wheel OPEL COMBO 2010 Service Manual
[x] Cancel search | Manufacturer: OPEL, Model Year: 2010, Model line: COMBO, Model: OPEL COMBO 2010Pages: 212, PDF Size: 2.49 MB
Page 148 of 212

142 Self-help, vehicle careTyre repair kit
3
Minor damage to the tyre tread or sidewall
can be repaired with the tyre repair kit.
Do not remove the foreign body from the
tyre.
T y r e d a m a g e e x c e e d i n g 4 m m o r t ha t i s o n
the rim cannot be repaired with the tyre
repair kit.
Important information 3145.
In the event of a flat tyre:
zSwitch on the hazard warning flashers,
apply the hand brake, engage first gear
or reverse.
zSet up the warning triangle correctly.
Warning triangle 3133.On the Combo, the tyre repair kit is located
behind a cover on the left in the side trim of
the luggage compartment. On the Combo
Van, it is located in a compartment behind
the driver’s seat.
To open the cover 3, press to release the
retaining lugs.
1. Remove bag containing tyre repair kit
from compartment. Carefully remove
parts from bag.
2. Remove the compressor.
Picture no: 13639T.tif
3. Remove the electrical connection
cable and air hose from the stowage
compartments on the underside of the
compressor.
9 Warning
Do not drive faster than 80 km/h.
Do not use the temporary spare wheel
for a lengthy period.
Steering and handling may be affected.
Page 163 of 212

157
Self-help, vehicle care
Picture no: 12449s.tif
Tail lamps 1. Disengage cover by pressing retaining
lugs and remove.
Picture no: 13725s.tif
2. Detach plug connector from bulb
mounting.
3. Grip the bulb housing from the outside,
slacken the two knurled nuts using the
wheel bolt spanner 3 and unscrew by
hand.
4. Detach bulb housing.
5. Press retaining lugs on bulb mounting
together and remove bulb mounting, as
shown in illustration 13726 S.
Picture no: 13726s.tif
Lamps from top to bottom:
6. Remove bulb from socket.
7. Insert a new bulb. Engage the bulb
mounting in the bulb housing. Insert the
bulb housing into the vehicle body.
Screw the fixing nuts onto setscrews by
hand and tighten. Engage the plug
connector. Place the cover in position
and close. Reversing light/brake light
Turn signal lamp
Reversing light
Fog tail lamp (country-specific version:
fog tail lamp at one side only).
Page 167 of 212

161
Self-help, vehicle care
Washing
The paintwork of your vehicle is exposed to
environmental influences. Wash and wax
your vehicle regularly. When using
automatic car washes, select a programme
that includes waxing.
Bird droppings, dead insects, resin, pollen
and the like should be cleaned off
immediately, as they contain aggressive
constituents which can cause paint
damage.
When using a car wash, follow the car-
wash manufacturer’s instructions. Switch
off the windscreen wipers 3. Unscrew the
antenna 3 and remove the roof rack 3.
If you wash your vehicle by hand, make
sure that the insides of the wings are also
thoroughly rinsed out.
Clean edges and folds on opened doors
and flaps as well as the areas they cover. Thoroughly rinse off and leather-off the
vehicle. Rinse leather frequently. Use
separate leathers for paint and window
surfaces: remnants of wax on the windows
will impair vision.
Do not use hard objects to remove spots of
tar. Use tar removal spray on painted
surfaces.
Polishing and waxing
Wax the vehicle regularly (at the latest
when water no longer beads). Otherwise,
the paintwork will dry out.
Polishing is necessary only if the paint has
become dull or if solid deposits have
become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts should not be treated
with wax and polish. Wheels and tyres
Do not use high-pressure jet cleaners.
Clean wheels with a pH-neutral wheel
cleaner.
Wheels are painted and can be treated
with the same agents as the body.
Paintwork damage
Rectify minor paintwork damage with a
touch-up pen before rust forms. Have more
extensive damage or rust areas repaired
by a workshop.
Page 172 of 212

166 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
⊕
Replace toothed belt and tension roller
Z 16 YNGevery 6 years/90,000 km
Z 17 DTHevery 10 years/90,000 km
Z 16 XEPevery 10 years/150,000 km
Change engine oil and oil filter x x x x x
⊕o
Drain water from diesel fuel filter
(with high humidity and/or low fuel grade)xxxxx
Empty oil separator, Z 16 YNG every 4 years/60,000 km
Replace and drain water from fuel filter,
Z 13 DTJ, Z 17 DTHevery 2 years/60,000 km
Replace fuel filter, Z 16 YNG every 4 years/60,000 km
Check and adjust parking brake (wheels unladen); visually inspect wheel suspension
and spring suspension front and back, brake pipes, brake pressure hoses, fuel pipes,
gas lines on natural-gas powered vehicles and exhaust systemxx
Check external bodywork/underbody corrosion protection; note damage in
the Service and Warranty Bookletxxxxx
⊕o
Visually inspect front and rear wheel brakes
2)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xx
Annual service check when the annual mileage is more than 20,000 km
Visually inspect engine, transmission (AT, MT), air conditioning compressor for leaks
2)
xxxxx
⊕o
Remove, clean and visually inspect brake drum every 4 years/60,000 km
Page 173 of 212

167 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect steering bellows, track rods and axle drive xxxxx
Check track-rod ends and suspension ball joints xxxxx
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not out
of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and not
out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
For Germany only: carry out emissions inspection (AU), general inspection (HU) First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
Page 175 of 212

169 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
⊕
Replace toothed belt and tension roller
Z 16 YNGevery 6 years/90,000 km
Z 17 DTHevery 10 years/90,000 km
Z 16 XEPevery 10 years/150,000 km
Change engine oil and oil filter x x x x x
⊕o
Drain water from diesel fuel filter
(with high humidity and/or low fuel grade)xxxxx
Empty oil separator, Z 16 YNG every 4 years/60,000 km
Replace and drain water from fuel filter,
Z 13 DTJ, Z 17 DTHevery 2 years/60,000 km
Replace fuel filter, Z 16 YNG every 4 years/60,000 km
Check and adjust parking brake (wheels unladen); visually inspect wheel suspension
and spring suspension front and back, brake pipes, brake pressure hoses, fuel pipes,
gas lines on natural-gas powered vehicles and exhaust systemxx
Check external bodywork/underbody corrosion protection; note damage in the
Service and Warranty Bookletxxxxx
⊕o
Visually inspect front and rear wheel brakes
2)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xx
Annual service check when the annual mileage is more than 20,000 km
Visually inspect engine, transmission (AT, MT), air conditioning compressor for leaks
2)
xxxxx
⊕o
Remove, clean and visually inspect brake drum every 4 years/60,000 km
Page 176 of 212

170 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect steering bellows, track rods and axle drive x x x x x
Check track-rod ends and suspension ball joints x x x x x
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not
out of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and
not out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
Page 197 of 212

191
Technical data
Tyres Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3121. Winter tyres
3
Tyre sizes 185/60 R 15, 185/65 R 15,
195/45 R 16 and 195/50 R 16 are not
permitted for winter driving.
Exception: Tyres of size 185/60 R 15 may be
used as winter tyres on the Combo
Tramp/Arizona. If winter tyres are in use, the spare wheel
may still be fitted with a summer tyre. Use
of the spare wheel may alter vehicle
handling. Obtain a replacement for the
faulty tyre as soon as possible, and have
the wheel balanced and fitted to the
vehicle.
Further information 3124.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on the spare
wheel and tyres sizes 185/60 R 15,
185/65 R 15, 195/45 R 16 and 195/50 R 16.
Exception: Tyre chains on tyres of size
185/60 R 15 are permitted on Combo
Tramp/Arizona.
Tyre chains are generally permitted on
tyres of size 185/55 R 15.
Further information 3125. Wheels Wheel bolt tightening torque: 110 Nm.
Spare wheel
3
Depending on the version, the spare wheel
is designed for use as a temporary spare
wheel 3: the handling of the vehicle may
change if the spare wheel is used. Replace
a defective tyre as soon as possible,
balance the wheel and fit it to vehicle. Pay
attention to notes on this page and on
3125, 3135.
On vehicles with alloy wheels 3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1) and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure)The specified tyre pressure are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressure specified on
the following pages apply to both summer
and winter tyres.
The spare wheel must always be filled with
the tyre pressure for a full load - see tables
on following pages.
Temporary spare wheel tyre pressure 3 –
see tables on the following pages.
Further information 3121 to 3125. 1)Country-specific version: The spare wheel is
only permitted for use as a temporary spare.
Page 198 of 212
![OPEL COMBO 2010 Service Manual 192 Technical dataTyre pressure (overpressure) Combo vanComfort when loaded with up to 2 persons
and 100 kg luggage [kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70 OPEL COMBO 2010 Service Manual 192 Technical dataTyre pressure (overpressure) Combo vanComfort when loaded with up to 2 persons
and 100 kg luggage [kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70](/img/37/58222/w960_58222-197.png)
192 Technical dataTyre pressure (overpressure) Combo vanComfort when loaded with up to 2 persons
and 100 kg luggage [kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70 R 14
1)2)
,
175/65 R 14
2),
185/55 R 153)4)
,
185/60 R 15
1)Recommendation: Dunlop SP 10, Firestone F 580, Pirelli P 3000. 2)Not permitted in version with "increased payload".3)Only permitted in version with "increased payload".4)Recommended winter tyres: Conti Vanco Winter C90Q.
240/2.4 240/2.4 240/2.4 350/3.5
Z 13 DTJ 175/70 R 14
1)2)
,
175/65 R 14
2),
185/55 R 153)4)
,
185/60 R 15240/2.4 240/2.4 240/2.4 350/3.5
Z 17 DTH 185/60 R 15,
185/55 R 15
4)
240/2.4 240/2.4 240/2.4 350/3.5
Z 16 YNG 185/60 R 15,
185/55 R 15
4)
240/2.4 240/2.4 240/2.4 350/3.5
all T 115/70 R 16
(Temporary spare
wheel)
5)
5)Notes on temporary spare wheel
3125,
3135.420/4.2 420/4.2 420/4.2 420/4.2
Page 199 of 212
![OPEL COMBO 2010 Service Manual 193 Technical data
Tyre pressure (overpressure) ComboComfort when loaded with up to
3persons[kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70 R 14
1),
175/65 R 14, OPEL COMBO 2010 Service Manual 193 Technical data
Tyre pressure (overpressure) ComboComfort when loaded with up to
3persons[kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70 R 14
1),
175/65 R 14,](/img/37/58222/w960_58222-198.png)
193 Technical data
Tyre pressure (overpressure) ComboComfort when loaded with up to
3persons[kPa/bar]Fully loaded
[kPa/bar]
Engine Tyres Front Rear Front Rear
Z 14 XEP 175/70 R 14
1),
175/65 R 14,
185/55 R 152)3)
,
185/60 R 15
4),
185/65 R 15,
195/45 R 16,
195/50 R 16
1)Recommendation: Michelin Agilis 41, Continental VancoContact. 2)Only permitted in version with "increased payload".3)Recommended: Conti C90Q.4)Recommended: Pirelli P 6000, Continental CPC, Goodyear NCT5, Dunlop SP 01.
240/2.4 240/2.4 240/2.4 350/3.5
Z 13 DTJ 175/70 R 14
1),
175/65 R 14,
185/55 R 152)3)
,
185/60 R 15
4),
185/65 R 15240/2.4 240/2.4 240/2.4 350/3.5
Z 17 DTH 185/60 R 15,
185/55 R 153),
185/65 R 15,
195/50 R 16240/2.4 240/2.4 240/2.4 350/3.5
Z 16 YNG 185/60 R 15,
185/55 R 153),
185/65 R 15 240/2.4 240/2.4 240/2.4 350/3.5
all T 115/70 R 16
(Temporary spare
wheel)
5)
5)Notes on temporary spare wheel
3125,
3135.420/4.2 420/4.2 420/4.2 420/4.2