stop start VOLVO V60 2014 Repair Manual

||
10 Maintenance and service
10
366
Location of the batteries
A: Left-hand drive car. B: Right-hand drive car. (1) Starter battery14
(2) Support battery.
The support battery normally requires no more service than the normal battery used forstarting. A workshop should be contacted inthe event of questions or problems - anauthorised Volvo workshop is recommended.
IMPORTANT
If the following instruction is not observed then the Start/Stop function may tempo-rarily cease to work after the connection ofan external battery or battery charger:
• The negative battery terminal on the car's starter battery must
never be
used for connecting an external bat-tery or battery charger - only the car
chassis may be used as the ground-
ing point.
See Jump starting with battery (p. 270) for a description of how the cable clampsmust be attached.
NOTE
If the battery has become so discharged that everything is "black" and in principlethe car does not have all the normal elec-trical functions and the engine is subse-quently started using an external battery orbattery charger, then the Start/Stop func-tion will be activated. It will then be possi-ble for the engine to be auto-stopped butin the event of an auto-stop the Start/Stopfunction may fail to auto-start the enginedue to inadequate capacity in the battery. The battery must first be charged in order to ensure a successful auto-start after anauto-stop. At an outside temperature of+15 °C the battery needs to be charged forat least 1 hour. At a lower outside tem-perature a charging time of 3-4 hours isrecommended. The recommendation isthat the battery is charged using an exter-nal battery charger. If this is not possible then the recommen- dation is to temporarily deactivate theStart/Stop function until the battery hasbeen adequately recharged. For more information on charging the starter battery, see Battery (p. 361).
Related information
• Battery - symbols (p. 362)
14
See Battery (p. 361) for a detailed description of the starter battery.
ProCarManuals.co’

10 Maintenance and service
10
367
Fuses - general
All electrical functions and components are protected by a number of fuses in order toprotect the car's electrical system from dam-age by short circuiting or overloading. If an electrical component or function does not work, it may be because the component'sfuse was temporarily overloaded and failed. Ifthe same fuse fails repeatedly then there is afault in the circuit. Volvo recommends thatyou visit an authorised Volvo workshop forchecking.
Changing1. Look in the fuse diagram to locate thefuse.
2. Pull out the fuse and check from the side to see whether the curved wire hasblown.
3. If this is the case, replace it with a new fuse of the same colour and amperage.
WARNING
Never use a foreign object or a fuse with an amperage higher than that specifiedwhen replacing a fuse. This could causesignificant damage to the electrical systemand possibly lead to fire.
Location of central electrical units
Central electrical unit locations in a left-hand drive car. In a right-hand drive car the centralelectrical units under the glovebox changesides.
Engine compartment
Under the glovebox
Under the glovebox
Cargo area under the cargo floor
Engine compartment cold zone (only Start/Stop)
Related information
• Fuses - in engine compartment (p. 368)
• Fuses - under glovebox (p. 372)
• Fuses - in the control module under the glovebox (p. 374)
• Fuses - in cargo area (p. 376) •
Fuses - in the engine compartment's coldzone (p. 377)
ProCarManuals.co’

||
10 Maintenance and service
10
370* Option/accessory, for more information, see Introduction.
FunctionA
Relay coils5
Auxiliary lamps*20
Horn15
Relay coil in main relay for engine management system;Engine control module (4-cyl. 2.0 l B
, 5, 6-cyl.)10
Transmission control module15
Solenoid clutch A/C (not 4-cyl. 2.0 l C
, not 5-cyl. diesel); Sup-
porting coolant pump (4-cyl. 2.0 l diesel)15
Relay coil in relay for solenoid clutch A/C (not 5-cyl. diesel);Relay coil in relay for coolantpump (1.6 l petrol Start/Stop);Relay coils in central electricalunit in engine compartmentcold zone (Start/Stop)5
Start relay A30
FunctionA
Ignition coils (1.6 l petrol, engine B4204T7); Glow controlmodule (5-cyl. diesel)10
Engine control module (4-cyl. 2.0 l
B
); Ignition coils (5, 6-cyl.
petrol); Capacitor (6-cyl.)20
Engine control module (petrol except 4-cyl. 2.0 l C
)10
Engine control module (1.6 l diesel, 5-cyl. diesel)15
Engine control module (4-cyl. 2.0 l B
)20
FunctionA
Valves (1.6 l petrol); mass air flow sensor (1.6 l, 4-cyl. 2.0 l B
);
Thermostat (4-cyl. 2.0 l pet-rol B
); EVAP valve (4-cyl. 2.0 l
petrol B
); Cooling valve for cli-
mate control system (4-cyl. 2.0 l diesel); Cooling pump for EGR(4-cyl. 2.0 l diesel) Mass air flow sensor (engine D4162T); Control valve, fuelflow (engine D4162T)10
Mass air flow sensor (5-cyl. diesel, 6-cyl.); Control valves(5-cyl. diesel); Injectors (5, 6-cyl. petrol); Engine controlmodule (5-cyl. petrol, 6-cyl.)15
ProCarManuals.co’

10 Maintenance and service
10
371
FunctionA
Solenoid clutch A/C (5, 6-cyl.); Valves (1.6 l, engine B4204T7;5-cyl., 6-cyl.); Engine controlmodule (6-cyl.); Solenoids (6-cyl. without turbo); Actuatormotors, intake manifold (6-cyl.without turbo); Mass air flowsensor (engine B4204T7; 5-cyl.petrol); Oil level sensor (5-cyl.diesel)10
Valves (4-cyl. 2.0 lB
); Oil pump
(4-cyl. 2.0 l petrol B
); Lambda-
sond, centre (4-cyl. 2.0 l pet- rol B
); Lambda-sond, rear (4-cyl.
2.0 l diesel)15
Lambda-sonds (1.6 l petrol, engine B4204T7); Lambda-sond (5-cyl. diesel); Controlmodule, radiator roller cover(1.6 l diesel, 5-cyl. diesel)10
Lambda-sond, front (4-cyl. 2.0 l B
); Lambda-sond, rear (4-
cyl. 2.0 l petrol B
); EVAP valve
(5, 6-cyl. petrol); Lambda- sonds (5, 6-cyl. petrol)15
FunctionA
Coolant pump (1.6 l petrol Start/Stop); Crankcase ventila-tion heater (5-cyl. petrol); Oilpump automatic gearbox(5-cyl.petrol Start/Stop)10
Ignition coils (4-cyl. 2.0 l pet- rol B
)15
Diesel filter heater20
Control module, radiator roller cover (5-cyl. petrol)5
Crankcase ventilation heater (5-cyl. diesel); Oil pump auto-matic gearbox (5-cyl. dieselStart/Stop)10
Solenoid clutch A/C (4-cyl. 2.0 l B
); Glow control module (4-
cyl. 2.0 l diesel); Oil pump (4- cyl. 2.0 l diesel)15
Coolant pump (4-cyl. 2.0 l pet- rol B
)50
Glow plugs (diesel)70
FunctionA
Cooling fan (1.6 l, 4-cyl. 2.0 l petrol, 5-cyl. petrol)60
Cooling fan (6-cyl., 4-cyl. 2.0 l diesel, 5-cyl. diesel)80
Power steering100
A For cars with the Start/Stop function this fuse location is empty - see instead Fuses - in the engine compartment'scold zone (p. 377).
B Does not apply to the B4204T7 engine.
C However, does apply to the B4204T7 engine.
Related information
• Fuses - under glovebox (p. 372)
• Fuses - in the control module under the glovebox (p. 374)
• Fuses - in cargo area (p. 376)
ProCarManuals.co’

10 Maintenance and service
10
}}
* Option/accessory, for more information, see Introduction.377
Fuses - in the engine compartment's cold zone
Fuses in the engine compartment's cold zone are fitted in cars with the Start/Stop function.
Location of fuses for the Start/Stop function. • Fuses A1 and A2 are of the "MEGA Fuse" type and must only be replaced by a workshop 16
.
• Fuses 1-11 are of the "Midi Fuse" type and must only be replaced by a work- shop 16
.
• Fuse 12 is of the "Mini Fuse" type.
For more information on Start/Stop - see Start/Stop* (p. 279).
Positions
FunctionA
Main fuse for central electrical unit in the engine compartment175
Main fuse for central electronic module (CEM) under the glove-box, relay/fuse box under theglovebox, central electrical unitin cargo area175
FunctionA
Electric additional heater*100
Primary fuse for the central electronic module (CEM) underthe glovebox50
Primary fuse for relay/fuse box under the glovebox60
16 An authorised Volvo workshop is recommended.
ProCarManuals.co’

11 Specifications
11
411
Starter battery - specification
The starter battery is used to drive the starter motor and other electrical equipment in thecar.
EngineVoltage (V)Cold start capacity,
CCA - Cold Cranking Amperes (A)Reserve capacity (minutes)
Petrol (Ethanol)12520–800100–160
Diesel12700–800135–160
Petrol/Diesel with Start/Stop function12760A135
A
Battery type AGM (Absorbed Glass Mat) must be used in cars with the Start/Stop function.
IMPORTANT
If the battery is replaced, take care to replace it with a battery with the same coldstarting capacity and reserve capacity asthe original battery (see the label on thebattery).
NOTE
• The starter battery's container size should be consistent with the originalbattery's dimensions.
• The starter battery's height is differentdepending on size.
Related information
•
Starter battery - replacement (p. 363)
• Battery (p. 361)
ProCarManuals.co’

||
11 Specifications
11
426* Option/accessory, for more information, see Introduction.
SymbolSpecificationSee
Stability system, DSTC, Trailerstability assist(p. 64), (p. 178), (p.312)
Stability system, sport mode(p. 64), (p. 178)
Engine preheater (diesel)(p. 64)
Low level in fuel tank(p. 64), (p. 132)
Information, read display text(p. 64)
Main beam On(p. 64), (p. 81)
Left-hand direc- tion indicators(p. 64)
Right-hand direction indica-tors(p. 64)
Start/Stop*, engine auto-stopped(p. 64), (p. 286)
ECO function* on(p. 64), (p. 288)
Tyre pressure system*(p. 64), (p. 330)
Information symbols in the combined instrument panel
SymbolSpecificationSee
Cruise control*(p. 185)
Adaptive cruise control*(p. 200)
Adaptive cruise control*, time inter-val(p. 188), (p. 190)
Adaptive cruise control*, DistanceWarning* (DistanceAlert)(p. 192), (p. 202)
Radar sensor*(p. 200), (p. 204),(p. 222)
Speed limiter(p. 182)
Camera sensor*, Laser sensor*(p. 211), (p. 222),(p. 227),(p. 232),(p. 238)
SymbolSpecificationSee
Auto Brake*, Dis- tance Warning*(Distance Alert), City Safety TM
, Col-
lision warning sys- tem*(p. 204), (p. 211),(p. 222)
ABL system*(p. 84)
Driver Alert Sys- tem*, Time for abreak(p. 225)
Driver Alert Sys- tem*, Time for abreak(p. 227)
Parking brake(p. 293)
Rain sensor*(p. 90)
Active high beam, AHB (Active HighBeam)*(p. 82)
Windscreen sen- sor*(p. 82)
Start/Stop*(p. 286)
ProCarManuals.co’

11 Specifications
11
* Option/accessory, for more information, see Introduction.427
SymbolSpecificationSee
Start/Stop*(p. 286)
Driver Alert Sys- tem*, Lane Depar-ture Warning(LDW), Lane Keep-ing Aid (LKA)(p. 227), (p. 232),(p. 238)
Driver Alert Sys- tem*, Lane Depar-ture Warning*(p. 230)
Driver Alert Sys- tem*, Lane Depar-ture Warning*(p. 232)
Recorded speed information*(p. 179)
Engine block and passenger com-partment heater*(p. 132)
Activated timer*(p. 132)
Activated timer*(p. 132)
SymbolSpecificationSee
Low battery(p. 132)
Fuel filler flap, right-hand side(p. 300)
Information symbols in the roof console display
SymbolSpecificationSee
Seatbelt reminder(p. 26)
Airbag, passenger seat, activated(p. 30)
Airbag, passenger seat, deactivated(p. 30)
Related information
• Combined instrument panel - meaning of indicator symbols (p. 64)
• Combined instrument cluster - meaningof warning symbols (p. 65)
• Messages - handling (p. 102)
ProCarManuals.co’

12 Alphabetical Index
12
431
Electrical socket...................................... 141
cargo area........................................... 144
Electrical system...................................... 410 Electric parking brake low battery voltage............................. 293
Electronic climate control - ECC............. 121Emergency equipment first aid kit........................................... 329
warning triangle.................................. 329
Emergency puncture repair..................... 333 action.................................................. 335
inflating the tyres................................ 337
rechecking.......................................... 336
Emergency puncture repair kit location............................................... 333
overview.............................................. 334
sealing fluid......................................... 338
Emissions of carbon dioxide................... 403 Engine deactivate........................................... 265
overheating......................................... 306
start..................................................... 264
Start/Stop........................................... 279
Engine and passenger compartment heater direct start/immediate stop................ 130
messages........................................... 132
timer.................................................... 130
Engine block heater......................... 129, 269 Engine compartment
coolant................................................ 349
oil........................................................ 345
overview.............................................. 343
power steering fluid............................ 351
Engine drag control................................. 176
Engine oil......................................... 345, 395 adverse driving conditions.................. 395
filter..................................................... 345
grade and volume............................... 396
Engine specifications............................... 393 Error messages Adaptive Cruise Control..................... 200
Driver Alert Control............................. 227
Lane Departure Warning..................... 232
LKA..................................................... 238
see Messages and symbols....... 200, 295
Error messages in BLIS........................... 257
ERS - Remote Start................................. 266
exhaust gases, toxic, sucked in.............. 298
External dimensions................................ 389
F
Fan ECC.................................................... 123
Fault tracing for the camera sensor......... 208 First aid.................................................... 329
First aid kit............................................... 329
Flexifuel.................................................... 269
Fluids, capacities............. 398, 399, 401, 402
Fluids and oils.......................... 398, 399, 401Fog lamp
rear........................................................ 85
Foot brake....................................... 290, 291
FOUR-C - Active chassis......................... 175
FSC, ecolabelling....................................... 21
Fuel.......................................... 301, 302, 304 fuel consumption................................ 403
fuel economy...................................... 328
fuel filter.............................................. 303
Fuel-driven heater direct start/immediate stop................ 130
timer.................................................... 130
Fuelling filling................................................... 300
fuel cap............................................... 300
fuel filler flap....................................... 300
fuel filler flap, manual opening............ 300
Fuel tank volume................................................ 402
Fuse box.................................................. 367
Fuses....................................................... 367 cargo area........................................... 376
ProCarManuals.co’

12 Alphabetical Index
12
432
changing............................................. 367
cold zone............................................ 377
engine compartment.......................... 368
General............................................... 367
Start/Stop........................................... 377
under glovebox........................... 372, 374
G
Gearbox................................................... 271automatic.................................... 273, 276
manual................................................ 271
Gear indicator.......................................... 272
Gear selector inhibitor............................. 278Gear selector inhibitor, mechanical disen-
gagement................................................. 278
Geartronic................................................ 273Glass laminated/reinforced............................. 21
Glovebox................................................. 140 locking................................................ 167
Gross vehicle weight............................... 390
GSI - Gear selector assistance................ 272
H
Handbrake............................................... 293
Hazard warning flashers............................ 86
Headlamp control...................................... 78
Headlamp levelling.................................... 79
Headlamp pattern, adjusting..................... 90
Headlamp pattern adjustment................... 90 Active Bending Lights .......................... 90
Headlamps............................................... 353head restraint centre seat, rear.................................... 74
lowering.......................................... 75, 76
Heated washer nozzles.............................. 91 Heating rearview and door mirrors.................... 96
rear window.......................................... 96
seats................................................... 122
steering wheel....................................... 77
Heat-reflecting windscreen........................ 17
High engine temperature......................... 306
High-pressure headlamp washing............. 91
Hill Start Assist........................................ 279
Home safe light duration........................... 89
Horn........................................................... 77
I
IAQS - Interior Air Quality System........... 118
Immobiliser.............................................. 150
Indicator symbols...................................... 64
Inflatable curtain.................................. 33, 36
Information button, PCC.......................... 153
Information display.............................. 59, 60
Inlaid mats............................................... 140
Instrument lighting, see Lighting................ 79Instrument overview left-hand drive car................................ 53
right-hand drive car.............................. 56
Instruments and controls..................... 53, 56 Interior Air Quality System (IAQS) Air cleaning......................................... 118
Interior lighting, see Lighting..................... 88
Interior rearview mirror............................... 96 automatic dimming............................... 97
Intermittent wiping..................................... 90
J
Jack......................................................... 321
Jacket holder........................................... 139
ProCarManuals.co’