Citroen C4 2016 2.G Owner's Manual

229
C4-2_en_Chap07_infos-pratiques_ed02-2015
Used products
The additive reservoir low level is indicated by:
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
-
 
f
ixed   illumination   of   the   particle  
f

ilter   warning   lamp,   accompanied  
b

y   an   audible   signal   and   a  
m

essage   that   the   particle   filter  
a

dditive   level   is   too   low.
Additive level (Diesel with
particle filter)
Avoid prolonged contact of used oil or f
luids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do not discard used oil or fluids into
sewers
  or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
7
Practical information

230
C4-2_en_Chap07_infos-pratiques_ed02-2015
Checks
Particle filter (Diesel)
- fixed  illumination   of   the   particle  f
ilter   warning   lamp,   accompanied  
b

y   an   audible   signal   and   a  
m

essage   that   there   is   a   risk   of  
b

lockage   of   the   particle   filter.
The presence of this label, in particular with
the
 
Stop
 
&
 
Start
 
system,
 
indicates
 
the
 
use
 
of
 
a s

pecific 12 V lead-acid battery with special
technology
 
and
 
specification.
 
The
 
involvement
 
o

f
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop
 
i

s
 
essential
 
when
 
replacing
 
or
 
disconnecting
 
t

he
 
battery. As
 
soon
 
as   the   traffic   conditions   permit,  
r

egenerate   the   filter   by   driving   at   a   speed   of   at  
l

east
 
40
 
mph   (60   km/h)   until   the   warning   lamp  
g

oes
 
off.
If
 
the
 
warning   lamp   stays   on,   refer   to   the  
"

Additive
 
level"   section.
Unless
 
other wise
 
indicated,
 
check
 
these
 
components
 
in
 
accordance
 
with
 
the
 
manufacturer's
 
service
 
schedule
 
and   according   to   your   engine.
Other wise,
 
have
 
them
 
checked
 
by
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop.
Air filter and passenger compartment filter
Refer to the manufacturer's s
ervice schedule for details of the
replacement
  intervals   for   these  
c

omponents.
Oil filter
Replace the oil filter each time the e ngine   oil   is   changed.
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  replacement   interval   for   this  
c

omponent.
12 V battery
The battery does not require any maintenance.
H owever,   check   that   the   terminals   are   clean a

nd   correctly   tightened,   particularly   in   summer
 a

nd   winter.
When carrying out work on the battery, refer to the "12 V battery" section for details of the
precautions
  to   be   taken   before   disconnecting  
t

he   battery   and   following   its   reconnection.Depending
  on   the   environment   (e.g.   dusty  a
tmosphere)   and   the   use   of   the   vehicle  
(e.g.
  city   driving),   replace them twice as often
if necessary .
A
  clogged   passenger   compartment   filter   may  
h

ave   an   adverse   effect   on   the   per formance  
o

f   the   air   conditioning   system   and   generate  
u

ndesirable
 o
dours.The start of saturation of the particle filter is
indicated
  by:
On a new vehicle, the first operations of
regeneration   of   the   particle   filter   may   be  
a

ccompanied   by   the   smell   of   "burning",  
w

hich   is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle at very low speed or at idle,
you
  may,   in   exceptional   circumstances,  
n

otice   the   emission   of   water   vapour   at  
t

he   exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
  the   environment.
Practical information

231
C4-2_en_Chap07_infos-pratiques_ed02-2015
Automatic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  level   checking   interval   for   this  
c

omponent.
Electric parking brake
This system does not require any routine   servicing.   However,   in  
t

he   event   of   a   problem,   have   the  
s

ystem   checked   by   a   CITROËN  
d

ealer   or   a   qualified   workshop.
Manual parking brake
If a loss of effectiveness of this
system i s  n oticed,  t he  p arking  b rake  
m

ust   be   checked,   even   between  
t

wo   services.
Brake pads
Brake wear depends on the style of   driving,   particularly   in   the   case  
o

f vehicles used in town, over short
distances.
  It   may   be   necessary   to  
Brake disc wear
For information on checking brake disc wear, contact a CITROËN
dealer
  or   a   qualified   workshop.
For
  more   information   on   the   electric   parking  
b

rake,   refer   to   the   corresponding   section.
Manual gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   the   checking   interval  
f

or   this   component.
Only
  use   products   recommended   by  
C

ITROËN   or   products   of   equivalent  
q

uality
 an
d
 sp
ecification.
In
  order   to   optimise   the   operation   of  
u

nits   as   important   as   those   in   the  
b

raking   system,   CITROËN   selects   and  
o

ffers   very   specific   products.
After
  washing   the   vehicle,   dampness,  
o

r   in   wintry   conditions,   ice   can   form  
o

n   the   brake   discs   and   pads:   braking  
e

fficiency   may   be   reduced.   Make   light  
b

rake   applications   to   dry   and   defrost  
t

he   brakes.
have
 
the
 
condition   of   the   brakes   checked,   even  
b

etween
 v

ehicle
 s
ervices.
Unless
 
there   is   a   leak   in   the   circuit,   a   drop   in  
t

he
 
brake
 
fluid   level   indicates   that   the   brake  
p

ads
 
are
 
worn. Checking
  this   system   must   be   done   by   a  
C

ITROËN   dealer   or   a   qualified   workshop.
7
Practical information

232
C4-2_en_Chap07_infos-pratiques_ed02-2015
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing urea, a
 
catalytic
 
converter
 
turns
 
up
 
to
 
85%   of   nitrous o

xides
 
(NOx)
 
into
 
nitrogen
 
and
 
water,   which   are
 h

armless
 
to
 
health
 
and
 
the
 
environment.
The AdBlue® additive is held in a special
tank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once the AdBlue
® tank is empty, a s
ystem
 
required
 
by   regulations   prevents  
s

tarting
 
of
 
the
 
engine.
If the SCR is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   your  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
Freezing of the AdBlue
® additive
The AdBlue
® additive freezes at
temperatures   below   around   -11°C.
The
 
SCR
 
system   includes   a   heater  
f

or the AdBlue
® tank, allowing you to c
ontinue
 
driving   in   very   cold   conditions.
Practical information

233
C4-2_en_Chap07_infos-pratiques_ed02-2015
Topping-up the AdBlue® additive
Precautions in use
Use only AdBlue® additive that meets t
he ISO 22241
 
standard.
The
 
supply
 
in
 
a
 
non-drip   bottle   simplifies  
t

oping-up.
 
You
 
can   obtain   1.89   litre   (half   a  
U

S gallon)
 
bottles   from   a   CITROËN dealer   or   a  
q

ualified
 w

orkshop.
Keep AdBlue
® out of the reach of
children,
 
in
 
its
  original   bottle.
Never transfer AdBlue
® to another
container:
 
it
 
would
 
lose
  its   purity. Never
  dilute   the   additive   with   water.
Never pour the additive into the Diesel
fuel   tank.
Never   top-up   from   an   AdBlue®
dispenser
 
reserved
 
for
 
heavy
 
goods  
v

ehicles.
Filling
 
the
 
AdBlue
® tank is an operation i
ncluded in every routine service on your
vehicle
 
by
 
a
 
CITROËN   dealer   or   a   qualified  
w

orkshop.
Nevertheless,
 
given   the   capacity   of   the   tank,  
i

t
 
may
 
be
 
necessary   to   top-up   the   additive  
b

etween
 
services,
  more   particularly   if   an   alert  
(

warning
 
lamps
 
and   a   message)   signals   the  
r

equirement.
You
 
can
 
got
 
to
 
a
 
CITROËN   dealer   or   a   qualified  
w

orkshop.
If
 
you
 
envisage
 
topping-up   yourself,   please  
r

ead
 
the
 
following
 
warnings   carefully. The AdBlue
® additive is an urea-based
solution.
 
This   liquid   is   non-flammable,  
c

olourless
 
and   odourless   (kept   in   a   cool   area).
In
 
the
 
event
 
of   contact   with   the   skin,   wash  
t

he
 
affected
 
area   with   soap   and   water.   In   the  
e

vent
 
of
 
contact   with   the   eyes,   wash   (irrigate)  
t

he
 
eyes
 
with   large   amounts   of   water   or   with  
a

n
 
eye
 
wash
  solution   for   at   least   15   minutes.  
I

f
 
a
 
burning
 
sensation   or   irritation   persists,   get  
m

edical
 
attention.
If
 
swallowed,   immediately   wash   out   the   mouth  
w

ith
 
clean
 
water   and   then   drink   plenty   of   water.
In
 
certain
 
conditions   (high   ambient  
t

emperature,
  for   example),   the   risk   of   release  
o

f
 
ammonia
 
cannot   be   excluded:   do   not   inhale  
t

he
 
product.
 
Ammonia   vapour   has   en   irritant  
e

ffect
 
on
 
mucous   membranes   (eyes,   nose   and  
t

hroat).
7
Practical information

234
C4-2_en_Chap07_infos-pratiques_ed02-2015
Recommendations on storageProcedure
F Switch  off   the   ignition   and   remove   the  k
ey,   or   if   your   vehicle   has   one,   press   the  
S

TART/STOP   button   to   switch   off   the  
e

ngine. F

R
aise the boot floor for access to the
AdBlue
® tank. S
ecure
 
the   boot   floor   by   attaching   its   cord  
t

o
 
the
 
hook   on   the   parcel   shelf   support.
F
 
U

nclip
 
the   black   plastic   blanking   plug   using  
i

ts
 
tab.
F
 
I

nsert
 
your   fingers   into   the   aperture   and  
t

urn
 
the
 
blue   cap   a   6
th of a turn anti-
clockwise.
F
 
C

arefully
 
lift
 
off
 
the
 
cap,   without   dropping   it.
Never store bottles of AdBlue
® in your
vehicle. Before
  topping-up,   ensure   that   the   vehicle   is  
p

arked   on   a   flat   and   level   sur face.
In wintry conditions, ensure that the
temperature   of   the   vehicle   is   above   -11°C.  
O

therwise the AdBlue
® may be frozen and s
o
 
cannot
 
be
 
poured
 
into   its   tank.   Park   your  
v

ehicle
 
in
 
a
 
warmer
 
area   for   a   few   hours   to  
a

llow
 
the
 
top-up
 
to
 
be
 
carried   out.
AdBlue
® freezes at about -11°C and d
eteriorates   above   25°C.   It   is   recommended  
t

hat bottles be stored in a cool area and
protected
  from   direct   sunlight.
Under
 
these   conditions,   the   additive   can   be  
k

ept
 
for
 
at   least   a   year.
If the additive has frozen, it can be used once it
has
 
completely   thawed   out.
Practical information

235
C4-2_en_Chap07_infos-pratiques_ed02-2015
F Obtain a bottle of AdBlue®. After first c
hecking
 
the
 
use-by
 
date,
  read   carefully  
t

he instructions on use on the label before
pouring
 
the
 
contents
 
of
 
the   bottle   into   your  
v

ehicle's
 Ad

Blue
® tank. F  
A
fter   emptying   the   bottle,   wipe   away   any  
s

pillage   around   the   tank   filler   using   a   damp  
c

loth.
F  
R
efit   the   blue   cap   to   the   tank   and   turn   it   a  
6th of a turn clockwise, to its stop.
F
 R
efit   the   black   plastic   blanking   plug,  
c

lipping   it   in   on   the   flap
F
 
D

etach   the   cord   from   the   parcel   shelf  
s

upport   and   lower   the   boot   floor.
Important:
 
if
 
your
 
vehicle's
 
AdBlue®
tank
 
is
 
completely
 
empty
 
-
 
which
 
is
 
c

onfirmed
 
by
 
the
 
alert
 
displays
 
and
  the  
i

mpossibility
 
of
 
starting
 
the
 
engine
 
-   you  
m

ust
 
add
 
at
 
least
 
3.8
 
litres
 

(so
 
two
 
1.89 litre
 
bottles). If any additive is split or splashed, wash
immediately
 
w
ith  
c
old  
w
ater  
o
r  
w
ipe  
w
ith  
a

  damp   cloth.
If the additive has crystallised, clean it
off   using   a   sponge   and   hot   water.Important:
 i
n the event of a top-up
after a breakdown because of a lack
of additive ,   you   must   wait   around  
5   minutes   before   switching   on   the  
ig

nition,
 w
ithout opening the
driver's door, locking the vehicle,
introducing the key into the ignition
switch, or introducing the key of the
"Keyless Entr y and Star ting" system
into the passenger compartment .
Switch   on   the   ignition,   then,   after  
10   seconds,   start   the   engine.
Never dispose of AdBlue® additive
bottles
 
in
 
the
 
household
 
waste.   Place  
t

hem
 
in
 
a
 
special
 
container   provided  
t

his
 p

urpose
 o

r
 t

ake
 t

hem
 t
o
 y
our
 d
ealer.
7
Practical information

236
C4-2_en_Chap07_infos-pratiques_ed02-2015
Accessories
Conversion kits
You can obtain an "Enterprise" kit to convert a trade   vehicle   to   a   private   car   and   vice-versa.
"Comfort":
door deflectors, side window blinds, rear
screen  blind,   insulated   module,   coat   hanger  
f

ixed   to   head   restraint,   reading   lamp,   mirror   for  
c

aravan, cruise control, scented air freshener
and
  cartridges,   parking   sensors...
"Transport systems":
boot carpet, boot liner, boot net, boot spacers,
transverse  roof   bars,   bicycle   carrier,   ski   carrier,  
r

oof   boxes,   towbars,   towbar   wiring   harnesses...
"Styling":
gear lever knobs, aluminium foot rest, alloy wheels,   wheel   embellishers,   chrome   mirror  
s

hells,   chrome   door   
a
perture   finishers,   door   sill  
f

inishers,   tailgate   lower   chrome   finisher...
*
 
T
o   avoid   any   risk   of   jamming   the   pedals:
-
 
e
nsure   that   mats   are   correctly   positioned  
a

nd secured,
-
 
n
ever   fit   one   mat   on   top   of   
a
nother.
"Security and safety":
anti-intrusion alarm, microwave sensor, anti-tilt sensor,   stolen   vehicle   tracking   system,   child  
sea

ts and booster cushions, breathalyser, first
aid
  kit,   fire   extinguisher,   warning   triangle,   high  
v

isibility   vest,   dog   guard,   pet   seat   belt,   wheel  
s

ecurity bolts, snow chains, non-slip covers,
front
  foglamp   kit...
"Protection":
mats*, seat covers compatible with  l ateral  a
irbags,   door   sill   protectors,   mud   flaps,   door  
p

rotective   rubbing   strips,   bumper   protection  
s

trips, protective covers for pets, vehicle
cover...
If
 
a
 
towbar
 
and
 
wiring
 
harness
 
are
 
fitted
 
o

utside
 
the
 
CITROËN
 
dealer
 
network,
 
t

he
 
installation
 
must
 
be
 
done
 
using
 
t

he
 
vehicle's
 
electrical
 
pre-equipment
 
a

nd
 
in
 
line
 
with
 
the
 
manufacturer's
 
r

ecommendations.
A
 
wide
 
range
 
of
 
accessories
 
and
 
genuine
 
parts
 
is
 
available
 
from
 
the
 
CITROËN
 
dealer
 
network.
These
 
accessories
 
and
 
parts
 
are
 
all
 
suitable
 
for
 
your
 
vehicle
 
and
 
benefit
 
from
 
CITROËN's
 
recommendation   and   warranty.
Practical information

237
C4-2_en_Chap07_infos-pratiques_ed02-2015
"Multimedia":
audio systems, steering mounted audio controls,   speakers,   Hi-Fi   module,   Bluetooth  
h

ands-free   system,   portable   satellite   navigation  
s

ystem,   semi-integral   support   bracket   for  
p

ortable   navigation   system,   mapping   update  
C

D,   driving   assistant,   portable   video   screen,  
p

ortable   video   support   bracket,   230 V/50 Hz  
s

ocket,   230   V/50   Hz   adaptor,   iPhone
®
compatible
 
mobile
 
phone
 
charger,
 
mobile  
p

hone/smartphone
 
bracket,
 
Wi-Fi
 
on
 
board...
By
  going   to   a   CITROËN dealer,   you   can   also  
o

btain   cleaning   and   maintenance   products  
(

interior   and   exterior) - including   ecological  
p

roducts   in   the   "TECHNATURE"   range   -,  
p

roducts   for   topping   up   (screenwash...),   touch-
up
  pens   and   paint   aerosols   for   the   exact   colour  
o

f   your   vehicle,   recharges   (cartridge   for   the  
t

emporary   puncture   repair   kit...),   ...
Installation of radio
communication
transmitters
Before installing any after-market radio communication   transmitter,   you   can  
c

ontact a CITROËN dealer for the
specification
  of   transmitters   which   can  
b

e   fitted   (frequency,   maximum   power,  
a

erial position, specific installation
requirements),
  in   line   with   the   Vehicle  
E

lectromagnetic
 C
ompatibility
 D

irective (2004/104/EC). The
  fitting   of   electrical   equipment   or
 a

ccessories   which   are   not   recommended
 b

y   CITROËN   may   result   in   a   failure   of
 y

our   vehicle's   electronic   system   and
 e

xcessive   electrical   consumption.
Contact a CITROËN dealer
for
  information   on   the   range   of
 r

ecommended   equipment   and
 
 a

ccessories.
Depending
  on   the   legislation   in   force   in  
t

he   country,   certain   safety   equipment  
m

ay   be   compulsory:   high   visibility  s
afety   vests,   warning   triangles,  b
reathalyzers, spare bulbs, spare fuses,
fire
  extinguisher,   first   aid   kit,   mud   flaps  
a

t   the   rear   of   the   vehicle.
7
Practical information

238
C4-2_en_Chap08_en-cas-de-panne_ed02-2015
Running out of fuel (Diesel)
Other HDi engines
(except BlueHDi version)
On
 
vehicles
 
fitted
 
with
 
Diesel
 
engines,
 
the
 
fuel
 s
ystem
 
must
 
be
 
primed
 
if
 
you
 
run
 
out
 
of
 
fuel.
For all versions other than BlueHDi, refer to the
corresponding
 
engine
 
compartment
 
view.
For
 
more
 
information
 
on
 
the
 
Diesel
 
m

isfuel
 
prevention
 
device,
 
refer
 
to
 
the
 
c

orresponding
 s

ection.
BlueHDi engines
If the engine does not start first time, d on't   keep   trying   but   start   the   procedure  
a

gain   from   the   beginning. F

A
dd at least five litres of Diesel fuel to the
tank.
F  
O
pen   the   bonnet.
F  
I
f   necessary,   unclip   the   styling   cover   for  
a

ccess   to   the   priming   pump.
F  
S
queeze   and   release   the   priming   pump  
r

epeatedly   until   resistance   is   felt   (there  
m

ay   be   resistance   at   the   first   press).
F  
O
perate   the   starter   to   start   the   engine  
(

if   the   engine   does   not   start   at   the   first  
a

ttempt,   wait   around   15   seconds   before  t
rying ag ain).
F  I f   the   engine   does   not   start   after   a   few  
a

ttempts,   operate   the   priming   pump   again  
t

hen   start   the   engine.
F
 
R
efit   the   styling   cover   and   clip   it   in   place.
F
 
C
lose   the   bonnet.
F
 
F
ill   the   fuel   tank   with   at   least   five   litres   of  
D

iesel.
F  
S
witch   on   the   ignition   (without   starting   the  
e

ngine).
F  
W
ait   around   6   seconds   and   switch   off   the  
ig

nition.
F  
R
epeat   the   operation   10   times.
F  
O
perate   the   starter   to   run   the   engine.
In the event of a breakdown