Peugeot 308 CC Dag 2009.5 Owner's Manual
Manufacturer: PEUGEOT, Model Year: 2009.5, Model line: 308 CC Dag, Model: Peugeot 308 CC Dag 2009.5Pages: 256, PDF Size: 19.04 MB
Page 131 of 256
9
!
132
CHECKS
CHECKING LEVELS
Check all of these levels regularly and
top them up if necessary, unless other-
wise indicated.
I f a l e v e l d r o p s s i g n i fi c a n t l y , h a v e t h e
corresponding system checked by a
PEUGEOT dealer. Brake fluid level
In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying
out any work.
To avoid any risk of scalding, unscrew
the cap by two turns to allow the pres-
sure to drop. When the pressure has
dropped, remove the cap and top up
the level.
Oil level The reading will only be correct
if the vehicle is on level ground
and the engine has been off for
more than 15 minutes.
The check is carried out either when the
ignition is switched on using the oil level
indicator on the instrument panel, or us-
ing the dipstick. T h e b r a k e fl u i d l e v e l s h o u l d b e
close to the "MAX" mark. If it is
not, check the brake pad wear.
C h a n g i n g t h e fl u i d
Refer to the Warranty and Maintenance
Record for details of the interval for this
operation.
Power steering fluid level T h e p o w e r s t e e r i n g fl u i d l e v e l
should be close to the "MAX"
mark. Unscrew the cap, with the
engine cold, to check the level. Screenwash and headlamp
wash fluid
I n t h e c a s e o f v e h i c l e s fi t t e d
with headlamp washers, the
m i n i m u m l e v e l o f t h i s fl u i d i s
indicated by an audible signal
and a message on the multifunction
screen.
Top up the level when you stop the ve-
hicle.
Engine oil change
Refer to the Warranty and Maintenance
Record for details of the interval for this
operation.
In order to maintain the reliability of the
engine and emission control system,
the use of additives in the engine oil is
prohibited.
O i l s p e c i fi c a t i o n
The oil must correspond to your engine
and conform to the manufacturer's rec-
ommendations. F l u i d s p e c i fi c a t i o n
T h e b r a k e fl u i d m u s t c o n f o r m t o t h e
manufacturer's recommendations and
f u l fi l t h e D O T 4 s t a n d a r d s .
Changing the coolant
The coolant does not have to be
changed.
F l u i d s p e c i fi c a t i o n
For optimum cleaning and to avoid
f r e e z i n g , t h i s fl u i d m u s t n o t b e t o p p e d
up with or replaced with water.
Coolant level
The coolant level should be
close to the "MAX" mark but
should never exceed it.
When the engine is warm, the tempera-
ture of the coolant is regulated by the fan.
This can operate with the ignition off.
O n v e h i c l e s w h i c h a r e fi t t e d w i t h a
p a r t i c l e e m i s s i o n fi l t e r , t h e f a n m a y
operate after the vehicle has been
s w i t c h e d o f f , e v e n i f t h e e n g i n e i s
cold. F l u i d s p e c i fi c a t i o n
The coolant must conform to the manu-
facturer's recommendations.
When working under the bonnet,
take care, as certain areas of the
engine may be extremely hot (risk
of burns).
Page 132 of 256
9
!
i
133
CHECKS
Avoid prolonged contact of used oil
o r fl u i d s w i t h t h e s k i n .
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
D o n o t d i s c a r d u s e d o i l o r fl u i d s
into sewers or onto the ground.
Take used oil to a PEUGEOT dealer
(France) or an authorised waste dis-
posal site.
Diesel additive level (Diesel
engine with particle emission
filter)
A low additive level is indicated by light-
ing of the service warning lamp, accom-
panied by an audible warning and a
message on the multifunction screen.
Used products
CHECKS
Unless otherwise indicated, check
these components in accordance with
the Warranty and Maintenance Record
and according to your engine.
Otherwise, have them checked by a
PEUGEOT dealer.
B a t t e r y
The battery does not require
any maintenance.
H o w e v e r , c h e c k t h a t t h e t e r -
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.
Air filter and passenger
compartment filter Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environment (e.g.
dusty atmosphere) and the use of the
vehicle (e.g. city driving), replace them
t w i c e a s o f t e n i f n e c e s s a r y (refer to
the "Engines" paragraph).
A c l o g g e d c a b i n fi l t e r m a y h a v e a n a d -
verse effect on the performance of the
air conditioning system and generate
undesirable odours. Particle emission filter (Diesel)
It is imperative that the maintenance of
t h e p a r t i c l e e m i s s i o n fi l t e r i s c a r r i e d o u t
by a PEUGEOT dealer.
Oil filter
R e p l a c e t h e o i l fi l t e r e a c h t i m e
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
val for this component.
Following prolonged operation of
the vehicle at very low speed or at
idle, you may, in exceptional cir-
cumstances, notice the emission
of water vapour at the exhaust on
acceleration. This does not affect
the behaviour of the vehicle or the
environment.
Topping up
This additive must be topped up by a
PEUGEOT dealer without delay.
Page 133 of 256
9
!
i
133
CHECKS
Avoid prolonged contact of used oil
o r fl u i d s w i t h t h e s k i n .
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
D o n o t d i s c a r d u s e d o i l o r fl u i d s
into sewers or onto the ground.
Take used oil to a PEUGEOT dealer
(France) or an authorised waste dis-
posal site.
Diesel additive level (Diesel
engine with particle emission
filter)
A low additive level is indicated by light-
ing of the service warning lamp, accom-
panied by an audible warning and a
message on the multifunction screen.
Used products
CHECKS
Unless otherwise indicated, check
these components in accordance with
the Warranty and Maintenance Record
and according to your engine.
Otherwise, have them checked by a
PEUGEOT dealer.
B a t t e r y
The battery does not require
any maintenance.
H o w e v e r , c h e c k t h a t t h e t e r -
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.
Air filter and passenger
compartment filter Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environment (e.g.
dusty atmosphere) and the use of the
vehicle (e.g. city driving), replace them
t w i c e a s o f t e n i f n e c e s s a r y (refer to
the "Engines" paragraph).
A c l o g g e d c a b i n fi l t e r m a y h a v e a n a d -
verse effect on the performance of the
air conditioning system and generate
undesirable odours. Particle emission filter (Diesel)
It is imperative that the maintenance of
t h e p a r t i c l e e m i s s i o n fi l t e r i s c a r r i e d o u t
by a PEUGEOT dealer.
Oil filter
R e p l a c e t h e o i l fi l t e r e a c h t i m e
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
val for this component.
Following prolonged operation of
the vehicle at very low speed or at
idle, you may, in exceptional cir-
cumstances, notice the emission
of water vapour at the exhaust on
acceleration. This does not affect
the behaviour of the vehicle or the
environment.
Topping up
This additive must be topped up by a
PEUGEOT dealer without delay.
Page 134 of 256
9
!
1 3 4
CHECKS
Only use products recommended
by PEUGEOT or products of equiv-
a l e n t q u a l i t y a n d s p e c i fi c a t i o n s .
In order to optimise the operation
of units as important as the brak-
ing system, PEUGEOT selects and
o f f e r s v e r y s p e c i fi c p r o d u c t s .
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compartment
is strictly prohibited .
Brake disc wear
Brake pads Parking brake
Brake wear depends on the
style of driving, particularly in
the case of vehicles used in
town, over short distances. It
may be necessary to have the
condition of the brakes checked, even
between vehicle services.
Unless there is a leak in the circuit, a
d r o p i n t h e b r a k e fl u i d l e v e l i n d i c a t e s
that the brake pads are worn. For information relating to
checking the brake disc wear,
contact a PEUGEOT dealer.
If a loss of effectiveness of this
system is noticed, the parking
brake must be checked, even
between two services.
This system must be checked by a
PEUGEOT dealer.
Manual gearbox
The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Warranty and
Maintenance Record for the
details of the level checking
interval for this component.
Automatic gearbox The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Warranty and
Maintenance Record for de-
tails of the level checking in-
terval for this component.
Page 135 of 256
10
i
135
PRACTICAL INFORMATION
TEMPORARY PUNCTURE REPAIR KIT Using the kit
Access to the kit
The kit is stowed in the boot below the
fl o o r . I t i s fi t t e d i n t h e t o o l b o x , l o c a t e d
b e l o w t h e s t o r a g e c o m p a r t m e n t . T h i s p r o c e d u r e , c o m p r i s i n g s e v e r a l
s t e p s , m u s t b e c a r r i e d o u t i n f u l l .
S w i t c h o f f t h e i g n i t i o n .
T u r n t h e s e l e c t o r A to the "SEALANT"
p o s i t i o n .
C h e c k t h a t t h e s w i t c h B i s i n p o s i -
tion "0" .
C o n n e c t t h e w h i t e p i p e C to the
v a l v e o f t h e t y r e t o b e r e p a i r e d .
C o n n e c t t h e c o m p r e s s o r ' s e l e c t r i c
p l u g t o t h e v e h i c l e ' s 1 2 V s o c k e t .
A f fi x t h e s p e e d l i m i t a t i o n s t i c k e r t o
t h e v e h i c l e ' s s t e e r i n g w h e e l t o r e -
m i n d y o u t h a t a w h e e l i s i n t e m p o -
r a r y u s e .
S t a r t t h e v e h i c l e a n d l e a v e t h e e n -
g i n e r u n n i n g .
C o m p l e t e s y s t e m c o n s i s t i n g o f a c o m -
p r e s s o r a n d a n i n c o r p o r a t e d s e a l a n t
c a r t r i d g e w h i c h p e r m i t s
temporary re-
pair o f t h e t y r e s o t h a t y o u c a n d r i v e t o
t h e n e a r e s t g a r a g e .
T h i s r e p a i r k i t i s a v a i l a b l e f r o m
P E U G E O T d e a l e r s .
I t i s d e s i g n e d t o r e p a i r m o s t p u n c -
t u r e s w h i c h c o u l d a f f e c t t h e t y r e , l o -
c a t e d o n t h e t y r e t r e a d o r s h o u l d e r .
A v o i d r e m o v i n g a n y f o r e i g n b o d i e s
w h i c h h a v e p e n e t r a t e d t h e t y r e .
Page 136 of 256
10
i
i
136
PRACTICAL INFORMATION
R e m o v e t h e k i t , t a k i n g c a r e t o a v o i d
t o a v o i d s t a i n i n g y o u r v e h i c l e w i t h
t r a c e s o f fl u i d . K e e p t h e k i t t o h a n d .
D r i v e i m m e d i a t e l y f o r a p p r o x i m a t e -
l y t h r e e m i l e s ( fi v e k i l o m e t r e s ) , a t
r e d u c e d s p e e d ( b e t w e e n 1 5 a n d
3 5 m p h [ 2 0 a n d 6 0 k m / h ] ) , t o p l u g
t h e p u n c t u r e .
S t o p t o c h e c k t h e r e p a i r a n d t h e t y r e
p r e s s u r e u s i n g t h e k i t .
T u r n t h e s e l e c t o r A t o t h e A I R p o s i -
t i o n .
C o n n e c t t h e b l a c k p i p e D to the
v a l v e o f t h e w h e e l .
S w i t c h o n t h e c o m p r e s s o r b y m o v -
i n g t h e s w i t c h B t o p o s i t i o n "1" u n t i l
t h e t y r e p r e s s u r e r e a c h e s 2 . 0 b a r s . I f a f t e r a r o u n d 5 t o 7 m i n u t e s t h e
p r e s s u r e i s n o t a t t a i n e d , t h i s i n d i -
c a t e s t h a t t h e t y r e i s n o t r e p a i r a b l e ;
c o n t a c t a P E U G E O T d e a l e r f o r a s -
s i s t a n c e .
Y o u c a n u s e t h i s k i t f o r t h e r o u t i n e
c h e c k a n d a d j u s t m e n t o f t h e t y r e
p r e s s u r e s o n y o u r v e h i c l e . I t c a n
a l s o b e u s e d t o i n fl a t e o t h e r i t e m s
s u c h a s a b a l l o r b i c y c l e t y r e .
T o d o t h i s , t u r n t h e s e l e c t o r t o t h e
" A I R " p o s i t i o n , c o n n e c t t h e b l a c k
p i p e w i t h t h e a p p r o p r i a t e a d a p t e r
t o t h e i t e m t o b e i n fl a t e d , t h e n f o l -
l o w t h e r e m a i n d e r o f t h e p r o c e d u r e
b e l o w u n t i l t h e k i t i s r e m o v e d .
Page 137 of 256
10
!
i
!
1 3 7
PRACTICAL INFORMATION
T a k e c a r e , t h i s p r o d u c t i s h a r m f u l
( e . g . e t h y l e n e - g l y c o l , c o l o p h o n y ,
e t h a n e d i o l . . . ) i f s w a l l o w e d a n d
c a u s e s i r r i t a t i o n t o t h e e y e s . K e e p
i t o u t o f r e a c h o f c h i l d r e n .
T h e e x p i r y d a t e o f t h e fl u i d i s i n d i -
c a t e d o n t h e c a r t r i d g e .
T h e s e a l a n t c a r t r i d g e i s d e s i g n e d
f o r s i n g l e u s e ; e v e n i f o n l y p a r t l y
u s e d , i t m u s t b e r e p l a c e d .
T o r e m o v e t h e c a r t r i d g e , u n s c r e w i t
c o m p l e t e l y a t i t s c a p a n d p u l l o f f .
A f t e r u s e , d o n o t d i s c a r d t h e c a r -
t r i d g e i n t o t h e e n v i r o n m e n t , t a k e
i t t o a n a u t h o r i s e d w a s t e d i s p o s a l
s i t e o r a P E U G E O T d e a l e r .
C o n n e c t t h e c o m p r e s s o r ' s e l e c t r i c
p l u g t o t h e v e h i c l e ' s 1 2 V s o c k e t .
S t a r t t h e v e h i c l e a g a i n a n d l e a v e t h e
e n g i n e r u n n i n g .
A d j u s t t h e p r e s s u r e u s i n g t h e c o m -
p r e s s o r ( t o i n fl a t e : s w i t c h B i n p o s i t i o n
"1" ; t o d e fl a t e : s w i t c h B i n p o s i t i o n
"0" a n d p r e s s b u t t o n E ) , i n a c c o r d -
a n c e w i t h t h e v e h i c l e ' s t y r e p r e s s u r e
l a b e l ( l o c a t e d o n t h e l e f t h a n d d o o r
a p e r t u r e ) .
A l o s s o f p r e s s u r e i n d i c a t e s t h a t t h e p u n c t u r e h a s n o t b e e n f u l l y p l u g g e d ;
c o n t a c t a P E U G E O T d e a l e r f o r a s -
s i s t a n c e .
R e m o v e a n d s t o w t h e k i t . D o n o t f o r g e t t o o b t a i n a n e w s e a l a n t
c a r t r i d g e , a v a i l a b l e f r o m P E U G E O T
d e a l e r s .
T y r e u n d e r - i n fl a t i o n d e t e c t i o n
I f t h e v e h i c l e i s fi t t e d w i t h t y r e u n d e r -
i n fl a t i o n d e t e c t i o n , t h e u n d e r - i n fl a -
t i o n w a r n i n g l a m p w i l l r e m a i n o n a f t e r
t h e w h e e l h a s b e e n r e p a i r e d u n t i l t h e
s y s t e m i s r e i n i t i a l i s e d b y a P E U G E O T
d e a l e r .
D r i v e a t r e d u c e d s p e e d ( 5 0 m p h
[ 8 0 k m / h ] m a x ) l i m i t i n g t h e d i s -
t a n c e t r a v e l l e d t o a p p r o x i m a t e l y
1 2 0 m i l e s ( 2 0 0 k m ) .
G o t o a P E U G E O T d e a l e r a s
s o o n a s p o s s i b l e .
H a v e t h e t y r e i n s p e c t e d b y a t e c h n i c i a n , w h o c a n t h e n a d -
v i s e y o u w h e t h e r i t c a n b e r e -
p a i r e d o r s h o u l d b e r e p l a c e d .
Page 138 of 256
10
i
1 3 8
PRACTICAL INFORMATION
CHANGING A WHEEL
P r o c e d u r e f o r c h a n g i n g a f a u l t y w h e e l
f o r t h e s p a r e w h e e l u s i n g t h e t o o l s p r o -
v i d e d w i t h t h e v e h i c l e .
T h e t o o l s a r e i n s t a l l e d i n t h e b o o t u n d e r
t h e fl o o r .
F o r a c c e s s t o t h e m :
c h a n g e t o t h e " c o u p é " c o n fi g u r a t i o n ,
o p e n t h e b o o t ,
r a i s e t h e fl o o r ,
s e c u r e i t b y h o o k i n g i t s h a n d l e o n
t h e b o o t s e a l ,
u n c l i p a n d r e m o v e t h e b o x c o n t a i n -
i n g t h e t o o l s . A l l o f t h e s e t o o l s a r e s p e c i fi c t o y o u r
v e h i c l e . D o n o t u s e t h e m f o r o t h e r
p u r p o s e s .
1. W h e e l b r a c e .
P e r m i t s r e m o v a l o f t h e w h e e l t r i m a n d r e m o v a l o f t h e w h e e l fi x i n g
b o l t s .
2. J a c k w i t h i n t e g r a l h a n d l e .
P e r m i t s r a i s i n g o f t h e v e h i c l e .
3. " B o l t c o v e r " t o o l .
P e r m i t s r e m o v a l o f t h e b o l t p r o - t e c t o r s ( c o v e r s ) o n a l l o y w h e e l s .
4. S o c k e t f o r t h e s e c u r i t y b o l t s ( l o -
c a t e d i n t h e g l o v e b o x ) .
P e r m i t s a d a p t a t i o n o f t h e w h e e l - b r a c e t o t h e s p e c i a l " s e c u r i t y "
b o l t s .
List of tools
Access to the tools
Wheel with trim
When removing the wheel , d e t a c h t h e t r i m fi r s t u s i n g t h e w h e e l b r a c e 1 p u l l -
i n g a t t h e v a l v e p a s s a g e h o l e .
W h e n r e fi t t i n g t h e w h e e l , r e fi t t h e t r i m s t a r t i n g b y p l a c i n g i t s n o t c h f a c i n g t h e
v a l v e a n d p r e s s a r o u n d i t s e d g e w i t h t h e p a l m o f y o u r h a n d .
Page 139 of 256
10
i
i
139
PRACTICAL INFORMATION
Fitting the steel spare wheel
I f y o u r v e h i c l e i s fi t t e d w i t h a l l o y
w h e e l s , i t i s n o r m a l t o n o t i c e , w h e n
t i g h t e n i n g t h e b o l t s o n fi t t i n g , t h a t
t h e w a s h e r s d o n o t c o m e i n t o c o n -
t a c t w i t h t h e s t e e l s p a r e w h e e l . T h e
w h e e l i s s e c u r e d b y t h e c o n i c a l
c o n t a c t o f e a c h b o l t .
Access to the spare wheel
T h e s p a r e w h e e l i s i n s t a l l e d i n t h e b o o t
u n d e r t h e fl o o r .
A c c o r d i n g t o c o u n t r y , t h e s p a r e w h e e l
m a y b e s t e e l o r a l l o y .
F o r a c c e s s t o i t , r e f e r t o t h e p a r a g r a p h
" A c c e s s t o t h e t o o l s " o n t h e p r e v i o u s
p a g e .
Taking out the wheel
U n s c r e w t h e y e l l o w c e n t r a l b o l t .
R a i s e t h e s p a r e w h e e l t o w a r d s y o u
f r o m t h e r e a r .
T a k e t h e w h e e l o u t o f t h e b o o t .
Putting the wheel back in place
P u t t h e w h e e l b a c k i n i t s h o u s i n g .
U n s c r e w t h e y e l l o w c e n t r a l b o l t b y a
f e w t u r n s t h e n p u t i t i n p l a c e i n t h e
c e n t r e o f t h e w h e e l .
T i g h t e n f u l l y u n t i l t h e c e n t r a l b o l t
c l i c k s t o r e t a i n t h e w h e e l c o r r e c t l y .
P u t t h e b o x b a c k i n p l a c e i n t h e c e n -
t r e o f t h e w h e e l a n d c l i p i t .
T y r e u n d e r - i n fl a t i o n d e t e c t i o n
T h e s p a r e w h e e l i s n o t fi t t e d w i t h
a s e n s o r . T h e p u n c t u r e d w h e e l
m u s t b e r e p a i r e d b y a P E U G E O T
d e a l e r .
Page 140 of 256
10
i
1 4 0
PRACTICAL INFORMATION
Parking the vehicle
I m m o b i l i s e t h e v e h i c l e w h e r e i t
d o e s n o t b l o c k t r a f fi c : t h e g r o u n d
m u s t b e l e v e l , s t a b l e a n d n o n - s l i p -
p e r y g r o u n d .
A p p l y t h e p a r k i n g b r a k e , s w i t c h o f f
t h e i g n i t i o n a n d e n g a g e fi r s t g e a r *
t o l o c k t h e w h e e l s .
I f n e c e s s a r y , p l a c e a c h o c k u n d e r
t h e w h e e l d i a g o n a l l y o p p o s i t e t h e
w h e e l t o b e c h a n g e d .
I t i s i m p e r a t i v e t h a t y o u e n s u r e t h a t
t h e o c c u p a n t s g e t o u t o f t h e v e h i c l e
a n d w a i t w h e r e t h e y a r e s a f e .
N e v e r g o u n d e r n e a t h a v e h i c l e r a i s e d
u s i n g a j a c k ; u s e a n a x l e s t a n d .
Removing the wheel
List of operations
R e m o v e t h e c h r o m e d b o l t c o v e r f r o m
e a c h o f t h e b o l t s u s i n g t h e t o o l 3 .
F i t t h e s e c u r i t y s o c k e t 4 on the
w h e e l b r a c e 1 t o s l a c k e n t h e s e c u r i t y
b o l t .
S l a k e n t h e o t h e r b o l t s u s i n g t h e
w h e e l b r a c e 1 o n l y .
P l a c e t h e j a c k 2 i n c o n t a c t w i t h o n e
o f t h e t w o f r o n t A o r r e a r B l o c a t i o n s
p r o v i d e d o n t h e u n d e r f r a m e , w h i c h -
e v e r i s c l o s e s t t o t h e w h e e l t o b e
c h a n g e d .
E x t e n d t h e j a c k 2 u n t i l i t s b a s e p l a t e
i s i n c o n t a c t w i t h t h e g r o u n d . E n s u r e
t h a t t h e c e n t r e l i n e o f t h e j a c k b a s e
p l a t e i s d i r e c t l y b e l o w t h e l o c a t i o n A
o r B u s e d .
R a i s e t h e v e h i c l e u n t i l t h e r e i s s u f -
fi c i e n t s p a c e b e t w e e n t h e w h e e l a n d
t h e g r o u n d t o a d m i t t h e s p a r e ( n o t
p u n c t u r e d ) w h e e l e a s i l y .
R e m o v e t h e b o l t s a n d s t o r e t h e m i n
a c l e a n p l a c e .
R e m o v e t h e w h e e l .
* p o s i t i o n P f o r t h e a u t o m a t i c g e a r b o x .