engine Peugeot Boxer 2002.5 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2002.5, Model line: Boxer, Model: Peugeot Boxer 2002.5Pages: 182, PDF Size: 2.81 MB
Page 8 of 182
16-09-2002
REAR PARKING
ASSISTANCE This system, installed in the rear
bumper, detects any obstacle
(person, vehicle, tree, barrier,kerb etc) behind the vehicle. Activation With the engine running, the sys- tem is activated when reversegear is engaged; a bleep indi-cates that it is active. The proximity information is given by an audible signal, consisting ofbleeps which become faster asthe vehicle approaches the obs-tacle. When the distance between the rear of vehicle and the obstacle isless than approximately twenty-five centimetres, theaudible signal becomescontinuous. When you switch to neu- tral, the system becomesinactive again.
Activation ➜
Press control A(ON posi-
tion).
A speed can now be memorised.
➜ Press control D(in the OFF
position) to deactivate the system.
Memorising a speed When you reach the required speed, press control Bor C. The
speed is memorised and will be
maintained automatically. Deactivating the memorised speed If you wish to deactivate the memorised speed: ➜ press button Dor the brake
or clutch pedal.
Recalling the memorised speed After deactivation, press button E.
Y our vehicle reverts to the last
memorised speed. Cancelling the stored speed ➜ Place control D(OFF posi-
tion) or switch off the ignition.
9YOUR BOXER AT A GLANCE
CRUISE CONTROL The cruise control makes it pos- sible to maintain a constantvehicle speed, programmed by
the driver, irrespective of the pro-file of the road and without anyaction on the accelerator or thebrake pedals. In order for the vehicle speed to be memorised, it must be greaterthan approximately 40 km/h
135134
Page 9 of 182
OPENING THE BONNET Inside the vehicle: Push the
control on the right-hand side, under the instrument panel. Outside the vehicle: lift the control, raise thebonnet and secure thestrut to keep the bonnetopen.
FILLING WITH FUEL This operation must be carried out with the
engine switched off.
➜ Open the fuel filler flap by pressing the front of it.
➜ Insert the key then turn it to the left.
➜ Remove the cap and hook it onto the hook on the inside of the flap.
An indication on the cap shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the
pump. This could cause a malfunction. The capacity of the tank is approximately 70 litres. ➜ After filling the tank, lock the cap and close the flap.
Low fuel level warning light
From the time this light comes on, you have approxima-
tely 8 litres of fuel left.
YOUR BOXER AT A GLANCE14
120120
16-09-2002
Page 10 of 182
16-09-2002
Moving Off With the engine running, to move
off from position P:
➜ it is essential to press thebrake pedal to exit positionP,
➜ select the function R, D or M,
then gradually release thepressure on the brake pedal;
the vehicle will move off
immediately.
Y ou can also move off from posi-
tion N:
➜ release the handbrake, with
your foot on the brake,
➜ select function R, D or M, then
gradually release the pressureon the brake pedal; the vehicle
will move off immediately.
When the engine is idlingwith the brakes notapplied, if function R, D
or Mis selected, the
vehicle moves without the acce-lerator being pressed. For this reason, do not leave
children unsupervised inside the vehicle, with theengine running.
10YOUR BOXER AT A GLANCE
AUTOMATIC GEARBOX "PORSCHE TIPTRONIC SYSTEM"
The four-speed automaticgearbox offers a choice between the comfort of
automatic integral regulation enhanced by a snow programme , or the
pleasure of manual gear changing .
Gear selection gate ➜ Move the lever in the gate to select one of the functions. Once the function is selected, the indicator light for that function is dis- played on the instrument panel screen.
W: snow programme.
P ark: to immobilise the vehicle or to start the
engine , with the handbrake on or off.
R everse to reverse(select this function with the
vehicle stationary and the engine at idle). N eutral to start the engine or to park, with the
handbrake on.Note : if position Nis engaged by mistake while the
car is moving, allow the engine to return to idling speed before engaging function Dto accelerate.
D rive for automatic gear changing.
M anual: for manualgear changing.
To change the four gearsmanually:
➜ Push the lever to the +symbol to change up a gear and pull the handle
towards the –symbol to change down a gear.
Note: theW (snow) programme does not operate when in manual mode.
130
Page 14 of 182
16-09-2002
PEUGEOT SERVICING Your vehicle benefits from extended service intervals.
¥ For petrol engines: every 30,000 km or every two years.
¥ For dual-fuel Petrol or LPG*/UNG** engines: every 30,000 km or every two years. W arning, LPG/UNG checks every 15,000 km or every year.
¥ For direct injection diesel engines: every 20,000 km or every two years.
* Liquid Petroleum Gas. ** Urban Natural Gas.
PEUGEOT SERVICING
18
Page 15 of 182
16-09-2002
The extension of the service intervals means that the engine oil level must be checked regularly: topping up of the oil between oil changes is normal. This is why the PEUGEOT network is offering you an intermediate service between regular services.
The date of this visit is not shown by the service indicator. It is to be carried out at least every 15,000 km for petrol engines and dual-fuel petrol or LPG/UNG engines; every 10,000 km for direct injection diesel engines. APeugeot dealer will carry out a quick check and top up the levels if necessary (oil, coolant, windscreen wash up
to 2 litres).If the oil level is too low there is a risk of serious damage to the engine : check the engine oil level at least every 3 000 to 5 000 km, depending on the conditions of use. This extended servicing has been made possible by modifications to our vehicles and to the lubricants:
THUS IT IS ESSENTIAL TO ONLY USE ENGINE LUBRICANTS THAT ARE APPROVED AND RECOMMENDED BY THE
MANUFACTURER.
PEUGEOT SERVICING 19
Page 17 of 182
16-09-2002
Zero re-set Your PEUGEOT dealer carries out
this operation after each service.
However, if you carry out the service yourself, the re-set procedure is asfollows: ☞ switch off the ignition,
☞ press and hold the trip recorder re-set button,
☞ switch on the ignition.
The distance remaining to the nextservice flashes. ☞ Press and hold the trip distance recorder zero reset button untilthe display indicates "=0"and
the service spanner disappears.
Important: after this operation, if you
wish to disconnect the battery, lockthe vehicle and wait for at least fiveminutes, otherwise the zero re-setwill not be registered. MAINTENANCE OF PARTS SUBJECT TO WEAR AND A CHECK OF CONSUMABLES Certain essential components on your vehicle are subject to checks at specific frequencies. -
The brake fluid is to be replaced at a maximum of every 60 000 kmor every
two years;
- The coolant is to be replaced at a maximum every 120 000 kmor every 5
years for HDI / TED direct injection Diesel vehicles;
- The pollen filter must be checked at each serviceby a PEUGEOT dealer
(services and intermediate visits) or more often, depending on the environ-
ment (dust, pollution, etc.);
- For HDI turbo diesel engines with particulate emission filter , maintenance
of the filterand topping up of the additive reservoirmust be carried out
every 80 000 km by a PEUGEOT dealer;
- Replacement of the timing belt: contact a PEUGEOT dealer;
- Air bags and pretensioning parts on seat belts must be checked every
10 years ;
- The check on tyre inflation presure must be carried out cold at least once a
month .
PEUGEOT SERVICING 21
Page 18 of 182
16-09-2002
KM 30 000 60 000 90 000
THE SERVICE LEVELS Each vehicle has its own servicing cycle, based upon the engine type.
This cycle consists of alternating 3 types of service, A, B and C, intermediate visits and a few additional operations specific to your vehicle; these correspond to key stages in the life of your vehicle. At your first and each subsequent service, your dealer will advise you of the type and content of the next service due.
PEUGEOT SERVICING
22
MAINTENANCE CYCLE FOR YOUR BOXER PETROL ENGINE
Service every 2 years or 30 000 km maximum
1st service at 10 000 km or 6 months*.
This is necessary in order to benefit from the warranty.
These fixed operations are carried out with synthetically based oil.
Synthetic oil or fuel economy oil may also be used.
Arduous conditions of use (see corresponding section).
* Whichever comes first.
Intermediate visit included in the fixed interval services.
120 000 150 000 180 000 210 000 240 000
Page 19 of 182
16-09-2002
PEUGEOT SERVICING23
MAINTENANCE CYCLE FOR YOUR BOXER PETROL/LPG OR UNG ENGINE
Service every 2 years or 30 000 km maximum + LPG/UNG checks every 15 000 km or every year.
LPG/UNG checks: - union sealing check.- LPG/UNG autodiagostics memories check.- adjustment of the pressure relief valve pressures. These fixed operations are carried out with synthetically based oil.
Synthetic oil or fuel economy oil may also be used.
Arduous conditions of use (see corresponding section).
* Whichever comes first.
Intermediate visit included in the fixed interval services + LPG/UNG checks.
KM 30 000 60 000 90 000
1st service at 10 000 km
or 6 months*.
This is necessary in order to benefit from the warranty.
120 000 150 000 180 000 210 000 240 000
+ LPG/UNG checks + LPG/UNG checks
+ LPG/UNG solenoid valve filter
replacement + LPG/UNG checks
+ LPG/UNG checks
+ LPG/UNG solenoid valve filter
replacement + LPG/UNG checks
+ LPG/UNG checks
+ LPG/UNG solenoid valve filter
replacement + LPG/UNG checks
+ LPG/UNG checks
+ LPG/UNG solenoid valve filter
replacement
Page 20 of 182
16-09-2002
PEUGEOT SERVICING
24
MAINTENANCE CYCLE FOR YOUR BOXER TURBO DIESEL HDI 2.0/2.2 LITRE ENGINE
Service every 2 years or 20 000 km maximum
Arduous conditions of use (see corresponding section)
* Whichever comes first.
Intermediate visit included in the fixed interval services.
KM 20 000 40 000 60 000 80 000 100 000
First service at
10 000 km
or 6 months*.
This is necessary
in order to benefit from the warranty
120 000 140 000 160 000 180 000 200 000 220 000 240 000
These fixed operations are carried out with synthetically based oil.
Page 21 of 182
16-09-2002
PEUGEOT SERVICING25
+ replacement
of air
filter for HDI engine
MAINTENANCE CYCLE FOR YOUR BOXER 2.8 LITRE TURBO DIESEL HDI/TED ENGINE
Service every 2 years or 20 000 km maximum
Arduous conditions of use (see corresponding section)
* Whichever comes first.
Intermediate visit included in the fixed interval services.
These fixed operations are carried out with
synthetically based oilor synthetic oil .
KM 20 000 40 000 60 000 80 000 100 000
First service at
10 000 km or 6 months*. This is necessary
in order to benefit from the warranty
120 000 140 000 160 000 180 000 200 000 220 000 240 000
+ replacement of air
filter for HDI engine + replacement
of air
filter for HDI engine
+ check and adjustment of valve clearances + replacement
of air
filter for HDI engine + check and adjustment
of valve clearances
+ replacement
of air
filter for HDI engine
+ replacement
of air
filter for HDI engine