engine SSANGYONG MUSSO 2003 Service Manual

2-2 POSITION OF CONNECTORS AND GROUNDS
1. POSITION OF CONNECTOR, GROUND & SPLICE PACK
W/H - ENG. MAIN W/H - ENGINEW/H - MAIN W/H - FLOORW/H - T/M

POSITION OF CONNECTORS AND GROUNDS 2-3
C361 C371C381C401C402C403 22
88626 White
ColorlessColorlessColorlessColorlessColorless Main - Co-Driver DoorFloor - Rear Left DoorFloor - Rear Right DoorFloor - Tail GateFloor - Tail GateFloor - Tail Gate
Inside Co-Driver Side Cowl PanelCenter 'B' PillarCenter Left 'B' PillarBehind The Left LampBehind The Left LampBehind The Left Lamp
2. CONNECTOR, GROUND AND SPLICE PACK INFORMATION
1) CONNECTOR
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
C101 C102C103C104C105C106C107 C108 C109C110C111C112C201C203C204C205 C206
C206B C207 C208C208
C208B C209C210C211C212 C213 C251C301C302C303 C304 C305 C351212 2
15 143 2
16 6
40 6 84
10 33
4 [6]
1616121584
1417 6 3
20 1614 12 6
22 Colorless Colorless
WhiteBlackBlackBlackBlack Black BlackBlackBlack Gray
White
Colorless WhiteBlackBlack Black BlackBlackBlackBlackBlackBlackBlack
White
Colorless Black
White WhiteWhite
Colorless White
Blue Main - Engine Main - EngineMain - EngineEngine - MainEngine - EngineGenerator - EngineGenerator - Engine Genertor - Engine Engine - MainMain - Engine MainEngine Main - ECM MainEngine Main - ECM MainMain - RoofMain Air BagMain - Driver SeatMain - T/MMain - Fuel Tank Main - Fuel Tank Main - T/MMain - T/MMain - T/MMain - T/MMain - T/MMain - T/MDLC Connector - MainMain - Air ConMain - ECM Main Driver Seat - Driver Seat, AUX Main - FloorMain - Floor Main - Floor Main - FloorMain - Floor Main - Driver DoorInside The Engine Room Fuse Block Inside The Engine Room Fuse BlockInside The Engine Room Fuse BlockUnder The Engine Room Fuse BlockBeside Pre-Heating Unit (DSL)Under The Air Cleaner Housing (DSL, Turbo)Under The Air Cleaner Housing (DSL, N/Turbo) Under The Air Cleaner Housing (GSL) Under The Coolant Reservoir TankBehind The ABS Module (HFM)Center The Engine Room Dash PanelCenter The Engine Room Dash PanelUpper The I/P Fuse BlockLeft The AudioUnder The Driver SeatUpper The T/C MotorUpper The T/C (DSL) Upper The T/C (GSL) Upper The T/CUpper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Beside The Steering ColumnBehind The Glove BoxBeside The ECM (MSE) Under The Driver Seat Beside The I/P Relay BlockBeside The I/P Relay BlockBeside The I/P Relay Block Inside Co-Driver Side Cowl Panel Beside Center ConsoleUpper The I/P Fuse Block
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
2) GROUND
G101 G102 G103G201 G202 G203G204G205 G206 G207G208 G209 G301G302G303 Ground Position
Wiring Harness
Ground
Number
Behind The Left LampBeside The Start Motor Behind The Right Head Lamp Right The I/P Fuse BlockBeside The STICSUpper The ECM Behind The Ashtray Beside The TCCUBeside The ABS Module Beside THe ECM Under THe CO-Driver SeatBeside The EBCMCenter The Left 'B' Pillar Beside The Left Rear Speaker Beside The Right Rear Speaker
Engine Engine Engine
Main MainMain Main MainMain Main MainMain
Floor Floor Floor
* [ ] : EURO III

POSITION OF CONNECTORS AND GROUNDS 2-5
3. WIRING HARNESS, CONNECTOR & GROUND LOCATION
1) W/H ENGINE ROOM • GSL  DSL
C109
C111 C112
C101, C102 S101, C104C103
C109 C101,
C102
S101,
C104 C103

CONTENTS
1. FUSIBLE LINK FUSE BLOCK & ENGINE ROOM FUSE BLOCK POWER DISTRIBUTION .................................................... 3-2
2. I/P FUSE BLOCK POWER DISTRIBUTION ..................................... 3-3
SECTION 3
WIRING DIAGRAM FOR POWER SUPPLIES

3-2 WIRING DIAGRAM FOR POWER SUPPLIES
1. FUSIBLE LINK FUSE BLOCK & ENGINE ROOM FUSE BLOCK POWER DISTRIBUTION

SECTION 4
USAGE AND CAPACITY OF FUSES IN FUSE BLOCK
1. ENGINE ROOM FUSE & RELAY BLOCK ....................................... 4-2
2. I/P FUSE BLOCK ............................................................................... 4-3
3. POSITION OF RELAY, CONTROL UNIT AND PARTS NUMBER .. 4-4 CONTENTS

4-2 USAGE AND CAPACITY OF FUSES IN FUSE BOX
60A 80A 80A30A30A40A40A60A60A10A10A15A15A15A15A10A10A30A
Ef1Ef2Ef3Ef4Ef5Ef6Ef7Ef8Ef9
Ef10Ef11Ef12Ef13Ef14Ef15Ef16Ef17Ef18
1. ENGINE ROOM FUSE & RELAY BOX
1) ENGINE ROOM FUSE BLOCK
2) USAGE OF FUSE IN ENGINE ROOM FUSE BOX
* 30 : Battery(+) Power Supply
Front
fog
Lamp
Head
Lamp
(LOW)
Head
Lamp (HI)
Illumination
Relay
Horn
Relay
A/CON C101
C102 C103 S101
Cooling fan-2
Cooling fan-1
Ef10 10ATAIL LAMP LH
Ef11 10ATAIL LAMP RH
Ef12 15AHEAD LAMP LH
Ef13 15AHEAD LAMP RH
Ef14 15AFRT FOG LAMP
Ef15 15ADOOR LOCK
Ef16 10AHORN
Ef17 10AA/CON COMP
Ef18 30ABLOWER
DSL GSL
COMP RESIS
TOR
109876 5432121 20 19 18 17 16 15 14 13 12 11
21
123
12
Ef9 60A
BATT1
Ef8 60ABATT2
Ef7 40AIGNITION SWITCH
Ef6 40A
FUSIBLE LINK
HEADLAMP
Ef5 30ACOOLING FAN
Ef4 30APOWER
WINDOW
2) FUSIBLE LINK FUSE BOX
80A 80A 60A
E
f3Ef2Ef1
3) RELAY TERMINAL NUMBER
8687
8530
S
BL8587a
30
87
86
4PIN RELAY 3PIN RELAY 5PIN RELAY ABS & ABD
Generator
Preheating
Power Window
Cooling FanHead Lamp
Ignition Switch Battery 2 Battery 1
Tail Lamp LH
Tail Lamp RH
Head Lamp LH
Head Lamp RH
Front Fog Lamp Door LockHorn
A/C Compressor
Blower
Fuse No Capacity UsagePower Supply
30 BAT(+)
Illumination(58)
30 BAT(+)

4-4 USAGE AND CAPACITY OF FUSES IN FUSE BOXSDM Chime BellImmobilizer UnitSticsRekesEBCM
4 Pin 4 Pin 4 Pin4 Pin4 Pin4 Pin4 Pin 4 Pin 3 Pin3 Pin
82330-05000 84190-05100 84150-0130084150-0130084150-0130084150-0130084150-01300 84150-01300 84130-0500084130-05000
Part Name Part Number
Remarks
Resistor W/Diode (GSL) A/C Compressor Relaly (DSL)A/C RelayCooling Fan - 1 RelayCooling Fan - 2 RelayFront Fog Lamp Relay Head Lamp Relay (Low) Head Lamp Relay (Hi)Illumination RelayHorn Relay
3. POSITION OF RELAY, CONTROL UNIT AND PARTS NUMBER
1) ENGINE ROOM FUSE BLOCK
2) RELAY BOX ABOVE I.P FUSE BLOCK
5 Pin 5 Pin 3 Pin5 Pin5 Pin4 Pin4 Pin 4 Pin 4 Pin 4 Pin 4 Pin 4 Pin
84210-05001 84210-05001 84410-05100
66182253386618225338
84150-0130084150-01300 84150-01300 84150-01300 84150-0130084150-0130084190-05100
Part Name Part Number Remarks
Front Wiper Relay Defogger RelayTurn Signal Lamp RelayFuel Pump Relay (GSL)Cigar Lighter, P/socket Relay (DSL)A/T Shift lock Relay PNP Relay Sun Roof RelayA/T "B" Switch Interlock Relay Power Window Relay ECL RelayABS Warning Lamp Relay
3) CONTROL UNIT
Below The Audio
Beside The SDM
Behind the Wiper Switch Upper The Accelerator Upper The Stics
I/P Center Console Floor Panel
8690005800 8661005000869500580087110058008716105000
4891005000X
Part Name Part Number Remarks

8. ECM(E32, HFM) .......................................................................................................................... 5-64
1) INJECTOR, OVPR, IGNITION COIL, FUEL PUMP CIRCUIT(W/ IMMOBILIZER) ........................................... 5-64
2) INJECTOR, OVPR, IGNITION COIL, FUEL PUMP CIRCUIT(W/O IMMOBILIZER) ........................................ 5-66
3) SENSOR (CKP, CMP, KNOCK, MAF), CCP SOLENOID, CAM SHAFT ACTUATOR CIRCUIT ....................... 5-68
4) THROTTLE MOTOR & SENSOR, SENSOR (IAT, ECT, HEATED O 2), VSS, CIRCUIT (UNLEAD) ................. 5-70
5) THROTTLE MOTOR & SENSOR, SENSOR (IAT, ECT), CO POTENTIO METER, VSS CIRCUIT(LEAD) ..... 5-72
9. DLC CIRCUIT ................................................................................................................. ............. 5-74
10. TCM(GSL, BTRE) .............................................................................................................. ......... 5-76
1) POWER SUPPLY, GROUND, INDICATION LAMP CIRCUIT ............................................................................. 5- 76
2) KICK DOWN SWITCH, SELECT LEVER POSITION SENSOR, TRANSMISSION CIRCUIT ........................ 5-78
11. TCM(DSL, BTRE) .............................................................................................................. ......... 5-80
1) POWER SUPPLY, GROUND, INDICATION LAMP, SENSOR (TR, ENGINE SPEED) CIRCUIT .................... 5-80
2) KICK DOWN SWITCH, SELECT LEVER POSITION SENSOR, TRANSMISSION CIRCUIT ........................ 5-82
12. KICK DOWN RELAY, 'B' SWITCH CIRCUIT (MB A/T) ........................................................... 5-84
13. TCCU-PART TIME .............................................................................................................. ........ 5-86
1) POWER SUPPLY, GROUND, INDICATION LAMP, PNP RELAY, CLUTCH SWITCH CIRCUIT ..................... 5-86
2) 4WD SWITCH, T/C SPEED SENSOR, T/C MOTOR CIRCUIT ........................................................................ 5-88
14. TCCU-FULL TIME .............................................................................................................. ........ 5-90
1) POWER SUPPLY, GROUND, INDICATION LAMP, NEUTRAL RELAY, CLUTCH CIRCUIT ............................ 5-90
2) 4WD SWITCH, T/C SPEED SENSOR, T/C MOTOR CIRCUIT ........................................................................ 5-92
15. TOD(TORQUE ON DEMAND)-E32,MSE .................................................................................. 5-94 1) POWER SUPPLY, GROUND, WARNING LAMP, 4WD SWITCH, T/C MOTOR CIRCUIT .............................. 5-94
2) T/C SPEED SENSOR, PNP RELAY, CLUTCH SWITCH, CAN CIRCUIT .......................................................... 5-96
16. ECS ......................................................................................................................... ..................... 5-98
1) POWER SUPPLY, GROUND, SENSOR(WHEEL'G, VERTICAL, LATERAL) CIRCUIT ................................... 5-98
2) ECS SWITCH, DAMPER CIRCUIT ...................................................................................................................... 5-100

5-8 ELECTRICAL WIRING DIAGRAMS
1. STARTING & CHARGING SYSTEM
1) GSL E23 MB A/TC101 (21Pin, Colorless) C102 (2Pin, Colorless) C108 (2Pin, Black) C110 (6Pin, Black) C208B (15Pin, Black)
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
C108
W/H GENERA- TOR C208B
W/H MAIN
C101
W/H MAIN C102
W/H MAIN C110
W/H MAIN
START LOCK
SWITCH (MB A/T) IGNITION SWITCH
CLUSTER
CONNECTOR(NUMBER)CONNECTING. WIRING HARNESS
Main - Engine Main - Engine Genertor - Engine Main - Engine MainMain - T/M
CONNECTOR POSITION
Inside The Engine Room Fuse Block Inside The Engine Room Fuse Block Under The Air Cleaner Housing (GSL)Behind The ABS Module (HFM) Upper The T/C (GSL)
12345 678910
11 12 13 14 15 16 17 18 19 20 211212
135 2 46
1
4 52
8
14
7
93
15
13
10
11 6
12
76
12
4
38 N
P IGNR
D
3910123 456
11 2
29 38
28
13 2021
39 434842
M
+-30 (BAT +)
: M/T (HFM E20, E23)
15 (IGN 1) 15A (IGN 2)
15C (ACC)
31 GND
Cluster (Charging
WarningLamp)
G105
G104
B B
G201
BST 3
4
OFF
"12"ICU
ACC
ONST BL
BY BY BY
BL
BG
BG 162
F22
10A
F24
10A
RG
W
RGLB 18 5
2 1 YW YW YW
C108
Generator
I.C Regulator D+
B+ 1
C101
Resister 15
C101
14
Ef7
40A
E
f2 80A
BW L LW
Ignition Switch
C102
1
Battery Start LockSwitch(MB A/T)
BY StarterMotor
1
30 87
8685
2
Clutch Switch
1 2
C110
4 C208B
PNP
Relay
8
C208B
2