belt Ram ProMaster City 2020 Workshop Manual

SERVICING AND MAINTENANCE 243
Mileage or time passed (whichever comes first)
20,00030,000
40,00050,00060,00070,00080,00090,000
100,000
110,000120,000130,000
140,000150,000
Or Years: 2 3 4 56
7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000 48,000
64,00080,00096,000
112,000 128,000144,000160,000
176,000192,000208,000
224,000240,000
Additional Inspections
Inspect the CV joints. X X X X X X X X X X X X X X
Inspect front suspension, boot seals, tie rod ends,
and replace if necessary. X X X X X X X
Inspect the brake linings, parking brake function. X X X X X X X
Inspect front accessory drive belt, tensioner, idler
pulley, and replace if necessary. X
Additional Maintenance
Replace engine air cleaner filter.
1X XX XX
Replace air conditioning/cabin air filter. X X X X X X X
Change brake fluid every two years.
2X X X X X X X
7
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 243

SERVICING AND MAINTENANCE 251
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the start
of each warm season. This service should include cleaning of
the condenser fins and a performance test. Drive belt tension
should also be checked at this time.Refrigerant Recovery And Recycling — R–1234yf
R–1234yf Air Conditioning Refrigerant is a hydrofluo-
roolefin (HFO) that is endorsed by the Environmental
Protection Agency and is an ozone-friendly substance with a
low global-warming potential. The manufacturer recom -
mends that air conditioning service be performed by an
authorized dealer using recovery and recycling equipment.
NOTE:
Use only manufacturer approved A/C system PAG
compressor oil, and refrigerants.
WARNING!
• Use only refrigerants and compressor lubricants approved by the manufacturer for your air condi -
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other unap -
proved refrigerants or lubricants can cause the system
to fail, requiring costly repairs. Refer to Warranty Infor -
mation Book, for further warranty information.
• The air conditioning system contains refrigerant under high pressure. To avoid risk of personal injury or
damage to the system, adding refrigerant or any repair
requiring lines to be disconnected should be done by
an experienced technician.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air
conditioning components. Such damage is not covered
by the New Vehicle Limited Warranty.
7
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 251

336
B
Battery................................................................................. 86, 247 Charging System Light......................................................... 86
Keyless Key Fob Replacement ............................................ 15
Belts, Seat ................................................................................. 154
Body Builders Guide ................................................................ 12
Body Mechanism Lubrication ............................................... 252
B-Pillar Location...................................................................... 272
Brake Assist System .................................................................. 98
Brake Fluid ............................................................................... 304
Brake System ................................................................... 260, 295 Anti-Lock (ABS) .................................................................... 97
Fluid Check .................................................................. 260, 304
Master Cylinder................................................................... 260 Parking.................................................................................. 161
Warning Light ....................................................................... 85
Brake, Parking ......................................................................... 161
Brake/Transmission Interlock .............................................. 164
Bulb Replacement ................................................................... 200
Bulbs, Light ...................................................................... 156, 200 C
Camera, Rear ........................................................................... 179
Capacities, Fluid...................................................................... 301
Caps, Filler Fuel ........................................................................................ 181Oil (Engine) .................................................................. 245, 249 Power Steering .....................................................................171
Radiator (Coolant Pressure)...............................................257
Car Washes ..............................................................................291
Carbon Monoxide Warning ...........................................153, 300
Cargo Area Cover .....................................................................66
Cargo Area Features .................................................................66
Cargo Compartment .................................................................66
Cargo Tie-Downs ......................................................................66
Cellular Phone .........................................................................320
Certification Label ...................................................................182
Chains, Tire ..............................................................................287
Changing A Flat Tire ......................................................212, 266
Chart, Tire Sizing .................................................................... 268
Check Engine Light (Malfunction Indicator Light)..............95
Checking Your Vehicle For Safety ........................................153
Checks, Safety ..........................................................................153
Child Restraint.........................................................................133
Child Restraints Booster Seats ........................................................................137Child Seat Installation.................................................147, 151
How To Stow An unused ALR Seat Belt .........................144Infant And Child Restraints...............................................136
Locating The LATCH Anchorages ...................................142
Lower Anchors And Tethers For Children .....................139Older Children And Child Restraints ..............................136Seating Positions..................................................................138
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 336

340
Descriptions ........................................................................... 92
Display .................................................................................... 77
Display Controls.................................................................... 77
Engine Oil Reset .................................................................... 80
Instrument Panel Lens Cleaning .......................................... 292
Interior And Instrument Lights .............................................. 46 Interior Appearance Care ...................................................... 292
Interior Lights ............................................................................ 46
Introduction ............................................................................... 10
iPod Control............................................................................. 318
iPod/USB/MP3 Control ........................................................ 318 Bluetooth Streaming Audio ............................................... 318 J
Jack Location............................................................................ 212
Jack Operation ................................................................. 212, 266
Jacking And Tire Changing ................................................... 212
Jump Starting........................................................................... 231 K
Key Fob Programming Additional Key Fobs ................................... 16
Key Fob Battery Service (Remote Keyless Entry)................. 15
Key Fob Programming (Remote Keyless Entry) .................. 16
Key-In Reminder ....................................................................... 18 Keys............................................................................................. 13 Replacement........................................................................... 19
Sentry (Immobilizer)............................................................. 19 L
Lane Change Assist...................................................................45
Lap/Shoulder Belts.................................................................111
Latches ...................................................................................... 156 Hood........................................................................................64
Leaks, Fluid ..............................................................................156
Life Of Tires ............................................................................. 280
Light Bulbs .......................................................................156, 200
Lights ........................................................................................156 Air Bag ............................................................................84, 154Brake Assist Warning .........................................................100
Brake Warning .......................................................................85
Bulb Replacement................................................................200
Cruise ......................................................................................93
Daytime Running ..................................................................43
Engine Temperature Warning .............................................87
Exterior............................................................................43, 156Hazard Warning Flasher ....................................................199
Headlights ..............................................................................43
Interior ....................................................................................46
Malfunction Indicator (Check Engine)...............................91
Park.................................................................................... 44, 93Passing ....................................................................................44
Seat Belt Reminder ................................................................88
Service ...................................................................................200
Tire Pressure Monitoring (TPMS) .....................................103
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 340

342
Recommendation ........................................................ 249, 301
Synthetic ............................................................................... 249Viscosity ....................................................................... 249, 301
Onboard Diagnostic System .................................................... 94
Operating Precautions.............................................................. 94
Operator Manual Owner's Manual ............................................................ 11, 333
Outside Rearview Mirrors ....................................................... 39
Overheating, Engine ............................................................... 234 P
Paint Care ................................................................................. 290
Parking Brake .......................................................................... 161
ParkSense System, Rear ......................................................... 175
Passing Light ............................................................................. 44
Personal Settings ..................................................................... 306
Pets ............................................................................................ 153
Placard, Tire And Loading Information .............................. 272
Power Mirrors .................................................................................... 41
Steering ................................................................................. 171
Windows ................................................................................ 60
Power Steering Fluid .............................................................. 304
Pregnant Women And Seat Belts.......................................... 116
Preparation For Jacking ................................................. 212, 217
Pretensioners Seat Belts............................................................................... 117 R
Radial Ply Tires .......................................................................278
Radiator Cap (Coolant Pressure Cap) ..................................257
Radio Operation ......................................................................320
Rear Camera............................................................................. 179
Rear ParkSense System ..........................................................175
Recreational Towing ...............................................................195
Reformulated Gasoline........................................................... 297
Refrigerant................................................................................251
Release, Hood ............................................................................64 Reminder, Seat Belt .................................................................109
Remote Keyless Entry Programming Additional Key Fobs ...................................16
Remote Sound System (Radio) Controls .............................317
Replacement Bulbs..................................................................200
Replacement Keys .....................................................................19
Replacement Tires ...................................................................280
Reporting Safety Defects ........................................................333
Restraints, Child ......................................................................133
Restraints, Head ........................................................................34 Rotation, Tires..........................................................................287 S
Safety Checks Inside Vehicle .................................................154
Safety Checks Outside Vehicle ..............................................156
Safety Defects, Reporting .......................................................333
Safety Information, Tire .........................................................266
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 342

343
Safety Tips ................................................................................ 153
Safety, Exhaust Gas ................................................................ 153
Schedule, Maintenance .......................................................... 241
Seat Belts .......................................................................... 109, 154 Adjustable Shoulder Belt ................................................... 115
Adjustable Upper Shoulder Anchorage .......................... 115
Adjustable Upper Shoulder Belt Anchorage................... 115
Child Restraints ................................................................... 133Energy Management Feature ............................................ 117
Front Seat.............................................................. 109, 111, 113
Inspection ............................................................................. 154
Lap/Shoulder Belt Operation ........................................... 113
Lap/Shoulder Belt Untwisting ......................................... 114Lap/Shoulder Belts............................................................. 111
Operating Instructions ....................................................... 113
Pregnant Women................................................................. 116
Pretensioners........................................................................ 117
Rear Seat ............................................................................... 111Reminder ........................................................................ 88, 109
Seat Belt Pretensioner ......................................................... 117
Untwisting Procedure ........................................................ 114
Seats ............................................................................................ 29 Adjustment............................................................................. 29
Heated..................................................................................... 32
Rear Folding........................................................................... 29
Tilting ...................................................................................... 29 Security Alarm ...........................................................................21
Selection Of Coolant (Antifreeze) .........................................302
Sentry Key (Immobilizer).........................................................19
Service Assistance ...................................................................329
Service Contract.......................................................................331
Service Manuals ......................................................................333
Shift Lever Override ...............................................................236
Shifting
Automatic Transmission ....................................................164
Shoulder Belts ..........................................................................111
Signals, Turn ......................................................................92, 156
Snow Chains (Tire Chains) ....................................................287
Snow Tires ................................................................................282
Spare Tires ........................................................................283, 285
Spark Plugs ..............................................................................302
Specifications Fuel (Gasoline) .....................................................................302
Oil ..........................................................................................302
Speed Control Cancel....................................................................................175
Speed Control (Cruise Control) ............................................172
Starting...................................................................................... 157 Automatic Transmission ....................................................157
Cold Weather .......................................................................158Engine Fails To Start ........................................................... 158
Steering .......................................................................................38
11
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 343

345
Traction..................................................................................... 196
Traction Control ...................................................................... 102
Trailer Sway Control (TSC) ................................................... 102
Trailer Towing ......................................................................... 184 Cooling System Tips ........................................................... 194
Hitches .................................................................................. 187
Minimum Requirements .................................................... 189
Tips ........................................................................................ 193Trailer And Tongue Weight .............................................. 188Wiring ................................................................................... 192
Trailer Towing Guide ............................................................. 188
Trailer Weight.......................................................................... 188
Transmission............................................................................ 164 Automatic ............................................................. 163, 164, 261
Fluid ...................................................................................... 304
Maintenance......................................................................... 261
Transporting Pets .................................................................... 153
Tread Wear Indicators............................................................ 280
Trip Computer........................................................................... 83 Turn Signals ............................................................................... 92 U
Uconnect Uconnect Settings ..................................................................15
Uconnect Voice Command ....................................................322
Uniform Tire Quality Grades ................................................288
Untwisting Procedure, Seat Belt ...........................................114
V
Vehicle Certification Label.....................................................182
Vehicle Identification Number (VIN) ..................................294
Vehicle Loading.......................................................182, 184, 273
Vehicle Modifications/Alterations .........................................12
Vehicle Storage ..................................................................58, 289
Viscosity, Engine Oil...............................................................249
Voice Recognition System (VR) ............................................322
11
2020_RAM_PROMASTER_CITY_OM_USA=GUID-7B6A7FCA-79B0-423F-95C5-ED2A949C3D13=1=en=.book Page 345