engine Peugeot 306 Break 2002 Owner's Guide

MAINTENANCE OF YOUR 30639
CHANGING A FUSE The fuse boxes are located under the fascia and in the engine compartment. Fascia fuse box Unscrew the catch a quarter turn using a coin then remove the cover togain access to the fuses.
Removing and changing a fuse Before changing a fuse you must find out the cause of the fault and have it put right. The fuse numbers are indicated on the fuse box. Use the special pliers
Aattached to the box.
Always change a faulty fuse for one of the same rating.
Correct Incorrect Pliers A

MAINTENANCE OF YOUR 306
44
Battery
To charge the battery using a battery charger:
- Disconnect the battery, starting with the negative (-) terminal.
- Follow the instructions for use given by the battery charger manufacturer.
- Reconnect starting with the positive (+) terminal.
- Check that the terminals and connectors are clean. If they are covered with sul-phate deposits (white or greenish deposit), disconnect them and clean them.
To start the vehicle and charge the battery from another battery: Ensure that the connections are good:
- Connect the red cable to the positive (+) terminals of the two batteries.
- Connect one end of the green or black cable to the negative (-) terminal of the slave battery.
- Connect the other end of the green or black cable to an earth point on the broken down vehicle as far as possible from the battery.
Operate the starter, let the engine run.
Wait for the engine to return to idle, and disconnect the cables.
- Never disconnect a terminal when the engine is running.
- Never charge a battery without first disconnecting the terminals.
- After every disconnection of the battery, switch on the ignitionand wait 10 seconds beforestarting. If slight difficulties areexperienced after this, please
contact a PEUGEOT dealer.
It is advisable to disconnect the battery if the vehicle
is not to be used for a period of more than one month.

MAINTENANCE OF YOUR 30647
Driving advice Distribution of loads: distribute the load in the trailer so that the heaviestloads are as close as possible to theaxle and the nose weight is close tothe maximum authorised without,
however, exceeding it. Cooling:
towing a trailer on a slope
increases the coolant temperature. As the fan is electrically controlled, itscooling capacity is not dependent onthe engine speed.
On the contrary, use a high gear to lower the engine speed, and reduceyour speed. The maximum towing load on a long slope depends on the gradient andthe outside temperature. In all cases, pay attention to the coolant temperature. If the warning light comes on, stop the
vehicle and switch off the engine assoon as possible.
TOWING A TRAILER,
CARAVAN, BOAT ETC.
Only use original PEUGEOT towbars which have been tested and approvedfrom the design stage of your vehicle. The towbar must be fitted by a
PEUGEOT dealer.
Your vehicle is mainly designed for transporting people and luggage but it
may also be used to tow a trailer. Driving with a trailer subjects the towing vehicle to more significantforces and requires particular atten-
tion on the part of the driver. Air density decreases with altitude, thus also reducing engine perfor-
mance. Above 1000 metres, reducethe maximum towing load by 10 %and so on for each additional 1000 metres.
For use in arduous conditions(towed load at the limit of the Permis-
sible Gross Train Weight, in Summeron a long hill)
certain engines (1.9 l
Diesel) must be equipped with a
more resistant cooling system.
Consult a PEUGEOT dealer who, depending on your vehicle and what it
is used for, will be able to advise youabout suitable equipment. Pay attention to the coolant tempera- ture at all times. If the alarm warning light comes on,
stop the vehicle and switch off theengine as soon as possible.
Tyres: check the tyre pressures of the
towing vehicle and the trailer, obser- ving the recommended pressures. Brakes: towing increases the braking
distance. Drive at a moderate speed,
change down early, brake graduallyand avoid jerky braking. Lighting: adjust your headlamps so
as not to dazzle other road users. Check the electrical signalling on the
trailer. Side wind: sensitivity to side wind is
increased. Drive smoothly and at a moderate speed.

112
TECHNICAL DATA
(1) With air conditioning. (2) Without air conditioning.
PETROL ENGINES
ENGINES 1.4 litre 1.6 litre 1.8 litre 1.8 litre 16V Capacity ( cm
3
) 1360 1587 1761 1761
Bore x stroke 75 x 77 78,5 x 82 83 x 81,4 83 x 81,4
Number of valves 8 8 8 16Max. power: EU standard (KW) 55 72,6 70 81
at engine speed (r.p.m) 5500 5750 6000 5500
Max. torque: EU standard (Nm) at r .p.m120 at 3400 137,8 at 3250 142 at 3000 155 at 4250
Fuel Unleaded Unleaded Leaded Unleaded
allowed
Catalytic converter yes yes no yes 7CKFW
7CNFT7CL6A7CLFY7AKFW7ANFT7AL6A7ALFY7SKFW7BNFT7BL6A7BLFY7BKFW7ENFT7EL6A7ELFY7EKFW
CAPACITIES (in litres)
Engines (with filter replacement) 3,2 3,2 3,2 4,25(1) - 4,75(2) 4,25(1) - 4,75(2)
Gearbox - Final drive 2 2,4 - 2 2 Manual Manual Automatic Manual Manual
(5-speed) (5-speed) (4-speed) (5-speed) (5-speed)
MODELS: Model codes
GEARBOX

113
TECHNICAL DATA
(1) With air conditioning. (2) Without air conditioning.
PETROL AND DIESEL ENGINES
ENGINES 1,8 litre 16V 2 litres 16 V Diesel DieselTurbo
1,9 litre 2 litres HDI
Capacity (cm 3
) 1761 1998 1868 1997
Bore x stroke 83 x 81,4 86 x 86 82,2 x 88 85 x 88
Number of valves 16 16 8 8Max. power: EU standard (KW) 81 97,4 51 66
at engine speed (r.p.m) 5500 5500 4600 4000
Max. torque: EU standard (Nm) at r .p.m155 at 4250 180 at 4200 125 at 2500 205 at 1900
Fuel Unleaded Unleaded Diesel Diesel
Catalytic converter Yes Yes 7ALFYE
7CWJY
7ALFYT 7AWJY
7BLFYE 7CRFV 7SWJY 7CRHY 7BLFYT 7ARFV 7BWJY 7ARHY
7ELFYE 7BRFV 7EWJY 7BRHY 7ELFYT 7ERFV 7TWJY 7ERHY
CAPACITIES (in litres)
Engines (with filter replacement) 4,25(1) 4,25(1) 4,25(1) 4,5(1) 4,25 4,75(2) 4,75(2) 4,75(2) 4,75(2)
Gearbox - Final drive 2 2 - 1,9 1,9
GEARBOX
Manual Manual Automatic Manual Manual
(5-speed) (5-speed) (4-speed) (5-speed) (5-speed)
MODELS: Model codes

113
TECHNICAL DATA
(1) With air conditioning. (2) Without air conditioning.
PETROL AND DIESEL ENGINES
ENGINES 1,8 litre 16V 2 litres 16 V Diesel DieselTurbo
1,9 litre 2 litres HDI
Capacity (cm 3
) 1761 1998 1868 1997
Bore x stroke 83 x 81,4 86 x 86 82,2 x 88 85 x 88
Number of valves 16 16 8 8Max. power: EU standard (KW) 81 97,4 51 66
at engine speed (r.p.m) 5500 5500 4600 4000
Max. torque: EU standard (Nm) at r .p.m155 at 4250 180 at 4200 125 at 2500 205 at 1900
Fuel Unleaded Unleaded Diesel Diesel
Catalytic converter Yes Yes 7ALFYE
7CWJY
7ALFYT 7AWJY
7BLFYE 7CRFV 7SWJY 7CRHY 7BLFYT 7ARFV 7BWJY 7ARHY
7ELFYE 7BRFV 7EWJY 7BRHY 7ELFYT 7ERFV 7TWJY 7ERHY
CAPACITIES (in litres)
Engines (with filter replacement) 4,25(1) 4,25(1) 4,25(1) 4,5(1) 4,25 4,75(2) 4,75(2) 4,75(2) 4,75(2)
Gearbox - Final drive 2 2 - 1,9 1,9
GEARBOX
Manual Manual Automatic Manual Manual
(5-speed) (5-speed) (4-speed) (5-speed) (5-speed)
MODELS: Model codes

114
TECHNICAL DATA
PETROL ENGINE FUEL CONSUMPTION
7CRFV
2 litres 16 V Manual 7ARFV
22.0 (12.8) 40.4 (7.0) 31.0 (9.1) 219 g/km
7BRFV 7ERFV
In accordance with directive 93/116 in MPG (litres/100km)
Engines Gearbox Model Urban Inter-urban Mixed Emission
codes driving driving driving of CO 2by mass
7CKFW 7AKFW
1,4 litre Manual 7SKFW 32.8 (8,6) 51.4 (5.5) 42.8 (6.6) 156 g/km 7BKFW7EKFW
7CNFT
1,6 litre Manual 7ANFT
31.0 (9.1) 50.4 (5.6) 40.9 (6.9) 165 g/km
7BNFT7ENFT
7CLFYT 7ALFYT 24.4 (11.6) 46.3 (6.1) 34.9 (8.1) 193 g/km7BLFYT
1,8 litre 16 V Manual 7ELFYT 24.1 (11.7) 45.6 (6.2) 34.4 (8.2) 196 g/km 7CLFYE7ALFYE 23.5 (12.0) 44.8 (6.3) 34.0 (8.3) 198 g/km7BLFYE
7ELFYE 22.8 (12.1) 44.1 (6.4) 33.6 (8.4) 198 g/km
7CRFVW
2 litres 16 V Automatic 7ARFVW
20.6 (13.7) 43.5 (6.5) 30.7 (9.2) 221 g/km
7BRFVW 7ERFVW 7CNFT
1,6 litre Automatic 7ANFT
25.7 (11.0) 47.9 (5.9) 36.2 (7.8) 185 g/km
7BNFT7ENFT
Consumption

115
TECHNICAL DATA
The fuel consumption values given are correct at the time of going to press.
CONSUMPTION FOR PETROL/LPG ENGINES
According to directive 93/116 (litres/100 km)
Engine Gearbox Model Urban Inter-urban Mixed Emission of codes roads roads roads C02 by mass
7CWJY 7AWJY
Diesel 1,9 litre Manual 7BWJY
34.0 (8.3) 56.5 (5.0) 44.8 (6.3) 166 g/km
7EWJY 7SWJY
7TWJY
7CRHY
Diesel turbo Manual7ARHY 40.4 (7.0) 64.2 (4.4) 53.3 (5.3) 143 g/km
2 litres HDI 7BRHY 7ERHY
Consumption

116
TECHNICAL DATA
* The speed of a towing vehicle is limited to 60 mph (100 Km/h).
TOWING WEIGHTS AND LOADS (IN KG)
Engines
1.4 litre 1.6 litre 1.6 litre 1.8 litre 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Auto.Manual Manual
Model codes : 7CÉ KFW N F T N F T LFY/L6A RFV R F V W J Y R H Y
¥
Kerb weight1 013 1 071 1 108 1 096 1 160 1 208 1 100 1 142
¥ Gross vehicle weight (GVW) 1 460 1 535 1 550 1 560 1 625 1 650 1 530 1 585 ¥
Gross Train weight (GTW)*2 360 2 435 2 450 2 560 2 625 2 650 2 480 2 585
¥ Unbraked trailer 540 570 575 580 610 630 570 600¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
Engines 1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7AÉ KFW
NFT NFT LFY/L6A
FYE/FYT RFV
RFV WJY RHY
¥
Kerb weight1 043 1 106 1 125 1 116 1 116 1 194 1 242 1 118 1 213
¥ Gross vehicle weight (GVW) 1 480 1 580 1 600 1 600 1 670 1 640 1 650 1 580 1 630 ¥
Gross Train weight (GTW)*2 380 2 480 2 500 2 600 2 670 2 640 2 650 2 530 2 630
¥ Unbraked trailer 550 580 585 590 625 620 640 580 610¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
5 DOOR
Engines 1.4 litre 1.9 l D1.8 l 16 V1.9 l D
Gearbox Manual Manual Manual Manual
Model codes : 7SÉ / 7TÉ KFW WJY FYE/FYT WJZ
¥
Kerb weight1 013 1 100 1 096 1 118
¥ Gross vehicle weight (GVW) 1 460 1 530 1 670 1 580 ¥
Gross Train weight (GTW)*2 360 2 480 2 670 2 530
¥ Unbraked trailer Ñ Ñ Ð Ð¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200
3 DOOR VAN 7S... 5 DOOR VAN 7T...
3 DOOR

117
TECHNICAL DATA
* The speed of a towing vehicle is limited to 60 mph (100 Km/h).
TOWING WEIGHTS AND LOADS (IN KG)
Engines
1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7BÉ KFW N F T N F T LFY/L6AFYE/FYT
RFV RFV WJY RHY
¥
Kerb weight1 042 1 117 1 180 1 162 1 162 1 198 1 225 1 227 1 225
¥ Gross vehicle weight (GVW) 1 515 1 575 1 610 1 615 1 695 1 635 1 660 1 590 1 635 ¥
Gross Train weight (GTW)*2 415 2 475 2 510 2 615 2 695 2 635 2 660 2 540 2 635
¥ Unbraked trailer 555 585 605 600 640 630 650 590 620¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
4 DOOR
Engines 1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7BÉ KFW N F T N F T LFY/L6AFYE/FYT
RFV RFV WJY RHY
¥
Kerb weight1 088 1 150 1 165 1 185 1 185 1 195 1 225 1 172 1 260
¥ Gross vehicle weight (GVW) 1 550 1 605 1 635 1 645 1 725 1 665 1 675 1 625 1 655 ¥
Gross Train weight (GTW)*2 450 2 505 2 535 2 645 2 725 2 665 2 675 2 575 2 655
¥ Unbraked trailer 570 590 620 630 675 640 650 600 635¥
Braked trailer (within GTW)1 000 1 000 1 000 1 000 1 000 1 000 1 000 1 000 1 000
ESTATE