Brake Peugeot Boxer 2018 Owner's Guide

149
Third brake lamp
Ty p e A, W5W – 5W (x 4)
F
R
emove the two lamp fixing screws.
F

R
emove the lamp by pulling it towards you.
F

R
emove the bulb holder by squeezing the
two tongues inwards.
F

R
emove the failed bulb by pulling it out.
F

C
hange the bulb.
Changing a fuse
The three fuseboxes are located on the
dashboard on the left-hand side, in the pillar
on the right-hand side and in the engine
compartment.
The designations provided are only for the
fuses that can be replaced by the user. For
any other work, visit a
PEUGEOT dealer or
a


qualified workshop. Professional repairers: for full information
on the fuses and relays, consult the
wiring information and diagrams via the
PEUGEOT dealer network.
Removing and fitting a fuse
PEUGEOT accepts no responsibility for
the cost incurred in repairing your vehicle
or for rectifying malfunctions resulting
from the installation of accessories not
supplied by and not recommended by
PEUGEOT and not installed in accordance
with its specifications, in particular when
the combined power consumption of all
of the additional equipment connected
exceeds 10


milliamperes.
Good
Failed
Before changing a fuse, the cause of the fault
must be found and rectified. The numbers of
the fuses are indicated on the fusebox.
Always replace a faulty fuse with a fuse of
the same rating.
8
In the event of a breakdown

150
Dashboard, left-hand side,
fuses
F Remove the bolts and tilt the box to access the fuses. Fuses A (amps)
Allocation
12 7. 5Right-hand dipped headlamp
13 7. 5Left-hand dipped headlamp
31 5Engine compartment control unit relay – Dashboard control unit
relay (ignition +)
32 7. 5Cabin lighting (battery +)
33 7. 5Battery check sensor on Stop & Start model (battery +)
34 7. 5Minibus interior lighting – Hazard warning lamps
36 10Audio system – Air conditioning controls – Alarm – Tachograph –
Battery cut-off control unit – Additional heating programmer (battery +)
37 7. 5
Brake lamps switch – Third brake lamp – Instrument panel (ignition +)
38 20Central door locking (battery +)
42 5ABS control unit and sensor – ASR sensor – DSC sensor – Brake
lamps switch
43 20Windscreen wiper motor (ignition +)
47 20Driver's electric window motor
48 20Passenger's electric window motor
49 5Parking sensors control unit – Audio system – Steering wheel
mounted controls – Centre and side switch panels – Auxiliary switch
panel – Battery cut-off control unit (ignition +)
50 7. 5Airbags and pre-tensioners control unit
51 5Tachograph – Power steering control unit – Air conditioning – Reversing
lamps – Water in Diesel sensor – Air flow sensor (ignition +)
53 7. 5Instrument panel (battery +)
89 -Not used
90 7. 5Left-hand main beam
91 7. 5Right-hand main beam
92 7. 5Left-hand front foglamp
93 7. 5Right-hand front foglamp
In the event of a breakdown

155
To w i n g
General recommendations
Obser ve the legislation in force in your
c o u nt r y.
Ensure that the weight of the towing
vehicle is higher than that of the towed
vehicle.
The driver must remain at the wheel of
the towed vehicle and must have a valid
driving licence.
When towing a
vehicle with all four wheels
on the ground, always use an approved
towbar; rope and straps are prohibited.
The towing vehicle must move off gently.
When the vehicle is towed with its engine
off, there is no longer braking and steering
assistance.
In the following cases, you must always
call on a
professional recovery ser vice:
-

v
ehicle broken down on a motor way or
main road,
-
f

our-wheel drive vehicle,
-

w
hen it is not possible to put the
gearbox into neutral, unlock the
steering, or release the parking brake,
-

t
owing with only two wheels on the
ground,
-

w
here there is no approved towbar
available.
The charging operation must be carried
out in a

ventilated area away from naked
flames or any possible sources of sparks
to eliminate the risk of explosion and fire.
Do not try to charge a

frozen battery: it
must first be thawed out to avoid the risk
of explosion. If the battery has frozen,
before charging it have it checked by
a

specialist who will verify that the internal
components have not been damaged and
that the case is not cracked, which could
mean that there is a

risk of a

leak of toxic
and corrosive acid.
Proceed with a

slow charge at low current
for a

maximum of about 24

hours to avoid
damaging the battery.
Charging the battery using
a battery charger
F Go to the battery located in the front left
f l o o r.
F

D
isconnect the battery.
F

F
ollow the instructions for use provided by
the manufacturer of the charger.
F

R
econnect starting with the negative (-)
terminal.
F

C
heck the condition of the terminals and
clamps. If they are covered with sulphate
(whitish or greenish deposits), disconnect
them and clean them all.
After refitting of the battery by
a
PEUGEOT dealer or a qualified
workshop, the Stop & Start system will
only be active after a
continuous period
of immobilisation of the vehicle, a period
which depends on the climatic conditions
and the state of charge of the battery (up
to about 8
hours).
The presence of this label, in particular
with the Stop & Start system, indicates
the use of a
12 V lead-acid battery with
special technology and specification; the
involvement of a
PEUGEOT dealer or
a
qualified workshop is essential when
replacing or disconnecting the battery.
8
In the event of a breakdown

159
Weights and towed loads
These tables present the type-approved weights (in kg) according to the vehicle model and dimensions.Minibus
Dimensions Model name GV WUnbraked trailer Recommended nose
weight
L3
H2 440 4,005 XX
L4
H2 442 4,250 XX
Combi 5- 6
seat
Dimensions Model name GV WUnbraked trailer Recommended nose
weight
L1


H 1 330
3,000 75010 0
333 3,300 75010 0
L2
H2 333
3,300 75010 0
435 3,500 750120
Combi 7- 8-9
seat
Dimensions Model name GV WUnbraked trailer Recommended nose
weight
L1


H 1 330 3 ,1 5 0 75010 0
L2
H2 333 3,300 75010 0
9
Technical data

160
Van
Dimensions Model name GV WUnbraked trailer Recommended nose
weight
L1


H 1 328
2,800 75010 0
330 3,000 75010 0
333 3,300 75010 0
335 3,500 75010 0
435 3,500 750120
440 4,005 750120
L1

H2 330
3,000 75010 0
333 3,300 75010 0
335 3,500 75010 0
L2

H1 330
3,000 75010 0
333 3,300 75010 0
335 3,500 75010 0
435 3,500 750120
L2

H2 330
3,000 75010 0
333 3,300 75010 0
335 3,500 75010 0
435 3,500 750120
440 4,005 750120
Technical data

161
Van
Dimensions Model name GV WUnbraked trailer Recommended nose
weight
L3

H2 333
3,300 75010 0
335 3,500 75010 0
435 3,500 750120
440 4,005 750120
L3

H3 333
3,300 75010 0
335 3,500 75010 0
435 3,500 750120
440 4,005 750120
L4

H2 435
3,500 750120
440 4,005 750120
L4

H3 435
3,500 750120
440 4,005 750120
9
Technical data

173
Rear lampsF Identify the defective bulb.
Carry out these operations in reverse order to
put each bulb in place.
1.
Direction indicators
Ty p e B , PY21W – 21W
2. Brake lamps
Ty p e B , P21W – 21W
3. Sidelamps
Ty p e A , W5W – 5W
4. Reversing lamps
Ty p e A , W16W – 16W
5. Foglamps
Ty p e A , W16W – 16W F

R
emove the four fixing screws of the lamp
unit.
F

P
ull the lamp unit out towards you.
F

C
hange the bulb.
10
Special features

182
Weights and towed loads
(kg)
With load transfer, the braked trailer weight can
be increased, on condition that the equivalent
of this load is removed from the vehicle so that
the GTW is not exceeded. Warning: towing with
a lightly loaded towing vehicle may have an
adverse effect on its road holding.
The kerb weight is equal to the weight without
load + driver (75
kg) + fuel tank filled to 90%.
Hydraulic system
These precautions are mandator y for any
work on the hydraulic system. Before towing a trailer, check that:
-
t
he nose weight on the towbar ball does
not exceed the value (S) indicated on the
trailer's weight plate,
-
t
he maximum trailer weight is less than
the value indicated on the trailer's weight
plate and the Gross Vehicle Weight (GV W)
does not exceed the value indicated on the
vehicle's weight plate.
-
i
n the case of a self-supporting trailer,
the Gross Train Weight (GTW) must not
exceed the value indicated on the vehicle's
weight plate.
• N ever work under a tipper body that is not
supported,
•

S
witch off the power supply to the electro-
hydraulic unit using the circuit breaker,
•

V
ehicle stationary, engine off.
•

W
hen carrying out maintenance work
under the tipper body, place the tipper body
in the safety position secured with its stay
(position indicated by a red arrow under the
back of the tipper body),
Special features

185
Accessories .................................................... 67
AdBlue® .................................................. 13 2-13 3
Adjusting the date ........................................... 28
Adjusting the seat angle


................................. 37
Adjusting the seat belt height
.................... 7

2-73
Adjusting the time


........................................... 28
Advice on driving


...................................... 87- 8 9
Airbags
...............................

.............................78
Airbags, curtain


............................................... 76
Airbags, front ....................................... 75 -76, 79
Airbags, lateral


................................................ 76
Air conditioning


......................................... 46 - 47
Air conditioning, additional
....................... 4

6 - 47
Air conditioning, automatic


.......................44, 50
Air conditioning, manual
........................... 4

3, 50
Alarm


............................................................... 35
Anti-lock braking system (ABS)
..........12, 68 - 69
Armrest, front
.................................................. 38
Anti-slip regulation (ASR)


.........................68-69
Assistance, emergency braking


...............68-69
Audio streaming (Bluetooth)


..........................7- 8
Audio system
..................................................... 1
Battery


............................................. 91, 129, 153
BlueHDi


................................................... 21, 132
Bluetooth (hands-free)
........................... 1

2-13, 5
Bluetooth (telephone)
............................. 1

2-13, 5
Bonnet


........................................................... 125
Brake discs


............................................. 12 9 -131
Brakes


........................................................... 131
Brightness


......................................................... 8
Bulbs (changing)


.................................... 143 -14 4
Bulbs (changing, type)


.................................. 14 4Cable, audio
..................................................
7, 4
Cable, Jack ...................................................7, 4
Capacity, fuel tank
..................................20, 116
CD


.....................................................................7
CD, MP3


............................................................7
Centre console


..................................................4
Changing a


bulb
.....................................14

3 -14 4
Checking the levels


................................126 -128
Checks


...................................................12 9 -131
Checks, routine


.....................................129, 131
Child seats

..............................
...........74, 77, 85
Cigarette lighter


..............................................58
Configuration, vehicle
............................... 2

2, 27
Control, heated seats


......................................38
Control stalk, lighting


................................15, 61
Control stalk, wipers

.......................................65
C

ourtesy lamp, front ...........................52-54, 56
Courtesy lamp, rear
........................................58
Courtesy lamps
...............................................58
Cruise control


.........................................101-105
DAB (Digital Audio Broadcasting) – Digital radio


..........................5
Dashboard


.........................................................4
Daytime running lamps


...................................61
Daytime running lamps, LED


..........................62
Deactivating the passenger airbag


.....75, 78 -79
Dimensions
..............................

.....................162
Direction indicators


...................................15, 61
Display screen, instrument panel


...............7, 92
Driving abroad ................................................. 61
Dynamic stability control (DSC)


................68-69 Emergency braking assistance (EBA)
......
68-69
Electric windows .............................................36
Electronic brake force distribution (EBFD)
....68-69
Engine compartment
.................................... 12

6
Engine, Diesel


...............................118, 126, 158
Engines


..................................................157-15 8
Filling the AdBlue
® tank ................................ 132
Filling the fuel tank ................................ 11 6 , 11 8
Filter, air


........................................................ 12 9
Filter, Diesel fuel


................................... 126, 131
Filter, oil
................

......................................... 12 9
Filter, particle


......................................... 12 9 -13 0
Filter, passenger compartment


..................... 12 9
Fittings, front


............................................. 52-56
Fittings, interior
......................................... 5

2-56
Flap, fuel filler


................................................ 11 6
Fluid, brake


............................................ 126 -128
Fluid, engine coolant


.............................. 126 -128
Fluid, power steering
............................. 12

6 -128
Foglamps, front


............................................... 61
Foglamps, rear
................................................ 61
Fr

ont doors
...................................................... 33
Fu

el ................................................................ 11 8
Fuel tank ........................................................ 11 6
A
B
C
D
E
F
.
Alphabetical index

186
Hazard warning lamps ....................................68
Headlamp flash ............................................... 61
Headlamps, dipped beam


...............................61
Headlamps, main beam


............................16, 61
Head restraints, front
...................................... 37
Heating
............................................................ 43
H

eating, additional

.................................... 46 - 47
Hill Descent Control


................................... 71-72
Hill start assist
................................................. 95
Horn ................................................................. 68
Immobiliser, electronic


....................................89
Indicator, coolant temperature


........................20
Indicator, engine oil level
...........................18 -19
Indicator lamps, operation
................................ 9
I

ndicators, direction

........................................ 61
Information, vehicle ......................................... 14
Instrument panels


............................................. 7
Instruments and controls
..................................4
Intelligent Traction Control


..............................71Kit, hands-free
.......................................
1
2-13, 5
Jack
...............................
................................
7, 4Pads, brake

............................................
12 9 -131
Parking brake

........................
11, 91-92, 129 -131
Player, USB ................................................
6 - 7, 4
Port, USB ...................................................
6 - 7, 4
Pre-tensioning seat belts

................................
74
Protecting children

..............................
75, 77, 79
Radio ......................................................4, 7, 2-3
Radio, digital (Digital Audio Broadcasting – DAB)
......................................5
Range, AdBlue


................................................21
Regeneration of the particle filter
..........12 9 -13 0
Remote control


..........................................30, 89
Replacing bulbs
..................................... 14

3 -14 4
Replacing the air filter
................................... 12

9
Replacing the oil filter
................................... 12

9
Replacing the passenger compartment filter


....12 9
Resetting the service indicator


..................18 -19
Rev counter


.......................................................7
Safety, children


...................................75, 77, 79
Screen, colour
................................................... 4
S

creen menu map

.........................4, 6, 9, 12, 14
Screenwash fluid


...................................126 -128
SCR (Selective Catalytic Reduction)


............132
Seat belts


...................................................7 2 -74
Seat belts, rear


................................................73
Seats, heated


..................................................38
Service indicator


........................................18 -19
Servicing
.................................................... 1

8 -19
Settings, equipment


..................................22, 27
Oil, engine


..............................................126 -128
On-board tools


.......................................137-142
Opening the bonnet


......................................125
Overhead storage
............................... 5

2-54, 56
Menu


.......................................22, 4, 6, 9, 12, 14
Menus (audio)


...............................................4, 6
Mirrors, door .................................................... 42
Lane Departure Warning
System (LDWS)


...................................10 6 -107
Level, engine coolant


......................................20
Levels


.....................................................126 -128
Levels and checks

..............................
..........126
Lighting dimmer


................................................8
Low fuel level

..........................................2

0, 116
Lumbar


............................................................37H
I
K
JP
R
S
O
M
L
Gauge, fuel.............................................. 20, 116
Gearbox, manual .............................. 92, 94, 130
Gear shift indicator ~ Gear efficiency indicator


....................................... 17
Glove box
.................................................. 52-55G
Alphabetical index