DRL TOYOTA RAV4 1996 Service Repair Manual

System
2 - DOME 15 Amp Personal Lights, Open Door Warning Light, Clock
3 - EFI 15 Amp Multiport Fuel Injection System/Sequential Multiport Fuel Injection System
4 - HAZ-HORN 15 Amp Emergency Flashers, Horns
5 - ALT-S 5 Amp Charging system
6 - SPARE 15 Amp Spare fuse
7 - SPARE 7.5 Amp Spare fues
8 - H-LP (LH) 15 Amp Left-Hand Headlight
9 - H-LP (RH) 15 Amp Right-Hand Headlight
10 - DRL 7.5 Amp Daytime Running Light System
11 - H-LP LH-L 10 Amp Left Hand Headlight (Low Beam)
12 - H-LP RH-L 10 Amp Right Hand Headlight (Low Beam)
13 - H-LP LH-H 10 Amp Left Hand Headlight (High Beam)
14 - H-LP RH-H 10 Amp Right Hand Headlight (High Beam)
15 - TAIL 10 Amp Tail Lights, Parking Lights, License Plate Lights, Interior Lights
16 - GAUGE 10 Amp Gauges And Meters, Service Reminder Indicators (Except Discharge And Open
Door Warning Lights), Back-up Lights, Air Conditioning System, Power Windows, Rear Window
Defogger, Center Differential Lock System, Electronically Controlled Automatic Transaxle System
17 - TURN 7.5 Amp Turn Signal Lights
18 - CIG & RAD 15 Amp Cigarette Lighter, Clock, Car Audio System, Power Rear View Mirrors
19 - DEF-I/UP 7.5 Amp Multiport Fuel Injection System/Sequential Multiport Fuel Injection System
20 - IGN 7.5 Amp Multiport Fuel Injection System/Sequential Multiport Fuel Injection System,
Discharge Warning Light
21 - ECU-IG 7.5 Amp Anti-Lock Brake Syste, Electronically Controlled Automatic Transmission
System
22 - WIPER 20 Amp Windshield Wipers And Washer, Rear Window Wiper And Washer
23 - SRS 7.5 Amp SRS Airbag System
24 - OBD 7.5 Amp On-Board Diagnostic System
25 - STOP 10 Amp Stop Lights
26 - A/C 7.5 Amp Air Conditioning System
27 - MAIN No. 1 30 Amp Starting System, Headlights
28 - RDI FAN 30 Amp Electric Cooling Fan
29 - CDS FAN 30 Amp Electric Cooling Fan
30 - POWER 30 Amp Power Windows, Power Door Lock System
31 - DEF 30 Amp Rear Window Defogger
32 - AM 1 40 Amp CIG & RAD, WIPER, GAUGE, ECU-IG, TURN, TAIL, and PANEL fuses
33 - MAIN 80 Amp AM 2, HAZ-HORN, EFI, DOME, RADIO and ALT-S fuses
34 - ALT 100 Amp Tail lights, ABS, RADIO, HTR, AM 1, POWER, STOP and DEF fuses

1999 Toyota RAV4
MAINTENANCE INFORMATION 1997-99 MAINTENANCE Toyota Maintenance Information
Microsoft
Sunday, November 22, 2009 10:32:42 AMPage 26 © 2005 Mitchell Repair Information Company, LLC.

Fig. 2: Identifying Headlight Control Relay Terminals
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
HEADLIGHT DIMMER RELAY
Except Land Cruiser & Tundra Without DRL
Remove dimmer relay located on left side of engine compartment, in relay block No. 2. Continuity should exist
between relay terminals No. 1 and 4, and 2 and 4 at all times. For relay terminal locations, see Fig. 3
.
Continuity should not exist between relay terminals No. 3 and 4. Apply battery voltage across relay terminals
No. 2 and 4. Continuity should now exist between relay terminals No. 3 and 4. If continuity is not as specified,
replace rela
y.
NOTE: For Land Cruiser, use testing procedure for headlight control relay. See
HEADLIGHT CONTROL RELAY
. Tundra without Daytime Running Lights (DRL)
does not use headlight dimmer relay.

1999 Toyota RAV4
1999 ACCESSORIES & EQUIPMENT Steering Column Switches - Trucks
Microsoft
Sunday, November 22, 2009 10:56:55 AMPage 3 © 2005 Mitchell Repair Information Company, LLC.

Fig. 3: Headlight Dimmer Relay Terminals (Except Land Cruiser & Tundra Without DRL)
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
TAILLIGHT CONTROL RELAY
Remove taillight control relay. See TAILLIGHT CONTROL RELAY LOCATION
table. Continuity should
exist between relay terminals No. 1 and 2 at all times. See Fig. 4
or Fig. 5 . Apply battery voltage across
specified terminals of relay connector. See TAILLIGHT CONTROL RELAY TEST
table. Check for
continuity between other specified terminals. If there is no continuity, replace relay.
TAILLIGHT CONTROL RELAY LOCATION
TAILLIGHT CONTROL RELAY TEST
NOTE: Tundra uses an integration relay instead of taillight relay. Integration relay
testing information is not available. 4Runner does not use a taillight relay.
ApplicationLocation
Land Cruiser & RAV4Behind Left Kick Panel, In Junction Block No. 1
SiennaUnder Left Side Of Dash, In Junction Block No. 1
TacomaLeft Side Of Engine Compartment, In Relay Block No. 2
Application
(1) Apply Voltage To Terminals
No.(1)Continuity Between Terminals
No.

1999 Toyota RAV4
1999 ACCESSORIES & EQUIPMENT Steering Column Switches - Trucks
Microsoft
Sunday, November 22, 2009 10:56:55 AMPage 4 © 2005 Mitchell Repair Information Company, LLC.

Fig. 15: Headlight Circuit, W/ DRL

1999 Toyota RAV4
1999 System Wiring Diagrams Toyota - RAV4
Microsoft
Sunday, November 22, 2009 10:50:58 AMPage 31 © 2005 Mitchell Repair Information Company, LLC.

Fig. 16: Headlight Circuit, W/O DRL
HORN

1999 Toyota RAV4
1999 System Wiring Diagrams Toyota - RAV4
Microsoft
Sunday, November 22, 2009 10:50:58 AMPage 33 © 2005 Mitchell Repair Information Company, LLC.