SUZUKI NEXA 2015 1.G Workshop Manual
Manufacturer: SUZUKI, Model Year: 2015, Model line: NEXA, Model: SUZUKI NEXA 2015 1.GPages: 288, PDF Size: 8.02 MB
Page 51 of 288
Downloaded from www.Manualslib.com manuals search engine
% ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
80JS029
To lengthen, release the latch plate from the
buckle, pull the latch plate (adjuster) in the
direction of the arrow, at right angles to the
belt. The latch plate should then be refitted
into the buckle and the belt tightened as
previously described.To unfasten the belt, press the release but-
ton on the buckle catch.NOTE:
To identify the center seat belt buckle and
latch plate in the rear seat, “CENTER” is
marked on the buckle and latch plate of the
center lap belt. The buckles are designed so
a latch plate cannot be inserted into the
wrong buckle. ' U L Y H U
Page 52 of 288
Downloaded from www.Manualslib.com manuals search engine % ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
6 K R X O G H U $ Q F K R U + H L J K W $ G M X V W H U
64J198
Adjust the shoulder anchor height so that
the shoulder belt rides on the center of the
outboard shoulder. To move upward, slide
the anchor up. To move downward, slide
the anchor down while pulling the lock
knob out. After adjustment, make sure that
the anchor is securely locked.
6 H D W % H O W , Q V S H F W L R Q
65D209S
Periodically inspect the seat belts to make
sure they work properly and are not dam-
aged. Check the webbing, buckles, latch
plates, retractors, anchorages, and guide
loops. Replace any seat belts which do not
work properly or are damaged.
& K L O G 5 H V W U D L Q W 6 \ V W H P V
60G332S
, Q I D Q W U H V W U D L Q W U H D U V H D W R Q O \
80JC007
: $ 5 1 , 1 *
% H V X U H W K D W W K H V K R X O G H U E H O W L V
S R V L W L R Q H G R Q W K H F H Q W H U R I W K H R X W
V L G H V K R X O G H U 7 K H E H O W V K R X O G E H
D Z D \ I U R P \ R X U I D F H D Q G Q H F N E X W
Q R W I D O O L Q J R I I \ R X U V K R X O G H U 0 L V D G
M X V W P H Q W R I W K H E H O W F R X O G U H G X F H
W K H H I I H F W L Y H Q H V V R I W K H V D I H W \ E H O W
L Q D F U D V K
( ; $ 0 3 / (
: $ 5 1 , 1 *
% H V X U H W R L Q V S H F W D O O V H D W E H O W
D V V H P E O L H V D I W H U D Q \ F R O O L V L R Q $ Q \
V H D W E H O W D V V H P E O \ Z K L F K Z D V L Q X V H
G X U L Q J D F R O O L V L R Q R W K H U W K D Q D Y H U \
P L Q R U R Q H V K R X O G E H U H S O D F H G H Y H Q
L I G D P D J H W R W K H D V V H P E O \ L V Q R W
R E Y L R X V $ Q \ V H D W E H O W D V V H P E O \
Z K L F K Z D V Q R W L Q X V H G X U L Q J D F R O O L
V L R Q V K R X O G E H U H S O D F H G L I L W G R H V Q R W
I X Q F W L R Q S U R S H U O \ L W L V G D P D J H G L Q
D Q \ Z D \ R U W K H V H D W E H O W S U H W H Q V L R Q
H U V Z H U H D F W L Y D W H G W K D W L V L I W K H I U R Q W
D L U E D J V Z H U H D F W L Y D W H G ( ; $ 0 3 / (
( ; $ 0 3 / (
Page 53 of 288
Downloaded from www.Manualslib.com manuals search engine
% ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
& K L O G U H V W U D L Q W
80JC016
% R R V W H U V H D W
80JC008
MARUTI SUZUKI highly recommends that
you use a child restraint system to restrain
infants and small children. Many different
types of child restraint systems are avail-
able; make sure that the restraint system
you select meets applicable safety stan-
dards.All child restraint systems are designed to
be secured in vehicle seats by either seatbelts (lap belts or the lap portion of lap-
shoulder belts). MARUTI SUZUKI recom-
mends that child restraint systems be
installed on the rear seat as per the Child
Restraint System table in this section.
According to accident statistics, children are
safer when properly restrained in rear seat-
ing positions than in front seating positions.
NOTE:
Observe any statutory regulation about
child restraints.
58MS03065D608
65D609
( ; $ 0 3 / ( ( ; $ 0 3 / (
: $ 5 1 , 1 *
' R Q R W L Q V W D O O D U H D U I D F L Q J F K L O G
U H V W U D L Q W L Q W K H I U R Q W S D V V H Q J H U
Page 54 of 288
Downloaded from www.Manualslib.com manuals search engine % ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
, Q V W D O O D W L R Q Z L W K / D S 6 K R X O G H U 6 H D W
% H O W VNOTE:
If the most upper position head restraint
interferes a child restraint system and pre-
vents the child restraint system from being
installed securely, remove the head
restraint.
Stow the removed head restraint in the lug-
gage compartment so it will not inconve-
nience the occupants.
( / 5 W \ S H E H O W
Install your child restraint system accord-
i
ng to the instructions provided by the child
restraint system manufacturer.
Make sure that the seat belt is securely
latched.Try to move the child restraint system in all
directions to make sure it is securely
installed.
, Q V W D O O D W L R Q Z L W K D / D S % H O W
60G132
Install your child restraint system according
to the instructions provided by the child
restraint system manufacturer.
To lengthen or tighten the belt, refer to the
“ / D S E H O W” item in this “Seat Belts and Child
Restraint Systems” section. After making
sure that the seat belt is securely latched,
try moving the child restraint system in all
directions, to make sure it is securely
installed. If you need to tighten the belt, pull
the free end of the webbing.
: $ 5 1 , 1 *
& K L O G U H Q F R X O G E H H Q G D Q J H U H G L Q D
F U D V K L I W K H L U F K L O G U H V W U D L Q W V \ V W H P V
D U H Q R W S U R S H U O \ V H F X U H G L Q W K H Y H K L
F O H : K H Q L Q V W D O O L Q J D F K L O G U H V W U D L Q W
V \ V W H P E H V X U H W R I R O O R Z W K H L Q V W U X F
W L R Q V E H O R Z % H V X U H W R V H F X U H W K H
F K L O G L Q W K H U H V W U D L Q W V \ V W H P D F F R U G
L Q J W R W K H P D Q X I D F W X U H U
Page 55 of 288
Downloaded from www.Manualslib.com manuals search engine
% ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
& K L O G 5 H V W U D L Q W 6 \ V W H P I R U , Q G L D & K L O G 5 H V W U D L Q WThe suitability of each passenger’s seat position for carriage of children and fitting of child restraint system is shown in the table below.
Whenever you carry children up to 12 years of age, properly use the child restraints which conform to AIS 072, the standard for child
restraints, referring to the table.
MASS GROUPSeating position (or other site)
Front
PassengerRear
OutboardRear
CentreIntermediate
OutboardIntermediate
Centre
Group 0
Up to 10 kgXUXN.A.N.A.
Group 0+
Up to 13 kgXUXN.A.N.A.
Group I
9 to 18 kgXUXN.A.N.A.
Group II
15 to 25 kgXUXN.A.N.A.
Group III
22 to 36 kgXUXN.A.N.A.
Key of letters to be inserted in the above table:
U =Suitable for ‘universal’ category restraints approved for use in this mass group
X =Seat position not suitable for children in this mass group
N.A = Seat position not available for children in this mass group.
NOTE: ‘universal’ is the category in the AIS 072.
: ‘Outboard’ indicates window side seat.
Page 56 of 288
Downloaded from www.Manualslib.com manuals search engine % ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
6 H D W % H O W 3 U H W H Q V L R Q H U 6 \ V W H P
L I H T X L S S H G
63J269
To determine if your vehicle is equipped
with a seat belt pretensioner system at the
front seating positions, check the label on
the front seat belt at the bottom part. If the
letters “p” and/or “PRE” appear as illus-
trated, your vehicle is equipped with the
seat belt pretensioner system. You can usethe pretensioner seat belts in the same
manner as ordinary seat belts.
Read this section and the “Supplemental
Restraint System (air bags)” section to
learn more about the pretensioner system.
The seat belt pretensioner system works
with the 6 8 3 3 / ( 0 ( 1 7 $ / 5 ( 6 7 5 $ , 1 7
6 < 6 7 ( 0 $ L U % D J V . The crash sensors
and the electronic controller of the air bag
system also control the seat belt preten-
sioners. The pretensioners are triggered
only when there is a frontal crash severe
enough to trigger the air bags and the seat
belts are fastened. For precautions and
general information including servicing the
pretensioner system, refer to the “Supple-
mental Restraint System (air bags)” sec-
tion in addition to this “Seat Belt
Pretensioner System” section, and follow
all those precautions.
The pretensioner is located in each front
seat belt retractor. The pretensioner tight-
ens the seat belt so the belt fits the occu-
pant’s body more snugly in the event of a
frontal crash. The retractors will remain
locked after the pretensioners are acti-
vated. Upon activation, some noise will
occur and some smoke may be released.
These conditions are not harmful and do
not indicate a fire in the vehicle.
The driver and all passengers must be
properly restrained by wearing seat belts
at all times, whether or not a pretensioner
is equipped at their seating position, toSit fully back in the seat; sit up straight; do
not lean forward or sideways. Adjust the
belt so the lap portion of the belt is worn
low across the pelvis, not across the waist.
Please refer to the “Seat Adjustment” sec-
tion and the instructions and precautions
about the seat belts in this “Seat Belts and
Child Restraint Systems” section for details
on proper seat and seat belt adjustments.
Please note that the pretensioners along
with the air bags will activate in severe
frontal collisions. They are not designed to
activate in side impacts, rear impacts, roll-
overs, or minor frontal collisions. The pre-
tensioners can be activated only once. If
the pretensioners are activated (that is, if
the air bags are activated), have the pre-
tensioner system serviced by an
D X W K R U L V H G 0 D U X W L 6 X ] X N L Z R U N V K R S as
soon as possible.
: $ 5 1 , 1 *
7 K L V V H F W L R Q R I W K H R Z Q H U
Page 57 of 288
Downloaded from www.Manualslib.com manuals search engine
% ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
To prevent damage or unintended activa-
tion of the pretensioners, be sure the bat-
tery is disconnected and the ignition switch
has been in the “LOCK” position or the igni-
tion mode has been LOCK (OFF) for at
least 90 seconds before performing any
electrical service work on your Y H K L F O H Do
not touch pretensioner system compo-nents
or wiring. The wires are wrapped with
yellow tape or yellow tubing, and the
couplers are yellow. When scrapping your
Vehicle, ask your D X W K R U L V H G 0 D U X W L 6 X ] X N L
Z R U N V K R S body repair shop, or scrap yard
for assistance. trained. Improper service could result in
unintended activation of pretensioners or
could render the pretensioner inoperative.
Either of these two conditions may result
in personal injury.
Page 58 of 288
Downloaded from www.Manualslib.com manuals search engine % ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
6 X S S O H P H Q W D O 5 H V W U D L Q W 6 \ V W H P
D L U E D J V L I H T X L S S H G Your vehicle is equipped with a Supple-
mental Restraint System consisting of the
following components in addition to a lap-
shoulder belt at each seating position.
1. Driver’s front air bag module (if
equipped)
2. Front passenger’s front air bag mod-
ule (if equipped)
3. Seat belt pretensioners (if equipped)
4. Air bag controller
5. Forward crash sensor (if equipped)
: $ 5 1 , 1 *
7 K L V V H F W L R Q R I W K H R Z Q H U
Page 59 of 288
Downloaded from www.Manualslib.com manuals search engine
% ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
$ , 5 % $ * O L J K W
63J030
If the AIR BAG light on the instrument clus-
ter does not blink or come on when the
ignition switch is first turned to the “ON”
position, or the ignition mode is first
changed to “ON”, or the air bag light stays
on, or comes on while driving, the air bag
system (or the seat belt pretensioner sys-
tem (if equipped)) may not work properly.
Have the air bag system inspected by an
D X W K R U L V H G 0 D U X W L 6 X ] X N L Z R U N V K R S as
soon as possible. $ L U E D J V \ P E R O L I H T X L S S H G P H D Q L Q J
72M00150
You may find this label on the sun visor.
) U R Q W $ L U % D J V L I H T X L S S H G
63J113
Front air bags are designed to inflate in
severe frontal collisions when the ignition
switch is in the “ON” position or the ignition
mode is ON.
Front air bags are not designed to inflate in
rear impacts, side impacts, rollovers or
minor frontal collisions, since they would
offer no protection in those types of acci-
dents. Remember, since an air bag
deploys only one time during an accident,
seat belts are needed to restrain occu-
pants from further movements during the
accident.
Therefore, an air bag is NOT a substitute
for seat belts. To maximize your protection,
$ / : $ < 6 : ( $ 5 < 2 8 5 6 ( $ 7 % ( / 7 6. Be
aware that no system can prevent all pos-
sible injuries that may occur in an accident.
: $ 5 1 , 1 *
$ Q D L U E D J V X S S O H P H Q W V R U D G G V W R
W K H F U D V K S U R W H F W L R Q R I I H U H G E \ V H D W
E H O W V 7 K H G U L Y H U D Q G D O O S D V V H Q J H U V
P X V W E H S U R S H U O \ U H V W U D L Q H G E \ Z H D U
L Q J V H D W E H O W V D W D O O W L P H V Z K H W K H U R U
Q R W D Q D L U E D J L V P R X Q W H G D W W K H L U V H D W
L Q J S R V L W L R Q W R P L Q L P L ] H W K H U L V N R I
V H Y H U H L Q M X U \ R U G H D W K L Q W K H H Y H Q W R I D
F U D V K
: $ 5 1 , 1 *
1 ( 9 ( 5 X V H D U H D U Z D U G I D F L Q J F K L O G
U H V W U D L Q W R Q D V H D W S U R W H F W H G E \ D Q
$ & 7 , 9 ( $ , 5 % $ * L Q I U R Q W R I L W ' ( $ 7 +
R U 6 ( 5 , 2 8 6 , 1 - 8 5 < W R W K H & + , / '
F D Q R F F X U
( ; $ 0 3 / (
( ; $ 0 3 / (
Page 60 of 288
Downloaded from www.Manualslib.com manuals search engine % ( ) 2 5 ( ' 5 , 9 , 1 *
0 6 (
' U L Y H U