engine MAZDA 626 1987 Workshop Manual

OUTLINE 13
Front Coil Springs
Transa-
xle
Sun-
roof
Identification color
Model Market Engine Transa-
xle
Sun-
roof AAS ABS Green Light
green Pink Brown Purple Gray Orange
Sedan ECE F8 M4 — — — O
M5 — — — 0
4HAT — — — O
FE M5 — — — O
0 — — O
— o — o
o o — o
4HAT -— — o
— o — O
— — — o
o — — o
FE (DOHC) M5 — — — o
— o — 0
— o o o
— — o o
0 — — o
o o — o
0 0 o o
o — 0 o
FE (Fuel M5 — — — o
Injection) — 0 — O
EC-AT O — — o
o o — o
RF-N M5 — — — 0
RF-CX — — — o
Left Hand F8 M5 — — — o
Drive „ o — o
4HAT — — — o
RF-N M5 — — — o
Middle East FE M5 — — — o
-o — o
4HAT — — — o
— o — 0
Right Hand F6 3AT — — — 0
Drive M5 — — — o
FE M5 — — — 0
— o _ o
4HAT — — — o
— 0 — o
FE (DOHC) M5 — — — o
— o o 0
RF-N M5 — — — o
F8 M5 — — — 0
4HAT — — — o
76G13X003
O Available M4, M5.... ...Manual transaxle
— Not available EC-AT ....Electronically controlled automatic transaxle 4HAT ....Hydrallic controlled automatic transaxle
4WS ... 4-Wheel steering
AAS ....Auto adjusting suspention ABS ....Anti-lock brake system
3AT ... Automatic transaxle
13—5

13
OUTLINE
Transa-
xle Sun-

roof
Identification color
Model Market Engine Transa-
xle Sun-

roof
AAS ABS
Green Light
green Pink Brown Purple Gray Orange
Hatchback
ECE F8 M4 — — — O
M5 — — — O

4HAT
— — — O
FE M5 — — — o
O — — o

4HAT
-— — o
o — — O
FE
(DOHC)
M5 — — — o
— o — O
— o 0 o
— — 0 o
o — — o
o o — o
o o o 0
o — 0 o
— — 0 O (4WS)
o — 0 o
(4WS)

Left Hand
F8 M5 — — o
Drive 4HAT
— — — o
FE M5 — — — 0
— o — o

Middle East
FE M5 — — — o
— o — o

4HAT
— — — 0
-o — 0

Right Hand
F8 M5 — — — o
Drive 4HAT
— — o
FE M5 — — — o
— o — o

4HAT
— — — o
— o — o
FE
(DOHC)
M5 — — — o
— o — o
— o o

76G13X-004

13—6

OUTLINE
13

Transa-
xle Sun-

roof
Identification color
Model Market Engine Transa-
xle Sun-

roof
AAS ABS
Green Light
green Pink Brown Purple Gray Orange
Coupe/MX-6
ECE FE M5 — — — 0
O — — O

4HAT
— — — O
o — — 0
FE
(DOHC)
M5 — — — O
— o — o
— o o o
— — o o
o — — o
o o — o
o o o o
o — o o

Left Hand
FE M5 — — — O
Drive
— o — O
F8 M5 — — — o

Middle East
FE M5 o — — O
— o — o

Right Hard
F8 M5 — — — o
Drive
FE M5 — — — o
— o — o

4HAT
— — — o
— o — o
FE
(DOHC)
M5 — — — o
— o — o
— o o o

76G13X-005

13—7

13 OUTLINE
Rear Coil Springs
Transa-xle
Sun-
roof
Identification color
Model Market Engine Transa-xle
Sun-
roof AAS ABS Orange White Yellow Brown Blue Green Red Pink
Sedan ECE F8 M4 — — — R L
M5 — — — R L
4HAT — — R L
FE M5 — — — R L
— — R L
— o — R L
O 0 — R L
4HAT — „ — R L
— 0 — R L
— — — R L
o — — R L
FE (DOHC) M5 — — — R L
— o — R L
— o 0 R L
— — o R L
0 — — R L
0 o — R L
o 0 0 R L
o — o R L
FE (Fuel M5 — — — R L
Injection) — o — R L
EC-AT o — — R L
o o — R L
RF-N M5 — — — R R L L
RF-CX _ — — R L
Left Hand F8 M5 — — — R L
Drive — o — R L
4HAT — — — R L
RF-N M5 — — — R L
Middle East FE M5 — — — R L
— o — n L
4HAT — — — R L
— o — L
Right Hand F6 3AT — — — L R
Drive M5 — — — L R
FE M5 — — — L
— o — L R
4HAT — — — L
— o — L R
FE (DOHC) M5 — — — L R — o o L R
RF-N M5 — — L R
F8 M5 — — — L R
4HAT — — — L R
76G13X-006
0 Available R Right side M4, M5 Manual transaxle 3AT Automatic transaxle — Not available L Left side EC-AT... Electronically controlled automatic transaxle 4HAT..., Hydrallic controlled automatic transaxle 4WS...... 4-wheef steering AAS Auto adjusting suspention ABS Anti-lock brake system
13-8

OUTLINE
13

Transa-
xle Sun-
roof
Identification color
Model Market Engine Transa-
xle Sun-
roof
AAS ABS
Orange White Yellow Brown Blue Green
Red
Pink
Hatchback
ECE F8 M4 — — — R L
M5 — — — R L

4HAT
— — — R L
FE M5 — — — R L
O — — R L

4HAT
— — — R L
o — — R L
FE
(DOHC)
M5 — — — R L
— o — R L
— 0 o R L
— — o R L
o — — R L
o o — R L
o o o R L
o — o R L
— — o R
(4WS)
L
(4WS)
o — o R
(4WS)
L
(4WS)

Left Hand
F8 M5 — — — R L
Drive 4HAT
— — — R L
FE M5 — — — R L
— o — R L

Middle East
FE M5 — — — R L
— o — R L

4HAT
— — — R L
— o — R L

Right Hand
F8 M5 — — — L R
Drive 4HAT
— — — L R
FE M5 — — — L R
— o — L R

4HAT
— — — L R
— o — L R
FE
(DOHC)
M5 — — — L R
— o — L R
— o o L R

76G13X-007

13—9

13
OUTLINE
Transa-
xle Sun-

roof
Identification color
Model Market Engine Transa-
xle Sun-

roof
AAS ABS
Orange White Yellow Brown Blue Green
Red
Pink
Coupe/MX-6
ECE FE M5 — — — R L
O — — R L

4HAT
— — — R L
0 — — R L
FE
(DOHC)
M5 — — — R L
— o — R L
— o o R L
— — o R L
0 — — R L
o o — R L
o o o R L
o — o R L

Left Hand
FE M5 -— — R L
Drive
— o — R L
F8 M5 — — — R L

Middle East
FE M5 o — — R L
— o — R L

Right Hand
F8 M5 — — — L R
Drive
FE M5 — — — L R
— o — L R

4HAT
— — — L R
— o — L R
FE
(DOHC)
M5 — — — L R
— o — L R
— o o L R

76G13X-008

13—10

13 REAR WHEEL ALIGNMENT
2. Measure the camber angle with the caster/cam-
ber gauge.
Camber: -0°30' ± 45' (2WS)
0°00' ± 45' (4WS)
86U13X-123
Front
EAR TURNING ANGLE (4WS)
Place the rear wheels on a turning radius gauge.
Jack up the front of the vehicle.
Start the engine and let it idle.
Caution
If the engine is stopped while the steering
wheel is left turned to one side or the other,
the rear wheels will return to the straight-
ahead direction, and, when the engine is later
started once again, the direction of the rear
wheels will change. Be sure, therefore, to
check to be sure that the wheels are not
touching, or close to, anyone's hands or feet,
or any other object, when the engine is
stopped or started.
Turn the steering wheel fully left and right, and
measure the rear turning angle.
Rear turning angle Inner 5°00' ± 45'
Outer 5°00' ± 45'
If not within specification, adjust the rear turning
angle. (Refer to Section 10)
86U13X-125
13—54

LOCATION OF UNIT, RELAY AND SWITCH 1 5
LOCATION OF
UNIT,
RELAY AND SWITCH
STRUCTURAL VIEW
Door SW
Power window SW
AAS control unit
Cruise control unit
Relay box
(EGI and Diesel model)
Engine control unit
Brake fluid level sensor
Main fuse block
(EGI model)
Main fuse block
(Carburetor model) | \ Relay box
Main fuse block Relay box
(Diesel model) (Carburetor model)
Power window SW
Door SW
Door lock SW
AAS control SW
CPU and joint box
86U15X-002
15-7

JOINT
BOX AND FUSE
1
5
JOINT BOX AND FUSE
STRUCTURAL VIEW
Joint box Circuit breaker
(Rear window
defroster)
Reset button
Fuses
West Germany
(REAR FOG* RADIO 15A 15A (HEADCLEANER) 20A
(POWER 30A WIND) TAIL (LH) 15A STOP 15A
TAIL (RH) 15A METER 15A TURN 15A
ROOM 15A f(D00R LOCK) [ 30A c
HORN 5A
(AIR COND)' 15A (COOLING 20A FAN>I ENGINE 15A
(REAR 15A WIPER) WIPER 20A (SUN ROOF) [ 15A
ECE, LHD and RHD General (Diesel model)
. Q .
(REAR FOG) 15A J RADIO 15A (rHEADCLEAMEfii I joa J (POWER 1 30A WIND)j (DIM DIP) 15A ( HAZAARD ' I TAIL 15A METER 15A TURN 15A
' ROOM ' ISA j flBOOR LOCKl"1 L STOP 1SA -[(AIR COND) 15A J ' ENGINE 15A
(REAR 15A WIPER) WIPER 20A (SUN ROOF) I 16A
RHD General
only
UK, RHD General
(REAR FOG)
[
15A J
RADIO 15A (HEADCLEANER) 20A
(POWER 30A WIND) (DIM DIP) 15A HAZARD 10A
TAIL 15A METER 10A TURN 15A
ROOM 15A (DOOR LOCK) 30A STOP 15A
(AIR COND) 15A '(COOLING 20A FAN) ENGINE 15A
(REAR 15A WIPER) WIPER 20A (SUN ROOF) [ 15A ,
ECE, Middle East, LHD General
Q
(REAR FOG) 15A J RADIO 15A (HEADCLEANER) 20A
(POWER 30A WIND) HAZARD 10A
TAIL 15A METER 15A TURN 15A
ROOM 5A (DOOR LOCK) 3CA STOP tSA ] (AIR CONO)| . ISA jj| ((COOLING! ( ENGINE 1 J [
BOA
FAfJ)J [ 15A J
(REAR 15AWIP£R), ^ C WIPER "1[SUN HOOF?
1)J
[ 2QA
J
[ 15A
West Germany (Diesel model)

MAIN (fWl
ISA I
MALM (LM1
15A
DIM iLHI
ISA
PEAfl FOCii
I 'SA | RAQIO T5A I
HEAP CLEANEF*
1 I (POWEfl I
3PA WI^D;. TAIL (LH)
15A
)C
TAIL <flHf
I ISA METER 1OA TURN 15A FIOQM
(DOOR LOC*C|
HOflN 15A Jt 1SA

(
AIR COND)
jy (COOUNQ
gqA FAN)
ENGINE 16A

|fl£AR WlPEFl!
ILJSi '
DEfOO
3 OA
Dtf
WtPEfl
USUNROQF Jl JPA H 15A [
86U15X-006
15-11

15 METER

Standard indication
(km/h)
Allowable range
(km/h)

40 40-
43

80 80-
84

120
120—126
Standard indication

(mph)

Allowable range

(mph)
30
30-32

50
50-53

80
80—84

86U15X-029

Standard Indication

(rpm)

Allowable range

(rpm)
1000
850—1090
2000 1910-2210
3000 2850-3330
4000 3820-4420
5000 4790—5510
6000 5760-6600

86U15X-030
INSPECTION OF ANALOG METER
Speedometer
1. Using a speedometer tester, check the speedom-
eter for allowable indication error, and check the
operation of the odometer. Replace if necessary.
2. Check the speedometer for fluctuation and/or ab-
normal noise.
Caution
a) If significant fluctuation occurs or the
speedometer does not move at all, remove
the speedometer cable. If normal, replace
the speedometer assembly.
b)Tire wear and improper inflation will in-
crease speedometer error.
Tachometer
1. Connect a test tachometer to the engine, and start
the engine.
2. Check the tachometer for allowable indicator er-
ror. Replace if necessary.
Caution
When removing or installing the tachometer,
be careful not to drop it.
Fuel Gauge
1. Disconnect the connector from the fuel tank unit.
86U15X-031
Connect the red lead of the SST to the terminal
"Y", and the black lead to a body ground.
86U15X-032
15-26