technical specifications FIAT PANDA 2009 169 / 2.G Owners Manual

Car maintenance should be charged to
a Fiat Dealership. For routine and minor
maintenance operations you wish to carry
out yourself, always make sure you have the prop-
er equipment, genuine Fiat spare parts and the nec-
essary fluids; do not however carry out these
operations if you have no experience.
IMPORTANT – Battery
Check the battery charge once a year, preferably before
at the beginning of winter to limit the risk of electrolyte
freezing.
This check should be carried out more frequently if the
car is used mainly for short journeys, or if it is fitted with
accessories that permanently absorb electricity even with
the ignition key removed, especially in the case of after-
market accessories. If the car is used in hot climates or
particularly harsh conditions it is advisable to check the
level of the battery fluid (electrolyte) more frequently than
specified in the “Scheduled Servicing Programme”.
❒
frequently idling engine or long distance low speed dri-
ving (e.g. taxis or door-to-door deliveries) or in case
of a long term inactivity;
change engine oil more frequently than required on the
“Scheduled Servicing Programme”.
IMPORTANT – Diesel filter
The possibility of topping-up with diesel fuel not comply-
ing with EN 590 European Standard might make it neces-
sary to replace the filter more frequently than indicated in
the “Scheduled Servicing Programme”.
IMPORTANT – Air filter
When the car is used on dusty roads, change the air fil-
ter more frequently than shown on the “Scheduled Ser-
vicing Programme”. If in doubt as to how often the en-
gine oil and air filter should be changed according to how
you use the car, contact a Fiat Dealership.
IMPORTANT – Pollen filter
It is advisable to replace the filtering element more fre-
quently if the car is used in dusty or very polluted places.
Specifically, replace if a lower air flow into the passen-
ger’s compartment is found.
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE173
169-190 PANDA EN 7-10-2009 14:14 Pagina 173

fig. 172
F0Z0700m
Never smoke while working in the engine
compartment: gas and inflammable
vapours may be present, with the risk of fire.
WARNING
Be careful, when topping-up and take care
not to confuse the various types of fluids:
they are all incompatible with one anoth-
er and could seriously damage the car.
Versions 1.1 and 1.2 (with heater) fig. 172
1. Engine oil
1a. Engine oil for version 1.2 Euro 5
2. Battery
3. Brake fluid
4. Windscreen washer fluid
5. Engine coolant.
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGESCORRECT USE
OF THE CARSAFETYKNOW
YOUR VEHICLE
174
169-190 PANDA EN 7-10-2009 14:14 Pagina 174

Versions 1.1 and 1.2
(with climate control system)
fig. 173
1. Engine oil
1a. Engine oil for version 1.2 Euro 5
2. Engine coolant
3. Windscreen washer fluid
4. Brake liquid
5. Battery.
fig. 173
F0Z0812m
fig. 174
F0Z0261m
Versions 1.3 Multijet – fig. 174
1. Engine oil
2. Engine coolant
3. Windscreen washer fluid
4. Brake liquid
5. Battery.
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE175
169-190 PANDA EN 7-10-2009 14:14 Pagina 175

176KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0184m
fig. 175 – version 1.1
F0Z0262m
fig. 177 – version 1.3 Multijet
F0Z0106m
fig. 176 – version 1.2-1.2 Euro 5 (C)
IMPORTANT The oil consumption depends on driving
style and the car utilisation conditions.
IMPORTANT After adding or changing the oil, let the en-
gine run for a few seconds and wait a few minutes after
switching it off before checking the level. ENGINE OIL fig. 175 – 176 and 177
Check the oil level a few minutes (about five) after the en-
gine has stopped, with the car parked on level ground.
Check the level is within the MIN. and MAX. marks on the
dipstick B.
The range between the MIN. and MAX. marks corre-
sponds to about 1 litre of oil. If the oil level is close to or
actually below the MIN. mark, pour in the prescribed oil
through the filler A until it reaches the MAX mark. The oil
level must never exceed the MAX mark.
ENGINE OIL CONSUMPTIONThe maximum engine oil consumption is usually 400 grams
every 1000 km.
When the car is new, the engine needs to be run in, there-
fore the engine oil consumption can only be considered
stabilised after the first 5,000 ÷ 6,000 km.
169-190 PANDA EN 7-10-2009 14:14 Pagina 176

177KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
F0Z0182m
fig. 179
F0Z0107m
fig. 178
ENGINE COOLANT fig. 178 and 179
The coolant level must be checked when the engine is cold
and must range between the MIN. and MAX. marks on the
reservoir.
If the level is low, pour slowly a mixture of 50% deminer-
alised water and 50% PARAFLU
UP
of FL Selenia through
the filler neck A until approaching the MAX. level.
A 50-50 mixture of PARAFLU
UP
and demineralised wa-
ter gives freeze protection to −35 °C.
For particularly harsh climate conditions, a mixture of 60%
PARAFLU
UP
and 40% demineralised water is recom-
mended.
When the engine is hot, take care when
working inside the engine compartment to
avoid burns. Remember that when the engine is
hot, the fan may cut in: danger of injury. Scarves,
ties and other loose clothing might be pulled by
moving parts.
WARNING
Never add any oil with different specifica-
tions than those of the existing engine oil. Used engine oil and the replaced oil filter
contain substances that may be dangerous
for the environment. It is advisable to have
oil and filters changed by a Fiat Dealership where
they will be disposed respecting the environment
and according to law prescription.
169-190 PANDA EN 7-10-2009 14:14 Pagina 177

The engine cooling system is pressurised.
If necessary, only replace the cap with an-
other genuine one or the operation of the system
may be adversely affected. Do not remove the cap
from the reservoir when the engine is hot: dan-
ger of scalding.
WARNING
The engine cooling system uses protective
antifreeze fluid PARAFLU
UP. Use the same
fluid as in the cooling system when topping
up. PARAFLU
UP
fluid cannot be mixed with any oth-
er type of fluid. If this accidentally occurs, do not
start the engine and contact a Fiat Dealership.
Do not travel with the windscreen wash-
er reservoir empty: the windscreen
washer is fundamental for improving visibility.
WARNING
WINDSCREEN/REAR WINDOW WASHER
FLUID fig. 180
To top-up, remove the cap A.
Pour a mixture of water and TUTELA PROFESSIONAL
SC35, in the following concentrations:
30% TUTELA PROFESSIONAL SC35 and 70% water in
summer.
50% TUTELA PROFESSIONAL SC35 and 50% water in
winter.
At temperatures below −20 °C, use undiluted TUTELA
PROFESSIONAL SC35 fluid.
Check level through the reservoir.
fig. 180
F0Z0183m
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGESCORRECT USE
OF THE CARSAFETYKNOW
YOUR VEHICLE
178
169-190 PANDA EN 7-10-2009 14:14 Pagina 178

Certain commercial additives for wind-
screen washers are inflammable. The en-
gine compartment contains hot parts which could
start a fire if they come into contact.
WARNING
Prevent brake fluid which is highly corrosive
from coming into contact with painted
parts. Should this occur, immediately wash
with water. Brake fluid is poisonous and highly corro-
sive. In the event of accidental contact, im-
mediately wash the affected parts with water
and neutral soap. Then rinse thoroughly. If swal-
lowed call a doctor straight away.
WARNING
BRAKE FLUID fig. 181
Undo the cap A and check that the liquid contained in the
reservoir is at the maximum level.
Fluid level in the reservoir must not exceed the MAX
mark.
Use the brake fluid shown in the “Fluids and lubricants”
table (see “Technical Specifications”).
NOTE Carefully clean the reservoir cap A and the sur-
rounding surface.
Take great care that impurities do not enter the reservoir
when the cap is opened.
For topping-up, always use a funnel with integrated filter
with mesh equal to or lower than 0.12 mm.
IMPORTANT Brake fluid is hygroscopic (i.e. it absorbs
moisture). For this reason, if the car is mainly used in ar-
eas with a high degree of atmospheric humidity, the fluid
should be replaced at more frequent intervals than spec-
ified in the “Scheduled Servicing Programme”.
fig. 181
F0Z0109m
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE179
169-190 PANDA EN 7-10-2009 14:15 Pagina 179

180KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0135m
fig. 183
F0Z0134m
fig. 182
AIR FILTERREPLACEMENT (petrol versions) fig. 182 and 183
Release the clips A, remove the cover front side B
and extract the filtering element C to be replaced.
Brake fluid is poisonous and highly corro-
sive. In the event of accidental contact, im-
mediately wash the affected parts with water
and neutral soap. Then rinse thoroughly. Call a
doctor immediately if swallowed.
WARNING
The symbol
π
on the container indicates
a synthetic brake fluid, distinguishing it
from the mineral kind. Use of a mineral type flu-
ids will damage the special rubber seals of the
braking system beyond repair.WARNING
The symbol πon the container indicates
a synthetic brake fluid, which is different
from a mineral fluid. Use of a mineral-based flu-
id will damage the special rubber seals of the brak-
ing system beyond repair.
WARNING
169-190 PANDA EN 7-10-2009 14:15 Pagina 180

181KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
fig. 184
BATTERYThe car fits a low-maintenance battery: no top-ups with
distilled water are needed in standard conditions of use.
INSPECTING THE CHARGE AND
THE ELECTROLYTE LEVEL
The operations must be carried out as described in this
Owner Handbook only by skilled personnel. Any top-up
operations must be carried out by skilled personnel
and by a Fiat Dealership. REPLACEMENT (Diesel versions) fig. 184
Undo the screws D, remove the cover E and extract the
filtering element F to be replaced.
POLLEN FILTERPollen filter replacement shall be carried out at a
Fiat Dealership.
F0Z0263m
Battery liquid is poisonous and corrosive.
Avoid contact with the skin and eyes. Keep
naked flames or possible sources of sparks away
from the battery: risk of explosion or fire.
WARNING
169-190 PANDA EN 7-10-2009 14:15 Pagina 181

182KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Using the battery when the fluid is too low
can damage it irreparably and generate
a risk of explosion.
WARNING
CHANGING THE BATTERY
If required, replace the battery with a genuine spare part
having the same specifications.
If a battery with different specifications is fitted, the ser-
vice intervals given in the “Scheduled Servicing Pro-
gramme” in this chapter will no longer be valid.
Follow the battery manufacturer’s instructions for main-
tenance.
Incorrect assembly of electric and electronic
devices may cause severe damage to your
car. Contact a Fiat Dealership if you want
to install accessories (alarms, mobile phone, etc...):
they will suggest the most suitable devices and ad-
vise you if a higher capacity battery needs to be
installed.
If the car must remain unused for a long
time at very low temperature, remove the
battery and carry it to a warm place, to avoid
freezing.
WARNING
Batteries contain substances that can be
very dangerous for the environment. It is
advisable to have battery replaced by a
Fiat Dealership where it will be disposed respecting
the environment and according to law prescription.
USEFUL ADVICE FOR EXTENDING
THE LIFE OF YOUR BATTERY
To avoid draining your battery and make it last longer, ob-
serve the following instructions:❒
when you park the car, ensure the doors, tailgate and
bonnet are closed properly, to prevent any light switch-
ing-on inside the passenger’s compartment;
When you must perform any operation on
the battery or near it, always protect your
eyes with the special goggles.
WARNING
169-190 PANDA EN 7-10-2009 14:15 Pagina 182