GEELY CK 2008 Workshop Manual

Page 181 of 392

174Section 2 Malfunction Symptom Table and Solution ProcedureI.MALFUNCTION SYMPTOM TABLEThe table below lists the typical malfunction symptoms of the combination meter. These malfunctions can be
solved by the procedure in the section of the Malfunction Diagnosis.Serial No. MALFUNCTION SYMPTOM
1 The whole c ombination me te r does not ope ra te
2 Spe e dome ter ma lfunction
3 Tac home te r malfunc tion
4 Water temperature gauge malfunction
5 Fue l ga uge malfunc tion
6 O dome te r ma lfunc tion

Page 182 of 392

175II. DETAILED SOLUTION PROCEDURE1. THE WHOLE COMBINATION METER
DOSE NOT OPERATE.
(a) Inspect fuse
1Check fuse CLUSTER (10A) in the main fuse
box for continuity.
2Check fuse AM (30A) in the main fuse box
for continuity.
3Check fuse MAIN (80A) in the fuse box for
continuity.
Result and solution: If a certain fuse is burnt, replace a fuse
with the same capacity.Ignition SwitchMain Fuse BoxCombined Meter AssemblyBatteryFuse Box

Page 183 of 392

176(b) Inspect the combination meter connectors.
1 Inspect continuity
yDisconnect the connector from the combination meter assembly
y Inspect continuity between terminals
Standard:
2Inspect voltage
yDisconnect the connector from the combination meter assembly
yTurn the ignition switch ON
yInspect voltage between terminals
Standard:
Result and solution:
NormalReplace the combination meter assembly
AbnormalRepair or replace the harness or connectorTe ste r c onne c tion Condition Sta ndard c ondition
B4 - ground Turn the ignition switc h ON 10 – 14VTe ste r c onne c tion Condition Sta nda rd c ondition
B7 - ground Norma l condition Continuity
B8 - ground Norma l condition Continuity

Page 184 of 392

1772. SPEEDOMETER MALFUNCTION
CIRCUIT DIAGRAM
INSPECTION
(a) Inspect the combination meter assembly
1Remove the combination meter assembly and retain the connection of connectors.
2Inspect continuity
yInspect continuity between terminals
Standard:
3Inspect voltage between terminals
Standard:
Result and solution:
If it is abnormal, go to (b) Inspect the combination meter assembly speed input signal
If normal, go to (c) Inspect the combination meter assemblyTe ste r c onne c tion Condition Sta ndard c ondition
A9 - ground Norma l c ondition ContinuitySpeedometer SensorCombined Meter AssemblyGround the
Speedometer Sensor
Speedometer Sensor+8V
Power Source
Speed SignalTe ste r c onne c tion Condition Sta nda rd c ondition
A10 - ground Turn the ignition switch to ON 7.5 – 9V

Page 185 of 392

178(b) Inspect the combination meter assembly speed input signal
1Inspect voltage
yHold the front wheels up
yPush the shift lever to NEUTRAL
yTurn the ignition switch to ON
ySlowly turn the front wheel, measure the voltage between terminal A9 and A11
Standard voltage is as follows:
Voltage changes alternately
Result and solution:
Normal Replace the combination meter assembly
If abnormal, inspect the speed sensor
2Inspect the speed sensor
y Inspect continuity
Inspect continuity between terminals
Standard:Tester connection Condition Standard condition
2 - ground Normal c ondition ContinuityTurning WheelsBelow 0.5V

Page 186 of 392

179yInspect voltage between terminals
Standard:
Result and solution:
AbnormalRepair or replace the harness or connector
NormalInspect the speed sensor output signal
3Inspect the speed sensor output signal
Inspect voltage
yHold the front wheels up
yPush the shift lever to NEUTRAL
yTurn the ignition switch to ON
ySlowly turn the front wheel, measure the voltage between terminal 1 and 2
Standard voltage is as follows:
Voltage changes alternately
Result and solution:
NormalRepair or replace the harness or connector
Abnormalreplace the speed sensorTurning WheelsBelow 0.5VTe ste r c onne c tion Condition Sta nda rd c ondition
3 - ground Turn the ignition switch to ON 7.5 – 9V

Page 187 of 392

180(c) Inspect the combination meter assembly
1Remove the combination meter assembly and disconnect connectors.
2 Inspect continuity
yInspect continuity between terminals
Standard:
3Inspect voltage between terminals
Result and solution:
AbnormalRepair or replace the harness or connector
NormalReplace the combination meter assemblyTeste r c onne ction Condition Sta ndard c ondition
B7 - ground Normal c ondition Continuity
B8 - ground Normal c ondition ContinuityTe ste r c onne c tion Condition Sta nda rd c ondition
B4 - ground Turn the ignition switch to ON 10 – 14V

Page 188 of 392

1813. TACHOMETER MALFUNCTION
CIRCUIT DIAGRAM
Inspection procedure
(a) Inspect the combination meter assembly revolution input signal
1Remove the combination meter assembly and retain the connection of connectors.
2Connect the oscilloscope to the terminal B11 and
ground.
3Start the engine
4Inspect the signal wave form
Standard:
Show the correct wave form
Result and solution:
NormalInspect and replace the combination
meter assembly
AbnormalInspect the engine ECU revolution out-
put signalEngine ECUCombined Meter Assembly
Engine Revolution Signal

Page 189 of 392

182(b) Inspect the engine ECU revolution output signal
1Remove the engine ECU and retain the connection of connectors.
2Connect the oscilloscope to the terminal 54 and ground.
3Start the engine
4Inspect the signal wave form
Standard:
Show the correct wave form
Result and solution:
NormalRepair or replace the harness or
connector
AbnormalInspect the engine control system

Page 190 of 392

1834. WATER TEMPERATURE GAUGE MALFUNCTION
CIRCUIT DIAGRAM
(a) Get the value of water temperature with the diagnosis tester
1Connect the diagnosis tester to the diagnosis interface
2Turn the ignition switch to ON
3Read the value of engine water temperature displayed on the diagnosis tester
Standard: The same with the actual engine coolant temperature.
Result and solution:
If it is normal, the water temperature gauge has no malfunction
If abnormal, Inspect the combination meter assembly
(b) Inspect the combination meter assembly
1Inspect resistance
yRemove the combination meter assembly and disconnect connectors
yInspect continuity between terminalsWater Temperature SensorCombined Meter Assembly
Water
Temperature
Signal

Page:   < prev 1-10 ... 141-150 151-160 161-170 171-180 181-190 191-200 201-210 211-220 221-230 ... 400 next >