warning OLDSMOBILE AURORA 2003 Service Manual

Uniform Tire Quality Grading
Quality grades can be found where applicable on the
tire sidewall between tread shoulder and maximum
section width. For example:
Treadwear 200 Traction AA Temperature A
The following information relates to the system
developed by the United States National Highway
Traffic Safety Administration, which grades tires by
treadwear, traction and temperature performance. (This
applies only to vehicles sold in the United States.)
The grades are molded on the sidewalls of most
passenger car tires. The Uniform Tire Quality Grading
system does not apply to deep tread, winter-type
snow tires, space-saver or temporary use spare tires,
tires with nominal rim diameters of
10 to 12 inches
(25 to 30 cm), or to some limited-production tires.
While the tires available on General Motors passenger
cars and light trucks may vary with respect to these
grades, they must also conform to federal safety
requirements and additional General Motors Tire
Performance Criteria (TPC) standards.
Treadwear
The treadwear grade is a comparative rating based on
the wear rate
of the tire when tested under controlled
conditions on a specified government test course.
For example, a tire graded
150 would wear one and
a half
(1.5) times as well on the government course as
a tire graded
100. The relative performance of tires
depends upon the actual conditions of their use,
however, and may depart significantly from the norm
due to variations in driving habits, service practices and
differences in road characteristics and climate.
Traction - AA, A, B, C
The traction grades, from highest to lowest, are AA, A,
B, and C. Those grades represent the tire’s ability
to stop on wet pavement as measured under controlled
conditions on specified government test surfaces of
asphalt and concrete. A tire marked C may have poor
traction performance. Warning: The traction grade
assigned to this tire is based on straight-ahead braking
traction tests, and does not include acceleration, cornering, hydroplaninGr or peak traction characteristics.
5-67
ProCarManuals.com

Temperature - A, B, C
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation
of heat and its ability to dissipate heat when tested
under controlled conditions on a specified indoor
laboratory test wheel. Sustained high temperature can
cause the material of the tire to degenerate and
reduce tire life, and excessive temperature can lead to
sudden tire failure. The grade
C corresponds to a
level of performance which all passenger car tires must
meet under the Federal Motor Vehicle Safety Standard
No. 109. Grades B and A represent higher levels of
performance on the laboratory test wheel than the
minimum required by law.
Warning: The temperature grade for this tire is
established for a tire that is properly inflated and not
overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest tire life
and best overall performance.
Scheduled wheel alignment and wheel balancing are
not needed. However,
if you notice unusual tire wear or
your vehicle pulling one way or the other, the alignment
may need to be reset. If you notice your vehicle
vibrating when driving on a smooth road, your wheels
may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked or badly rusted
or corroded.
If wheel nuts keep coming loose, the
wheel, wheel bolts and wheel nuts should be replaced.
If the wheel leaks air, replace it (except some
aluminum wheels, which can sometimes be repaired).
See your dealer
if any of these conditions exist.
Your dealer will know the kind
of wheel you need.
Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted
the same way as the one it replaces.
5-68
ProCarManuals.com

A rear blowout, particularly on a curve, acts much like a
skid and may require the same correction you’d use
in a skid. In any rear blowout, remove your foot from the
accelerator pedal. Get the vehicle under control by
steering the way
you want the vehicle to go. It may be
very bumpy and noisy, but you can still steer. Gently
brake to a stop
- well off the road if possible.
If a tire goes flat, the next part shows how to use your
jacking equipment
to change a flat tire safely.
Changing a Flat Tire
If a tire goes flat, avoid further tire and wheel damage
by driving slowly to
a level place. Turn on your
hazard warning flashers. Changing a tire can cause an in-
y. The
vehicle can
slip off the jack and roll over you
or other people. You and they could be badly injured. Find a level place to change your tire.
To help prevent the vehicle from moving:
1. Set the parking brake firmly.
2. Put the shift lever in PARK (P).
3. Turn off the engine.
To be even more certain the vehicle won’t move, you can put blocks at the front and
rear of the tire farthest away from the one
being changed. That would be the tire on
the other side of the vehicle, at the
opposite end.
5-7 1
ProCarManuals.com

Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flames
if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous
if you breathe their fumes in a closed
space. When you use anything from a container to clean
your vehicle, be sure to follow the manufacturer’s
warnings and instructions. And always open your doors
or windows when you’re cleaning the inside.
Never use these to clean your vehicle:
Gasoline
Benzene
0 Naphtha
0 Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
Lacquer Thinner
Nail Polish Remover Don’t use any
of these unless this manual says you
can. In many uses, these will damage your vehicle:
Alcohol
Laundry Soap
Bleach
Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and
loose dirt. Wipe vinyl, leather, plastic and painted
surfaces with a clean, damp cloth.
FabridCarpet
Your dealer has cleaners for the cleaning of fabric and
carpet. They will clean normal spots and stains
very well.
You can get GM
- approved cleaning products from
your dealer. See
GM Vehicle Care/Appearance
Materials
on page 5-88.
They can all be hazardous - some more than
others -and they can all damage your vehicle, too
5-82
ProCarManuals.com

Accessory Power Outlets ................................. 3-21
Adding Washer Fluid
....................................... 5-38
Additional Program Information
........................... 7-8
Additives, Fuel
................................................. 5-6
Add-on Electrical Equipment
............................ 5-91
Adjusting the Speakers (Balance/Fade)
.............. 3-62
Air Bag
Readiness Light
.......................................... 3-34
Air Bag Systems
............................................. 1-47
How Does an Air Bag Restrain? .................... 1-52
Servicing Your Air Bag-Equipped Vehicle
......... 1-54
What Makes an Air Bag Inflate?
.................... 1-52
What Will You See After an Air Bag Inflates? ...... 1-52
When Should an Air Bag Inflate?
................... 1-51
Where Are the Air Bags?
.............................. 1-49
Air CleanedFilter, Engine
................................. 5-21
All Overseas Locations
...................................... 7-4
Aluminum or Chrome-Plated Wheels
.................. 5-86
Antenna, Diversity
........................................... 3-76
Anti-Lock Brake, System Warning Light
.............. 3-36
Appearance Care
............................................ 5-82
Care
of Safety Belts .................................... 5-84
AM
............................................................... 3-74
r-11 It1-Iucln u1anG \JYQLGI II
uw) f-r A,-.+: I ,.-I, D.-~.I,A C?.,-+A- /A DC A7 ...........................
Appearance Care (cont.)
Chemical Paint Spotting
............................... 5-87
Cleaning the inside of Your Vehicle
................ 5-82
Cleaning the Outside of Your Vehicle
.............. 5-85
Finish Damage
............................................ 5-87
GM Vehicle Care/Appearance Materials
.......... 5-88
Sheet Metal Damage
................................ 5-87
Underbody Maintenance
........ ........ 5-87
Weatherstrips
........................... .... 5-84
Ashtrays
..................................... ........ 3-22
Assist Handles
............................................... 2-45
Audio System(s)
............................................. 3-59
Audio Systems
Audio Steering Wheel Controls
...................... 3-74
Care of Your Cassette Tape Player
................ 3-74
Care of Your CD Player
............................... 3-76
Care of Your CDs
........................................ 3-75
Chime Level Adjustment
............................... 3-76
Diversity Antenna System
............................. 3-76
NavigatiodRadio System
.............................. 3-69
Personal Choice Radio Controls
.................... 3-73
Radio with Cassette and CD
......................... 3-60
~eLlilly LIIt: I It lit3 3-a3
Theft-Deterrent Feature ................................ 3-73
Trunk-Mounted CD Changer
.......................... 3-70
Understanding Radio Reception
..................... 3-74
0 -LA:.- - . &I- - -r:.-- n rn ..........................................
1
ProCarManuals.com

Automatic Climate Control System ..................... 3-23
Automatic Door Locks
..................................... 3-54
Automatic Headlamp System
............................ 3-1 6
Automatic Level Control
................................... 4-36
Automatic Operation
........................................ 3-23
Automatic Transaxle Fluid
.......................................................... 5-22
Operation
................................................... 2-26
Automatic Transaxle Check
.............................. 6-1 0
Automatic Transaxle Shift Lock Control System
Check
........................................................ 6-1 1
Backing
Up .................................................... 4-41
Battery
.......................................................... 5-42
Battery Load Management
............................... 3-21
Battery Replacement
......................................... 2-9
Battery Warning Light
...................................... 3-35
Before Leaving on a Long Trip
......................... 4-23
Body Lubrication Service
.................................. 6-10
Brake
Parking
...................................................... 2-29
System Inspection
....................................... 6-1 4
System Warning Light
.................................. 3-35 Brake
Fluid
.................................................... 5-39
Brake Wear
................................................... 5-41
Brakes
.......................................................... 5-39
Braking
........................................................... 4-6
Braking in Emergencies
..................................... 4-8
Break.ln. New Vehicle
..................................... 2-23
Bulb Replacement
........................................... 5-54
Front Turn Signal and Parking Lamps
............. 5-57
Halogen Bulbs
............................................ 5-54
Headlamp Aiming
........................................ 5-50
Headlamps ................................................. 5-55
Replacement Bulbs ...................................... 5-58
Taillamps, Turn Signal, Stoplamps and Back-up Lamps
........................................ 5-58
Buying New Tires
........................................... 5-66
C
California Fuel .......................................... 5-6
Canada
........................................................... 7-4
Canadian Owners
................................................ ii
Canadian Roadside Assistance
........................... 7-6
Capacities and Specifications
.......................... 5-1 00
Carbon Monoxide ................... 4.26. 4.36. 2.14. 2-33
ProCarManuals.com

Driver Information Center (DIC) ___ ....... 3-45
DIC Vehicle Personalization .......................... 3-52
DIC Warnings and Messages .......... ....... 3-50
At Night ..................................................... 4-16
City ........................................................... 4-21
Defensive ..................................................... 4-2
Drunken ....................................................... 4-2
Freeway ..................................................... 4-22
Hill and Mountain Roads .............................. 4-24
In Rain and on Wet Roads ........................... 4-18
Winter ........................................................ 4-26
Driving On Grades .......................................... 4-42
Driving Through Deep Standing Water ............... 4-20
Driving Through Flowing Water ...................... 4-20
Driving with a Trailer .................................... 4-40
Driving
Driving on Snow or Ice
.................................... 4-28
E
Electrical System
Add-on Equipment
............................... 5-91
Fuses and Circuit Breakers ........................... 5-92
Headlamp Wiring ......................................... 5-91
Power Windows and Other Power Options ...... 5-91
Removing the Rear Seat Cushion .................. 5-95
Windshield Wiper Fuses ............................... 5-91
Emergency Trunk Release Handle ..................... 2-1 6
Emissions Inspection and Maintenance
Programs
................................................... 3-42
Engine
Air Cleaner/Filter
......................................... 5-21
Battery ....................................................... 5-42
Check and Service Engine Soon Light ............ 3-39
Coolant ...................................................... 5-24
Coolant Heater ............................................ 2-25
Coolant Temperature Gage ........................... 3-38
Cooling System Inspection ............................ 6-14
Engine Compartment Overview ...................... 5-14
Exhaust ..................................................... 2-33
Oil ............................................................. 5-15
Overheating ................................................ 5-28
Starting ...................................................... 2-24
Engine Compartment Fuse Block ...................... 5-92
Engine Coolant Level Check .............................. 6-9
Engine Cooling When Trailer Towing .................. 4-43
Engine Oil Additives ........................................ 5-19
Engine Oil Level Check ..................................... 6-9
Engine Oil Scheduled Maintenance ..................... 6-5
Engine Specifications ..................................... 5-1 00
Engiishiivietric ................................................. 3-45
Entry Lighting ................................................. 3-18
Erasing HomeLink@ Buttons .............................. 2-44
Express-Down Window .................................... 2-18
Extender, Safety Belt ....................................... 1-27
Exterior Lamps ............................................... 3-14
Exterior Lighting Battery Saver .......................... 3-17
5
ProCarManuals.com

H
Hazard Warning Flashers ................................... 3-4
Head Restraints
....................................... . 1-7
Headlamp
Aiming
....................................................... 5-50
Headlamp High/Low-Beam Changer .................... 3-7
Headlamp Horizontal Aiming
............................. 5-51
Headlamp Vertical Aiming
................................. 5-52
Headlamp Wiring ............................................ 5-91
Headlamps
.................................................... 5-55
Bulb Replacement
....................................... 5-54
Front Turn Signal and Parking Lamps
............. 5-57
Halogen Bulbs
............................................ 5-54
Headlamps on Reminder
.................................. 3-15
Heated Seats
............................................... 1-5
Highway Hypnosis ................................. ... 4-24
Hill and Mountain Roads
................ ... 4-24
Hitches
.......................................................... 4-39
HomeLink Transmitter, Programming
.................. 2-42
HomeLink@ Transmitter
.................................... 2-41
Hood
UI ICLRII ly I I Ill 1y3 VI IUGl 5- I L
Release ..................................................... 5-1 3
Horn
............................................................... 3-5
How to Add Coolant to the Coolant Surge Tank
.. 5-33
How to Add Fluid
............................................ 5-24
How to Check ........................................ 5-22, 5-61
OL--I..-- TI^: --.- I I--1- .. Am ................................
How to Check Power Steering Fluid ....... .... 5-37
How to Use This Manual
................................... ii
How to Wear Safety Belts Properly ............... 1-13
Hydroplaning
.............................................. 4-19
If
No Steam Is Coming From Your Engine .......... 5-30
If Steam Is Coming From Your Engine ............... 5-29
If the Light Is Flashing ..................................... 3-40
If the Light Is on Steady .................................. 3-41
If You Are Stuck in Sand, Mud, Ice or Snow ....... 4-32
If You Do Decide To Pull A Trailer
..................... 4-37
If You’re Caught in a Blizzard ........................... 4-29
Ignition Positions
............................................. 2-23
Ignition Transaxle Lock Check
.......................... 6-12
Inadvertent Power Battery Saver
....................... 3-20
Infants and Young Children, Restraints
............... 1-30
Inflation
-- Tire Pressure .................................. 5-60
Inspection
Brake System
.......................... ........ 6-14
Exhaust System
.......................................... 6-13
Fuel System
............................................... 6-13
Part C
- Periodic Maintenance ....................... 6-13
Steering, Suspension and Front Drive Axle
Boot and Seal
......................................... 6-13
Throttle System
........................................... 6-14
Engine
Cooling System
................. .... 6-14
7
ProCarManuals.com

Instrument Panel Cluster
.............. .... .... ........... 3-31
Overview
..................................... ......... 3-2
Instrument Panel Brightness
........... ........... 3-17
Interior Lamps
............................................. 3-17
Interior Plastic Components
.............................. 5-83
Jump Starting
................................................. 5-44
Key Lock Cylinders Service
.............................. 6-10
Keyless Entry System
....................................... 2-5
Key Reminder Warning
.................................... 2-24
Keys
............................................................... 2-3
L
Lamps Exterior
................................... ....... 3-14
Interior
....................................................... 3-1 7
Lap-§boulder Belt ................................... 1-14, 1-22
Child Restraints
........................................... 1-40
Securing a Child Restraint Designed for the
LATCH System
........................................ 1-42
Leather
......................................................... 5-83
LATCH System Leaving
Your Vehicle
....................................... 2-14
Leaving Your Vehicle With the Engine Running
...... 2-31
Light
Air Bag Readiness
....................................... 3-34
Anti-Lock Brake System Warning
................... 3-36
Battery Warning
.......................................... 3-35
Brake System Warning
................................. 3-35
Cruise Control
............................................. 3-43
Malfunction Indicator
.................................... 3-39
Oil Pressure
............................................... 3-42
Safety Belt Reminder
................................... 3-33
TCS Warning Light
...................................... 3-37
Traction Control System Active
...................... 3-38
Traction Control System (TCS) Warning
.......... 3-37
Lighted Visor Vanity Mirror
............................... 2-18
Loading Your Vehicle
....................................... 4-34
Lockout Protection
.......................................... 2-14
Locks Central Door Unlocking System
..................... 2-11
Delayed Locking
.......................................... 2-11
Door
.......................................................... 2-10
Leaving Your Vehicle
.................................... 2-14
Lockout Protection
....................................... 2-14
Power Door
................................................ 2-11
Programmable Automatic Door Locks
............. 2-12
Rear Door Security Locks
............................. 2-13
Loss of Control
................... ................ 4-15
Lumbar Manual Controls
.......... ............ .. 1-3
Power Controls
............................................. 1-4
a
ProCarManuals.com

Magnetic-Speed Variable Assist Steering ............ 4-1 0
Maintenance. Normal Replacement Parts .......... 5-1 01
Maintenance Schedule
At Each Fuel Fill
....................................... 6-9
At Least Once a Month
....... ............... 6-9
At Least Once a Year
..... .............. 6-10
At Least Twice a Year
.................................. 6-10
Brake System Inspection
.............................. 6-14
Exhaust System Inspection
........................... 6-1 3
How This Section is Organized ....................... 6-3
Introduction
.................................................. 6-2
Maintenance Requirements
............................. 6-2
Part
A - Scheduled Maintenance Services ......... 6-4
Part B
- Owner Checks and Services ............... 6-9
Part C
- Periodic Maintenance Inspections ...... 6-13
Part D
- Recommended Fluids and Lubricants . 6-15
Part E
- Maintenance Record ........................ 6-16
Scheduled Maintenance
................................. 6-5
Boot and Seal Inspection
.......................... 6-13
Throttle System Inspection
............................ 6-14
Engine
Cooling System Inspection
................. 6-14
Fuel System Inspection
................................ 6-13
cv---.- -. . .----- :-.- -.--I I- L n .. f. ._ A . . I - ateGI II IY, auq.~w IWWI I IU rl UI 11 UI IV~ nx~e
Using Your ................................................... 6-4 Maintenance Schedule
(cont.)
Your Vehicle and the Environment
............... 6-2
Maintenance When Trailer Towing
..................... 4-43
Making Turns
................................................. 4-41
Malfunction Indicator Light
................................ 3-39
Manual Lumbar Controls
.................................... 1-3
Manual Operation
........................................... 3-24
Manual Passenger Seat
.................................... 1-2
Matching Transmitter(s) to Your Vehicle
............... 2-8
Memory Mirrors
.............................................. 2-48
Memory Seat
................................................. 2-48
Memory Seats
................................................ 3-58
Message DIC Warnings and Messages
........................ 3-50
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and
US
. Virgin Islands) ....................... ..... 7-4
Mirror Operation
............................................. 2-35
Mirrors Automatic Dimming Rearview with Compass
.... 2-35
Memory
..................................................... 2-48
Outside Curb View Assist Mirror
.................... 2-37
Outside Heated Mirrors
................................ 2-38
Outside Power Mirrors
.............................. 2-37
A, ttcirla Pnnrrnv hl;rrnr WUL~IUU -ut IVUfi *Vfftt ut 1-30 n on .................................
9
ProCarManuals.com