technical specifications FIAT MULTIPLA 2006 1.G Owners Manual

194
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
IF A FUSE BLOWS
GENERAL
The fuse is a protective device for the electric system: it comes into
action (i.e. it cuts off) mainly due to a fault or improper action on the
system.
When a device does not work, check the efficiency of its fuse. The
conductor element (A) must be intact; if not, replace the fuse with one of
the same amp rating (same colour).
(B): undamaged fuse.
(C): fuse with damaged filament.
To replace fuse, use the pliers (D) hooked inside the fuse box cover on
the left side of the dashboard.
F0E0625m
Never replace a fuse with metal wires or anything else.
WARNINGIf a general fuse (MEGA-FUSE, MIDI-FUSE, MAXI-FUSE) cuts in, do not attempt
any repair and contact a Fiat Dealership. Before replacing a fuse, make sure the
ignition key has been removed and that all the other services are switched off
and/or disengaged.
WARNINGNever replace a fuse with another with a higher amp rating; DANGER OF FIRE. If
a fuse blows again, contact Fiat Dealership.

195
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
Certain fuses are protected by a plastic grid.
To replace these fuses, first of all remove the grid
using a screwdriver. Replace the blown fuse and refit
the plastic grid.
To locate the fuse, refer to the tables on the following
pages.
FUSE BOX
The fuse box is located under the oddments tray on
the driver’s side.
The fuse location (n. 16 to n. 28) is not binding; to
replace a blown fuse, refer to the fuse colour that
must be the same as the fuse box colour.
To reach the fuses:
❒Raise the oddments tray compartment flap.
F0E0694m
The numbers indicating the electrical components
corresponding to each fuse can be seen on the inside
of the flap inner wall.
❒Take out the inner cover, rotating the two knobs
(A).
The group of fuses marked with letter (B) contains
spare filaments.
To facilitate fuse replacement, use the pliers (C)
located near the fuse box.
After use return pliers to their place.
IMPORTANT Never turn the ignition key to MAR
with a fuse removed; doing so would turn on warning
light
¬and the “fault” would be stored by the airbag
control unit. In such an event, go to Fiat Dealership to
reset the fault stored on the airbag control unit.

196
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
FUSES IN THE ENGINE COMPARTMENT
Fuses next to the battery
Press the two locking tabs and remove the cover.
Fuses on the passenger compartment separating wall
Remove the protection cover from the fuse to be replaced.
Replace and refit the cover.
General protection fuses (MAXI- FUSE)
The car is fitted with a set of general protection fuses (MAXI-FUSE) that
individually protect, besides the fuses for the various services, the
electrical system functions.
Press the 2 locking side tabs and remove the cover.
Do not make these replacements yourself, but contact Fiat Dealership.
F0E0626mF0E0627m
F0E0628m
F0E0692m

197
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
1
2
2
3
3
3
4
5
6
6
6
6
6
6
6
7
7
7
7
8
8
8
8
9
9
10 10
10
10
20
20
20
10
30
10
10
10
10
10
10
10
10
10
10
10
10
10
10
10
15
15
20
Fuses inside the car Ampere Fuse no.
Right-hand main beam
Left-hand main beam
Main beam warning light
Rear fog lights
Rear fog lights warning light
Side/taillight power
Left-hand dipped beam
Car interior fan
Right-hand number plate light
Right-hand front sidelight
Cigar lighter light
Ashtray light
Side/taillight warning light
Sound system light
Left-hand taillight
Left-hand number plate light
Left-hand front sidelight
Right-hand taillight
Heating system lighting
Right-hand dipped beam
Brake fluid warning light
Headlight beam adjuster
Headlight washer relay coil
Cigar lighter
Conditioner compressor
Headlight washer

198
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
10
10
11
12
12
12
12
12
12
12
12
12
12
12
13
13
13
13
13
13
13
13
13
13
13 20
20
20
10
10
10
10
10
10
10
10
10
10
10
15
15
15
15
15
15
15
15
15
15
15Windscreen wiper
Rear window wiper
Horn
+ 30 instrument panel
+ 30 front ceiling light
+ 30 EOBD Fiat tester
+ 30 rear ceiling light
+ 30 sound system
+ 30 connect-nav
+ 30 navigator
+ 30 clock
+ 30 sunroof
+ 30 webasto (additional heater)
+ 30 anti-theft control unit
Reversing light
Front direction indicators
Brake light
Third brake light
Rear direction indicators
Direction indicator warning light
Side direction indicators
Hazard light warning light
+ 15 cellular phone
+ 15 sound system
+ 15 connect-nav
Fuses inside the car Ampere Fuse no.

199
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
13
13
14
14
14
15
15
16
17
17
17
17
17
17
17
17
18
19
19
20
20
21
22
23
24 15
15
10
10
10
30
30
15
7.5
7.5
7.5
7.5
7.5
7.5
7.5
7.5
30
25
25
25
25
7.5
7.5
7.5
20
Fuses inside the car Ampere Fuse no.
+ 15 navigator
Anti-theft control unit
Hazard light power
Anti-theft led
Anti-theft control unit
Heated rear window
Electric mirror defrosting
Front fog lights
Electric mirror movement
Air recirculation
Cigar lighter relay coil
Windscreen wiper relay coil
Electric seat relay coil
Heater relay coil
Heated rear window relay coil
12V socket relay coil
Front power windows
Tunnel 12V outlet
Boot 12V outlet
Refrigerator presetting
Electric seat riser
Electric mirror defrosting
Airbag circuit
ASR ON button
ABI control unit (power windows/front door lock)

200
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
25
25
25
25
25
25
25
25
25
26
27
28
29
30
31
32
33
34
35 7.5
7.5
7.5
7.5
7.5
7.5
7.5
7.5
7.5
7.5
25
25
7.5
20
7.5
10
25
7.5
30+ 15 phone presetting
+ 15 sound system
+ 15 sunroof relay coil
+ 15 navigator
+ 15 remote control receiver
+ 15 taxi-meter
+ 15 Airbag
+ 15 GSM box
+ 15 ABI control unit
+ 30 taxi-meter
+ 30 sunroof
Rear power windows
Fuses in engine compartment (next to battery, JTD versions only)
Fiat code
Webasto boiler (additional heater)
Main relay
ABS
Diesel fuel filter heating
+ 15 CCM and Fiat code control unit
Headlight washer pump
Fuses inside the car Ampere Fuse no.

201
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
36
37
38
39
40
41
41
42
43
44
45
46
47
48 15
7.5
7.5
7.5
20
40
50
60
60
30
30
60
80
7.5
Fuses in engine compartment (next to battery, petrol versions only) Ampere Fuse no.
Lambda probe
+ 15 CCM and Fiat code control unit
+ 30 Fiat code control unit
+ 15 ABS
Headlight washer pump
Fuses in engine compartment (on passenger’s compartment partition)
Engine cooling fan (with heater)
Engine cooling fan (with air conditioner)
Glow plugs
ABS
Fuses in engine compartment (next to battery, MAXI FUSE)
Ignition switch (EFI)
Electronic injection (IGN)
Secondary control unit protection
Passenger’scompartment control unit protection
Radiotaxi

202
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
IF THE BATTERY IS FLAT
IMPORTANT Battery recharging procedure is given as
information only since this operation shall be only
performed at a Fiat Dealership.
You are advised to recharge the battery slowly for a
period of approximately 24 hours at a very low
amperage. Charging for too long could result in the
battery being damaged.Proceed as follows:
❒Disconnect battery negative terminal (–).
IMPORTANT If the car is equipped with electronic
alarm, switch it off with the remote control.
❒Connect the charger cables to the battery terminals,
observing the poles.
❒Turn on the charger.
❒When you have finished, turn the charger off before
disconnecting the battery.
❒Reconnect battery negative terminal (–).
The liquid contained in the battery is poisonous and corrosive. Avoid contact with
the skin or eyes. The battery should be charged in a well ventilated place, away
from naked flames or possible sources of sparks: danger of explosion and fire.WARNING
WARNINGDo not attempt to charge a frozen battery: it must firstly be thawed, otherwise it
may burst. If freezing has occurred, the battery should be checked by skilled
personnel to make sure that the internal elements are not damaged and that the
body is not cracked, with the risk of leaking poisonous and corrosive acid.

203
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
JACKING THE CAR
If the car needs to be jacked up, go to a Fiat Dealership which is
equipped with shop jacks and jack arms.
Jack up the car only by positioning the jack arms or the shop jack in the
points shown in the figure.
TOWING THE CAR
The tow ring provided with the car is housed in the tool box or in the
FIX & GO container (where provided).
FITTING THE TOW RING
Proceed as follows:
❒release the front (A) or rear (B) cap;
❒take the tow hook (C);
❒tighten the ring on the rear or front threaded pin.
F0E0667m
F0E0678m
F0E0679m