towing Peugeot Boxer 2003 Owner's Manual

05-05-2003
YOUR BOXER IN DETAIL127
REAR PARKING ASSISTANCE This system consists of proximity
sensors, located in the rear bumper,and a special speaker fitted in thefascia. This detects any obstacle (person, vehicle, tree, gate, etc.) behind the
vehicle. However, it may not detectobstacles located just below the
bumper. An object, such as a stake, a road- works cone or any other similarobject may be detected at the begin-ning of the manoeuvre, but may nolonger be detected when the vehicleis close to it. Note:
this function will be disarmed
automatically when the vehicle is
towing a trailer.
In bad or wintry weather, ensure that the sensors are not covered with
mud, frost or snow. Activation The system is activated as soon as reverse gear is engaged; an audiblebleep shows that it is active. The proximity information is given by an audible signal, which becomesmore rapid as the vehicle approachesthe obstacle. When the distance between the rear of the vehicle and the obstacle is lessthan approximately twenty centi-metres, the audible signal becomescontinuous.Deactivation ☞
Change to neutral, the system is again inactive.
Detection zone
If there is an operating fault, the audible signalwill be a short bleep follo-wed by a long bleep when
changing to reverse gear.

05-05-2003
TOWING YOUR VEHICLE
W ithout lifting (4 wheels on the ground)
Y ou must always use a tow bar.
The towing eyes are located at the front and the rear under the vehicle's bumpers. Lifting (2 wheels only on the ground) It is preferable to raise the vehicle with a professional lifting device. Special features of the automatic gearbox When towing with four wheels on the ground, the following rules must beobeyed: -
lever in position N,
- tow the vehicle at less than 30 mph (50 km/h) over a maximum distanceof 30 miles (50 km).
- do not add oil to the gearbox.
PRACTICAL INFORMATION
148
When towing with the engine switched off, thereis no braking or steeringassistance.

05-05-2003
TOWING A TRAILER,
CARAVAN, BOAT etc.
Only use original PEUGEOT tow bars that have been tested andapproved from the design stage of
your vehicle. The tow bar must be
fitted by a PEUGEOT dealer. Y our vehicle is primarily designed for
transporting people and luggage but it may also be used for towing a
trailer. Driving with a trailer subjects the towing vehicle to more significantstress and its driver must be particu-larly careful. Air density decreases with altitude, thus reducing engine performance.Above 1000 metres, the maximumtowing load must be reduced by 10%and so on for every 1000 metres ofaltitude. Driving advice Distribution of loads :
Distribute the
load in the trailer so that the heaviest items are as close as possible to theaxle and the nose weight approachesthe maximum permitted without excee-ding it. Cooling : Towing a trailer on a slope
increases the temperature of the coolant. As the fan is electrically controlled, its cooling capacity is not dependenton the engine speed.
On the contrary, use a high gear to lower the engine speed and reduceyour speed. The maximum towing load on a long slope depends on the gradient andthe outside temperature. In all cases, pay attention to the coolant temperature. If the warning light comes on, stop
the vehicle and switch off the engineas soon as possible. T
yres : Check the tyre pressures
of the towing vehicle and of the
trailer, observing the recommendedpressures. Braking : Towing increases the
braking distance. Lights : Check the electrical
signalling on the trailer.Side wind : Take into acount the
increased sensitivity to side wind.
PRACTICAL INFORMATION 149

05-05-2003
2 LITRE INJECTIONVAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1695 1730 1735 1745 1780 1695 1730 1735 1745 1780
¥ Gross vehicle weight (GVW) 2900 2900 2900 2900 2900 3300 3300 3300 3300 3300
¥ Payload 1205 1170 1165 1155 1120 1605 1570 1565 1555 1520
¥ Gross train weight (GTW)* Ð ÐÐÐÐ ÐÐ ÐÐ Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000 2000
TECHNICAL DATA
156
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2 LITRE INJECTION VAN
Model codes:
330LH 330LHS 350C 350CS 350M 350MH 350MHS 350LH 350LHS
¥ Kerb weight 1815 1865 1765 1800 1785 1795 1830 1865 1915
¥ Gross vehicle weight (GVW) 3300 3300 3500 3500 3500 3500 3500 3500 3500
¥ Payload 1485 1435 1735 1700 1715 1705 1670 1635 1585
¥ Gross train weight (GTW)* ÐÐÐÐÐ ÐÐÐÐ
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000

05-05-2003
TECHNICAL DATA157
2 LITRE INJECTION
CHASSIS CHASSIS DOUBLE PLATFORM PLATFORM DOUBLE CAB CAB CAB CAB
Model codes: 330L 350L 350L 330L 350L 350L
¥ Kerb weight 1565 1615 1770 1795 1845 1950
¥ Gross vehicle weight (GVW) 3300 3500 3500 3300 3500 3500
¥ Payload 1735 1885 1730 1505 1655 1550
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2 LITRE INJECTIONFLAT FLOOR COMBI MINIBUS CAB
Model codes: 330L 350L 290C 330M 330MH 290C 330MH
¥ Kerb weight 1530 1580 1805 1845 1945 1925 2065
¥ Gross vehicle weight (GVW) 3300 3500 2900 3300 3300 2900 3300
¥ Payload 1770 1920 1095 1455 1355 975 1235
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000

05-05-2003
TECHNICAL DATA
158
2 LITRE TURBO HDI
VAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1755 1790 1795 1805 1840 1755 1790 1795 1805 1840
¥ Gross vehicle weight (GVW) 2900 2900 2900 2900 2900 3300 3300 3300 3300 3300
¥ Payload 1145 1110 1105 1095 1060 1545 1510 1505 1495 1460
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600 1600 1600 1600
W eights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h). 2 LITRE TURBO HDI
CHASSIS CAB
Model codes: 290C 290M 330C 330M 330L
¥ Kerb weight 1600 1610 1600 1610 1625
¥ Gross vehicle weight (GVW) 2900 2900 3300 3300 3300
¥ Payload 1300 1290 1700 1690 1675
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð
¥ Unbrakd trailer 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600

05-05-2003
TECHNICAL DATA159
W eights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h). 2 LITRE TURBO HDI BARE CHASSIS COMBI MINIBUS
Model codes: 290C 330C 330M 330L 290C 330M 290C
¥ Kerb weight 1310 1310 1320 1335 1865 1905 1985
¥ Gross vehicle weight (GVW) 2900 3300 3300 3300 2900 3300 2900
¥ Payload 1590 1990 1980 1965 1035 1395 915
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600
2 LITRE TURBO HDI PLATFROM CAB FLAT FLOOR CAB
Model codes:
290C 290M 330C 330M 330L 290C 290M 330C 330M 330L
¥ Kerb weight 1780 1815 1780 1815 1855 1555 1570 1555 1570 1590
¥ Gross vehicle weight (GVW) 2900 2900 3300 3300 3300 2900 2900 3300 3300 3300
¥ Payload 1120 1085 1520 1485 1445 1345 1330 1745 1730 1710
¥ Gross train weight (GTW)* Ð ÐÐÐÐ ÐÐ ÐÐ Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600 1600 1600 1600

05-05-2003
TECHNICAL DATA
160
2.2 LITRE TURBO HDI
VAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1825 1860 1865 1875 1910 1825 1860 1865 1875 1910
¥ Gross vehicle weight (GVW) 2900 2900 2900 2900 2900 3300 3300 3300 3300 3300
¥ Payload 1075 1040 1035 1025 990 1475 1440 1435 1425 1390
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000 2000
W eights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2.2 LITRE TURBO HDI VAN
Model codes: 330LH 330LHS 350C 350CS 350M 350MH 350MHS 350LH 350LHS
¥ Kerb weight 1945 1995 1895 1930 1915 1925 1960 1995 2045
¥ Gross vehicle weight (GVW) 3300 3300 3500 3500 3500 3500 3500 3500 3500
¥ Payload 1355 1305 1605 1570 1585 1575 1540 1505 1455
¥ Gross train weight (GTW)* ÐÐÐÐÐ ÐÐÐÐ
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000

05-05-2003
TECHNICAL DATA161
2.2 LITRE TURBO HDI CHASSIS CAB
Model codes: 330C 330M 330L 330XL 350C 350M 350L 350XL
¥ Kerb weight 1670 1680 1695 1735 1720 1730 1745 1785
¥ Gross vehicle weight (GVW) 3300 3300 3300 3300 3500 3500 3500 3500
¥ Payload 1630 1620 1605 1565 1780 1770 1755 1715
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000
W eights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2.2 LITRE TURBO HDICHASSIS DOUBLE CAB
Model codes: 330M 330L 350M 350L
¥ Kerb weight 1840 1850 1890 1900
¥ Gross vehicle weight (GVW) 3300 3300 3500 3500¥ Payload 1460 1450 1610 1600
¥ Gross train weight (GTW)* Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000

05-05-2003
TECHNICAL DATA
162
2.2 LITRE TURBO HDI FLAT FLOOR CAB
Model codes: 330C 330M 330L 350C 350M 350L
¥ Kerb weight 1625 1640 1660 1675 1690 1710
¥ Gross vehicle weight (GVW) 3300 3300 3300 3500 3500 3500
¥ Payload 1675 1660 1640 1825 1810 1790
¥ Gross train weight (GTW)* Ð ÐÐÐÐ Ð
¥ Unbraked trailer 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000
W eights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2.2 LITRE TURBO HDI PLATFORM CAB PLATFORM DOUBLE CAB
Model codes: 330C 330M 330L 350C 350M 350L 330M 330L 350C 350L
¥ Kerb weight 1850 1885 1925 1900 1935 1975 1990 2030 2040 2080
¥ Gross vehicle weight (GVW) 3300 3300 3300 3500 3500 3500 3300 3300 3500 3500
¥ Payload 1450 1415 1375 1600 1565 1525 1310 1270 1460 1420
¥ Gross train weight (GTW)* Ð Ð ÐÐÐÐÐÐÐÐ
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000 2000