminal 70

through fuel lid opener actuator terminals 1 and 2, and

through body grounds B5, B6, and T14.
Then fuel lid opener actuator opens fuel lid.
FUEL LID OPENER CANCEL OPERATION
Fuel lid cannot open when vehicle condition is in arm or alarm phase.

FUEL FILLER LID OPENER
BL-53
C
D
E
F
G
H
J
K
L
MA
B
BL
Revision: 2006 November2007 350Z
Wiring Diagram — F/LID — /For CoupeNIS0000Z
TIWT1574E

BL-54
FUEL FILLER LID OPENER
Revision: 2006 November2007 350Z
Wiring Diagram — F/LID — / For RoadsterNIS00010
TIWT1575E

FUEL FILLER LID OPENER
BL-55
C
D
E
F
G
H
J
K
L
MA
B
BL
Revision: 2006 November2007 350Z
CONSULT-III Function (BCM)/For RoadsterNIS00011
CONSULT-III can display each diagnostic item using the diagnostic test modes shown following.
DATA MONITOR
ACTIVE TEST
BCM diagnosis
partInspection item, self-diagnosis
modeContent
Fuel lidData monitor Displays BCM input data on real-time basis.
Active test Sends drive signals to fuel lid opener actuator to perform operation check.
Monitor item “operation” Content
F/LID OPN SW Indicates [ON/OFF] condition of fuel lid opener switch.
Test item Content
FUEL LID OPENThis test is able to check fuel lid opener actuator unlock operation. This actuator unlocks when “ON” on
CONSULT-III screen is touched.

BL-56
FUEL FILLER LID OPENER
Revision: 2006 November2007 350Z
Terminals and Reference Value for BCM/For RoadsterNIS00012
Trouble Diagnosis/For RoadsterNIS00013
FUEL LID DOSE NOT OPEN WITH FUEL LID OPENER SWITCH
1. VEHICLE CONDITION
Check vehicle security system.
Ye s o r N o
Yes >> Cancel arm phase or alarm phase condition.
No >> GO TO 2.
2. CHECK FUEL LID OPEN INPUT SIGNAL
With CONSULT-III
Check door switches (“F/LID OPN SW”) in “DATA MONITOR” mode with CONSULT-III.
Without CONSULT-III
1. Turn ignition switch OFF.
2. Check voltage between BCM and ground.
OK or NG
OK >> GO TO 3.
NG >> GO TO 6.
Termi-
nalWire
colorItemSignal
Input/
OutputConditionVoltage [V]
(Approx.)
11 LG Ignition switch (ACC) Input Ignition switch (ACC or ON) Battery voltage
39 L CAN-H Input — —
40 P CAN-L Input — —
42 GY Power source (Fuse) Input — Battery voltage
52 B Ground — — 0
55 R Power source (Fusible link) Input — Battery voltage
58 Y/B Fuel lid opener switch InputFuel lid opener switch is ON 0
Fuel lid opener switch is OFF Battery voltage
70 W/LFuel lid opener release
output signalOutputFuel lid opener switch is ON 0
Fuel lid opener switch is OFFBattery voltage
(For 0.5s)
Arm phase or alarm phase?
Monitor item Condition
F/LID OPN SWOPEN : ON
CLOSE : OFF
ConnectorTerminal
(Wire color)
ConditionVoltage [V]
(Approx.)
(+) (–)
B83 58 (Y/B) GroundFuel lid opener switch ON 0
Fuel lid opener switch OFF Battery voltage
PIIB1259E

FUEL FILLER LID OPENER
BL-57
C
D
E
F
G
H
J
K
L
MA
B
BL
Revision: 2006 November2007 350Z
3. CHECK FUEL LID OPEN OUTPUT SIGNAL
Check voltage between BCM connector and ground.
OK or NG
OK >> GO TO 4.
NG >> Replace BCM. Refer to BCS-17, "
Removal and Installation of BCM" .
4. CHECK FUEL LID OPENER ACTUATOR CIRCUIT
1. Disconnect BCM connector and fuel lid opener actuator connector.
2. Check continuity between BCM harness connector B83 terminal
70 and fuel lid opener actuator harness connector T19 terminal
1.
3. Check continuity between fuel lid opener actuator harness con-
nector T19 terminal 1 and ground.
OK or NG
OK >> GO TO 5.
NG >> Repair harness or connector.
5. CHECK FUEL LID OPENER ACTUATOR GROUND CIRCUIT
Check continuity between fuel lid opener actuator harness connector
T19 terminal 2 and ground.
OK or NG
OK >> Replace fuel lid opener actuator.
NG >> Repair harness or connector.
ConnectorTerminal
(Wire color)
ConditionVoltage [V]
(Approx.)
(+) (–)
B83 70 (W/L) GroundFuel lid opener switch
ONBattery voltage
(for 0.5s)
Fuel lid opener switch
OFF0
PIIB1264E
70 (W/L) - 1 (W/L) : Continuity should exist.
1 (W/L) - ground : Continuity should not exist.
PIIB1265E
2 (B) - ground : Continuity should exist.
PIIA8090E

BL-58
FUEL FILLER LID OPENER
Revision: 2006 November2007 350Z
6. CHECK FUEL LID OPENER SWITCH
1. Disconnect fuel lid opener switch
2. Check continuity between fuel lid opener switch harness con-
nector M13 terminals 1 and 2.
OK or NG
OK >> GO TO 7.
NG >> Replace fuel lid opener switch.
7. CHECK FUEL LID OPENER SWITCH CIRCUIT
1. Disconnect BCM connector.
2. Check continuity between BCM harness connector B83 terminal
58 and fuel lid opener switch harness connector M13 terminal 1.
3. Check continuity between BCM harness connector B83 terminal
58 (Y/B) and ground.
OK or NG
OK >> GO TO 8.
NG >> Repair harness or connector.
8. CHECK FUEL LID OPENERE SWITCH GROUND CIRCUIT
Check continuity between fuel lid opener switch harness connector
M13 terminal 2 and ground.
OK or NG
OK >> Replace fuel lid opener switch.
NG >> Repair harness or connector.
Connec-
torTerminalsFuel lid opener switch
conditionContinuity
M13 1 2ON (Pushed) Yes
OFF (Released) No
PIIA8091E
58 (Y/B) - 1 (L/R) : Continuity should exist.
58 (Y/B) - ground : Continuity should not exist.
PIIB3792E
2 (B) - ground : Continuity should exist.
PIIA8093E

REMOTE KEYLESS ENTRY SYSTEM
BL-59
C
D
E
F
G
H
J
K
L
MA
B
BL
Revision: 2006 November2007 350Z
REMOTE KEYLESS ENTRY SYSTEMPFP:28596
Component Parts and Harness Connector LocationNIS00014
FOR COUPE
PIIB7456E

BL-60
REMOTE KEYLESS ENTRY SYSTEM
Revision: 2006 November2007 350Z
FOR ROADSTER
PIIB9172E